Falcon G3925 User manual

Suggested PPE
Heat resistant gloves
Apron
Rubber gloves
Equipment
Scourer
Cloth
Scraper (supplied with unit)
Step 1 - switch off the
chargrill and allow to
cool for at least 30
minutes
Step 2 - remove any food
debris from the brander
bars using the scraper.
Step 3 - using a damp
cloth, wipe any
remaining debris from
the bars
Ensure you are wearing an apron and heat resistant gloves
before cleaning the chargrill
Chemicals
Sanitiser
Washing up liquid
All purpose cleaner
Oven / Grill cleaner
Step 5 - remove the
upper drip tray and
clean in hot soapy
water
Step 6 - remove splash-
guard and clean in hot
soapy water (this is heavy
and may require 2 people to
lift safely)
Step 4 - starting at the
left hand side, use both
hands to lift off the grill
plates and remove from
the unit
Deep Cleaning Procedure
IMPORTANT! FOR GUIDANCE ONLY PLEASE REFER TO YOUR OWN HEALTH AND
SAFETY POLICY FOR SITE SPECIFIC OPERATIONAL AND PPE REQUIREMENTS
G3925 Chargrill
www.falconfoodservice.com

Step 11 - using scourer
and all purpose cleaner
clean the inside and
surround of the unit,
paying attention to sides
and ledges
Step 12 - replace burners in
reverse order (right to left)
and ensure each one
is positioned properly.
Front part covers gas inlet
and rear pegs slot into
locating holes
Step 14 - replace metal
splashguard and upper
drip tray
Step 13 - replace the
pyramid radiants in
reverse order (right to left),
ensuring they are securely
located on front and rear
mounting tabs
Step 15 - remove fat
collection jug, clean
in hot soapy water then
replace
Step 8 - remove the
radiants (left to right)
and clean with a scourer
and hot soapy water
Step 9 - starting from left
hand side remove
burners (lift back of burner
out rst) and clean with dry
scourer (do not immerse
burners in water)
Step 10 - check jet holes
and unblock as required
(a paper clip is suitable
but must be disposed of
immediately after use)
Step 7 - use the other
end of the scraper to
remove burnt-on debris
from the pyramid
radiants
Deep Cleaning the Falcon Chargrill - Page 2

Deep Cleaning the Falcon Chargrill - Page 3
Step 17 - replace
brander bars
Step 18 - clean outside
of unit using all purpose
cleaner and clean cloth,
paying attention to shelf,
sides, legs and castors.
ENSURE:
• hand contact points are sanitised at regular intervals
during service and at the end of the day
• the drip tray is relled with water at regular intervals
Step 16 - remove
lower drip tray, clean in
hot soapy water then
replace. Remember to
rell with water
www.falconfoodservice.com