Elkay FGDF71051H Series Installation manual

98133C (Rev. B - 02/07)
FGDF7105*1H, FGDF7105*2H
PAGE1
Installation/Care/Use Manual
USES HFC-134A REFRIGERANT
FIG. 1
SEE FIG. 4 7
16
SEE FIG. 3
25
23
21, 22, 31 8, 29 & 30
14
15
13
24
26
27
28
9
17
20
19
18

98133C (Rev. B - 02/07)
FGDF7105*1H, FGDF7105*2H
PAGE2
FIG. 2
FINISHED FLOOR PISO ACABADO PLANCHER FINI
LÍNEADELAPARED LIGNEDUMUR
D = POWER CORD 4 FEET (1219mm) LONG
CABLEELÉCTRICO DE4PIE (1219mm),DELARGO CORDOND’ALIMENTATION4' (1219mm)
E = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.
ASEGUREUNAVENTILACIÓNADECUADAMANTENIENDOUNESPACIO E 4" (102mm) (MÍN.) DE HOLGURAENTRE LA REJILLADE VENTILACIÓN DELMUEBLEYLAPARED ASSUREZ-VOUSUNE BONNE VENTILATIONENGARDANT4" (102mm) (MIN.) ENTRE LES ÉVENTS DE L’ENCEINTEETLE MUR.
F = TO LEVEL UNIT, LOOSEN SCREWS TO ADJUST BASE FOR CONTACT WITH FLOOR. TIGHTEN SCREWS AFTER UNIT HAS BEEN LEVELED. PARANIVELAR LAUNIDAD,AFLOJE LOS TORNILLOSPARAAJUSTARLABASE PARAQUE HAYACONTACTOCON ELPISO. APRIETELOS TORNILLOSDESPUÉS DE QUE SE HAYANIVELADOLAUNIDAD. POUR NIVELER L’UNITÉ, DESSERREZ LES VIS POURAJUSTER LABASEAU CONTACTAVECLE PLANCHER. SERREZ LES
VIS APRÈSQUE L’UNITÉ AITÉTÉNIVELÉE.
LEGEND/LEYENDA/LÉGENDE A= RECOMMENDED WATER SUPPLY LOCATION. SHUT OFF VALVE (NOT FURNISHED) TOACCEPT 3/8 O.D. UNPLATED COPPER TUBE.
POSICIÓN DEABASTECIMIENTO DEAGUARECOMENDADA. VÁLVULA CERRADA(NOAMUEBLADO)
PARAACEPTAR 3/8" O.D. TUBO DE COBRE NO PLATEADO. ENDROIT D’APPROVISIONNEMENT EN EAU RECOMMANDÉ. LAVALVE ARRÊTÉE (NON FOURNI) POUR ACCEPTER 3/8" PO. (9,5mm) TUBE COULEUR CUIVRE NON PLAQUÉ. B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4” O.D. DRAIN
UBICACIÓNRECOMENDADAPARAELDRENAJE DE SALIDADEAGUA,DE1-1/4"DE DIÁMETRO. EMPLACEMENTRECOMMANDÉPOURLEDRAINDED.E.1-1/4"DESORTIED’EAU.
C = 1-1/4 TRAP NOT FURNISHED
PURGADORDE 1-1/4 NO PROPORCIONADO SIPHON1-1/4 NON FOURNI

98133C (Rev. B - 02/07)
FGDF7105*1H, FGDF7105*2H
PAGE3
Stream height is factory set at 35 PSI. If supply pressure varies greatly from this,
remove Items 1 & 2 and adjust screw on Item 4. Clockwise adjustment will raise
stream and counter-clockwise adjustment will lower stream. For best adjustment,
stream should hit basin approximately 6-1/2" (165mm) from bubbler.
BASIN
FIG. 4
4
3
1
5
6
2
12
10
Note: Wheninstallingreplacementbubbler,tightennut(Item12)
only to hold parts snug in position. Do not over tighten.
FIG. 3
11

98133C (Rev. B - 02/07)
FGDF7105*1H, FGDF7105*2H
PAGE4
REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640
FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620
ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484
PRINTED IN U.S.A.
DESCRIPTION
40089C
40048C
15005C
61313C
40169C
50986C
21781C
21782C
36231C
56092C
98118C
100322740560
15009C
55996C
66533C
31513C
31501C
31341C
30824C
56237C
42677000
50144C
19037000
66704C
66749C
66473C
20460C
21482C
21239C
21486C
36242C
35768C
36236C
75706C
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
*28
29
30
31
PARTNO.
Cover
Button
Regulator Retaining Nut
Regulator
Hex Nut
RegulatorHolder
Basin & Drain Assy
Basin & Drain Assy (GF)
Relay
Poly Tubing (Cut To Length)
Bubbler Assembly
Washer
BubblerNipple
Strainer
Evaporator Assy
Cold Control
PowerCord
FanMotor
Fan Blade
Shroud - Fan
Fan Motor Bracket
Grommet - Compressor Mtg.
Clip - Compressor Mtg.
Drier
Heat Exchanger
Condenser
Front Panel (Stainless Steel)
FrontPanel (Sandalwood)
Cabinet (Stainless Steel)
Cabinet(Sandalwood)
Compressor Serv. Pak EM45HHR
Cover - Relay
Overload
Stud - Compressor Mtg.
ITEM NO.
PARTS LIST 115V
*REPLACEWITH SAMECOMPRESSORUSEDINORIGINALASSEMBLY.
NOTE: All correspondence pertaining to ELKAY water coolers or orders
for repair parts MUST include Model No. and Serial No. of cooler, name
and part number of replacement part.
12
FIG. 5
11
Glass Filler Shown for Reference Only.
Llenador de cristal demostrado para la referenia
solamente.
Remplisseur de verre montré pour la référence
seulement.
BASIN
DESCRIPTION
36232C
31505C
31395C
66763C
36243C
36237C
8
16
17
24
*28
30
PARTNO.
Relay
PowerCord
FanMotor
Heat Exchanger
Compressor Serv Pak
Overload
ITEM NO.
PARTS LIST 230V-50/60Hz