BlueChip Adapt Pro Elite 9200 User manual

!
Product!Symbol!Description!
!
!
SYMBOLS!
DESCRIPTION!
I!
POWER!ON!
O!
POWER!OFF!
!
ATTENTION!
!
DOUBLE!ISOLATION!
!
“BF”!SYMBOL,!INDICATE!THIS!PRODUCT!IS!ACCORDING!TO!THE!
DEGREE!OF!PROTECTION!AGAINST!ELECTRIC!SHOCK!FOR!TYPE!BF!
EQUIPMENT,!APPLIED!PART:MATTRESS!
!
CAUTION,!READ!THE!INSTRUTION!BEFORE!USE!
!
AWAY!FROM!THE!FLAME!
IP21!
WATER!AND!DUST!PROTECTION!CLASSIFICAITON!
!
FUSE!SPECIFICATION!
!
DISPOSAL!OF!ELECTRICAL!&!ELECTRONIC!EQUIPMENT!(WEEE):!THIS!
PRODUCT!SHOULD!BE!HANDED!OVER!TO!AN!APPLICABLE!
COLLECTION!POINT!FOR!THE!RECYCLING!OF!ELECTRICAL!AND!
ELECTRONIC!EQUIPMENT.!
!
UL!CERTIFICATION!LOGO!(COMPLIACE!WITH!IEC60601-1)!
WITH!RESPECT!TO!ELECTRICAL!SHOCK,!FIRE!AND!MECHANICAL!
HAZARDS!ONLY!IN!ACCORDANCE!WITH!IEC60601-1.!
!
CB!CERTIFICATION!LOGO!
!
CE!CERTIFICATION!LOGO!
!
!
!
!
!
!
2

2!
!
!
!
!
!
Contents!
1.! INTRODUCTION!......................................................................................................................!3!
2.! INTENDED!USE!.......................................................................................................................!3!
3.! PRODUCT!DESCRIPTION!.........................................................................................................!3!
4.! PRODUCT!INSTALLATION!GUIDE!.............................................................................................!4!
5.! PANEL!DISPLAY!AND!OPERATION!GUIDE!................................................................................!6!
6.! CLEANING!.............................................................................................................................!11!
7.! STORAGE!..............................................................................................................................!12!
8.! MAINTENANCE!.....................................................................................................................!13!
9.! THE!DISPOSAL!OF!AIR!MATTRESS!.............................................!Error!%Bookmark%not%defined.!
10.! TROUBLESHOOTING!.............................................................................................................!14!
11.! TECHNICAL!DATA!..................................................................................................................!15!

!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
4
4
4
5
7
12
13
14
15
TROUBLESHOOTING……………….…………………………………………………………………..………15
TECHNICAL DATA….……………….…………………………………………………………………..………16
.
3
13
14
4
4
4
5
7
12
13
14
15
TROUBLESHOOTING……………….…………………………………………………………………..………15
TECHNICAL DATA….……………….…………………………………………………………………..………16
.
3
13
14

4!
4. PRODUCT%INSTALLATION%GUIDE%
1. Unpack!the!box!to!inspect!all!items!for!any!damage!that!may!have!occurred!
during!shipping.!If!there!is!any!damage,!please!contact!your!dealer!
immediately!for!assistance.!
2. Place!the!mattress!on!top!of!the!bed!frame.!The!foot!symbol!on!both!sides!of!
the!mattress!indicates!location!of!the!foot!end.! !
!
3. Secure!the!mattress!onto!the!bed!
frame!by!using!the!elastic!straps!or!
binding!side!straps.!
!
4. Ensure!the!CPR!valve!is!in!CLOSED!
position!before!turning!on!the!
power.!
!
5. Position!the!Pump!by!its!spring!
loaded!hanger!brackets!over!
footboard!of!the!bed.!The!elastic!
hanger!brackets!will!self-adjust!onto!
the!footboard!tightly.! !
6. Remove!the!Transport!Cap!of!the!
hose!connector!and!connect!the!
hose!connector!to!the!Pump!unit.!
Firmly!push!the!hose!connector!into!
position!and!a!“clicking”!sound!will!
secure!the!connection.!
!
Pump!Unit!
CPR!
Hose!Connector!
Air!Mattress!
Patient Head
Elastic!
Strap!
Binding!Side!Strap! !
Model!No.!
(Inside!the!cover)!
CPR!Position!Indicator!
5!
6!
5

