Chicco Tot Quad 05079726720070 User manual

Tot Quad™
Playpen
Owner's Manual
IS0196E_01 ©2020 Artsana USA, INC. 06/20
Read all instructions BEFORE
assembly and USE of product.
KEEP INSTRUCTIONS FOR
FUTURE USE.

2
• PLEASE READ THESE INSTRUCTIONS
CAREFULLY TO ENSURE THE SAFETY
OF YOUR CHILD.
• ALWAYS PROVIDE THE
SUPERVISION NECESSARY FOR
THE CONTINUED SAFETY OF YOUR
CHILD. WHEN USED FOR PLAYING,
NEVER LEAVE CHILD UNATTENDED.
• Playpen MUST be fully assembled
with all top rails locked into position
and the center floor hub pushed
down. Make sure latches are secure.
• DO NOT place child in playpen
unless all top rails are securely
locked into position and floor pad is
in proper place. Infant may roll into
space between pad and loose mesh
sides causing suffocation.
• Stop using this product when your
child reaches 35 inches (89 cm) in
height, weighs more than 30 lbs
(14 kg), or is able to climb out.
• Child can become entrapped and die
when improvised netting or covers are
placed on top of product. Never add
such items to confine child in product.
• Never use this product if there are
any loose or missing fasteners, loose
joints, broken parts, or torn mesh/
fabric. Check before assembly and
periodically during use. Contact
Chicco for replacement parts
and instruction if needed. Never
substitute parts.
• Although Chicco DOES NOT
RECOMMEND refinishing this
product, if you choose to refinish,
use a nontoxic finish specified for
children's products.
SUFFOCATION HAZARDS - Infants
can suffocate:
• In gaps between a mattress too
small or too thick and product sides
• On soft bedding.
• Use ONLY the mattress provided
by Chicco. Never add a pillow,
comforter, or another mattress for
padding.
• If a sheet is used with the pad, use
only a fitted playpen sheet specifically
designed to fit snug with at least 2”
(5 cm) under all sides of the mattress.
The sheet must allow proper use of
the mattress retention straps.
• DO NOT leave child in product with
any side lowered. Be sure all sides
are raised and locked in position
whenever child is in product.
• NEVER use plastic shipping bags as
mattress covers. Do not use plastic
film as mattress cover unless sold and
intended for that purpose. They can
cause suffocation.
• DO NOT use a water mattress with
this product.
Failure to follow these warnings and the instructions could result in
serious injury or death
WARNING

3
STRANGULATION HAZARDS:
• NEVER use additional mattresses,
padding, sheets, or other objects that
will permit your child to climb out,
fall and/or be injured. If you choose
to ignore this warning, then remove
additional padding, large toy, and
other objects that could serve as steps
for climbing out when your child is
able to pull to a standing position.
• Strings can cause strangulation! DO
NOT place items with a string around
child’s neck (hood strings, pacifier
cords,etc.) or attach strings to toys.
• DO NOT suspend strings on or over
the playpen.
• DO NOT place the playpen near a
window where cords from blinds or
drapes can strangle a child.
OTHER HAZARDS:
• Keep playpen away from stoves,
heaters, fireplaces and other hazards
which can cause injury to your child.
• To reduce the risk of SIDS (Sudden
Infant Death Syndrome), pediatricians
recommend healthy infants be
placed on their back to sleep unless
otherwise advised by a physician.
• DO NOT place more than one child in
playpen.
• DO NOT move or fold playpen with
child in it - child could be injured.
Failure to follow these warnings and the instructions could result in
serious injury or death
WARNING

4
Parts List
A. - Tot Quad Frame
B. - Mattress Pad
C. - Carry Bag
A.
B.
C.

5
1
Setting Up the Playpen
1. Remove Tot Quad from the Carry
Bag. Undo the hook and loop strap on
the Mattress Pad and remove the Tot
Quad frame.
WARNING
Before use remove and dispose of any plastic bags and keep them out of reach
of children to avoid the danger of suffocation. Failure to follow these warnings
and instructions could result in serious injury or death. Make sure top rails are
locked and secure with the center floor hub pushed down before use. This
product requires adult assembly. Keep fingers clear of top corners during setup.

6
2
Setting Up the Playpen
2. With the Tot Quad Frame
standing upright, pull the corners
apart as shown.
If needed, pull up on the center floor
hub release strap to lift the floor.

