Hover-1 INSTINCT H1-EGBR User manual

PEDAL-ASSISTED BICYCLE
OPERATION MANUAL
H1-EGBR
INSTINCT

@RideHover1
@RideHover1
@RideHover1
www.Hover-1.com

HELMETS
SAVE
LIVES!
RIDE WITH
CAUTION!
Always wear a properly tted helmet that complies
with CPSC or CE safety standards when you ride
your bicycle.
Correct Fitting:
Make sure your helmet covers
your forehead.
Incorrect Fitting:
Forehead is exposed and
vulnerable to serious injury.

WARNING
As with all mechanical components, the Hover-1
Instinct is subjected to wear and high stresses.
Dierent materials and components may react to
wear or fatigue in dierent ways. If the design life of
a component has been exceeded, it may
suddenly fail possibly causing injuries to the rider.
Any form of crack, scratch or change of coloring in
highly stressed areas indicate that the life of the
component has been reached and it should be
replaced. Do not ride in an abusive manner.
In this manual, the CAUTION sign indicates a
hazardous situation which, if not avoided, can
cause minor or moderate injury.
CAUTION
WARNING
In this manual, the WARNING sign indicates a
hazardous situation which, if not avoided, can
cause death or serious injury.
Great care should be taken when adjusting the
bike hardware on the Hover-1 Instinct. If you do not
understand how to adjust the bicycle hardware,
please contact your local bike specialist.
DO NOT RIDE YOUR HOVER-1 INSTINCT WITHOUT
ALL HARDWARE SECURELY FASTENED.
WARNING

1
This operation manual is designed to give you the
information you need for the safe operation and
maintenance of your new Hover-1 Instinct (referred to as
“Instinct” from here on). Please read it thoroughly before
riding your Instinct.
The Instinct is a pedal-assisted bicycle. Our technology
and production processes are developed with strict
testing for each Instinct. Operating the Instinct without
following the contents of this manual may lead to
damage to your Instinct, or bodily injury.
PACKAGE CONTENTS
• Hover-1 Instinct Pedal-assisted Bicycle
• Battery Pack
• Charge Cable
• Operation Manual
• Wall Charger
The Instinct is not a toy. Do not ride the Instinct recklessly
and always keep in mind the safety of you and of those
around you.
Your Instinct's serial number is stamped on the steering
column and battery column, respectively. Record the
serial number in this manual in the event that your
Instinct is lost or stolen.
WARNING
Make sure you read this complete manual
before riding your Instinct. Failure to do so,
or failure to follow its guidelines could lead
to serious injury or death.
INTRODUCTION

• This manual contains detailed information and
useful suggestions about your Instinct.
• Make sure that you understand the proper use,
maintenance, and care of the electrical system and
all other components of your Instinct.
• The user of this Instinct acknowledges both an
understanding and an assumption of the risks
involved in cycling and cycling with cargo.
• Children incapable of riding a bicycle on their own
or under the age of 6 should not ride on the Instinct,
unless it’s equipped with an approved Child Seat
accessory.
• Children should not ride as passengers without an
adult operating the Instinct.
1. Even if you have ridden a bicycle for years, it is
important for all riders to read this operation manual
thoroughly before riding on the Instinct.
• Do not ride the Instinct without the battery pack.
The battery pack must be on the Instinct while riding
or else the Instinct’s motor and safety lights will not
function when needed.
• Do not misuse the Instinct by riding it without a
seat. The Instinct has a quick release on the seat
post. If the seat is removed, it may lead to hazardous
situations while riding on the pedal-assisted bicycle.
• Standing, kneeling, or sitting backwards or
sideways (both legs on the same side of the Instinct)
on the seat while the Instinct is moving or stopped
can easily result in bodily harm, loss of control of the
Instinct, destroyed rims, a destroyed bicycle frame,
or worse.
2. Think about safety. Your safety and that of others is
very important.
2
IMPORTANT

3
• Always check your Instinct for normal operation,
loose parts and defects before riding. If you nd any
problem, contact the customer support center for
repairs before riding.
• Be aware that other road users do not expect that
a pedal-assisted bicycle can ride faster than a
standard bicycle. Riding faster also increases the risk
of accidents.
• Do not ride aggressively. Refer to the “Operation
Conditions” section of this operation manual for
more detailed information.
• Make sure no straps are dangling where they could
get caught in the wheels - No bags, boxes or any
items are in a position where they could be caught in
the spokes.
• Check that your brakes are well adjusted.
• Check to see that your wheels are securely
fastened and that your helmet is securely fastened.
• Check to see if the frame and components are
cracked or broken. If at any time you notice a crack
or bend in your bike, stem, forks, or bars of your
Instinct, stop riding immediately and contact the
customer support center.
• Do not clean your Instinct with a high pressure
washer. High pressure water might enter through
connectors or other parts of the electric system and
could cause damage or cause the electric system
to stop working correctly.
Instead, clean your Instinct with a damp rag and
gently wipe the frame and other dirty areas, while
avoiding any parts of the electrical system. Any
3. The electric system of your Instinct needs special
attention and care.

