Delta Children HERCULES User manual

1
Customer Service [email protected] www.DeltaChildren.com
INSTRUCTION MANUAL
Customer Experience Center
email: [email protected] DCP-IM05212021-F1
www.DeltaChildren.com
WARNING:
Adult assembly required because of
small parts. Keep assembly parts
out
of reach of children under 3 years.
CHOKING HAZARD
HERCULES
WAGON
STROLLER
Read all instructions BEFORE assembly and USE of product
KEEP INSTRUCTIONS FOR FUTURE USE.
62004
ADULT ASSEMBLY REQUIRED
STYLES AND COLORS MAY VARY

2
Customer Service [email protected] www.DeltaChildren.com
• To clean the wagon use a mild household soap with warm water on a sponge or clean cloth.
• Check your wagon for loose screws, worn parts, torn material or stitching on a regular basis. Replace or
repair parts as needed.
• Discontinue use of wagon if it should become damaged or malfunctions. Please contact our customer
service email at [email protected] to arrange for repair or obtain replacement parts.
• If you experience any difculty with assembly, missing parts or use, please DO NOT return this item to the
store. Retail stores are unable to properly assist you. Contact our Customer Service Department directly
for assistance [email protected]
CARE AND MAINTENANCE
WARNING: Please follow all of these instructions to ensure the safety of your child. Keep these instructions
for future reference.
WARNING: Failure to follow these instructions could result in serious injury or death.
WARNING: Avoid serious injury from falling or sliding out. Always ensure that the child is properly positioned
by using the safety harness according to these instructions.
WARNING: Never leave children unattended.
WARNING: INJURY HAZARD: Do not use the shade aps during high wind conditions. Product may become
unstable and tip-over causing injury to occupants.
CAUTION: This is a double occupant stroller wagon for two children only. The use of more than two children
may cause an unstable condition which can injure your child. Do not place parcels, diaper bags or accessory
items on sides of wagon or handles as this can cause an unstable condition.
• The maximum weight that can be carried in the wagon is 110 lbs combined. Any additional weight will
cause a hazardous unstable condition.
• Use of the wagon with children weighing more than 55 pounds (24.92 kg) or over 42 inches (106.7 cm)
tall, may cause a hazardous unstable condition to the wagon.
• ALWAYS lift wagon from handlebars when going over curbs.
• ALWAYS remove canopy before folding.
• ALWAYS lock brakes when adding and removing children from wagon, or when parked.
• NEVER allow children to play with this product.
• NEVER allow children to play in or around the wagon. This wagon is not a toy.
• NEVER use the wagon on stairways, escalators, or moving walkways.
• NEVER use the wagon in conjunction with bicycles, skateboards, roller skates, or in-line skates.
• NEVER use on unstable or uneven terrain.
• NEVER put child inside wagon when using wagon as storage for other items.
• NEVER use second seat for child when using the infant car seat adapter.
• NEVER use near open ames or other sources of heat.
• NEVER sit on top rail or canopy, doing so may cause a hazardous unstable condition.
NEVER install mattresses or similar items for use in wagon. Doing so may cause a hazardous unstable
condition.
• NEVER allow children to stand up or place arms and legs outside of wagon while moving.
• NEVER leave wagon on sloped surface even if brakes are engaged.
• We recommend that the child occupant needs to be 6 months of age, at the minimum, before use of the
wagon. NOTE: With the use of infant car seat adapter, the minimum age is newborn and up.

3
Customer Service [email protected] www.DeltaChildren.com
LIMITED MANUFACTURER WARRANTY
This Delta product is warranted to be free from defects for a period of 90 days from the
date of purchase under normal use. This warranty extends only to the original retail
purchaser and is valid only when supplied with proof of purchase, or if received as a gift, when the
registration is on file with Delta. This limited manufacturer warranty does not cover the following:
• Products purchased as floor models or samples.
• Items purchased on an “as-is” basis, as a second hand product, or as a resale product.
• Items purchased at a Final sale, a “Going out of Business” sale, or a Liquidation sale.
TO REGISTER YOUR PRODUCT for important safety alerts and updates to your product please
visit www.deltachildren.com
TO REPORT A PROBLEM, please log on to www.deltachildren.com and click the Consumer
Care Tab, or contact us by email at [email protected]
Date of Purchase: _____________ (you should also keep your receipt)
DON’T MISS YOUR CHANCE TO BE COVERED FOR ALL OF LIFES MISHAPS!
With Delta’s Extended Warranty, you’re covered for mechanical failure from normal use or if your item
stops working due to normal wear and tear, plus all those unexpected surprises.
2 YEARS OF PROTECTION
For Additional Information:
Simply visit our Website, register your product, and add the Extended Warranty
https://www.deltachildren.com/pages/product-registration
Extended Warranty only available in the following States: Arkansas, Colorado, Delaware, District of Columbia, Georgia, Idaho, Illinois, Indiana,
Iowa, Kansas, Kentucky, Louisiana, Maryland, Michigan, Mississippi, Missouri, Nebraska, Nevada, New Hampshire, New York, North Carolina,
North Dakota, Pennsylvania, Rhode Island, South Dakota, Tennessee, Utah, West Virginia
EXTENDED WARRANTY

