Furrion FGH4ZSA-SS User manual

1
Operating and Installation Instructions
RV Gas Cooktop
Furrion FGH4ZSA-SS
RV Gas Cooktop
Furrion FGH4ZSA-SB
RV Gas Cooktop
This manual is for use with

2
IMPORTANT SAFETY INSTRUCTIONS
WARNING: If the information in this manual is not followed
exactly, a re or explosion may result causing
property damage, personal injury or death.
WARNING: NEVER cover any slots, holes or passages in
the oven bottom or cover an entire rack with
material such as aluminum foil. Doing so blocks
airow through the oven and may cause carbon
monoxide poisoning. Aluminum foil lining may
also trap heat, causing a re hazard.
— Do not store or use gasoline or other ammable vapors and liquids in
the vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your recreational vehicle.
• Clear the recreational vehicle of all occupants.
• Turn o the gas supply tank valve(s) or main gas supply.
• Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the re department.
— Have the gas system checked and leakage source corrected by a
qualied installer, service agency, manufacturer or dealer or the gas
supplier.
Keep this instruction manual with your appliance for future use.
The model and serial number are printed on the enclosed product
registration card.

3
Welcome
Furrion FGH4ZSA-SS RV Gas Cooktop
Furrion FGH4ZSA-SB RV Gas Cooktop
Thank you for your purchase of our Furrion RV cooktop, we hope you will have an enjoyable
experience with this product and it provides many memorable mealtimes.
With your purchase, you receive one of the best warranties in the RV industry.Take a moment
to read the full warranty statement. It’s also important to register your Furrion appliance to
ensure that you don’t miss out on exclusive owner benets, such as; assurance that you will
be taken care of in the unlikely event that service becomes necessary during the warranty
period, and a proof-of-purchase record in case of a insurance claim. You may register online
at http://furrion.com/productregistration-com/
If you have any further questions regarding our products, please contact us at
suppor[email protected]

4
Contents
Safety Instruction ............................................................................................
Cooktop Feature Guide ..................................................................................
Using Your Cooktop..........................................................................................
Getting Started ................................................................................................
Installation ........................................................................................................
Igniter Battery Replacement...........................................................................
Technical Specications...................................................................................
Trouble Shooting ..............................................................................................
Warranty ............................................................................................................
Exploded Drawing ............................................................................................
5-6
7
8
9
10-12
13
14
15
16-17
18-19

5
Safety Instruction
IMPORTANT SAFETY INSTRUCTIONS
WARNING: To reduce the risk of re, electrical shock, injury to persons, or damage when
using the cooktop, reading the user manual before use.
All installation must conform with state or other and Standards for Recreational
Vehicles, ANSI/NFPA 1192.
•Do not touch surface Burners, grates, or metal areas near these Burners or
on the cooktop. Surface burners may be hot even though the ames are not
visible. Areas near surface burners may become hot enough to cause burns. During
and after use, do not touch or let clothing or other ammable materials touch
these areas until they have had sucient time to cool. Among these areas are the
cooktop and the surfaces facing the cooktop.
•Wear Proper Apparel—Loose-tting or hanging garments should never
be worn while using the appliance. Do not let clothing or other ammable
materials contact hot surfaces.
• Do Not Use Water or Flour on Grease Fires— Smother the re with a pan lid, or
use baking soda, a dry chemical or foam-type extinguisher.
• When heating fat or grease, watch it closely. Fat or grease may catch re if
allowed to become too hot.
•Use Only Dry Pot holders—Moist or damp pot holders on hot surfaces may
result in burns from steam. Do not let the pot holders touch the ame or
burners. Do not use a towel or other bulky cloth instead of a pot holder.
• Do Not Heat Unopened Food Containers— Buildup of pressure may cause
container to burst and result in injury.
• Know which knob controls each surface burner.
• Always turn the knob to the LITE position when igniting the burners. Visually
check that the burner has lit. Then adjust the ame so it does not extend
beyond the edge of the utensil.
• never leave surface Burners unattended at High Heat settings—Boilovers
cause smoking and greasy spillovers that may ignite, or a pan that has boiled dry
may melt.
• use proper pan size—This appliance is equipped with one or more surface
burners of dierent sizes. Select utensils having at bottom large enough to cover
the surface burner. The use of undersized utensils

