Gronomics EGB 24-48 User manual

www.gronomics.com East Bethel, MN USA 763-753-7374
Continued
ITEM QTY.
1 1 FL3652 Fabric Liner, 36” x 52”
2 4 4545 Post Cap, 4-5/8” x 4-5/8” x 1-1/2”
3 2
4 6 2178 Bottom Board, 21-7/8” x 5-1/2” x 1”
5 4 2100T Side Rail, 21” x 5-1/2” x 7/8”
6 2 4500T 4500TL Side Rail (one w/Logo), 45” x 5-1/2” x 7/8”
7 2
8 4
4502T
3200E
Side Rail w/Cleat, 45” x 5-1/2” x 7/8”
Corner Post, 4” x 4” x 32” w/2 Dovetail sides 12-3/4"
1
Parts Identification
Stack matching pieces in piles. Using the parts list, locate
and count the individual pieces and verify that you have
received the correct number of pieces.
If any pieces are missing or replacement parts
are required, contact Gronomics at
1-855-299-6727.
NOTE: Ground preparation is optional, however we
recommend leveling area under frame of product, or
place product directly on a flat level surface before
filling with soil.
Elevated Garden Bed (24” x 48”)
Assembly Instruction
Item #: EGB 24-48
Item #: EGB 24-48S
5
68
347
1
2
Packaged & Inspected by: Date:
Side Rail Assembly
2
Stand two 4” x 4” x 30” corner posts (Item 8) upright with slots facing you
and slots facing each corner post.
Locate a 45” x 5 1/2 “ side rail w/cleat (Item 7). With cleat located at the
bottom and facing you, install side rail w/cleat into the slots and slide down
to the bottom of the slots.
Repeat procedure for the two remaining corner posts and 45” x 5-1/2 “ side
rail w/cleat.
(Soil depth option: Cleats located as shown will provide a soil depth of
approximately 8”. Reverse side rail w/cleat installation, cleats located at top,
if a soil depth of approximately 6” is desired).
7
Cleat
8 8
PART # DESCRIPTION
Parts List Product Care and Maintenance
Western Red Cedar will turn a
weathered grey if left unfinished.
Although no finish is required for
cedar when used outdoors, a natural
oil finish applied regularly will help
Corner Notched Bottom Board, 21-7/8” x 5-1/2” x 1” maintain the beauty and minimize
cracking and drying. It is
recommended to use Gronomics
Garden Bed Oil (Item # GBO-1Q), a
non-toxic, food safe finish that is very
easy to apply. Apply Oil when air and
wind temperatures are between
50-90degrees. Avoid applying in
direct sunlight.
2178N

www.gronomics.com East Bethel, MN USA 763-753-7374
5
Bottom Board and Fabric Installation
Place one 22” x 5-1/2” corner notched bottom board (Item 3) on each
end of the garden bed.
Place six 22” x 5-1/2” bottom boards (Item 4) into the garden bed. (Gap
boards evenly to allow for water drainage).
Place fabric liner into the garden bed.
Soil Capacity: 4.7 Cubic Feet
3
End Rail Assembly
Install two 21” x 5-1/2” side rails (Item 5) into the slots and slide down to
the bottom of the slots.
4
Final Side Rail Assembly
Install two 45” x 5-1/2” side rails (Item 6) into the slots on each side of
the garden bed and slide down. (Side rail with Logo located to outside).
Install two 21” x 5-1/2” side rails (Item 5) into the slots on each end of the
garden bed and slide down.
5
5
5
65
Logo
6
3
4
6
Post Cap Assembly
Remove the rubber cap from the corner posts studs.
Align the hole of the 4” x 4” post cap (Item 2) with stud and tighten until
the cap makes contact with the post.
NOTE: Do not overtighten.
Repeat procedure on all posts.
Rubber Cap
Stud
2