Broan QTR140L User manual

Page 3
MODEL QTR140L
5. Connect electrical wiring.
Run 120 VAC house wiring to installation location. Use
proper UL approved connector to secure house wiring to
wiring plate. Connect wires as shown in wiring diagrams.
CONNECT WIRING
3. Attach
damper/duct
connector.
Snap damper /
duct connector
onto housing.
Make sure con-
PGEVQTKUƀWUJYKVJ
top of housing and
FCORGTƀCRHCNNU
closed. If using
4-inch ductwork,
install 6” to 4” duct reducer over duct connector.
4. Install
6-inch or 4-
inch round
ductwork.
Connect 6-inch
or 4-inch round
ductwork to
damper / duct
connector or
reducer. Run
ductwork to a
roof cap or wall cap. Tape all ductwork connections to
make them secure and air tight.
INSTALL HOUSING & DUCT
1. Bend
housing
tabs.
Use a pliers to
bend housing
TABS out to 900.
2. Mount
housing to
joist.
Hold housing
in place so that
the housing tabs
contact the bottom
QHVJGLQKUV6JG
housing mounts
YKVJHQWT
screws or nails.
SPACER
WUGHQTOQWPVKPIVQ+,QKUV
I-JOIST
TABS
INSTALL GRILLE
6. Finish ceiling.
Install ceiling material. Cut out around housing.
7. Attach grille
to housing.
 5SWGG\GITKNNG
springs and insert
them into slots
on each side of
housing.
5ETGYQTPCKNJQWUKPIVQLQKUVVJTQWIJNQYGUVJQNGUKPGCEJ
OQWPVKPIƀCPIGVJGPVJTQWIJJKIJGUVJQNGU016'
Mounting to I-JOISTUJQYPTGSWKTGUWUGQHSPACERS
KPENWFGFDGVYGGPVJGJKIJGUVJQNGQHGCEJOQWPVKPI
ƀCPIGCPFVJG+LQKUV
Broan at ::bathroomsource.com is a division of kitchen:: accessories
U N L I M I T E D

bathroomsource com Call 1-800-667-8721 anywhere in the US and Canada - www.bathroomsource.com

Page 4
MODEL QTR140L
SERVICE PARTS
99043902B
Key No. Part No. Description
1 97016466 Housing
2 475 Duct Reducer - 6” to 4”
3 97016450 Duct Connector - 6”
4 98010102 Wiring Plate
   5ETGY:TGSŏF
6 97016933 Wire Panel/Harness Assembly
7 99020284 Blower Wheel
8 99080595 Motor
   +UQNCVQTTGSŏF
10 97016468 Motor Plate
   9CUJGTTGSŏF
   0WV*GZ.QEMTGSŏF
* 97017069 Blower Assembly
    KPENWFGUMG[PQUVJTW
13 97017067 Grille Assembly
    KPENWFGUMG[PQU
   )TKNNG5RTKPITGSŏF
15 99111345 Lens
   5RCEGTUWRRNKGF
SERVICE NOTE
To remove Blower Assem-
DN[
7PRNWIOQVQT
4GOQXGUETGYHTQOOQ-
VQTRNCVGƀCPIG
Find the single TAB on the
OQVQTRNCVGNQECVGFPGZVVQ
VJGTGEGRVCENG
Push up near motor plate
tab while pushing out on
side of housing. Or insert a
straight-blade screwdriver
KPVQUNQVKPJQWUKPIPGZVVQ
VCDCPF
twist screwdriver.
TAB
Order service parts by “Part No.” - not by “Key No.”
9. Remove
light lens.
Carefully insert a
UOCNNƀCVDNCFG
screwdriver be-
tween grille and
lens. Pry lens
out.
8. Push grille
against ceil-
ing.
10.Install light bulbs.
Purchase an incandes-
EGPVDWND9/CZ
Purchase a 4W incan-
descent night light bulb.
Insert bulbs into their
sockets. Replace lens.
Broan at ::bathroomsource.com is a division of kitchen:: accessories
U N L I M I T E D

bathroomsource com Call 1-800-667-8721 anywhere in the US and Canada - www.bathroomsource.com