6
Safety Instruction
•Do not store ammable materials near burners or let grease or other ammable
substances accumu- late on this appliance.
•Never leave this appliance unattended when in use. Boilovers and greasy spills may
smoke or ignite.
WARNING: COOKTOP MUST BE SECURED BY THE SEALING TAPE PROVIDED.
WARNING:
NEVER use this appliance as a space heater to heat or warm the room. Doing so may
result in carbon monoxide poisoning and overheating of the oven.
Important safety notice
The California Safe Drinking Water and Toxic Enforcement Act requires the Governor
of California to publish a list of substances known to the state to cause cancer, birth
defects or other reproductive harm, and requires businesses to warn customers of
potential exposure to such substances.
CAUTION: Do not store items of interest to children in cabinets above a range or on the
back guard of a range – children climbing on the range to reach items could
be seriously injured.
WARNING: Gas leaks cannot always be detected by smell. Gas suppliers recommend
that you use a gas detector approved by UL or CSA. For more information,
contact your gas supplier. If a gas leak is detected, follow the “What to do
if you smell gas” instructions.Disconnect power before servicing. Always
perform a leak test according to the manufacter's instructions.
Maintenance – Keep cooktop area clear and free from combustible materials, gasoline,
and other ammable vapors and liquids.
Storage in or on the cooktop – Flammable materials should not be stored in an oven or
near surface cooktop units.
Pressure / Leak test using 11- 13.8WCI pressure

7
Cooktop Feature Guide
Feature
1 Product Rating Plate (bottom of cooktop)
2 Control Knob
3 Surface Burner (large)
4 Burner Grate
5 Burner Pan
6 Ignite button
1 26
5
4
3
Gas Cooktop : FGH4ZSA-SS / FGH4ZSA-SB

8
Using your cooktop
How to use your cooktop
A B C D
A: Manual electric igniter
B, C, D: Gas valve control knob.
Lighting the Surface burners:
1, Ensure all cooktop knobs are turned clockwise to the OFF position.
2, Check the main gas supply valve is in the OPEN position.
3, Push and turn cooktop knob 90 deg anti-clockwise to the large ame icon.
4, Push down on cooktop knob and press the spark ignition button together to light
the burner.
5, Continue to hold down the cooktop knob for 10-15 seconds to disable the safety cut
o.
6. To select simmer setting, turn the control knob counter clockwise at the lowest
setting.
* This cooktop is tted with a burner safety cut o, if a ame is not present the gas
supply will automatically shut o.
* If no spark is present when pressing the ignitor, check or replace the AA battery buy
unscrewing the ignitor cover.
NOTE: For your safety, never attempt to operate the appliance with battery power
exhausted.
Shut o instructions
When the cooktop is not in use or a replacemnet gas bottle is needed to be installed.
1, Turn all knobs clockwise to the o position.
2, Before transit, turn the main gas supply o at the shut o valve.

9
Getting Started
Important
Never extend the ame beyond the outer edge of the utensil. A higher ame simply
wastes heat and energy, and increases the risk of being burned by the gas ame.
Caring for your cooktop:
Use a nonabrasive stainless steel cleaner and apply with a soft lint-free cloth. To bring
out the natural luster, lightly wipe surface with a water-dampened microber cloth
followed by a dry polishing chamois. Always follow the grain of stainless steel.
To Clean the Burner Grates- Be sure burners and grates are cool before you place your
hand, a pot holder, cleaning cloths or other material on them. The cast iron burner
grates can be washed in hot soapy water. Rinse thoroughly and dry the grates with a
cloth - don't put them on the cooktop while still wet. Be sure the grates are positioned
securely over the burners. To remove burned on food, place the grates in a covered
container or plastic bag. Add 1/4 cup ammonia and soak for 30 minutes. Wash, rinse
well and dry. An abrasive cleaner can be used for stubborn stains.
Allow burners to cool. Use mild detergent or degreaser to clean. Rinse with water and
towel dry. Be careful not to damage or bend the igniters or thermocouples on the
side of each burner when cleaning. Ensure the burners are completely dry before
attempting to inginte
Using a damp cloth, wipe with mild detergent or spray degreaser; rinse and dry. Do not
place in dishwasher.
The Burner Flame
Keep your arms and face away from being
directly above the cooking area. Look through
the cooking grate and observe the burner's
ame below.
Flames should appear similar to the good
ame show in diagram right.
A good ame should be blue with a yellow tip.
Some yellow tips on ames up to 1 inch in
length are acceptable as long as no carbon or soot deposits appear.
If ames are excessively yellow and irregular, the oil residue may not be completely
burned o, or the venturi may be clogged or may not be properly positioned over the
orices. Allow the appliance to cool before repositioning the venturi over the valve and
orices.
Good
Blue
Blue
Bad
Yellow
Yellow
Holes in Burner

