Borri GALILEO UPS User manual

www.borri.it
Battery box

Page 1
Box baeria Borri Galileo UPS
1 Safety instructions 2
2 Introduction to the panel 3
3 Installation and operation 5
4 Battery box specification 8
Index page

Page 2
1 Safety instructions
Save these instructions
This manual contains important instructions that should be followed during installation
and maintenance of the battery box and batteries.
An important notice
• Thebatteryboxwhichissuppliedwithafactoryinputplugcanbesafelyconnected 
to the wall receptacle by the user.
• ThisbatteryboxisconnectedtoanUPS.Therewillbevoltageattheoutput
 terminalsiftheUPSisturnedoneveniftheinputACmainsisnotavailable.
• MakesurethattheACutilityoutletiscorrectlygrounded.
• Donottrytorepairtheunityourself,contactyourlocalsupplieroryourwarranty
 willbevoid.
• Useacertifiedinputpowercablewiththecorrectplugsandsocketsforthe
 appropriatevoltagesystem.
• Toeliminateanyoverheatingofthebatterybox,keepallventilationopeningsfree
from obstruction and do not place any foreign objects on top of the battery box.
Keep the battery box 30 cm away from the wall.
• Makesurethebatteryboxisinstalledwithintheproperenvironmentasspecified.
 (0°C-40°Cand30°C-90%non-condensinghumidity).
• Donotinstallthebatteryboxunderdirectsunlight.Yourwarrantywillbevoidifthe
 batteriesfailduetooverheating.
• Thisbatteryboxisdesignedforindooruseonly.
• Thisbatteryboxisnotdesignedforuseindusty,corrosiveandsaltyenvironment.
• Thewarrantyforthisbatteryboxwillbevoidifwaterorotherliquidisspiltor
poured directly onto the battery box. Similarly we do not warrant any damage to the
battery box if foreign objects are deliberately or accidentally inserted into the
battery box enclosure.
• Thebatterywilldischargenaturallyifthesystemisunusedforaperiodoftime.
• Itshouldberechargedevery2-3monthsifunused.Ifthisisnotdone,thenthe
 warrantywillbenullandvoid.Duringnormaloperation,thebatterieswillbe
automatically remained in charged condition.
• Servicingofbatteriesshouldbeperformedorsupervisedbytrainedpersonnelwith
 knowledgeofbatteriesandtherequiredprecautions.
• Whenreplacingbatteries,replacewiththesamequantity,type&capacity.
• CAUTION-Donotdisposeofbatteryorbatteriesinanopenfire.
The battery may explode.
• CAUTION-Donotopenormutilatethebatteries.Theelectrolytefromthebatteries
 istoxicandharmfultotheskinandeyes.
• CAUTION-Riskofelectricshock-batterycircuitisnotisolatedfromAC,hazardous
 voltagemayexistbetweenbatteryterminalsandground.Testbeforetouchingwith
bare hands.
• CAUTION-Abatterycanpresentariskofelectricalshockandhighshortcircuit
 current.Thefollowingprecautionshouldbeobservedwhenworkingonbatteries:
 A.Removewatches,rings,orothermetalobjects.
 B.Usetoolswithinsulatedhandles.
 C.Wearrubberglovesandboots.
 D.Donotlaytoolsormetalpartsontopofbatteries.
 E.Disconnectchargingsourcepriortoconnectingordisconnectingbatteryterminals.
Battery box

Page 3
2 Introduction to the panel
Rear panel descriptions
Tower
Battery box
1. DC Breaker 1.Batteryover-currentprotectionbreaker.
 2.Toeasyswappablebattery,pleaseputthepositionofthe
  breakerin“O”position.Incasethereis2nd (ornext)battery
  boxconnectedwiththebatterybox,theDCvoltagefromthe
  UPSBat.+/-willflowthroughwithoutanyinterruptionto
the 2nd battery box.
2. UPS battery +/- TotheUPSDCconnected.
3. External battery +/- TotheDCconnectedofthe2nd (ornext)batterybox
connector +/- connected.
1
1
2
2
33

Page 4
Battery box
Rack
1 3 2
1. DC Breaker 1.BatteryOver-currentProtectionBreaker.
 2.Toeasyswappablebattery,pleaseputthepositionofthe 
  breakerin“O”position.Incasethereis2nd (ornext)battery
  boxconnectedwiththebatterybox,theDCvoltagefrom
  theUPSBat.+/-willflowthroughwithoutanyinterruption
to the 2nd Battery Box.
2. UPS battery +/-   TotheUPSDCterminalorthenextbatterybox.
3. External Battery +/- TotheDCterminalofthe2nd (ornext)batterybox
connector +/- connected.

