Daikin RN50JV1 User manual

Warning
Daikin Industries, Ltd.’s products are manufactured for export to numerous countries throughout the
world. Daikin Industries, Ltd. does not have control over which products are exported to and used in a
particular country. Prior to purchase, please therefore confirm with your local authorised importer,
distributor and/or retailer whether this product conforms to the applicable standards, and is suitable for
use, in the region where the product will be used. This statement does not purport to exclude, restrict
or modify the application of any local legislation.
Ask a qualified installer or contractor to install this product. Do not try to install the product yourself.
Improper installation can result in water or refrigerant leakage, electrical shock, fire or explosion.
Use only those parts and accessories supplied or specified by Daikin. Ask a qualified installer or
contractor to install those parts and accessories. Use of unauthorised parts and accessories or
improper installation of parts and accessories can result in water or refrigerant leakage, electrical
shock, fire or explosion.
Read the User’s Manual carefully before using this product. The User’s Manual provides important
safety instructions and warnings. Be sure to follow these instructions and warnings.
If you have any enquiries, please contact your local importer, distributor and/or retailer.
All rights reserved
Printed in Japan 06/10/005 Y.K., P.C.
c
Dealer
Head Office:
Umeda Center Bldg., 2-4-12, Nakazaki-Nishi,
Kita-ku, Osaka, 530-8323 Japan
Tokyo Office:
JR Shinagawa East Bldg., 2-18-1, Konan,
Minato-ku, Tokyo, 108-0075 Japan
http://www.daikin.com/global_ac/
Specifications, designs and other content appearing in this brochure are current as of June 2010 but subject to change without notice.
1. Air conditioners should not be installed in areas where corrosive gases, such as acid gas or alkaline gas, are produced.
2. If the outdoor unit is to be installed close to the sea shore, direct exposure to the sea breeze should be avoided. If you need to install
the outdoor unit close to the sea shore, contact your local distributor.
Cautions on product corrosion
JMI-0107 JQA-1452
Organization:
DAIKIN INDUSTRIES, LTD.
AIR CONDITIONING MANUFACTURING DIVISION
Scope of Registration:
THE DESIGN/DEVELOPMENT AND MANUFACTURE OF
COMMERCIAL AIR CONDITIONING, HEATING, COOLING,
REFRIGERATING EQUIPMENT, COMMERCIAL HEATING
EQUIPMENT, RESIDENTIAL AIR CONDITIONING
EQUIPMENT, HEAT RECLAIM VENTILATION, AIR
CLEANING EQUIPMENT, MARINE TYPE CONTAINER
REFRIGERATION UNITS, COMPRESSORS AND VALVES.
Organization:
DAIKIN INDUSTRIES
(THAILAND) LTD.
Scope of Registration:
THE DESIGN/DEVELOPMENT
AND MANUFACTURE OF AIR
CONDITIONERS AND THE
COMPONENTS INCLUDING
COMPRESSORS USED FOR THEM
All of the Daikin Group’s business
facilities and subsidiaries in Japan
are certified under the ISO 14001
international standard for
environment management.
PCRHK1015
The refrigerant has been changed from R-22 to R-410A.
Please read the Installation Manual carefully before installing this product.
Special Warning

12
See page 6.
See page 5.
See page 4 and 7
The 5.0 kW model delivers a high COP
of 3.23. A high COP is important for
energy efficiency.
Ve r tical and Horizontal Auto-Swing plus
other airflow functions give you more
comfortable airflow.
Air-Purifying Filter with Photocatalytic
Deodorising function traps dust,
decompose odours and even removes
bacteria and viruses.

43
Wide-Angle Louvers
Horizontal Auto-Swing (left and right)
Power-Airflow Dual Flaps
Auto Fan Speed
Programme Dry Function
Vertical Auto-Swing (up and down)
Indoor Unit On/Off Switch
24-Hour On/Off Timer
Night Set Mode
Auto-Restart after Power Failure
Self-Diagnosis with Digital Display
Anticorrosion Treatment of
Outdoor Heat Exchanger Fins
Wipe-Clean Flat Panel
Air-Purifying Filter with
Photocatalytic Deodorising Function
3-D Airflow
FTN50JV1 / RN50JV1
5.3 kW 18,090 Btu/h
FTN60JV1 / RN60JV1
6.7 kW 22,860 Btu/h
The stylish flat panel design creates a simplicity and sophistication that enhances any interior space. FTN
series offer 5.0 and 6.0 kW models that are appropriate for spacious rooms as living rooms.
FTN50/60J
RN60JRN50J
Vertical Auto-Swing
automatically moves the flaps
up and down and Horizontal
Auto-Swing automatically moves the louvres to
the left and right. 3-D Airflow combines Vertical
and Horizontal Auto-Swing to circulate air to
every part of a room for uniform cooling of even
large spaces. These functions can create
comfortable airflow.
Comfortable Airflow
Indoor unit
Outdoor unit
Comfort Control
Lifestyle Convenience
Cleanliness
Worry Free
Worry Free
Timers
New Powerful Operation
Series

