Cazoner CZR-HD1002 User manual

Point for Attention
Donotinstallitintheplacethattooclosetothegasstove!
Donotinstallitintheplacewithtoomuchsmoke!
Donotinstallitintheplaceofexhaustfan,doors,
windows,bathroomsandotherlargeairfloworhumiditylarger!
Key Function Operation Guide
Self-testKey:Detectingthesoundandlightalarmtoseeifitis
abnormal.
Noalarmstate-->Presstheself-testbutton-->Thedisplayshows
8.8%whilethegreenlight,yellowlightandredlightareon
sequentially
-->buzzersounding-->100secondswarm-upcountdownstarts
Iftheringindicatorlightorbuzzerisabnormal,pleaserepairit
intime.
Two installation methods (A/B):
A: (Paste 3M tape)
1)Cleanthewallinasuitableposition
2)Stickthe3Mtapeonthedetachablebackplateofthealarm,
thenputthearrowupandperpendicularlytothegroundto
pressitonthewallfor10seconds.
3)Installthealarmonthedetachablebackplateandrotateitto
therighttolock
B: (Screw mounting)
1)Drillingtwosuitableholesonthewall,andthentightenthe
detachablebackplateontheholes
2)Installthealarmonthedetachablebackplateandrotateitto
therighttolock
Installation Location
Thedetectorandthegasstoveshouldbelocatedinthesame
indoorspace.
Thebestdistancebetweenthedetectorandthegasleaksourceis
1-3meters.
Naturalgasiscomprisedofmethanegasthatislighterthanair.
Incaseofgasleakage;gasrisestowardsceilingandaccumulates
inareasnearceiling.Therefore,fornaturalgas,thedetectorshall
belocatedinapositionof0.3mundertheceilingand（1-3）
metersawayfromgassupply.
LPGiscomprisedofmixtureofpropaneandbutanethatis
heavierthanair.Incaseofgasleakage,LPGfallsdownto
ground.Therefore,forLPG,thedetectorshallbelocatedina
positionof0.3mabovethefloorand（1-3）metersawayfrom
gassupply.
2
Contact
InstallationInstructions
3
CAZONERNaturalGasDetectorManual
USB1
USB2(Backup）
LCDdisplay
DetechableBackPlate
Self-testbutton
PowerIndicator
ProductIntroduction
CAZONER natural gas detector is a household detection
equipment for detecting the leakage of natural gas and
liquefied petroleum gas.Whenthe gas leaks reach to the
concentrationofdangerousvalueinthehouse,thesignalofthe
detector'saudibleandvisualalarmwillbeissuedimmediately
thatpromotingyoutotakeeffectiveactionquicklytoeliminate
the danger so that can avoid the accidents like fire and
explosioneffectively.
Sensor
Madewithoriginalcores
Thegas-sensingelectrodesmaterialis
100%pureplatinumpreciousmetal.
Alarmmode
Thesoundlevelalarmis85dB.Withtheincreaseofgas
concentration,theacousto-opticfrequencygradually
increase.
1
Website:http://www.cazoner.com/
Tel:8615811801081
Email:[email protected]
Address:A1564FNiulanqianBuildingLonghuanew
District
Shenzhen,China.
Zipcode:518101
THANKYOUFORREADING:)
Concentration value of working state(0-20%LEL):
GreenBreathing:0%-2%Greenlight"breathing",nocombustible
gasdetected(Normal)
YellowFlashing:2%-5%Yellowflashing,slightcombustiblegas
detected(Needtobevigilant)
Redflashing:5%-20%Redflashingquickly+Buzzerquick
alarm,highconcentrationcombustiblegasdetected(Dangerous)
YellowFlashing+Buzzeralarmsynchronously:Faultstatus
CZR-HD1002
Detect Natural Gas
(Methane)
Detect LP Gas
(Propane)
Installation Guide:
If the gas is natural gas,install the detector at the
distance of 0.3m from the ceiling and 1-3m from
the gas source.
If the gas is LPG,install it at the distance of 0.3m
from the floor and 1-3m from the gas source.
Floor
Ceiling
0.3m
0.3m
1-3m

CZR-HD1002
Natural Gas /LPG
70g
Semiconductor
70mm * 70mm * 28mm
Natural diffusion
DC5V±0.1V
0-20% LEL
100s
5%LEL
Visible and Audible alarm
Temperature: -20 to 40
Humidity: ≤ 95% RH (no frost)
85dB
5 years
Model
Applicable Gas
Weight
Overall Dimensions
Sampling Method
Working Voltage
Range
Self-test Time
Alarm presetting
level
Alarm
Working
Environment
Alarm Volume
Lifespan
Sensor Type
56
Failure
Phenomenon
The connection
of the power cord
is not well
Power indicator
has failed
Press the self-test
button without
sound and
light alarm
Circuit failure
No response
to detection
of gas
Pre-boot program
has not over yet
Circuit failure
After the
pre-start
procedure,
the detector has
been in the
alarm state
There are large
amount of volatile
organic compounds
surround
Place the
detector
in a clean
air environment
andrestart the
self-test
program
Long storage
Circuit failure
Please check
thepower cord
connection and
connect it again
Please contact
the seller for
assistance
Please contact
the seller for
assistance
Wait for the
program to
complete the
pre-boot
Please contact
the seller for
assistance
Please contact
the seller for
assistance
Continue to
aging it with
electricity
The green power
indicator does
not light
7
MainSpecifications Commonfaultsandsolutions
FailureAnalysis Solutions
After-sales service and Warranty Policy
4EquipmentMaintenance
1.First time to use: Please aging it with electricity for more than 24
hours when first to be used after a long-distance transport or long
storagesothatitcankeepthebestperformance.
2.Self-checking period: Please self-test it for every 4-6 months.When
youuseanknownconcentrationofgastotestthedetectortoconfirm
whether it will work, please be sure the operation environment is
absolutelysafe!
3.Cleaning:Pleaseusesoftbrush,velvetcleaningtoolstocleanitsface
end's dust or oil to ensure its detection hole breathable so that can
keep good display.Please do not use detergents, bleach or other
cleaningliquidtocleanit.
4.Indooruse only:Please avoidrain ormoisture whenuse it.Please
avoiditfalldown.Donotbeat,openorchangeit,oritmightcausesthe
productfailure.
6.Lifespan:Themaximumlifeofthedetectoris5yearsundernormal
situation.Pleasereplaceanewonewhenovertheuseoftheperiod.
5.Avoid volatile substances surround: Please do not use volatile
substanceslikealcoholorhairgelneartothedetector.Ifthiskindof
material causes the false report of the detector, please ventilates
promptlysothatitcanreturntothenormalexaminationcondition.
SUPPORT ONE-YEAR FREE REPLACEMENT,BUT CAN NOT ENJOY
THE WARRANTY UNDER THE SITUATION OF NON-NORMAL USE
(FOR EXAMPLE: LIGHTNING, VOLTAGE INSTABILITY, WATER AND
OTHER HUMAN FACTORS)