4
Customer Service [email protected] www.DeltaChildren.com
Chid Tray Wagon Pad
Fabric Liner
Front Wheel (x2)
(Lock & Swivel)
Wagon Frame
Canopy
IMPORTANT! Before assembly and each use, inspect this product for damaged hardware, loose joints, missing parts, or sharp
edges. NEVER use if any parts are missing or broken. Contact manufacturer for replacement parts and instructions if needed.
Never substitute parts. IMPORTANT! Adult assembly is required.
PARTS
IMPORTANT! Please remove all parts from the package and identify them before assembly.
Cup Holder (x2)

5
Customer Service [email protected] www.DeltaChildren.com
PREPARING WAGON
• Unfolding Wagon: Unlatch wagon by pulling latch away from latch post (Fig. 1).
• After latch is cleared, allow the wagon to unfold out, or manually pull the wagon apart (Fig. 1A)
NOTE: Fabric liner comes pre-assembled to the wagon.
PREPARING WAGON
• Locking Handle: When wagon is fully opened, press down on handle until center handle joint is in a fully locked position (Fig. 2).
*Frame shown without fabric
1
2
ASSEMBLY
Fig 1
FRONTREAR
* Unfolded
FRONT
FRONT
REAR
REAR
* Center Handle
Joint In A Fully
Locked Position
Fig 1A
Fig 2
FRONT FRONT
REARREAR

6
Customer Service [email protected] www.DeltaChildren.com
INSERTING WAGON PAD
ASSEMBLY
3
4
• Attaching Wagon Pad: Open up wagon pad so that the buckles are facing upward and insert into wagon (Fig. 3).
• Attaching Child Tray: Locate the child tray and insert one side to the wagon nubs so it is fastened in to place. Repeat on opposite side (Fig. 4).
*Child Tray
Fully Attached
To Wagon.
Fig. 3
ATTACHING CHILD TRAY
Fig. 4
NOTE: Center handle joint must be in a fully locked position before putting in the mattress pad

7
Customer Service [email protected] www.DeltaChildren.com
ASSEMBLY
5
6
ATTACHING & REMOVING CANOPY
USING SUNSHADE
• Removing Canopy: Pull up on each rod until it clears the wagon
frame (Fig. 5B).
• Canopy can be stored in front storage pocket (Fig. 5C)
• Storing Sunshade: Unfasten toggle & loop from frame of wagon (Fig. 6B).
Roll sunshade evenly towards the top of the wagon.
• Store in the storage compartment on the inside of the canopy (Fig. 6C).
• Attaching Canopy: Align each of the 4 canopy rods with their
corresponding posts (Fig. 5).
• Firmly insert each rod into its housing (Fig. 5A).
• Attaching Canopy: Locate the sunshade in the storage compartment
directly underneath the canopy at the sides of the wagon.
• Unfasten the toggle & loop from sunshade and roll down (Fig. 6).
• Secure sunshade around the frame of the wagon using toggle & loop
(Fig. 6A).
Fig. 5
Fig. 5A
Fig. 5B
Fig. 5C
Fig. 6 Fig. 6C
Fig. 6A Fig. 6B
Toggle
Loop

8
Customer Service [email protected] www.DeltaChildren.com
CURB
WARNING: Always lock brakes when the wagon is not being pushed so that
the wagon will not roll away. Never leave wagon unattended on a hill or incline
as the wagon may slide down the hill.
WARNING: NEVER leave children unattended in wagon.
WARNING: Please do not attempt to push down on rear handle bars to lift front
wheels.
CLEARING WAGON OVER SIDEWALKS AND CURBS
• To clear wagon over sidewalks and curbs: Lift wheels using the REAR
handlebars and PULL over the sidewalk or curb from a backwards
position (Fig. 3).
2
FRONT WHEEL BRAKE LOCK
• Engaging Brakes: Apply light downward pressure to the brake lever
located on the front of the wheel housing (Fig. 2).
• Check to make sure the brakes are in a fully locked position, making
sure stroller will not move when pushed.
• To release brakes: Gently lift the brake lever up (Fig. 2A).
SETUP AND USE
3
1
ADJUSTING HANDLEBARS
• Adjusting Handle: Press BOTH buttons (located on inner side of handle bar) (Fig. 1).
• With both buttons pressed, rotate the handle up or down to desired position (Fig. 1A).
• The buttons will “CLICK” on both sides once it is in a fully locked position.
• Confirm both buttons are depressed and handlebars are in a locked position before use.
Fig. 1
Fig. 3
Fig. 2A
Fig. 1A
Fig. 2

