Breville FoodCycler LWR550 User manual

the FoodCycler™
Instruction Book – LWR550

2
BREVILLE
RECOMMENDS
SAFETY FIRST
At Breville we are very safety
conscious. We design and
manufacture consumer
products with the safety of you,
our valued customer, foremost
in mind. In addition, we ask
that you exercise a degree
of care and adhere to the
following precautions.
IMPORTANT
SAFEGUARDS
READ ALL INSTRUCTIONS
BEFORE USE AND SAVE
FOR FUTURE REFERENCE
• Carefully read all instructions
before operating the FoodCycler
for the first time and save for
future reference.
• Remove and safely discard
any packing material, and
promotional labels before using
the FoodCycler for the first time.
• To eliminate a choking hazard
for young children, remove and
safely discard the protective
cover fitted to the power plug of
this appliance.
• Do not place the FoodCycler
near the edge of a bench or
table during operation.
• Ensure the surface is level, clean
and free of water and other
substances.
• Do not use the FoodCycler on a
sink drain board.
• Do not place the FoodCycler
on or near a hot gas or electric
burner, or where it could touch
another heated appliance.
• Do not operate the FoodCycler
on an inclined surface. Do not
move the FoodCycler while it is
switched on.
2 Breville Recommends Safety First
7 Components
8 Control Panel
9 Features
10 Assembly
11 Functions
14 Replacing the Filters
16 EcoChips™ Disposal
17 Care & Cleaning
18 Troubleshooting
Contents

3
• Do not cover the air vents while
the FoodCycler is operating.
• Never use the FoodCycler
without the bucket in place
correctly.
• Never use the FoodCycler with
an empty bucket.
• Never touch the inside of the
FoodCycler while it is operating
as it is very hot.
• Always operate the FoodCycler
on a stable and heat resistant
surface. Do not use on a cloth-
covered surface, near curtains or
other flammable materials.
• When using the FoodCycler,
provide sufficient clearance
(minimum 20cm) above and on
all sides for air circulation.
• Hot air is released through the
air vents on the rear side of the
FoodCycler during operation.
Always keep your hands and
face at a safe distance from the
hot air and from the air vents.
• Never use the FoodCycler
without the rear air outlet cover
installed as the inner accessible
surface of the FoodCycler is very
hot during, and sometime after,
operation.
• Never attempt to remove the
security seal sticker or open the
side cover of the FoodCycler.
Warranty void if seal is removed
or damaged. Misuse may cause
injury.
• Before starting to operate the
FoodCycler each time, clean
any dirt or food residue on the
external surface of the bucket
and the surface of the heating
plate.
• The FoodCycler is designed for
processing household FOOD
WASTE only. Do not add non-
food waste to the FoodCycler.
• Do not fill the bucket with hard
food waste such as hard bones
or other similar hard food waste
as it may damage the bucket
and the FoodCycler.
• Do not over-fill the bucket past
the ‘Fill line’ marked on the
interior of the bucket.
• Do not pack down food waste to
keep it beneath the fill-line once
full. Overloading the bucket
may cause a jam and damage
the motor and FoodCycler.
• Do not place anything on top of
the FoodCycler.
• Do not place any part of the
FoodCycler in the dishwasher
except the bucket.
• To prevent burns or personal
injury, always use protective
hot pads or insulated oven
mitts when inserting,
removing or handling items
from the FoodCycler when

