Gronomics ECOGW 30-48 User manual

WWW.gronomics.com EastBethel,MNUSA 763-753-7374
Eco Modular Rustic Garden Wedge
(30”W x 48”L x 32”H - 18D) Assembly Instruction
Continued
Parts List Product Care & Maintenance
ITEM QTY. PART # DESCRIPTION Western Red Cedar will turn a
weathered grey if left unfinished.
Although no finish is required for
cedar products when used out-
doors, a natural oil finish applied
regularly will help maintain the
beautyandminimizecrackingand
drying. It is recommended to use
Gronomics Garden Bed Oil
(Item # GBO-1Q), a non-toxic,
food safe finish that is very easy
to apply. Apply Oil when air and
wind temperatures are between
50-90 degrees. Avoid applying in
direct sunlight.
1 4 4125W Corner Post, 3-1/4” x 3-1/4” x 41-1/4”
2 8 R4501Front & Back Side Rails, 45” x 5-9/16" x 7/8"”
3 2 WER2538 End Side Rails, 25-3/16" x 4-1/8"x 5/8"”
4 2 WER1938 End Side Rails, 19-7/16"x 4-1/8" x 5/8"
5 2 WER1358 End Side Rails, 13-3/4"x4-1/8"x 5/8”
6 2 WER0775 End Side Rails, 8-1/8” x 4 -1/8”x 5/8”
7 1 BCR43 Bottom Center Rail, 43-3/8” x 2-1/2” x 13/16”
8 2 SP1-30 Stiffener Plate
9 4 Post Cap, 4-5/8” x 4-5/8” x 1-1/2”
10 1 FL3652 Fabric Liner, 36” x 52”
Stack matching pieces in piles. Using the parts list,
locate and count the individual pieces and verify that
you have received the correct number of pieces.
If any pieces are missing or replacement parts are
required, contact Gronomics at 1-855-299-6727.
NOTE: Ground preparation is optional, however we
recommend leveling area under frame of product, or
place product directly on a flat level surface before
filling with soil.
Parts Identification
Item #: ECOGW 30-48
1
123456
78
9
10
Packaged & Inspected by:Date:
Post Assembly
2
Place two 3-1/4” x 3-1/4” x 41-1/4” corner posts (Item 1)
together as shown.
Repeat procedure for the two remaining corner posts.
Note: It is a snug fit placing the posts together. You may
need to use a rubber mallet until corner posts are seated
(flush) together
1
Revised 8/28/2015
4545

WWW.gronomics.com EastBethel,MNUSA 763-753-7374
Install the eight 45” x 5-5/8” side rails (Item 2) into the
upper part of the slots between the corner posts and
slide down.
Side Rail Assembly
3
2
2
Install the four end side rails (Item 6, 5, 4 & 3) into the
upper part of the slots between the two corner posts
and slide down.
Remove the rubber caps from the post studs. Install a
stiffener plate (Item 8) on the top end rail as shown.
NOTE: May need to lift boards 3,4,5 & 6 slightly by
placing fingertips under board 6 to get the stiffener
plate in place.
Repeat procedure on the opposite end with the four
remaining end rails and stiffener plate.
End Rail Assembly
4
4
6
5
3
8
Install the 43-3/8” x 2-1/2” bottom center rail (Item 7)
with the tapered edges of the rail facing down.
Install the fabric liner into the Garden Wedge.
Soil Capacity: 6.5 Cubic Feet
Bottom Center Rail Assembly
5
7
Align the hole of the 4” x 4” post cap (Item 9) with stud
and tighten until the post cap makes contact with the
post. Do not overtighten.
Post Cap Assembly
6
Stud
9
Revised 8/28/2015