Four Seasons Courtyard GFT-30149 User manual

Assembly Instructions
SKU# 258745
Product name : 24” Tabletop Fire Pit (GFT-30149)

WARNING
FOR YOUR SAFETY:
For Outdoor Use Only.
Do Not Use For Cooking.
Table with Standard 1.1in. Umbrella
Opening Required
WARNING
FOR YOUR SAFETY:
If the information in this manual is not followed
exactly, a fire or explosion may result causing property
damage, personal injury or loss of life.
WHAT TO DO IF YOU SMELL GAS:
Do Not try lighting any appliance.
Do Not touch any electrical switch; do NOT use any
phone in your building.
Immediately call your gas supplier from a neighbor’s
phone.
Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the fire
department.
Installation and service must be performed by a
qualified installer, service agency or gas supplier.
Save these instructions for future reference.
If you are assembling this unit for someone else, give
this manual to him or her to read and save for future
reference.
1
DANGER
If you smell gas:
•Shut off gas to the appliance.
•Extinguish any open flame.
•If odor continues, keep away from the appliance
and immediately call your gas supplier or fire
department.
DANGER
CARBON MONOXIDE HAZARD. This appliance can
produce carbon monoxide, which has no odor. Using it
in an enclosed space can cause injury or death. Never
use this appliance in an enclosed space such as a
camper, tent or building.
WARNING
Do not store or use gasoline, or other
flammable vapors and liquids, in the
vicinity of this or any other appliance.
An LP-cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
WARNING
Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage.
Read this installation, operating, and
maintenance instructions thoroughly
before installing or servicing this
equipment.
WARNING:
FUELS USED IN LIQUEFIED PROPANE GAS
APPLIANCES, AND THE PRODUCTS OF
COMBUSTION OF SUCH FUELS, CAN
EXPOSE YOU TO CHEMICALS INCLUDING
BENZENE, WHICH IS KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER
AND CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. For more
information go to:
www.P65Warnings.ca.gov.

DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily
injury or death, or in a fire or an explosion causing damage to property.
-----------------------------------------------------------------------------------------------------------------
WARNINGS:
This appliance is for outdoor use only, and should NOT be used
in a building, garage or any other enclosed area.
Do NOT operate, light or use this appliance within ten feed
(3.05m) of walls, structures or buildings.
For residential use only. This outdoor fireplace is NOT for
commercial use.
Do NOT use this outdoor fireplace for indoor heating, TOXIC
carbon monoxide fumes can accumulate and cause
asphyxiation.
This outdoor fireplace is safety certified for use in the United
States and/or Canada only. Do NOT modify for use in any other
location. Modification will result in a safety hazard and will void
your warranty.
Apartment dwellers: Check with management to learn the
requirements and fire codes for using a liquid propane (LP) gas
outdoor fireplace in your apartment complex. If allowed, use
outside on the ground floor with a ten feet (3.05m) clearance
from any structure. Do NOT use on or under balconies.
This outdoor fireplace, from the factory, is for use with LP gas
only. The conversion to or attempted use of natural gas in this
outdoor fireplace is dangerous, may cause bodily harm and will
void your warranty.
Always use this outdoor fireplace on a hard, level, non-
combustible table such as concrete, rock/stone or metal.
NEVER use on a wood or composite table.
NEVER use a table cloth or other table covering when using the
outdoor fireplace.
LP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly.
Become aware of the characteristics before using any LP
gas product.
b. LP gas is explosive under pressure, heavier than air, and
settles/pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an
odorant is added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
LP gas tank need to operate. Only tank marked “propane” may
be used.
a. The LP gas cylinder must be constructed and marked in
accordance with the U.S. Department of Transportation
(D.O.T) Specifications for LP-Gas Cylinders, or the Standard
for Cylinders, Spheres and Tubes for the Transportation of
Dangerous Goods and Commission, CAN/CSA-B339 as
applicable.
b. LP gas tank must be arranged for vapor withdrawal.
c. Never use an LP gas tank with a damaged body, valve,
collar or footing.
d. Dented or rusted LP gas tanks may be hazardous and
should be checked by your LP gas supplier prior to use.
e. The LP gas tank should not be dropped or handled roughly.
f. Tanks must be stored outdoors, out of the reach of
children and must not be stored in a building, garage or
any other enclosed area. Your LP gas tank must never be
stored where temperatures can reach over 125F.
g. Do not insert any tool or foreign object into the valve outlet
or safety relief valve. You may damage the valve and cause
a leak. Leaking propane may result in explosion, fire, severe
personal injury or death.
h. Never keep an LP gas tank in a hot car or truck. Heat will
cause the gas pressure to increase, which may open the
relief valve and allow gas to escape.
i. Do NOT store a spare LP gas tank under or near this
appliance.
j. A fire causing serious injury or damage to property may
occur if the above is not followed exactly.
Your outdoor fireplace has been checked at all factory
connections for leaks. Recheck all connections as described in
the “Operating Instructions” section, as shipping can loosen
connections.
Check for leaks even if you unit was assembled for you by
someone else.
Do NOT operate if a gas leak is present. Gas leaks may cause a
fire or explosion.
You must follow all instructions in the “Checking for Leaks”
section before operating. To prevent a fire or explosion when
testing for a leak:
a. Always perform a leak test before lighting this outdoor
fireplace and each time the tank is connected for use.
b. No smoking. Do Not use or permit sources of ignition in the
area while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs
may impair the consumer’s ability to properly assemble or
safety operate the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the
detection of propane. Use caution and common sense when
testing for leaks.
g. Do NOT use this outdoor fireplace until any and all leaks are
corrected.
h. If you are unable to stop a leak, disconnect the LP gas
supply. Call a gas appliance serviceman or your local LP gas
supplier.
Do NOT store or use gasoline or other flammable liquids or
vapors with 25 feet (7.62m) of this appliance.
Do Not use in an explosive atmosphere. Keep outdoor fireplace
area clear and free from combustible materials, gasoline
and other flammable vapors and liquids.
This outdoor fireplace is NOT to be operated by children.
This outdoor fireplace is NOT to be used in or on boats or
recreational vehicles.
Do NOT connect to a remote gas supply.
2