65
Rustling of leaves
Pendulum of a wall clock Normal office
Indoor unit
Llibrary
Outdoor unit
FTN50J provides a high COP of 3.23. 5.0 and 6.0
kW models are appropriate for spacious rooms as
living rooms.
The FTN series offers low sound levels. Sound
levels for 5.0 kW model are 35 dB (A) for indoor
unit operation and 50 dB (A) for outdoor unit
operation.
COP (W/W)
FTN50J
3.23
FTN60J
3.03
Indoor unit FTN50J FTN60J
Sound levels (L) 35 36
Outdoor unit RN50J RN60J
Sound levels 50 52
(dB (A))
(dB (A))
3530 40 525020
Air-Purifying Filter
with Photocatalytic
Deodorising Function is
able to trap microscopic
particles, decompose odours and
even remove bacteria and
deactivate viruses. This filter
features a large active surface area
that effectively cleans the high volumes
of air required to air-condition living
rooms. The filter delivers consistent
performance for approximately 3 years if
washing with water is performed once in
6 months.
Air-Purifying Filter with
Photocatalytic Deodorising Function
Traps microscopic particles, decomposes odours
and even removes bacteria and viruses.
Photocatalytic deodorising filters are made of titanium oxide.
When titanium oxide is exposed to light, a powerful oxidising
action occurs. This decomposes substances adsorbed on
the filter surface into odourless carbon dioxide and water.
Bacteria removal test
Testing method: Dropping method
Testing organisation: Japan Spinners Inspecting Foundation
Result certificate: No. 012553-1 and 012553-2
Based on “Examples of Sound Levels”, Ministry of the Environment, Japan,
November 12, 2002
This filter is not a medical devices. Benefits such as the adsorption and
decomposition of bacteria and viruses are only effective for substances that
are collected on and in direct contact with the Air-Purifying Filter with
Photocatalytic Deodorising Function.
Air filter
Catches dust
FTN50/60J
Light strikes the
photocatalyst and activates
the surface particles.
A chemical reaction
decomposes the odours into
CO2, O3and H2.
The odourless substances are
released into the air.
Odours
Photocatalyst
Active
particles
Light Odours
Photocatalytic Mechanism
Air-Purifying Filter with Photocatalytic Deodorising Function
KAF952A42
What is COP?
An air conditioner’s COP (Coefficient of Performance)
indicates how efficiently the unit uses energy. A higher
COP means greater energy efficiency. It also means
lower electricity consumption, so you save money.
Capacity (W)
Power consumption (W)
COP (W/W) =
Flat panel models can be cleaned
instantly with a single wipe of a cloth
across their smooth surface. If more
thorough cleaning is required, the panel can also
be easily removed from the unit.
Front grille design units
collect dust on their air inlet
grilles unless these grilles
are cleaned regularly.
1. Difficult to remove dust on
the grille through wiping
alone
2. Reduced capacity due to
increased suction resistance
3. High sound levels due to
increased suction
resistance
Conventional Front Grille Design
Dust

87
Heat exchanger fin
Hydrophilic film
Aluminium
Corrosion-resistant
acrylic resin
Time
Cooling
60 min.
Set temp. before
Off timer begins
to operate
+0.5 C
Off timer turns on Off timer stops air conditioner
Malfunction codes are shown on the digital
display panel of the wireless remote
controller for fast and easy maintenance.
The outdoor unit’s heat exchanger fins
are processed using a special
anticorrosion treatment. The surface is
covered with a thin acrylic resin layer to
enhance the fins’ resistance to acid rain and
salt corrosion. A hydrophilic film layer also
prevents rust caused by the run off of water
droplets. Additional durability is provided by a
rustproof steel sheet on the bottom of the unit.
Cross section of anticorrosion-treated fin
Power-Airflow Dual Flaps can flatten out
during cooling operation to deliver cool
air to the corners of a room.
The smoothly curved Wide-Angle
Louvers provide wide airflow coverage
for effective cooling operation no matter
where the indoor unit is placed in a room. The
louvers can be adjusted by hand.
Covers even
a spacious room
From a corner
to the centre
Cool air slides off to reach the corner of the
room.
Selects fan speed
Selects mode:
cooling, dry, fan-only operation
Cancels On/Off Timer
24-Hour On Timer
24-Hour Off Timer
and Night Set Mode
Sets timer
Sets clock
On/Off switch
Sets room temperature
Vertical Auto-Swing
(up and down)
Horizontal Auto-Swing
(left and right)
Wireless remote controller for FTN50/60J
New Powerful Operation
Cooling operation: Room temperature is raised by 0.5 C after 60 minutes.
Pressing the Off timer button automatically
selects Night Set Mode. This function
prevents excessive cooling for your
pleasant sleep. Room temperature is raised by
0.5 C after 60 minutes for cooling operation.
New Powerful Operation boosts airflow
to maximum volume for a 20-minute
period. After this, the unit automatically
returns to its previous settings. This function is
activated by pushing the POWERFUL button
on the remote controller. So, for example, now
when you come home on a hot day, a powerful
airflow will always be right at your fingertips.