10!
from!the!Pump!to!speed!up!the!air!release.!
!
!
5.2.3 Audiovisual%Alarm%
l Power!Failure!–!When!an!electrical!shortage!occurs!or!power!cord!is!unpluged!
without!turning!off!the!Pump!or! is!pressed!(intentionally!or!
unintentionally),!the!“Power!Failure”!indicator!will!light!up!along!with!buzzer!
and!will!last!20!minutes.!
!NOTE:!When!the!Pump!has!not!been!used!for!more!than!3!months,!the!Pump!
may!need!6!hours!or!more!of!operating!time!for!the!alarms!to!function!properly.!
!
l Low!Pressure!–When!an!abnormal!low!pressure!occurs!in!body!section!for!2.5!
minutes!after!the!pressure!is!below!the!abnormal!pressure!threshold,!the!
"Low!Pressure"!indicator!will!flash!and!beep.!Should!the!situation!not!resolved!
and!fault!conditions!continue,!the!alarm!will!resume.!
!
l Service!(Malfunction)!–When!fault!conditions!occur,!the!"Service"!indicator!
will!light!up!along!with!buzzer.! !
!Note:!Refer!to!Table&2&for&Warning&Code&Reference&Table&if!error!code!
appears!on!the!display!or!refer!to&10.&TROUBLESHOOTING.! !
!
5.2.4 Alarm%Mute%
l When!alarms!are!triggered,!both!LED!light!and!buzzer!will!turn!on!to!warn!the!
patient!and!caregiver.!By!pressing!the!button,!it!will!temporarily!mute!the!
buzzer!so!the!caregiver!may!check!for!possible!causes.!Should!the!situation!
not!resolved!and!fault!conditions!continue,!the!alarm!will!resume.!Refer!to%10.&
TROUBLESHOOTING&for!diagnosis.! !
l During!“power!failure”,!pressing!“alarm!mute”!will!cease!all!buzzers!and!
indicators!and!turn!off!the!system.! !
l During!“low!pressure!alarm”!if!the!pressure!resumes!back!to!normal!then!the!
low!pressure!alarm!will!stop.!
l When!more!than!one!alarm!is!triggered,!the!alarm!will!be!performed!
according!to!priority!level.!Refer!to!Table&2&Warning&Code&Reference&Table%for!
priority!level.! !
!
!
!
!
!
11
the&hose&from&the&Pump&to&speed&up&the&air&release.
..
11
the&hose&from&the&Pump&to&speed&up&the&air&release.
..
11
the&hose&from&the&Pump&to&speed&up&the&air&release.
..
11
the&hose&from&the&Pump&to&speed&up&the&air&release.
..