9
Customer Service [email protected] www.DeltaChildren.com
Fig. 1AFig. 1
SETUP AND USE
1
INSTALLING CUP HOLDER
• To install cup holder: Align clip on cup holder with frame post and apply downward pressure until it “SNAPS” into place (Fig. 1).
• To remove cup holder: Apply upwards pressure until cup holder releases from post (Fig. 1A).

10
Customer Service [email protected] www.DeltaChildren.com
FOLDING WAGON FOR STORAGE
REMOVING CANOPY
• Removing Canopy: While release tab is pressed, pull up on each rod
until it clears the wagon frame (Fig. 1).
• Canopy can be stored in front storage pocket (Fig. 1A)
DETACHING CHILD TRAY
• Detaching Child Tray: Locate the child tray and remove flap from the
two nubs on the side of the wagon. Repeat on opposite side (Fig. 3)
REMOVING WAGON PAD
• Removing Wagon Pad: Unbuckle the harness from pad on both
sides and remove from wagon (Fig. 4).
• Wagon pad can be stored in front storage pocket (Fig. 4A)
ADJUST HANDLE UPWARD
• Adjusting Handle: Press BOTH buttons (located on inner side of
handle bar) and lift handle upward until in a fully upright position
(Fig. 2).
1
3
2
4
FRONT REAR
Fig. 1
Fig. 2
Fig. 1A
Fig. 3
Fig. 4
Fig. 4A

11
Customer Service [email protected] www.DeltaChildren.com
FOLDING WAGON FOR STORAGE
UNLOCKING HANDLE
• Unlocking Handle: Press button (located on center side of handle
bar) until center handle is facing down (Fig. 5).
LOCKING WAGON
• Locking Wagon: When wagon is fully folded, locate the latch on the side wagon and lock onto the peg (Fig. 7).
• Fully folded wagon (Fig. 7A).
FOLDING WAGON
• Folding Handle: Locate the loop inside of wagon and pull upward
until wagons starts to fold (Fig. 6).
5
7
6
*Frame shown without fabric
Fig. 7 Fig. 7A
FRONT REAR
Fig. 6
Fig.5
Child Tray
Wagon Pad
Canopy

12
Customer Service [email protected] www.DeltaChildren.com
SECURING CHILD
1
Securing Child
• Place your child in the stroller. Position the crotch belt between your
child’s legs.
• Pull shoulder straps over child’s arm and shoulder and fasten both strap
ends to the restraint system.
• Fasten both waist belts to the buckle on each side of the crotch belt.
Make sure you hear a “click” on both sides.
• Check to be sure the restraint system is securely attached by pulling it
away from your child. The restraint system should remain attached.
3
To tighten the waist belts and shoulder straps:
• Feed the anchored end of a waist belt up through the buckle to form a
loop A. Pull the free end of the waist belt B.
• Repeat this procedure to tighten the other waist belt.
To loosen the waist belts and shoulder straps:
• Feed the free end of the waist belt up through the buckle to form a
loop A. Enlarge the loop by pulling on the end of the loop toward the
buckle. Pull the anchored end of the waist belt to shorten the free end
of the waist belt B.
• Repeat this procedure to loosen the other waist belt.
Please Note: After adjusting the restraint system to t your child, make
sure you pull on it to be sure it is securely fastened.
TIGHTEN
LOOSEN
3Point Safety
Harness
2
• Tighten each waist belt and shoulder strap so that the restraint system
is snug against your child.
Please refer to the next section for instructions to tighten the waist
belts.
Before Placing your Child in Stroller:
Close Canopy. Press both brake pedals down until they “click” into the locke position.
Make sure the brake pedals are pressed down completely.
Always set both brake pedals when parking the stroller.
Waist Belt
Waist Belt
Crotch Belt
Restraint System

13
Customer Service [email protected] www.DeltaChildren.com

14
Customer Service [email protected] www.DeltaChildren.com

15
Customer Service [email protected] www.DeltaChildren.com

© 2021 Delta Children's Products. All rights reserved.
Delta Children's Products Corp.
114 West 26th Street
New York, NY 10001
[email protected]
www.DeltaChildren.com