4
hot. Alternatively, allow the
FoodCycler to cool down
before handling.
• Always use extreme caution
when removing any of the
accessories or disposing of
food waste from the bucket.
• It is recommended to use only
the accessories supplied with
this FoodCycler.
• The use of any accessory
attachments not recommended
by Breville may cause injuries.
• Do not attempt to operate the
FoodCycler by any method
other than those described in
this book.
• Always ensure the FoodCycler
is properly assembled before
use. Follow the instructions
provided in this book.
• The FoodCycler will not
operate unless properly
assembled with the lid locked
in place.
• Ensure the FoodCycler lid is
securely locked in place before
operating.
• The FoodCycler is not intended
to be operated by means of
an external timer or separate
remote-control system.
• Do not store any item on top
of the FoodCycler when in use
and when stored.
• Always ensure the FoodCycler
has cooled, is turned off at the
power outlet and the cord is
unplugged from the power
outlet before attempting to
move the FoodCycler, when not
in use, if left unattended and
before disassembling, cleaning
or storing.
• Do not place the FoodCycler
in direct sunlight. Colour
fading and discolouration may
occur when the FoodCycler is
consistently exposed to UV
light.
• Keep the FoodCycler
clean. Follow the cleaning
instructions provided in this
book.
SPECIFICATIONS
Filter Life Approx. 3-4 months ^
(or 500 cycle hours)
whichever comes first.
Processing Modes Drying, Grinding, Cooling
Product
Dimensions (mm)
(W)280 x (D)320 x (H)360
Power Input 220-240V 50Hz
Power
Consumption
500W
Energy Usage
(Running)
Approx.0.8KWh per cycle
Energy Usage
(Standby Mode)
2KWh per month
Processing Time Approx. 4-6 hours*
Waste Volume
Reduction
Approx. over 80%**
Bucket Capacity Approx. 2 Litres

5
^A filter replacement warning light will alert
you when it is time to replace.
* Typical processing time takes an average of
4-6 hours. Cycle time will vary depending on
the types of food being processed and the total
moisture content. Total maximum processing
time is maximum 8 hours. The cooling phase
takes up to an additional 30 minutes.
** The volume of the bucket contents may
be reduced by over 80% depending on the
amount and moisture content of the food
scraps being processed.
IMPORTANT SAFEGUARDS
FOR ALL ELECTRICAL
APPLIANCES
• Fully unwind the power cord
before use.
• Connect only to a 230V or
240V power outlet.
• The appliance must be used on
a properly grounded outlet. If
it is not sure, please consult a
qualified electrician.
• Do not, under any
circumstances, modify the
power plug or use a power plug
adapter.
• Do not place this appliance on
or near a heat source, such as
hot plate, oven or heaters.
• Position the appliance at a
minimum distance of 20cm
away from walls, curtains and
other heat or steam sensitive
materials and provide adequate
space above and on all sides for
air circulation.
• Do not let the power cord hang
over the edge of a bench or
table, touch hot surfaces or
become knotted.
• This appliance is for household
use only. Do not use this
appliance for anything other
than its intended use. Do not
use in moving vehicles or
boats. Do not use outdoors.
Misuse may cause injury.
• The appliance is not
intended for use by persons
(including children) with
reduced physical, sensory
or mental capabilities, or
lack of experience and
knowledge, unless they have
been given supervision or
instruction concerning use
of the appliance by a person
responsible for their safety.
• Children should be supervised
to ensure that they do not play
with the appliance.
• Always turn the appliance to
the OFF position, switch off at
the power outlet and unplug
at the power outlet when the
appliance is not in use.
• Before cleaning, always turn the
appliance to the OFF position,
switch off at the power outlet,
unplug at the power outlet
and remove the power cord, if
detachable, from the appliance
and allow all parts to cool.

6
• To protect against electric
shock, do not immerse the
power cord, power plug or
appliance in water or any other
liquid or allow moisture to
come in contact with the parts,
unless it is recommended in
the cleaning instructions.
• Any maintenance other than
cleaning should be performed
at an authorised Breville
Service Centre.
• It is recommended to regularly
inspect the appliance. To
avoid a hazard, do not use the
appliance if power cord, power
plug or appliance becomes
damaged in any way. Return
the entire appliance to the
nearest authorised Breville
Service Centre for examination
and/or repair.
FOR HOUSEHOLD USE ONLY
SAVE THESE INSTRUCTIONS
• The installation of a residual
current device (safety switch)
is recommended to provide
additional safety protection
when using electrical
appliances. It is advisable
that a safety switch with a
rated residual operating
current not exceeding 30mA
be installed in the electrical
circuit supplying the appliance.
See a qualified electrician for
professional advice.
• During electrical storms,
the appliance should be
disconnected from the power
source at the wall socket to
prevent any electrical surges
that may arise during the storm
and which may inadvertently
cause damage to the appliance
and its electronic componentry.