Never attempt to attach this outdoor fireplace to the self-
contained LP gas system of a camper trailer, motor home or
house.
Always use in accordance with all applicable local, state and
national codes. Contact your local fire department for details
on outdoor burning.
When using this outdoor fireplace, exercise the same
precautions you would with any open fire.
Do NOT use this outdoor fireplace without reading the entire
Owner’s Manual.
Do NOT burn solid fuels such as : wood, charcoal briquettes,
lump charcoal, manufactured logs, driftwood, trash, leaves,
paper, cardboard, plywood, painted/stained/pressure treated
wood in this outdoor fireplace.
It is essential to keep the outdoor fireplace’s valve
compartment, burners, and circulating air passages clean.
Inspect outdoor fireplace before each use.
Do NOT use this outdoor fireplace until it is COMPLETELY
assembled and all parts are securely fastened and tightened.
Do NOT use this outdoor fireplace near automobiles, trucks,
vans or recreational vehicles.
Do NOT use this outdoor fireplace under any overhang or near
any unprotected combustible constructions. Avoid using near
or under overhanging trees and shrubs.
Do NOT use this outdoor fireplace for cooking.
Do NOT use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the
appliance and to replace any part or control system and any gas
control which has been under water.
Do NOT wear flammable or loose clothing when operating this
outdoor fireplace.
Do NOT use in windy conditions.
Never lean over this outdoor fireplace when lighting or when in
use.
Do NOT use this outdoor fireplace unless burner is securely in
place.
Keep all electrical cords away from this outdoor fireplace
during use.
Certain areas of this outdoor fireplace when in use will become
too hot to touch. To avoid burns, do NOT touch hot surfaces
until the unit has completely cooled (about 45minutes), unless
you are wearing protective gear (such as insulated pot holders
or heat-resistant gloves/ mittens).
Do NOT leave a lit outdoor fireplace unattended, especially
around children and pets.
Children and adults should be alerted to the hazards of high
surface temperatures and should stay away to avoid burns or
clothing ignition.
Young children should be carefully supervised when they are in
the area of the appliance.
Do NOT hang or place clothing or other flammable material on or
near this appliance.
Any guard or other protective device removed for servicing the
appliance must be replaced prior to operating the appliance.
If applicable, protective cover must be removed when burner is
in operation.
Do NOT attempt to move outdoor fireplace when in use. Allow
the outdoor fireplace to cool before moving or storing.
This outdoor fireplace should be thoroughly cleaned and
inspected on a regular basis. Inspect the burner before each use
of the appliance. If there is evidence of burner damage, the
burner must be replaced prior to the appliance being operated.
This outdoor fireplace should be inspected at least annually by a
qualified service person. Depending on amount of use, more
frequent cleaning may be required. Do NOT operate until all
parts have been repaired or replaced.
Use only the regulator assembly provided.
Use only the burner provided.
Do NOT operate this appliance without reading “Operating
Instructions” in this manual.
Storage of this outdoor fireplace indoors is permissible only if
the tank is disconnected, removed from the outdoor fireplace
and properly stored outdoors.
Do NOT attempt to disconnect the gas regulator from the tank or
any gas fitting while the outdoor fireplace is in use.
The cylinder must be disconnected when the appliance is not in
use.
The pressure regulator is set for 11 inches of water column.
The maximum inlet gas pressure for this outdoor fireplace is 11
inches of water column.
Before pressure testing, close LP gas tank valve and disconnect
gas regulator. The gas supply piping system must test at
pressures equal to or less than ½ psi (3.5kPa).
Do NOT throw anything onto the fire when the unit is in
operation.
Fire logs glass and lava rock are very hot. Keep children or pets at
a safe distance from this appliance.
Do Not store any combustible materials in the base enclosure.
Use protective gloves when assembling this product.
Do NOT force parts together as this can result in personal injury
or damage to the product.
Death, serious injury or damage to property may occur if the
above is not followed exactly.
3

