ergoline PRESTIGE 990 DYNAMIC POWER User manual

1002835
OPERATING INSTRUCTIONS
JK-SALES GMBH .Köhlershohner Straße . 53578 Windhagen . GERMANY
Internet: www.ergoline.de · E-Mail: inf[email protected]
Phone: [phone] . Fax: + 49 (0) 2224/818-116
PRESTIGE SERIES
1002835_TB_PS_En_061214 14.12.2006 10:44 Uhr Seite 1

1002835-00- / en / 02.2007
Operating instructions
15047 / 0
PRESTIGE 990 DYNAMIC POWER
PRESTIGE 990 DYNAMIC POWER IQ
PRESTIGE 1100 EXTREME POWER PLUS

2
PRESTIGE 990 DYNAMIC POWER
PRESTIGE 990 DYNAMIC POWER CLIMATRONIC
PRESTIGE 990 DYNAMIC POWER CLIMATRONIC PLUS
PRESTIGE 990 DYNAMIC POWER IQ CLIMATRONIC
PRESTIGE 990 DYNAMIC POWER IQ CLIMATRONIC PLUS
PRESTIGE 1100 EXTREME POWER CLIMATRONIC PLUS
JK-Global Service GmbH
Rottbitzer Straße 69
53604 Bad Honnef (Rottbitze)
GERMANY
JK-Licht GmbH
Eduard-Rhein-Str. 3
53639 Königswinter
GERMANY
JK-Products GmbH
Köhlershohner Straße
53578 Windhagen
GERMANY
●+49 (0) 22 24 / 818-861
+49 (0) 22 24 / 818-205
E-mail:
[e-mail]
▲+49 (0) 22 44 / 9239-0
+49 (0) 22 44 / 9239-24
+49 (0) 22 24 / 818-140
+49 (0) 22 24 / 818-166
...
07814 / 0

3
Dear Customer,
In selecting an Ergoline sunbed you have acquired a high-performance
appliance featuring advanced technology. Your sunbed has been manu-
factured with the greatest care and precision, having undergone numer-
ous quality and safety tests to guarantee trouble-free and safe operation.
Nonetheless, you too can make a significant contribution to your long-
term satisfaction with your sunbed. If you follow the tips and information
provided in this operating manual, your sunbed will give you much joy
and pleasure.
We will be pleased to provide you with further advice if you have any que-
ries.1)
Yours sincerely,
JK-Sales GmbH
• Please read and follow the instructions in this operating manual care-
fully. This will help prevent accidents and ensure that your Ergoline
sunbed is always fully functional and operational.
• Always comply with generally accepted legal provisions and any fur-
ther directives and statutory regulations, as well as any environmen-
tal protection requirements in force, including those of the country in
which the system is operated.
• Always comply with local regulations in force established by profes-
sional associations and other regulatory authorities.
1) +49 (0) 2224/ 818-0 +49 (0) 2224/ 818-116

4

5
Table of contents
General safety instructions
and information
Recommended tanning times
Description
Operation
Maintenance
Technical data / appendix
Index