7
“CLICK!”
“CLICK!”
3
“CLICK!” “CLICK!”
Setting Up the Playpen
3. The center floor hub must be pulled
up to allow the top rails to lock.
With the center hub raised even with
the 4 corners, pull up on the top rail
center joint to lock them into the open
position. Each top rail center joint
has two pivots. Both sides of the joint
must lock for the top rail to stay open.
Repeat for all four top rails.
This step is very important for the
safety of your child. Make sure the
center hub is still pulled up during
this step or the side rails will not
latch.
Pivots

8
4. Push down on the center floor hub
until the bottom of the playpen is flat.
4
Setting Up the Playpen

9
5. Install Mattress Pad, padded side
up. Do not use playpen without
Mattress Pad and make sure to fold
hook and loop strap and D-ring
underneath Mattress Pad . Secure the
Mattress Pad corners to the frame as
shown in steps 6-7.
5
Setting Up the Playpen

10
Setting Up the Playpen
6. Locate 4 Mattress Pad strap holes
on the floor of the playpen. Thread
the 4 hook and loop straps through to
the floor of the playpen as shown.
6

11
Setting Up the Playpen
7.Turn the playpen on its side and pull
the straps through the floor of the
playpen. Thread the straps through
the slot in the playpen floor as shown.
Pull hook and loop strap tight and
then attach together to secure
Mattress Pad. Do this for all 4
mattress corners. Pull up on mattress
pad to make sure it is secure.
7

12
9. Undo the hook and loop straps
from the frame and remove Mattress
Pad from playpen. Pull up on the
center floor hub release strap and lift
the center hub up as far as possible.
Packing Up the Playpen
9

13
Packing Up the Playpen
10. Lift and squeeze the Top Rail
center release lock, then push down.
Release all of the Top Rail locks on all
4 sides. If theTop Rail does not unlock
pull up on the center hub. Center
floor hub must be even with top rails.
10

14
Packing Up the Playpen
11. Pull up on the center floor hub
release strap and pull the playpen
legs towards the center.
11

15
Packing Up the Playpen
12 12. Turn unit upright with feet on the
floor. Wrap Mattress Pad around fold-
ed playpen. Thread fastening strap
through ring on Mattress Pad.

16
Packing Up the Playpen
13. Place the playpen in the Carry
Bag. Pull up the sides of the Carry Bag
and close the zipper. Make sure the
Handle on the Mattress Pad is out.
13

17
Packing Up the Playpen
14. To keep instructions for future
use: Place the manual in the storage
sleeve located on the underside of the
Mattress Pad.
14

18
Trouble Shooting Guide
TOP RAILS FAIL TO LOCK INTO AN UPRIGHT POSITION :
Before top rails can be locked, the center floor hub must be pulled up as high as the 4
corners. If needed, pull up on the center floor hub release strap. If necessary, pull the
release strap up with one hand and lock rails one at a time. If you are still unable to
lock the top rails, call Chicco Customer Service (pg. 20).
THE FLOOR JOINTS DO NOT FLATTEN:
Turn playpen upside down and make sure joints are free from foreign objects.
TOP RAILS DO NOT UNLOCK TO FOLD:
Lift top rail first, then squeeze to release. Before top rails can be unlocked, the center
floor hub must be pulled up. If needed pull up on the center floor hub release strap
as high as the 4 corners.
FLOOR JOINTS DO NOT UNLOCK:
Pull up on the center floor hub release strap to unlock floor joints.
FOLDED PLAYPEN DOES NOT FIT INTO MATTRESS PAD:
Pull up on the center floor hub release strap and gather playpen legs towards the
center to make the playpen more compact. If necessary, shift playpen lower on pad
or turn slightly and try again.

19
This product requires regular maintenance. The cleaning and maintenance of the
playpen must only be carried out by an adult.
The mattress cover can be washed. Remove the boards from the mattress cover as
shown prior to washing.
Do not immerse the wooden boards in water. Wipe clean with a damp cloth and mild
detergent (do not use bleach).
CLEANING
Please refer to the care label for instructions on cleaning the fabric parts of the
playpen.
Periodically wipe clean plastic parts with a soft damp cloth. Always dry the metal
parts to prevent the formation of rust if the playpen has come into contact with water.
MAINTENANCE
Periodically check the playpen for loose screws, worn parts, torn material or stitching.
Replace or repair the parts as needed. Use only Chicco replacement parts. Keep the
playpen in a dry place. If playpen becomes wet open playpen and allow to dry
completely. Prolonged exposure to direct sunlight may cause the fabric to fade
and plastic parts to warp.
Cleaning and Maintenance
Locate and undo the hook
and loop flap on the mattress
cover. Remove all of the floor
boards and set them aside.

20
For More Information
If you have any questions or comments about this product, or are missing any of
the parts please do not return this product to the store. Contact us in one of the
following ways:
@
(877)-424-4226
[email protected]
1826 William Penn Way
Lancaster, PA 17601
www.chiccousa.com