14!
9. TROUBLESHOOTING%
PROBLEM!
SOLUTION!
The!mattress!is!not!able!to!
connect!with!the!Pump! !
l Check!if!the!mattress!model!(model!no.!located!inside!the!cover!by!
the!foot!end)!xxAAAxxx!matches!with!the!Pump!model!xxBBB-xxx.!
The!AAA!should!be!the!same!as!BBB.!If!not,!please!contact!with!the!
agent!or!distributor.!
l Check!if!the!Transport!Cap!is!removed!and!make!sure!the!
connector!is!not!broken.!
The!Pump!is!showing!no!
indications!of!working!
l Check!if!the!plug!is!connected!to!the!mains!supply.!
l Check!if!the!power!switch!is!switched!to!ON!position!(press ).!
l Check!if!there!is!any!blown!fuse.!
Power!failure!alarm!failed!
l If!the!Pump!is!in!operation!but!failed!to!trigger!the!power!failure!
alarm!during!power!off.!Charge!the!Pump!for!6!hours!or!more!of!
operating!time!and!if!the!power!failure!still!not!works!then!please!
contact!the!dealer!or!agent!for!further!investigation.!
The!low!pressure!light!is!
constantly!flashing!and!the!
alarm!is!sounded!
l Check!if!the!CPR!is!at!CLOSE!position!
l Check!if!the!connection!between!air!tubes!to!Pump!unit!is!tightly!
secured.!
l Check!if!all!coupling!connections!along!mattress!are!secured.!
l If!the!mains!supply!is!normal!but!there!is!no!sound!of!the!Pump,!
please!remove!the!connector!from!the!Pump!to!check!if!there’s!air!
comes!out.!If!not,!please!turn!off!the!machine!and!contact!the!
dealer!or!agent!for!further!investigation.! !
l If!all!of!above!steps!have!been!checked.!Press!“Alarm!Mute”!for!
system!to!be!verified!again.!
The!Pump!is!on!but!the!
mattress!is!not!alternated!
l Ensure!the!mattress!inflation!is!completed.!
l Check!the!Pump!control!panel!the!indicator!of!“Alternate”!should!
be!lighted!on,!if!not,!switch!it!to!“Alternate.”!
l Check!if!“Service”!alarm!indicator!is!on!with!buzzer,!if!yes,!contact!
the!dealer!or!agent!for!further!investigation.!
Service!(Malfunction)!
Alarm!is!on! !
l Press!“alarm!mute”!for!system!to!be!verified!again.!If!the!alarm!is!
still!on,!please!contact!dealer!or!agent.! !
The!Pump!is!operating!
noisily!
l Make!sure!the!Pump!is!resting!against!a!solid!surface.!
l If!the!noise!is!getting!louder,!contact!the!dealer!or!agent!for!further!
investigation.!
Patient!is!bottoming!out!
(without!alarm!triggered)!
l Pressure!setting!might!be!inadequate!for!the!patient,!adjust!
comfort!level!to!FIRM!(refer!to!Table&1&Weight&and&Comfort&Level&
Reference&Table)!and!wait!for!a!few!minutes!for!better!comfort.!
l Follow!the!procedures!“The!low!pressure!light!is!constantly!flashing!
and!the!alarm!is!sounded”!for!inspection.!
If!the!above!information!does!not!solve!the!problem,!please!contact!your!local!dealer!or!agent!for!further!support.!
15
Check&the&ma5ress&model&(model&no.&located&inside&the&cover&
by&the&foot&end)&Make&sure&that&connector&hoses&line&up&with&
the&pump.&If&not,&please&contact&Blue&Chip.
Check&if&plug&is&locked&into&pump&and&plugged&into&power&outlet
please&contact&Blue&Chip.
please&contact&Blue&Chip&for&further&support.
please&contact&Blue&Chip.
&&
please&contact&Blue&Chip.
If&the&power&supply&is&normal&please&remove&the&connector&from&
the&pump&to&check&if&there&is&air&coming&out.&If&not,&turn&off&
pump&and&contact&Blue&Chip&for&further&invesGgaGon.
Ensure&Pump&is&on&a&solid&surface&or&a5ached&to&footboard&of&bed
15
Check&the&ma5ress&model&(model&no.&located&inside&the&cover&
by&the&foot&end)&Make&sure&that&connector&hoses&line&up&with&
the&pump.&If&not,&please&contact&Blue&Chip.
Check&if&plug&is&locked&into&pump&and&plugged&into&power&outlet
please&contact&Blue&Chip.
please&contact&Blue&Chip&for&further&support.
please&contact&Blue&Chip.
&&
please&contact&Blue&Chip.
If&the&power&supply&is&normal&please&remove&the&connector&from&
the&pump&to&check&if&there&is&air&coming&out.&If&not,&turn&off&
pump&and&contact&Blue&Chip&for&further&invesGgaGon.
Ensure&Pump&is&on&a&solid&surface&or&a5ached&to&footboard&of&bed
15
Check&the&ma5ress&model&(model&no.&located&inside&the&cover&
by&the&foot&end)&Make&sure&that&connector&hoses&line&up&with&
the&pump.&If&not,&please&contact&Blue&Chip.
Check&if&plug&is&locked&into&pump&and&plugged&into&power&outlet
please&contact&Blue&Chip.
please&contact&Blue&Chip&for&further&support.
please&contact&Blue&Chip.
&&
please&contact&Blue&Chip.
If&the&power&supply&is&normal&please&remove&the&connector&from&
the&pump&to&check&if&there&is&air&coming&out.&If&not,&turn&off&
pump&and&contact&Blue&Chip&for&further&invesGgaGon.
Ensure&Pump&is&on&a&solid&surface&or&a5ached&to&footboard&of&bed
15
Check&the&ma5ress&model&(model&no.&located&inside&the&cover&
by&the&foot&end)&Make&sure&that&connector&hoses&line&up&with&
the&pump.&If&not,&please&contact&Blue&Chip.
Check&if&plug&is&locked&into&pump&and&plugged&into&power&outlet
please&contact&Blue&Chip.
please&contact&Blue&Chip&for&further&support.
please&contact&Blue&Chip.
&&
please&contact&Blue&Chip.
If&the&power&supply&is&normal&please&remove&the&connector&from&
the&pump&to&check&if&there&is&air&coming&out.&If&not,&turn&off&
pump&and&contact&Blue&Chip&for&further&invesGgaGon.
Ensure&Pump&is&on&a&solid&surface&or&a5ached&to&footboard&of&bed