6
Table of contents
General safety instructions and other information
How to use these operating instructions . . . . . . . . . . . . . . . . . . . . . . . . 8
Meaning of symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Safety information for the operator . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Safety information for the user. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Export . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Information for the operator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Environmental protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Manufacturer’s guarantee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Recommended tanning times
Use the sunbed - but use it properly!. . . . . . . . . . . . . . . . . . . . . . . . . . 22
Tanning table symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
PRESTIGE 990 DYNAMIC POWER . . . . . . . . . . . . . . . . . . . . . . . . . . 24
PRESTIGE 990 DYNAMIC POWER IQ (Maximum mode) . . . . . . . . . 25
PRESTIGE 990 DYNAMIC POWER IQ (Automatic mode) . . . . . . . . . 26
PRESTIGE 1100 EXTREME POWER PLUS. . . . . . . . . . . . . . . . . . . . 27
Description
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Description of the PRESTIGE series . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Operation
Operation at a glance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Operation buttons and display unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Operation / Navigation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Operating structure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Start PRESTIGE Series (except for PRESTIGE IQ). . . . . . . . . . . . . . 35
Start PRESTIGE IQ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Switching UV lamps on and off during a tanning session. . . . . . . . . . 41
Regulating the facial tanner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Switching the shoulder tanner on and off . . . . . . . . . . . . . . . . . . . . . . 46
Climatronic – regulating the temperature . . . . . . . . . . . . . . . . . . . . . . 48
Regulating body cooling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Regulating facial cooling. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Activating AQUA FRESH Impulse . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Switching AQUA FRESH comfort program on and off . . . . . . . . . . . . 55
Switching AQUA FRESH head nozzle on and off. . . . . . . . . . . . . . . . 57
Switching AQUA FRESH body nozzle on and off. . . . . . . . . . . . . . . . 59
Switching AROMA on and off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Voice Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Selecting an audio system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Adjusting the volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
Changing music track or studio music channel . . . . . . . . . . . . . . . . . 68
Connecting an MP3 player . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70

7
Table of contents
Maintenance
Safety instructions for maintenance and care . . . . . . . . . . . . . . . . . . . 72
Disconnect the device from the power supply and ensure that it
cannot be switched on again. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Malfunctions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Filters and filter mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
AQUA FRESH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Sensor: Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
UV lamps: Replacement intervals . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Acrylic glass panels: Replacement intervals . . . . . . . . . . . . . . . . . . . . 84
Filter panels: Replacement intervals . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Fan: Replacement intervals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
PRESTIGE IQ: Cleaning sensor and base station . . . . . . . . . . . . . . . 86
Cleaning/replacing UV low-pressure lamps in sunbed base . . . . . . . . 89
Cleaning/replacing UV low-pressure lamps in side section . . . . . . . . . 91
Cleaning/replacing UV low-pressure lamps in canopy . . . . . . . . . . . . 92
Cleaning/replacing interior lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Cleaning/replacing UV high-pressure lamps/filter
panels in canopy and side section. . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
PRESTIGE 1100: Cleaning/replacing UV low-pressure lamps in facial
tanner. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Cleaning/replacing accent lighting in canopy. . . . . . . . . . . . . . . . . . . 103
Cleaning/replacing accent lighting in front panel . . . . . . . . . . . . . . . . 105
Cleaning filter in sunbed base . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Cleaning/replacing filter mats in canopy . . . . . . . . . . . . . . . . . . . . . . .110
Climatronic: Emptying condensate tank and cleaning filter . . . . . . . .111
Climatronic plus: Emptying condensate tank and cleaning filter. . . . .114
Changing AROMA container . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117
AQUA FRESH system: Replacing canister . . . . . . . . . . . . . . . . . . . .119
Technical data
Connection ratings, power output and noise levels . . . . . . . . . . . . . 121
Installed lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
UV lamps, starter, filter panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Accent lighting (all models). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Spare parts and accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Installation location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
JK timers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128

8
How to use these operating instructions
There are headings above each section right at the top of the page so
that you can find the right page quickly. At the beginning of the section
the headings are large (1) and then on the following pages slightly small-
er (2).
Symbols are also used. There are several types of symbols:
• The sections are categorised by means of the symbols (3) in the over-
view on page 5.
• Symbols directly on top of a diagram (4) refer to the operating step
shown in the diagram.
The symbols are described in this section on page 9 and following.
Note:
The right to make technical modifications concerning the speci-
fications and information in these operating instructionsl is re-
served.
Reprinting and reproduction, in whole or in part, of this manual
is only permitted with our previous written approval and with
specification of the source.

