Furniture of America Prismo CMBK608FAG User manual

EASY
The Assembly Rating is a 5-point system that
shows the degree of effort needed in
assembling a specific product (with 1 being
easy and 5 being difficult). For some
products, two persons are recommended.
Allen Wrench (Included)
Assembly Instructions
Tools Required for Assembly:
Page 1 of 10
DIFFICULT
ASSEMBLY RATING
CM-BK608F
2 PERSONS RECOMMENDED
Phillips Screwdriver (Not Included)

Page 2 of 10

#1 x 1 pc
Lower Rt End G/Rail
Parts List
#16 x 1 pc
Ladder Rail Support
Page 3 of 10
#4 x 1 pc
Upper Lt. End G/Rail
#15 x 4 pcs
Ladder Rung
#2 x 1 pc
Lower Lt End G/Rail
#3 x 1 pc
Upper Rt. End G/Rail
#5 x 1 pc
Lower Front Side Rail #6 x 1 pc Lower Rear Side Rail
#7 x 1 pc
Upper Front Side Rail #8 x 1 pc
Upper Rear Side Rail
#9 x 2 pcs
Rear Guardrail #10 x 2 pcs
Front Guardrail
#11 x 2 pcs
Guardrail Support #12 x 1 pc
End G/Rail Support
#13 x 1 pc
Right Ladder Rail #14 x 1 pc
Left Ladder Rail
#17 x 1 set
Twin Slat Kit #18 x 1 set
Full Slat Kit
#19 x 1 pc
Support Rail #20 x 3 pcs
Support Rail Leg
Note: Right and left are determined by facing the ladder of the bunk bed in
its upright position.

#D x 8 pcs
Bolt 1/4”x1-9/16”
Hardware List
#A x 22 pcs
Bolt 1/4”x4-1/4”
#C x 6 pcs
Bolt 1/4”x1-3/16”
#G x 22 pcs
Screw 3/16”x1-3/16”
Before you begin, please read Page 2
for “Assembly and Care Advice” AND
Page 10 for “Safety Warnings”.
And remember, do not tighten until
each step is completed or instructed.
Page 4 of 10
#I x 4 pcs
Metal Dowel 90mm
#F x 8 pcs
Screw 5/16”x2”
#J x 1 pc
Allen Wrench
#B x 22 pcs
Barrel Nut
#E x 2 pcs
Bolt 1/4”x1-3/8”
#H x 13 pcs
Wood Dowel 40mm
Due to the size and/or weight of this product, it
is highly recommended that the assembly
should be done near the area of its intended
location. Make sure you have enough space to
move around during the assembly. ALWAYS
have at least two people to help with
transporting and assembling the product to
avoid any potential injury and/or damage.
MD

Page 5 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#A x 8 pcs
#B x 8 pcs
#A x 12 pcs
#B x 12 pcs
#H x 8 pcs

Page 6 of 10
Turn right (clockwise) to tighten
#A x 2 pcs
#B x 2 pcs
#C x 6 pcs
#D x 4 pcs
#H x 4 pcs
#I x 4 pcs

Page 7 of 10
Turn right (clockwise) to tighten
#F x 8 pcs
#G x 2 pcs
#H x 1 pc

Page 8 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#D x 4 pcs

Page 9 of 10
Turn right (clockwise) to tighten
ASSEMBLY IS COMPLETED
Safety is ALWAYS the main priority. Please take the time to
inspect the assembly and FULLY tighten all bolts/screws.
Read and follow the
information on the
WARNINGS shown on the end
structure of the upper bunk
and on the carton. Do not
remove warning label from the
bed. Keep these instructions
for future reference.
#G x 12 pcs
Turn right (clockwise) to tighten
#G x 8 pcs
Must use Bunkie mattress or
Bunkie board (sold separately).

Safety Warnings for Bunk Beds
1. Read and follow the information on the WARNINGS shown on the end
structure of the upper unk and on the carton.
2. Do not remove warning la el from the ed.
3. Keep these instructions for future reference.
4. IMPORTANT: Must use Bunkie mattress or Bunkie board. The proper
sizes for the UPPER TWIN-SIZE Bunkie mattress or unkie oard
should e 74'' - 75'' long and 37-1/2'' - 38-1/2'' wide with no more than 6''
thickness and for the LOWER FULL-SIZE should e 74'' - 75'' long
and 53'' - 54'' wide with no more than 6'' thickness.
5. Surface of mattress must e at least 5 inches (127mm) BELOW the upper
edge
of
guardrails.
6. The M XIMUM weight capacity for the upper unk is not to exceed 150 l s.
7. Do not allow children under 6 years of age to use the upper unk.
8. Periodically check and ensure that the guardrails, ladder, handle and other
components
are in
their
proper
position,
free from
damage,
and that all
connectors are
tightened
and secured.
9. DO NOT allow horseplay, rough playing or jumping on the eds and do not
allow playing or hiding under the eds.
10. Always use the ladder for entering or leaving the upper unk.
11. Do not use su stitute
parts.
Contact the manufacturer
or
dealer
for
replacement
parts.
12. Use of a nightlight may provide added safety precaution for a person using
the upper unk.
13. Always use the guardrails on oth sides of the upper unk.
14.
If
the unk ed will e
placed
next to a wall, the
guardrail
that runs the full
length
of
the ed should e
placed
against
the wall to
prevent
entrapment
etween the ed and the wall.
15. The use of water or sleep flotation mattresses is prohi ited.
16. No more than one person is allowed on the upper unk at all times
W RNING:
STR NGUL TION H Z RD
Never attach or hang o jects to any part of the unk ed
that are not designed for use with the ed. O jects such as
hanger, hook, elt, ag, rope, string, etc. should not e used
on or around the unk ed.
Safety Warnings for Bunk Beds
!
Page 10 of 10