7
A. Locking Lid
B. Control Panel
C. Main Housing Body
D. Back Panel
E. Air Vents
F. Power Cord Outlet
G. Set of EcoFilters (LWR050BLK)
H. Filter cavities
I. Filter Reset Button
J. Filter Air Guides
K. Bucket with Agitators
L. Bucket Lid Assembly
a. Carbon Foam Lid Liner
b. Back Cover
c. Locking Screw
NOT PICTURED
• Non-Slip Feet
• Power Cord
Components
A
C
D
E
F
J
G
H
I
L
B
K
a
b
c

8
Control Panel
CHANGE
FILTER
COOLING
GRINDING
DRYING
A
B
C
D
E
A. Power On/Off button with indicator light
B. Drying indicator light
C. Grinding indicator light
D. Cooling indicator light
E. Change filter indicator light

9
Carbon Filter Bucket Lid
Complete with an activated carbon foam lid-
liner to capture odours, the versatile carbon
filter bucket lid allows for accumulating food
waste outside of the FoodCycler until ready
to start your next cycle. Keep the bucket on
its own on your benchtop using the carbon
filtered lid while you accumulate your daily
food waste, then when full, place the bucket in
the FoodCycler to process (remove bucket lid
before placing into FoodCycler).
A set of 2 activated carbon EcoFilters
(LWR050BLK)
Activated carbon filters are designed to reduce
odours during cycling.
FFeatures
YOUR BREVILLE FOODCYCLER
Your Breville FoodCycler transforms your
household food waste into nutrient rich
EcoChips™, using an intuitive three stage cycle.
The FoodCycler pulverizes and dehydrates
nearly all types of food waste.
Agitators turn inside the grinding bucket,
reducing food waste to small particles, while
simultaneously the FoodCycler aerates and
heats the bucket content, decomposing and
sterilising the food waste.
Stage 1- Drying
Dehydrates household food waste
Stage 2- Grinding
Grinds food waste down by over 80% of the
original volume**
Stage 3- Cooling
Cools down the remaining EcoChips™ for safe
disposal
** The volume of the bucket contents may be reduced by
over 80% depending on the amount and moisture content of
the food scraps being processed.
The FoodCycler comes equipped with the
following items:
Removable, porcelain-coated aluminium
bucket
The grinding bucket is designed to fully
grind and process food waste, with perfectly
calibrated resistance and strength testing.

10
Filter Air Guides
Two small air guide covers sit on top of
the carbon filters, ensuring that the air and
water vapour is properly directed toward the
FoodCycler vents.
Locking Lid
Seamless design, slides and locks smoothly
into place prior to every cycle to help insulate
sound, reduce odours, and ensuring a safe,
reliable cycle. Removing the lid will pause
operation.
Each one of these parts forms the complete
FoodCycler system.
BEFORE FIRST USE
wIMPORTANT
Ensure all packaging is removed from the
FoodCycler, EcoFilters and filter air guides
before using.
• Remove and safely discard any packaging
material or promotional labels attached to
your FoodCycler.
• Remove the stickers located on the top of the
two activated carbon EcoFilters that come
fitted in the FoodCycler and ensure that the
filters and filter air guides are in place before
first use.
• Follow the direction found in Replacing the
Filters on page 14.
wIMPORTANT
Failure to remove the stickers located at the
top of each of the filters before first use may
impede air flow and cause the FoodCycler to
fail to operate properly.
• Select a flat, level and dry location for the
FoodCycler.
• For proper air flow, locate the FoodCycler at
least 20cm from any wall or furniture.
• Ensure the air inlet and outlets are not
blocked before use.
nNOTE
When moving the FoodCycler, always lift using
two hands under the base and set down gently
on a flat, level and dry surface.
aAssembly