10
14 3⁄8”
(365mm)
33⁄8”
(85mm)
1
23 ½”
(597mm)
2”min
(51mm min)
2”min
(51mm min)
2”min
(51mm min)
Installation
The appliance must be installed only by a qualied person in compliance with the
instructions provided.
Please ensure to install this product per manufacturers instructions to avoid harm to
persons, animals or damage property.
Important: Please ensure the battery or power supply has been removed before any
adjustments or maintenance work is completed.
Installation for Cooktop (without Oven)
• Make the cut-out in the countertop per gure (Fig. A)
• Install the gas supply hose with 5/8-18UNF connection and shut o valve to the
back wall on the left hand side of the cooktop cut out.
• Ensure to leave enough hose length so the cooktop can be tted and removed
• Ensure there is ventilation hole for air circulation around the cooktop in the cabinet.
• The depth of cabinets installed above cooking top should not exceed 13 in (330 mm).
• Ensure the countertop, surrounding materials and bonding agents have
a temperature rating of no less than 193˚F (95˚C) to avoid deformation or
discolouration.
• Before tting the cooktop to the cavity ax the roll of sealing putty (included in the
cooktop packaging) around the underside edge. Once putty is installed completely
around the underside, remove the putty protective lm and then t the cooktop in
cut out. Push down on the cooktop edges to seal and x the appliance securely.
Fig. A

11
Installation
Fig. B
Installation for Cooktop (with Furrion FSRI22LA Oven)
• Make the cut-out in the countertop per (Fig. B) When marking the cutout, ensure to
measure the cut out from the front of the cabinets to ensure the oven vent is in the
correct position.
• Install the gas supply hose with 5/8-18UNF connection and shut o valve to the
back wall on the left hand side of the cooktop cut out.
• Two gas lines will be run for a Oven + Cooktop installation. Ensure to connect the
cooktop to the upper gas connection.
• Ensure there is ventilation hole for air circulation around the cooktop in the cabinet.
• Ensure the countertop, surrounding materials and bonding agents have
a temperature rating of no less than 193˚F (95˚C) to avoid deformation or
discolouration.
• Before tting the cooktop to the cavity ax the roll of sealing putty (included in the
cooktop packaging) around the underside edge. Once putty is installed completely
around the underside, remove the putty protective lm and then t the cooktop in
cut out. Push down on the cooktop edges to seal and x the appliance securely.
When installing a oven with a cooktop, ensure to measure the cooktop cut out
position from the front of the cabinet. The critical dimension is to make sure the
distance from the front of the cabinet to the rear of the countertop cut out is 18 ⁄”.
This is so the oven vent can be tted together with the cooktop.
1
2
23 ½”
(597mm)
2”min
(51mm min)
2”min
(51mm min)
2”min
(51mm min)
18 ⁄”
(467mm)
16 ¾”
(426mm)
1 ⁄”
(41.3mm)

12
Installation
Gas connection:
Connect the cooktop to a designated gas supply line from the RV main gas line which
runs externally under the RV oor. Do not use a existing gas connection inside the RV
to supply two appliances.
Cooktop must be connected separately, each appliance must have separate isolation
valves to render them independent from one another.
This cooktop can be used with Propane Gas only.
This cooktop is tted with a threaded 5/8-18UNF male attachment. For installation use
copper pipe and CSA or UL certied connectors which comply to USA and Canadian
safety standards.
Ensure when cooktop is installed the exible gas supply pipe cannot touch any moving
parts. Make sure adequate space is available so the supply pipe will not be bent or
damage after installation.
Checking that the connection is gas tight
Once installation is complete, before nal tment check all pipe ttings for gas leaks
by pressurizing the system to 13.8WCI then using a soapy solution or certied gas leak
detector to check for possible leaks.

13
Igniter Battery Replacement
How to replace your 1.5V AA battery in the igniter:
1. Unscrew igniter by twisting the lower collar of the button
2. Remove the cover and remove the battery
3. Replace the battery with a new AA size 1.5VDC

14
Technical Specications
Technical Specications
BTU/HR (Left, Central, Right) 7,500 BTU
Fuel Propane (LP Gas)
Inlet Pressure 10”WCI Min to 13.8”WCI Max
Power Input 1.5V AA Battery