9
Meaning of symbols
Hazard information
Example:
Important information:
Danger! Type and source of danger!
This safety warning – warning triangle with the word “Danger” –
points out there is danger for persons (danger to life and limb,
risk of injury).
Danger to life! Electric current!
Personnel danger due to electric shock or electric burns
– Switch the device to a zero-potential state!
Caution!
This safety warning – a warning triangle with the word “Caution”
– points out there is danger for devices, materials and the envi-
ronment.
Note:
This symbol does not imply a safety warning, but states informa-
tion for a better understanding of the process.

10
Hazard information
Symbols for description, operation and maintenance
Customer service
Manufacturer
Part/article number (for orders)
Danger!
Switch off the device
– unplug the device from the power supply
Burn hazard!
Do not touch, hot surface.
Low-pressure lamps
UV low-pressure lamps
Starter for low-pressure lamps
UV high-pressure lamps
Filter panels
Cleaning and disinfectant agents
Operation
Presettings
Operating procedure continued on next page
End of operating procedure
Automatic mode
...

11
Hazard information
This function can also be used in automatic
mode
Skin without cosmetics
Tanning time display
Follow-up time display(fan run-on)
Fault display (example)
Description
Accent lighting
Body cooling with
AQUA SOLAR WITH SKIN+ ADDITIVE
Tanning time
03:25 min.
Follow-up time
02:59 min.
Error code
E040
Fragrance “Relax”, “Cabin”
Press button
Press button for 2 seconds
Duration: 3 minutes
Loudspeakers
Headphone jack
MP3 player connection
Maintenance
e.g:
2s
0-3 min

12
Hazard information
UV type
Caution, safety switch!
Unscrew/release screw
Tighten/lock screw
Suction cup
Cleaning
Replacing
Clean or replace depending on soiling
Test with test strip
Draining
Visual inspection
Climatronic
Filter mat
Filter and filter mats may not be damp.
Chip card for lamp set
Technical data / Appendix

13
Intended use
This unit is intended only for commercial use and not for private use.
This unit is used for tanning one adult person at a time.
Nursing infants and small children up to 7 years of age may not use this
unit.
The following applies for children and teenagers between the ages of 8
and 17 years: Only use tanning devices in agreement with a parent or
guardian, or after consulting a physician.
This unit is only to operated with the specified lamps or their equivalent.
The tanning times indicated in these operating instructions apply only for
the designated set of lamps.
Any other use shall be considered improper. The manufacturer cannot be
held liable for damage or injuries resulting from this. The operator bears
the sole risk for this.
Proper use also includes compliance with the manufacturer’s instructions
and its operating and maintenance conditions. The unit may only be op-
erated, maintained and repaired by persons familiar with these tasks and
who have been informed of the dangers involved.

14
Safety information for the operator
• All danger and safety notes attached to the device must be observed!
• Please see the Technical Data – see page121 for the maximum per-
missible weight loading of the acrylic glass panel.
• No safety equipment (e.g. panel switch) or safety warnings may be
removed or deactivated which would impair the safe operation of the
device!
• The device may only be operated in full working order!
1) In Germany: VDE regulations
• A timer must be installed so that the unit is automatically switched off
at the latest after <110% of the selected operating time even when
the controller fails. The device operating time must therefore have
dual regulation by means of a timer, as set forth in EN 60335-2-27.2)
• Do not change, obstruct or block the air inflow and outflow area to the
device or make any unauthorised changes to the device. The manu-
facturer shall bear no liability for damage or injuries resulting from
such actions.
• The device should not be installed and operated on the transport pal-
let. Danger of overheating by obstructing the air circulation.
2) For JK timers, see Page 127
Danger!
Installation and electrical connections must comply with the na-
tional regulations..1)
The electrical installation is to be fitted with an easily accessible
all pole isolating device (master switch) on the building side,
complying with overvoltage category III. This means that each
pin shall have a contact opening width complying with the condi-
tions of overvoltage category III for full isolation.
If the unit is connected via a plug and socket connection, a plug
system complying with EN 60309-1/A11; 5-pole; 400 VAC (35 A)
must be used.
Assembly, installation, upgrading or repair of the device may
only be carried out by specially trained and instructed personnel.
Caution!
The code for accessing the device via the infrared interface is
preset in the software of the hand-held unit, and can therefore
be used on any unit. Anyone downloading the software from the
Internet can access the unit's data using a hand-held unit.
Please make sure that customer service changes the preset ac-
cess code prior to initial start-up. Please make a note of the new
code for later use!
This code is independent of the access code for the presettings
via the control panel.