Danger and warning………………………………………………………………..…..2
Table of contents………………………………………………………………………….4
Tools and parts…………………………………………………………………………….5
Assembly……………………………………………………………………………………..6
Operating instruction…………………………………………………………..……...7
Maintenance and storage… ………………………………………………..………9
Trouble shooting…………………………………………………………………….….10
Warranty information…………………………………………………………….….11
4

Part Description Quantity
AGlass rock 1
BShort glass 2
CLong glass 2
DBase 1
ERegulator 1
FBase nut 1
5
A
B
C
D
E
F

Step 1:
Take protective cap off, place outdoor fireplace
directly over the umbrella opening on your table.
Secure with base nut (F) from underside. Fully
tighten.
Step 2:
Insert the short glass (B) and long glass (C) to the
base (D).
Step 3:
Place the glass rock (A) into the base. Leave small
area to see burner.
6
B
C
D
A
F
CAUTION: Wear gloves during assembly.
CAUTION: Do NOT dump glass rock out of
package.

Burner connections
1. Make sure the valve connections are securely fastened to the burner and the tank.
2. Visually check the connection between the burner / venturi tube and orifice.
3. Make sure the burner/ venturi tube fit over the orifice.
4. Please refer to diagram for proper installation (Figures 1 and 2). 5, If the burner/venturi tube
does not rest flush to the orifice, as shown, please contact 1-855-600-9294 for assistance.
Tank/Gas Line Connection
1. Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with
three parts water.
2. Make sure regulator/control knob is in the “OFF” position (Figure 3).
3.Apply the leak detection check solution on all “X” location (Figure 1 and 2)
a. If any bubbles appear, remove the LP gas tank and reconnect, making sure the connection is
secure.
b. If you continue to see bubbles after several attempts, remove the LP gas tank per
“Disconnecting LP Gas Tank” section, and contact 1-855-600-9294 for assistance.
c. If no bubbles appear after one minute, turn regulator/ control knob to the “OFF” position,
wipe away solution and proceed.
7
XX

LIGHTING
1. Make sure all labels, packaging and protective films have been removed from the outdoor
fireplace.
2. Check for obstructions of airflow to the burner. Spiders, insects and webs can clog the burner/
venturi tube. A clogged burner tube can lead to a fire.
3. Control knob must be in the “OFF” position (Figure 3).
4. Clear small area of glass rocks away from the igniter cover (Figure 4).
5. Connect LP gas tank per “ Assembling the LP Gas Tank” section.
6. Wearing heat-resistant gloves, position a long lit match or long lit butane lighter near the burner.
7. Turn the control knob to HIGH.
8. After 10 seconds, release and turn control knob counterclockwise to adjust flame to desired
height.
9. Remove match/ lighter once burner is lit.
10. If ignition does not occur in 5 seconds, turn burner control knob to OFF, wait 5 minutes, fan with
a newspaper or magazine, and repeat lighting procedure.
11. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height
matches illustration (Figure 5).
CAUTION: Keep outdoor gas appliance area clear and free from combustible materials, gasoline
and other flammable vapors and liquids.
CAUTION: Do NOT obstruct the flow ofcombustion and ventilation air.
CAUTION: Check and clean burner/venturi tubesfor insects and insect nests. Aclogged tube can
lead toafire.
CAUTION: After lighting-using a fireplace tool and heat-resistant gloves, carefully move the glass
rocks back to their proper position, being careful to avoid the flame.
CAUTION: After lighting-using a fireplace tool and heat-resistant gloves, carefully move the glass
rocks back to their proper position, being careful to avoid the flame.
TURNING OFF
1.Turn control knob to the “OFF” position. Note: A “poof” sound is normal as the last of the LP gas is
burned.
2. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
8
4 in. –6 in.
10 –15 cm