15
Trouble shooting
Important
Before you call for service, review this list. It may save you time and expense. The list
includes common occurrences that are not the result of defective workmanship or
materials in this appliance.
Problem Possible cause/solution
Burner will not light.
Surface Control knob has not been completely turned to
LITE. Push in and turn the Surface Control knob to LITE until
burner ignites and then turn control to desired ame size.
Ensure gas supply valve is open.
Burner ports or slots are clogged. With the burner o, use a
small-gauge wire or needle to clean ports or slots.
Check gas supply levelin bottles.
Battery power insufficient. Unscrew ignitor cap and replace
AA battery.
Surface burner
ame burns half
way around.
Moisture is present on the burner, dry burner thoroughly.
Surface burner
ame burns half
way around.
Burner ports or slots are clogged. With the burner o, clean
ports with a small-gauge wire or needle to clean ports or
slots.
Moisture is present after cleaning. Lightly fan the ame and
allow burner to operate until flame is full. Dry the burners
thoroughly following instructions under General Cleaning.
Surface burner
ame is orange.
Dust particles in main line. Allow the burner to operate a few
minutes until ame turns blue.
In coastal areas, a slightly orange ame is unavoidable due to
salt air.

16
Warranty
Your appliance is covered by a one year limited warranty. For one year from your
original date of purchase, Furrion will pay costs for repairing or replacing any
parts of this appliance that prove to be defective in materials or workmanship
when such appliance is installed, used and maintained in accordance with the
provided instructions.
Exclusions
this warranty does not cover the following:
1. Products with original serial numbers that have been removed, altered or cannot be
readily determined.
2. Product that has been transferred from its original owner to another party or
removed outside the USA or Canada.
3. Rust on the interior or exterior of the unit.
4. Products purchased second hand are not covered by this warranty.
5. Products used in a commercial setting.
6. Service calls which do not involve malfunction or defects in materials or
workmanship, or for appliances not in ordinary household use or used other than
in accordance with the provided instructions.
7. Service calls to correct the installation of your appliance or to instruct you how to
use your appliance.
8. Expenses for making the appliance accessible for servicing, such as removal of trim,
cupboards, shelves, etc., which are not a part of the appliance when it is shipped
from the factory.
9. Service calls to repair knobs, handles, or other cosmetic parts.
10. Surcharges including, but not limited to, any after hour, weekend, or holiday service
calls, tolls, ferry trip charges, or mileage expense for service calls to remote areas,
including the state of Alaska.
11. Damages to the nish of appliance or home incurred during installation, including
but not limited to oors, cabinets, walls, etc.
12. Damages caused by: services performed by unauthorized service companies; use
of parts other than genuine Furrion parts or parts obtained from persons other
than authorized service companies; or external causes such as abuse, misuse,
inadequate power supply, accidents, res, or acts of God.

17
Customer’s sole and exclusive remedy under this limited warranty shall be product
repair or replacement as provided herein. Claims based on implied warranties,
including warranties of merchantability or fitness for particular purpose, are limited
to one year or the shortest period allowed by law, but not less than one year. Furrion
shall not be liable for consequential or incidental damages such as property damage
and incidental expenses resulting from any breach of this written limited warranty
or any implied warranty. Some states and provinces do not allow the exclusion or
limitation of incidental or consequential damages, or limitations on the duration of
implied warranties, so these limitations or exclusions may not imply to you. This written
warranty gives you specic legal rights. You may also have other rights that vary from
state to state.
Keep your receipt, delivery slip, or some other appropriate payment record to establish
the warranty period should service be required. If service is performed, it is in your best
interest to obtain and keep all receipts. Service under this warranty must be obtained
contacting Furrion at [e-mail]
Product features or specifications as described or illustrated are subject to change
without notice.
Warranty

18
Exploded Drawing

19
Exploded Drawing
1Sealing glue
2Bottom tray
3Foam sheet
4Right venturi tube
5Thermocouple
6Burner bracket-Round burner
7Burner bracket-Track burner
8Top panel
9Sealer (round)
10 Sealer (track)
11 Round ame spreader(with
thermocouple hole)
12 Round burner cap
13 Trivet(Left)
14 Trivet(Mid)
15 Trivet(Right)
16 Track burner cap
17 Upper spring
18 Cross recessed small pan
headed screw
19 Lower spring
20 Track ame spreader
21 Valve knob
22 Waterproof ring
23 Waterproof ring - inner skirt
24 Valve - Clip lock
25 1.5V igniter
26 Ignition pin-1
27 Ignition pin-2
28 Cross/slotted round headed
screws
29 LP regulator cover
30 Rivet
31 LP regulator
32 Left venturi tube
33 Gas valve
34 Middle venturi tube
35 Main gas pipe
36 Valve position bracket
37 Valve position screw
38 LP regulator bracket

Instruction pour l’installation et l’emploi
Cuisinière àGaz RV
Furrion FGH4ZSA-SS
Cuisinière à Gaz RV
Furrion FGH4ZSA-SB
Cuisinière à Gaz RV
Ce mode d’emploi s’utilise
avec les modèles