15
Safety information for the user
▲: JK-Licht GmbH – see Page 2.
Danger of skin and eye injuries or skin diseases!
• Persons with very sensitive skin (skin type I) must not use
the system as, with this skin type, a tanning process without
skin damage (e.g. sunburn) is impossible.
• Individuals with acute sunburn, individuals who have had or
have skin cancer, or individuals who are at increased risk of
skin cancer, must not use the system.
• UV systems should not be used without medical advice, if
unexpected manifestations such as irritation occur within
48 hours of first using the sunbed.
• The device may never be used when a filter panel is missing
or damaged, or the timer is defective!
• UV radiation from the sun or UV systems can cause injuries
to the skin or eyes. This biological effect is dependent on the
sensitivity of the individual's skin and on the type and amount
of UV radiation.
• The skin can become sunburned when exposed to exces-
sive radiation. Excessive, frequently repeated UV radiation
with sunlight or UV devices can result in premature ageing of
the skin and an increased risk of skin tumours.
• Particular caution is advisable for individuals who are espe-
cially sensitive to UV radiation, and when certain medica-
tions or cosmetics are used.
• Particular caution is advisable for individuals who are espe-
cially sensitive to UV radiation, and when certain medica-
tions or cosmetics are used.
• Particular caution is advisable for individuals who are espe-
cially sensitive to UV radiation, and when certain medica-
tions or cosmetics are used.
• Remove cosmetics before tanning and do not use sun
screen products.
• See a physician if stubborn swelling, sores or pigmented
moles form on the skin.
• Some medications for internal or external use can consider-
ably increase the skin's sensitivity to UV radiation. For exam-
ple: Antibiotics, sulphonamides, psoralenes such as mela-
nin, vitamin A acid and derivatives. Sunbaths – including
those in the sun – should not be taken during and shortly af-
ter using preparations of this kind! If in doubt, ask your phy-
sician beforehand!
• The unprotected eye can become inflamed on the surface,
and in certain cases the retina can be damaged by exces-
sive radiation. Cataracts can form after frequently repeated
exposure to radiation.
Use the accompanying UV goggles
(Order No. ▲84592-..).
• The time between the first two sessions on the sunbed must
be at least 48 hours! Do not take an additional sunbath on
the same day.

16
Safety information for the user
1)
Applies only to automatic mode (PRESTIGE IQ):
• In automatic mode, the radiation dose is optimised for the
tanning type and the degree to which the skin is already
tanned by adjusting the lamp output. The tanning time is pre-
set and is the same for each tanning session – see separate
instructions Presettings.1)
The radiation dose is determined by the tanning time in max-
imum mode.
For all units, including maximum mode, the following
applies:
• Increased tanning requires prolonged exposure time (= irra-
diation time). After a certain degree of tanning has been
reached, it is no longer possible to achieve a deeper tan .
However, the radiation time should not be prolonged any
longer than the permitted radiation doses! Therefore, de-
pending on the skin type, there is always a limitation to the
degree of final tanning that can be achieved without endan-
gering your health.
1) Presettings: Order No. 1001971

