Gronomics RPB 18-48 User manual

www.gronomics.com East Bethel, MN USA 763-753-7374
Continued
Parts List
ITEM QTY. PART # DESCRIPTION
1 4 Corner Post, 4” x 4” x 19” w/2Dovetail Depth 12-3/4"
2 2
1900P
R4502 Side Rail w/Cleat, 45” x 5-1/2” x 1”
3 2 R4500 R4500L Side Rail, (One w/Logo), 45” x 5-1/2” x 1”
4 4
5 2
6 6
7 4
R1450
1538N
1538
4545
Side Rail, 14-1/2” x 5-1/2” x 7/8”
Corner Notched Bottom Board, 15-3/8” x 5-1/2” x 1”
Bottom Board, 15-3/8” x 5-1/2” x 1”
Post Cap, 4-5/8"x 4-5/8"x 1 1/2"
8 1 FL3652 Fabric Liner, 36” x 52”
Rustic Planter Box (18” x 48”)
Assembly Instruction
1
Parts Identification
Stack matching pieces in piles. Using the parts list,
locate and count the individual pieces and verify that
you have received the correct number of pieces.
If any pieces are missing or replacement parts are
required, contact Gronomics at 1-855-299-6727.
NOTE: Ground preparation is optional, however we
recommend leveling area under frame of product, or
place product directly on a flat level surface before
filling with soil.
Item #: RPB 18-48
12
6
3
5
4
78
Side Rail Assembly
2
Stand two 4” x 4” x 19” corner posts (Item 1) upright with slots facing you and
slots facing each post.
Locate a 45” x 5-1/2” side rail w/cleat (Item 2), (with cleat located at the bottom
and facing you). Install side rail w/cleat into the upper part of the slots and slide
down to the bottom of the slots.
Repeat procedure for the two remaining 4” x 4” x 19” corner posts and the 45” x
5-1/2” side rail w/cleat.
(Soil depth option: Cleats located as shown will provide a soil
depth of approximately 9”. Reverse side rail w/cleat installation,
cleats located at top, if a soil depth of approximately 6” is desired).
Cleat
2
11
Packaged & Inspected by: Date:
Product Care and Maintenance
Western Red Cedar will turn a weathered
grey if left unfinished. Although no finish is
required for cedar when used outdoors, a
natural oil finish applied regularly will help
maintain the beauty and minimize cracking
and drying. It is recommended to use
Gronomics Garden Bed Oil (Item #
GBO-1Q), a non-toxic, food safe finish that
is very easy to apply.Apply Oil when air
and wind temperatures are between
50-90degrees. Avoid applying in
direct sunlight.

www.gronomics.com East Bethel, MN USA 763-753-7374
5
Bottom Board and Fabric Installation
Place one 15” x 5-1/2” corner notched bottom board (Item 5) on each
end of the planter box.
Place six 15” x 5-1/2” bottom boards (Item 6) into the planter box. (Gap
boards evenly to allow for water drainage).
Place fabric liner into the planter box.
Soil Capacity: 3.9 Cubic Feet
3
End Side Rail Assembly
Install two 14” x 5-1/2” side rails (Item 4) into the slots at each end of the
planter box and slide to the bottom of the slots.
4
Final Side Rail Assembly
Install the two 45” x 5-1/2” side rails (Item 3) (one w/Logo) into the slots
and slide the side rails down. (Side rail with Logo located to outside).
Install the two remaining 14” x 5-1/2” side rails (Item 4) into the slots at
each end of the planter box and slide down.
4
4
3
4
4
Logo
5
6
6
Post Cap Assembly
Remove the rubber cap from the corner posts studs.
Align the hole of the 4” x 4” post cap (Item 7) with stud and tighten until
the cap makes contact with the post.
NOTE: Do not overtighten.
Repeat procedure on all posts.
Rubber Cap
Stud
7