Bradley S19-125SBF User manual

P.O. Box 309, Menomonee Falls, WI USA 53052-0309
PHONE 800.BRADLEY (800.272.3539) FAX [phone]
bradleycorp.com
Installation
215-1568 Rev. B; ECN 08-518
© 2008 Bradley Corporation
Page 1 of 7 9/29/08
S19-125SBF
S19-125SFMBF
Barrier Free Recess-Mounted
Drench Shower
Table of Contents
Pre-Installation Information . . . . . . . . . . . . . . 2
Assembly of Components . . . . . . . . . . . . . . . 3
Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . 3
Cabinet Dimensions . . . . . . . . . . . . . . . . . . . . 4
Rough-Ins. . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Installation . . . . . . . . . . . . . . . . . . . . . . . . . 6–7
www.bradleycorp.com
PUSH
PUSH
TO
TO
ACTIVATE
ACTIVATE
SHOWER
SHOWER
www.bradleycorp.com
PUSH
PUSH
TO
TO
ACTIVATE
ACTIVATE
SHOWER
SHOWER
S19-125SBF
S19-125SFMBF

2
S19-125SBF, S19-125SFMBF Installation
9/29/08 Bradley Corporation • 215-1568 Rev. B; ECN 08-518
IMPORTANT
Read this installation manual completely to ensure proper installation, then file it
with the owner or maintenance department. Compliance and conformity to drain
requirements and other local codes and ordinances is the responsibility of the installer.
Separate parts from packaging and make sure all parts are accounted for before
discarding any packaging material. If any parts are missing, do not begin installation
until you obtain the missing parts.
Flush the water supply lines before beginning installation and after installation is
complete. Test the unit for leaks and adequate water flow. Main water supply to the
eyewash should be “ON” at all times. Provisions shall be made to prevent unauthorized
shutoff.
The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a
minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per ANSI
Z358.1.
The inspection and testing results of this equipment should be recorded weekly to verify
proper operation. This equipment should be inspected annually to ensure compliance
with ANSI Z358.1.
Workers who may come in contact with potentially hazardous materials should be
trained regarding the placement and proper operation of emergency equipment per ANSI
Z358.1.
For questions regarding the operation or installation of this product, visit www.
bradleycorp.com or call 1-800-BRADLEY.
Product warranties and parts information may also be found under ”Products” on our
web site at www.bradleycorp.com.
Installation
THIS
SIDE
UP
Packing List
•
•
•
•
P.O.Box309,MenomoneeFalls,WI53051
R
TESTTHISUNITEACHWEEK
Test-operatevalve(s) each week and sign below.
Reportany malfunctions immediately.
Ventil(e)wöchentlich im Testbetriebprüfen, bestätigt
durchUnterschrift. Jegliche Störung sofort melden.
Date
Datum
Date
Signed
Unterschrift
Signe
Date
Date
Date Signed
Signed
Signed
DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.
ESSAIHEBDOMADAIRE
Testle fonctionnement des valves chaque semaine et
signeen bas. S'il y à quelque chose qui ne va pas fait
unrapport immédiatement.
P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA
TEL:1-800-BRADLEY FAX:[phone])
http://www.bradleycorp.com
114-051
Supplies Required:
• Teflon tape and Pipe sealant
• Piping to 1” NPT water supply inlet on unit
• Adequate supply pipe supports
• Hardware to mount escutcheon to ceiling
• Minimum 4” (102 mm) drain to accommodate 30 gallons per minute discharge for drench
shower waste
• Sign-mounting hardware

3
Installation S19-125SBF, S19-125SFMBF
Bradley Corporation • 215-1568 Rev. B; ECN 08-518 9/29/08
Assembly of Components and Parts List
113-864
(S19-125SBF ONLY)
204-421
www.bradleycorp.com
114-090
114-090
Valve/Handle Prepack
(includes Handle and Valve Assembly)
S45-2238
P.O.Box 309, Menomonee Falls,WI 53051
R
TESTTHIS UNIT EACH WEEK
Test-operate valve(s) each week and sign below.
Report any malfunctions immediately.
Ventil(e) wöchentlich imTestbetrieb prüfen, bestätigt
durch Unterschrift. Jegliche Störung sofort melden.
Date
Datum
Date
Signed
Unterschrift
Signe
Date
Date
Date Signed
Signed
Signed
DIESES GERÄT 1STWÖCHENTLICH ZU PRÜFEN.
ESSAI HEBDOMADAIRE
Test le fonctionnement des valves chaque semaine et
signe en bas. S'il y à quelque chose qui ne va pas fait
un rapport immédiatement.
150-212
(S19-125SBF ONLY)
186-1495
(COVER PLATE)
www.bradleycorp.com
PUSH
PUSH
TO
TO
ACTIVATE
ACTIVATE
SHOWER
SHOWER
204-605
(LABEL)
S24-189
(S19-125SBF only)
S24-197
(S19-125SFMBF only)
169-1027
(S19-125SBF only)

4
S19-125SBF, S19-125SFMBF Installation
9/29/08 Bradley Corporation • 215-1568 Rev. B; ECN 08-518
S19-125 Series Cabinet Dimensions
14"
(357mm)
7-11/16"
(195mm)
8-7/16"
(214mm)
2-1/4"
(57mm)
10"
(254mm)
12-1/2"
(318mm)
7"
(178mm)
3" (76mm)
Side View Front View

5
Installation S19-125SBF, S19-125SFMBF
Bradley Corporation • 215-1568 Rev. B; ECN 08-518 9/29/08
82" (2083mm) min.
to
96" (2438mm) max.
to floor
25"
(635mm)
min.
38" (965mm)
to 48" (1219mm)
from floor
S19-125SBF S19-125SFMBF
Ceiling hole
Ø 1-3/8" (35mm)
Wall opening
6" (152mm) wide
10" (254mm) high
Piping and
adequate
supports by
installer
38" (965mm)
to 48" (1219mm)
from floor
Ceiling hole
Ø 5" (127mm)
Piping and
adequate
supports by
installer
25"
(635mm)
min.
6" (152mm) min.
clearance
82" (2083mm) min.
to
96" (2438mm) max.
to floor
1Rough-ins

6
S19-125SBF, S19-125SFMBF Installation
9/29/08 Bradley Corporation • 215-1568 Rev. B; ECN 08-518
S19-125SBF S19-125SFMBF
Piping and
adequate
supports by
installer
Piping and
adequate
supports by
installer
2Installation
NOTE: Use
teflon tape
only.
NOTE: Use
teflon tape
only.

7
Installation S19-125SBF, S19-125SFMBF
Bradley Corporation • 215-1568 Rev. B; ECN 08-518 9/29/08
www.bradleycorp.com
114-090
To Showerhead
Connect supply
piping.
1" NPT supply
line
3Connect Water Supply