Notice:
1. This outdoor fireplace should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product
3. Never use oven cleaner to clean any part of this outdoor fireplace.
Before each use:
1. Keep the outdoor fireplace area clear and free from any combustible materials, gasoline, and
other flammable vapors and liquids.
2. Do NOT obstruct the flow of the combustion of LP gas and the ventilation of air.
3. Keep the ventilation opening(s) of the LP gas tank area free and clear from debris.
4. See below for proper cleaning instructions.
5. Check all gas connections for leaks.
6. Check components for any signs of damage or rust.
7. Check for obstructions of airflow to the burner. Spiders, insects and webs can clog the
burner/venturi tube. A clogged burner/venturi tube can lead to a fire.
8. If damage to any component is detected, do NOT operate until repairs are completed. Cleaning
surfaces
Cleaning surfaces
1.Wipe surfaces clean with mild dishwashing detergent or baking soda mixed with water.
2. For stubborn stains, use a citrus-based cleaner and a nylon scrubbing brush.
3. Rinse clean with water.
4. Allow to air dry.
Before storing
1. Turn control knob to the “OFF” position.
2. Disconnect LP gas tank per “ Disconnecting LP gas tank” section.
3. Clean all surfaces.
4. Lightly coat the burner with cooking oil to prevent excess rusting.
5. If storing the outdoor fireplace indoors, cover the outdoor fireplace and store in a cool dry
location away from children and pets.
6. If storing the outdoor fireplace outdoors, cover the outdoor fireplace with a cover for protection
from the weather.
CAUTION: All cleaning and maintenance should be done when outdoor fireplace is cool and with
the fuel supply disconnected.
CAUTION: Do NOT clean any outdoor fireplace part in a self-cleaning oven.
CAUTION: Do NOT enlarge valve orifices or burner ports when cleaning the valves or burners.
9

PROBLEM PROBLEM CAUSE SOLUTION
Burner will not light
with match.
No gas flow. Check if LP gas tank is empty A. If empty replace B. If LP
gas tank is not empty, refer to “ sudden drop in gas flow
or reduced flame height.
LP gas tank is low or
empty
Replace LP gas tank.
LP gas leak 1. Turn LP gas tank valve to “closed”.
2. Wait 5 minutes for gas to clear.
3. Follow “Checking for Leaks” section.
Coupling nut and
regulator not fully
connected.
Turn the coupling nut about one-half to three-quarter
additional turn until solid stop. Tighten by hand only-do
NOT use tools.
Obstruction of gas flow Clean burner/venturi tube.
Spider webs or insect
nest in venturi.
Clean burner/venturi tube.
Burner ports clogged or
blocked
Clean burner/venturi tube.
Sudden drop in gas
flow or reduced
flame height.
Out of gas Replace LP gas tank.
Excess flow valve tripped;
safety device may have
been activated.
1. Turn control knob to “OFF”.
2. Wait 30 seconds and light outdoor fireplace per
“Lighting” section.
3. If flames are still too low, reset the overfilling
prevention device:
a, Turn control knob “OFF”
b, Remove LP gas tank c, Wait one minute
d, Attach LP gas tank
e, Perform a leak check per “Checking for Leaks”
section
f, Light outdoor fireplace per “ Lighting” section
Irregular flame
pattern, flame does
not run the full
burner
Burner ports are clogged
or blocked.
Clean burner ports.
Flame is yellow or
orange.
New burner may have
residual manufacturing
oils. Spider dirty or
clogged. There are spider
webs or other matter in
venturi tube. The
propane regulator is in a
“low flow” state.
Burn outdoor fireplace for 15 minutes and reinspect.
Reposition the supply hose as necessary. Clean the burner
orifice. Clean out the venturi tube. Ensure the lighting
procedure is followed carefully. All valves must be in the
off position when the tank valve is turned on. Turn tank
on slowly to allow pressure to equalize. See the Lighting
Instructions in the Operating section.
10

11
6 Month Limited Warranty:
This product is warranted for 6 months against any defects in material and workmanship. Normal
wear or damage due to to abuse, mishandling or unauthorized repairs are not covered. This
warranty does not apply to accessories. This warranty gives you specific legal rights which vary from
state to state. For all warranty claims, contact Customer Care: 855-600-9294 (8:00am to 8:00pm
EST) or by email:[e-mail].
GARANTÍA LIMITADA DE 6 meses
Este producto tiene una garantía de 6 meses contra cualquier defecto en materiales y mano de obra.
El desgaste normal o los daños debidos a abuso, mal manejo o reparaciones no autorizadas no
están cubiertos. Esta garantía no se aplica a los accesorios. Esta garantía le otorga derechos legales
específicos que varían de estado a estado. Para todas las reclamaciones de garantía, comuníquese
con Atención al Cliente: 855-600-9294 (de 8:00 am a 8:00 pm EST) o por correo electrónico:
[e-mail].
6 MONTHS LIMITED WARRANTY
Manufactured for and distributed
by True Value Company
Chicago, IL 60631-3505
©2019 True Value Company
Four Seasons Courtyard™
is a trademark of the
True Value Company
Made in China
Fabricado para y distribuido por
la empresa True Value® Company
Chicago, IL 60631-3505
©2019 True Value Company
Four Seasons Courtyard®
es una marca comercial de True
Value Company
Hecho en China