17
Information for the operator
Guidelines
This device was manufactured according to the following guidelines:
• EC directive “Electromagnetic Compatibility” 89/336/EEC
(according to the version valid at the time).
• Low Voltage Directive 72/23/EEC
(according to the version in force at present).
Export
We emphasise that these devices are intended for the European market
and must not be exported to nor operated in the USA or Canada! The
manufacturer does not accept any liability in the event of non-observ-
ance! We explicitly emphasise that high liability risks may occur to the ex-
porter and/or the operator in the event of non-observance.
Note:
Depending on your local utility company, the units can transmit
interference to the in-house power system that impairs the au-
dio-frequency remote control system used by the utility compa-
ny. This can, for example, interfere with the function of night-
storage heaters.
Note:
If malfunctions occur due to the operation of the units, the oper-
ator is responsible for the installation of an audio frequency
blocking device in the building's electrical installation. Please
contact your electrician. The electrician is familiar with the tech-
nical connection conditions of your local utility company so that
the audio-frequency blocking device can be matched to the
power system of your utility company.

18
Information for the operator
MP3 music (optional)
If a personal MP3 player is used during a tanning session, it is not con-
sidered a public public performance according to copyright so that the
studio operator is not liable for registration or payment to the GEMA.
The same regulations apply to the public use of MP3 music files as to all
other music sources. As a studio operator/studio owner, you may only
play original Audio-CDs, MCs, audio-DVDs etc., on your premises and/
or play music via the “MP3-music modules” which are provided in the
professional sunbeds in the Ergoline range, if you have acquired the nec-
essary stage rights (GEMA/GVL [German copyright handling organisa-
tion]1)).
Copy protected audio CDs, MCs, audio DVDs etc, as well as the tracks
on such sound storage media should not converted to MP3 format and/
or stored on HDD, audio CDs, MCs, audio DVDs etc. if software is used
for this that voids or circumvents copy protection for the said storage me-
dia.
At the request of the GEMA's external staff or any other GEMA control-
ling body, you must always be in a position to prove that you have pur-
chased the performance rights by showing the relevant authorisation is-
sued by the GEMA.
As long as you observe all the listed instructions and have acquired the
necessary rights for use of the “MP3-music-module”, you may convert
your original audio-CDs, MCs, audio-DVDs etc. into the MP3 format re-
quired by the player. However, only one copy is to be made of each le-
gally purchased audio CD, MC, audio DVD etc. The source media (orig-
inal sound storage media) must be kept and are not permitted to be used
at the same time.
1) or have purchased the commercial performance rights from the associa-
tion responsible in your country.

19
Information for the operator
Environmental protection
Environmental Declaration – The JK Corporate Group
The JK corporate group is subject to the strict regulations of
EC Directive 761/2001 and the standard EN ISO
14001:1996 and undergoes regular internal and external
environment audits performed by trained auditors.
Environmental regulations – disposal of lamps and batteries
UV low-pressure lamps contain fluorescent materials and other waste
products containing mercury. Batteries contain heavy metal compounds.
According to national waste disposal laws and in accordance with munic-
ipal waste regulations, proof must be provided of proper disposal of UV
lamps and batteries.
Your local sales agency will be happy to assist you with the disposal of
UV lamps and batteries.
• Report the number of UV lamps and batteries to your local agency by
telephone or in writing.
• Your agency will refer you to a location1) where you can hand in your
lamps free or, together with a disposal company, will arrange to have
your lamps picked up and disposed of correctly.
Packaging
All packaging consists of 100 % recyclable materials. Packaging brought
into circulation by the JK Corporate Group that is no longer required can
be returned to the JK Corporate Group. Your agency partner or dealer
will be happy to advise you.
Disposal of old devices
This device has been manufactured with recyclable materials. When be-
ing scrapped later, the device must be disposed of properly. The JK Cor-
porate Group can provide you with information on the content or potential
hazards of the materials used.
On request this device can be disposed of correctly by the JK Company
Group. This service is free of charge.2). Your agency partner or dealer will
be happy to advise you.
1) Local national laws apply outside Germany.
Contact your local sales agency.