109
Indoor unit
Outdoor unit
See page 7
See page 5
See page 6
See page 8
See page 8
See page 7
See page 4
See page 4
See page 7
See page 4
See page 7
Comfortable Airflow Comfort Control
Lifestyle Convenience
Cleanliness
Timers
Worry Free
Power-Airflow Dual Flaps can flatten out during cooling
operation to deliver cool air to the corners of a room.
The microprocessor automatically controls fan speed to
adjust the room temperature to the set temperature.
This function automatically reduces the level of humidity.
The unit can be conveniently started manually in the
event the wireless remote controller is misplaced or the
wireless remote controller batteries are not charged.
The flat panel models can be cleaned with only the single
pass of a cloth across their smooth surface. The flat panel
can also be easily removed for more thorough cleaning.
This timer can be preset to start and stop at any time
within a 24-hour period. The air conditioner is
started/stopped simply by pressing the On/Off/setting
timer button on the wireless remote controller.
Pressing the Off timer button automatically selects Night
Set Mode. Room temperature is raised by 0.5 C after 60
minutes to prevent excessive cooling for your pleasant
sleep.
The air conditioner memorises the settings for mode,
airflow, temperature, etc., and automatically returns to
them when power is restored after a power failure.
Malfunction codes are shown on the digital display panel
of the wireless remote controller for fast and easy
maintenance.
The outdoor unit’s heat exchanger fins are processed
using a special anticorrosion treatment. The surface is
covered with a thin acrylic resin layer to enhance the fins’
resistance to acid rain and salt corrosion.
This filter traps microscopic particles, decomposes
odours and even removes bacteria and viruses. It can be
used for up to 3 years .
Power-Airflow Dual Flaps
Auto Fan Speed
Programme Dry Function
Indoor Unit On/Off Switch
24-Hour On/Off Timer
Night Set Mode
Auto-Restart After Power Failure
Self-Diagnosis with Digital Display
Anticorrosion Treatment of Outdoor Heat
Exchanger Fins
Wipe-Clean Flat Panel
Air-Purifying Filter with Photocatalytic
Deodorising Function
Notes: *1. The filter is a standard accessory. It should be replaced after approximately every 3 years.
Measurement conditions
1. Cooling capacity is based on: indoor temp. 27 CDB, 19 CWB; outdoor temp. 35 CDB; piping length 7.5 m.
2. Sound levels are based on temperature condition in 1 above. These are anechoic conversion values. These values are normally somewhat higher during actual
opration as a result of ambient conditions.
Specifications are subject to change.
No.
1
2
Item
Air-purifying filter with photocatalytic deodorising function without frame
Remote controller loss prevention with chain
FTN50/60JV1
*1
Air-purifying filter with photocatalytic
deodorising function without frame
KAF952A42
Remote controller loss
prevention with chain
KKF917A4
kW
Btu/h
A
W
W/W
mm
m
W
kg
dB (A)
kg
mm
dB (A)
mm
kg
1 phase, 220-240 V, 50Hz
White
5 steps and automatic
290 x 1,050 x 238
12
Ivory white
Hermetically sealed rotary type
19.4 to 46
6.4
18.0
30
20
Capacity
Power supply
Running current
Power consumption
COP
Front panel colour
Airflow rate (H)
Fan speed
Sound levels (H/L)
Dimensions (H x W x D)
Machine weight
Casing colour
Compressor
Refrigerant charge (R-410A)
Dimensions (H x W x D)
Machine weight
Operation range
Piping connections
Max. piping length
Type
Motor output
Liquid
Gas
Drain
5.3
18,090
7.5
1,640
3.23
FTN50JV1
17.5 (618)
45/35
RN50JV1
1,300
1.6
50
735 x 825 x 300
48
12.7
6.7
22,860
10.2
2,210
3.03
FTN60JV1
18.5 (653)
47/36
RN60JV1
1,700
2.0
52
770 x 900 x 320
63
15.9
Sound levels
Max. height difference
Model name FTN50JV1
RN50JV1
Indoor unit
Outdoor unit
FTN60JV1
RN60JV1
Indoor unit
Outdoor unit
CDB
m3/min (cfm)
KAF952A42
KKF917A4
No.
1
2
Item
Air direction adjustment grille
Drain plug
RN50/60JV1
KPW945A4
KKP937A4
The smoothly curved Wide-Angle Louvres provide wide
airflow coverage for effective operation no matter where
the indoor unit is placed in a room.
This function automatically moves the flaps up and down
to distribute air across a room.
Horizontal Auto-Swing automatically moves the louvres
to the left and right to cover a room with cool air.
New Powerful Operation boosts airflow to maximum
volume for a 20-minute period. After this, the unit
automatically returns to its previous settings.
This function combines Vertical and Horizontal Auto-
Swing to circulate a cloud of cool air right to the corners
of even large spaces.
Note: The above values are based on operation with a 220V, 50Hz power supply.
Wide-Angle Louvres
Vertical Auto-Swing (up and down)
Horizontal Auto-Swing (left and right)
New Powerful Operation
3-D Airflow