Page 5
Battery box
3 Installation and operation
Installation position
Itisnecessarytoselectaproperenvironmenttoinstallthe
unit,inordertominimizethepossibilityofdamagetothe
battery box and extend the life of the batteries.
Pleasefollowtheinstructionsbelow:
 Keepatleast30cm(12inches)clearancefromtherearpanel
of the battery box from the wall or other obstructions.
 Donotblocktheair-flowtotheventilationopeningsof
the unit.
 Pleaseensuretheinstallaonsiteenvironmentalcondions
 areinaccordancewiththebaeryboxworkingspecicaons
 toavoidoverheatandexcessivemoisture.
 Donotplacethebaeryboxinadustyorcorrosive
 environmentornearanyammableobjects.
Thisbaeryboxisnotdesignedforoutdooruse.
The packing condition and the external outlook of the unit must be
inspected carefully before installation.
Retain the packing material for future use.
Unpacking
TakethebatteryboxoutofthePEfoam.
Removethepackingmaterials.
Note: The battery box module is approx. 12.2 ~ 50 kgs, be cautious when unpacking
and lifting the unit to avoid injury.
Standard package includes:
DCconnectcable(C1orC2)
AccessoriesforTowerMount
AccessoriesforRack/TowerA1~A2,B1~B2,S1~S3
1pcsC1 C2 2pcs

Page 6
Battery box
Installation supports of Rack/Tower units
Installation instructions
Tower
UsewithUPS

Page 7
Battery box
Step 1
Step 2 Step 3
Rack
DCT connection cable
First battery Box Second battery box UPS
Storage instructions
 Forextendedstoragethroughmoderateclimate(-15°Cto+30°C/+5°Fto+86°F),
 thebatteriesshouldbechargedfor12hoursevery6monthsbypluggingtheUPS 
 powercordintothewallreceptacle.Repeatthisevery3monthsunderhigh
 temperature(+30°Cto+45°C/+86°Fto+113°F)environment.

Page 8
Battery box
Battery box GALILEO T specification
UPS 1000VA 2000VA 3000VA
Baeryboxcode MUPSBATT0001 MUPSBATT0002 MUPSBATT0003
Nominalsystemvoltage 24VDC 48VDC 72VDC
Baeryquanty 4 12 12
Baerytype  9Ah 9Ah 9Ah
MaxUPSchargecurrent*
Standard 2.2A  1.4A 1A
 Externalcharger 5.2A  4.4A 4A
Connectorcolor  Red(+),Black(-),Green(Gnd)
   DimensionsWxDxH(mm)
Unit  144x367x236 151x444x322 151x444x322
Shipping  304x398x527 304x484x604.6 304x484x604.6
   Weight(kg)
Unit  14.7 39.0 39.0
Shipping  15.9 40.5 40.5
* Batteryboxrequiresanexternal250Wbatterychargerforchargingthebatteries
 cod.MUPSACC0006
4 Battery box specification

Page9
Battery box
UPS 1000VA 2000VA 3000VA
Baeryboxcode MUPSBATT0006 MUPSBATT0007 MUPSBATT0008
Nominalsystemvoltage 24VDC 48VDC 72VDC
Baeryquanty 8 8 12
Baerytype  9Ah 9Ah 9Ah
MaxUPSchargecurrent*
Standard 1.5A  1A 1A
 Externalcharger 4.5A  4A 4A
Connectorcolor  Red(+),Black(-),Green(Gnd)
   DimensionsWxDxH(mm)
Unit  440x650x88 440x650x88 440x650x88
Shipping 560 x 833 x 228 560 x 833 x 228 560 x 833 x 228
   Weight(kg)
Unit  28.6 28.6 37.4
Shipping 30 30 39
Battery box GALILEO RT specification
Contactyourlocalrecyclingorhazardouswastecenterforinformationonproperdisposaloftheused
battery.

BorriS.p.A.Via8Marzo2-52011Bibbiena(Arezzo)-Italy-phone+3905755351-fax+390575561811-www.borri.it
OML65026revB - 07-2015
Battery box