BOON EDAM Circleslide Technical manual

Circleslide
1x
+
Maintenance
Check daily : • Emergency-, safety devices and general operation of the door.
• Presence of loose parts, sharp edges or broken glass.
• Safety and contrasting stickers are applied.
• Lighting; to provide a proper level of illumination inside the door.
• Floor condition; avoid slipping or tripping hazards and excessive dirt inside the door.
Weekly : • Clean the anodised, powder coated and/or stainless steel surfaces with a wet cloth.
Monthly : • Clean the anodised, powder coated and/or stainless steel surfaces with a wet cloth
and a non-aggressive soap. Stainless steel surfaces need to be cleaned
according the instruction below, Vacuum clean all the brushes.
Yearly : • The door needs a major maintenance check once a year.
This has to be done by Boon Edam or an approved agent. This applies as well for repairs.
Note :
• Make sure maintenance is properly recorded in the Logbook inside the door.
Caution !
• Don’t use water near the drive-units or control boxes.
Warning !
• Switch OFF the power supply of the door during maintenance or other work.
Cleaning Instruction
Sensors :
• Remove dirt and dust with a wet cloth and dry with a clean soft cloth.
Avoid scratching!!
Stainless steel parts:
• Use sponge to wipe the parts clean and dry with a clean cloth.
• Apply an even spray Inno-x on the surface to be treated or spray it on a clean,
dry and soft cloth and apply. Rub off with a clean, dry and soft cloth.
Instruction card
Circleslide
Safety- and operating instructions
Control panel
Maintenance
Cleaning Instruction
Explanation of the symbols
outside
inside
Doorset movement.
Doorset movement will be stopped.
Doorset opens on normal speed.
Doorset opens on slow speed.
Doorset does not open.
Valid for both doorsets.
Valid for one doorset.
Safety sensor is active.
Motion detector is active.
Free out pushbutton.
Doorset can be operated manually.
Use key to open both doorsets once.
Doorset is locked.
Doorset is unlocked.
Function is adjusted.
Able to leave the area.
Emergency power system.
After 30 min. one programmable action.
No power supply.
Optional / CE Plus.
Extra country specific.
Caution :
• Any children or minors using the product must be supervised by a responsible adult.
• This product should not be considered as a playground. Do not let children play inside
or near the door.
• Push doorwing for emergency open position (optional collapsible doorset).
• Running or dashing into a closing door are prohibited.
• In case of broken glass do not use the door. Take all necessary precautions
to avoid people coming into contact with sharp edges of the broken glass.
Boon Edam B.V. P.O. Box 40, 1135 ZG Edam Holland Version : 2015/01/12
Edition : CS-INS-UK

Circleslide
>
#
#<
><
<< >>
>> <<
< >
EXIT
30 min.
max.
30 min.
max.
>30 min.
30 min.
max.
>30 min.
30 min.
max.
>30 min.
Safety- and operating instructions
A. The Circleslide safety devices
1 Reversing- and stop mechanism.
2 Threshold Safety (THS).
3 Side wing Safety (SWS).*
4 Emergency power system (day).
5 Emergency unlocking.
6 Emergency open button.*
7 Fire alarm.*
B. Last action after power failure.*
1 Sliding doors will open.*
2 Sliding doors will close, doorset locks.*
3 Sliding doors will close, doorset unlocked.*
C. Operating modes
1 Automatic mode.
2 Night mode (closed).
3 Permanently open mode.
4 Manual mode.
5 One-way mode (outer doorset).
6 Winter mode.
7 Key-impuls switch.*
8 Free out pushbutton.*
9 Interlocking.*
10 Reset mode.
Control panel
A. The Circleslide control panel
1 Control panel inside door.
Keys
C-key (Cancel)
Exit menu.
OK-key.
Confim the selection.
Arrow keys.
Navigate within
the menus.
Inner
doorset
Outer
doorset
Display
Section frame
Indicating priority operating mode
with key switch.
Section frame
Indicating operating mode selected
with control panel.
Automatic mode.
Night mode (closed).
Permanently open mode.
Manual mode.
One-way mode.
Winter mode, reduced opening width.
Summer mode, full opening width.
Closed and locked.*
Closed.
Opening.
Closing.
Open.
B. Control panel Inter-locking*
1 Control panel inside door.
1 Inter-locking mode enabled.
2 Inter-locking mode disabled.
3 Night mode, outer doorset locked.
C. Free out pushbutton*
1 Control panel inside door.
1 Free out (one passage, in night position).
D. Entry (one passage, in night position)*
1 Key switch outside door.
1 Entry (one passage, in night position).
E. Escape route*
1 Control panel inside door.
1 Escape route enabled, doorset unlocked.
2 Escape route disabled, doorset locked.
Version : 2015/01/12
Edition : CS-INS-UK