4
• The Instinct is heavier than a standard bicycle. If
transporting on a vehicle, be aware of the maximum
load capacity of the vehicle’s roof, towing hook
and/or of the preferred bicycle carrier.
• Remove the battery pack from the bicycle and
store it elsewhere in the vehicle during your transport.
• Always respect local laws about transportation of
an electric bicycle.
• Lithium battery packs of this size and power are
considered ‘Dangerous goods, class 9’, when
transporting, regulations may restrict the transport of
separate lithium batteries in some places.
The restrictions apply to most airlines and some
trucking companies. But, if you intend to ship or
travel with your complete Instinct (with installed
battery pack), the regulations are less strict. Make
sure to check ahead with your airline or carrier,
before booking your trip to nd out if you’re allowed
to travel with your complete Instinct.
4. Be careful when transporting your Instinct.
water damage to the electrical system will void the
warranty.
• Protect the battery docking connector. When the
battery pack is removed, apply a protective cover to
prevent corrosion and damage to the connector.

5
• If the Instinct is not going to be used for an extended
period of time, you may need to recharge the battery
every 2 months to maintain the battery life.
• Ensure that the screws on the front and back tires are
locked rmly before each ride.
• Check to ensure the tires are not worn.
• Check to ensure all connections are maintained on
your Instinct.
• Ensure the brake cables are well lubricated. It is
suggested you lubricate brakes every 6 months.
• Ensure all gears move smoothly.
• Make sure there are no frayed cables, loose
connections, missing fasteners or axle/lug nuts.
CHECKING BRAKES
Your Instinct is equipped with front and rear disc brakes for
maximum reliability. A cable connects the brake handle to
your brakes. Applying hand pressure to the brake handles
will cause the brake pad to apply pressure against the
brake disc, slowing down the wheels. The more hand
pressure applied to the brake handle, the faster the
Instinct will come to a stop.
SAFETY PRECAUTIONS
GRAB BRAKE
HANDLES TO STOP
DISK BRAKES

When brakes are not applied, brake pads should be 1 - 2
mm from the rotor. If brake pads are too close to the rotor,
the brakes are too tight. The brake pads should be in line
with the rotor surface.
Bicycles equipped with disc brakes will occasionally make
a slight scraping noise when the wheels are turning without
the brakes being applied. This is normal.
The rear brake should always be applied before and while
the front brake is applied. Applying only the front brake to
slow or stop at high speeds may result in the rider being
ejected from the seat and potentially forward over the
handlebars. It is best to apply even pressure to both brake
handles when slowing or stopping.
Pull the lever to ensure the brake moves freely and stops
the Instinct. If the lever can be pulled at to the handlebar,
the brake is too loose.
Brakes will wear down over time. If the brakes do not
perform well, they may need to be adjusted or to have
the pads replaced. To have your bicylce hardware tted
and maintained contact your local bike specialist.
6
Brake pads and rotors get very hot during use and
could burn skin. The edges can also be very sharp
and cut skin. Do not touch the brake pads or rotors
directly after riding your Instinct.
CAUTION
Proper use of your brake is vital to ensure safe,
eicient stopping. To avoid misuse and potential
injury, do not apply sudden or excessive force to
your brakes. Apply your brakes gradually and give
yourself enough room to come to a complete stop
safely.
WARNING

7
The rst rule in safe riding is to use common sense. The
Instinct is vulnerable; it cannot protect you in a crash,
against impact, or loss of control the way driving a car
can. The Instinct can tip over sideways or pitch you over
the front wheel. It moves faster than a standard bicycle. It
does not have bumpers or airbags as a car does.
This section is a guide of safe riding practices for on and
o-road operation. Make sure you are using your Instinct
properly.
Dierent localities and countries have dierent laws
governing riding on public roads, and you should check
with local oicials to ensure you are complying with these
laws.
Hover-1 is not liable for tickets or violations given to riders
who do not follow these regulations.
• For your safety, always wear a helmet that meets CPSC
or CE safety standards. In the event of an accident, a
helmet can protect you from serious injury and in some
cases, even death.
• Obey all local traic laws. Obey red and green lights,
one-way streets, stop signs, pedestrian crosswalks, etc.
• Ride with the traic, not against it.
• If riding with friends and/or multiple Instincts, ride in a
single le, straight line.
• Use the Instinct’s bell to warn drivers and pedestrians of
your approach.
• Ride defensively; expect the unexpected.
• Give pedestrians the right-of-way.
• Do not ride too close to pedestrians and alert them if you
intend to pass them from behind.
• Slow down at all street intersections and look to the left
and right before crossing.
• Obey all traic signals.

8
• Always use proper hand signals for turning and stopping.
Give signals 100ft before stopping or turning and always
return both hands to the handle bars before stopping or
turning.
• Watch for cars pulling out into traic and for the sudden
opening of car doors.
• Avoid potholes, drainage grates or other road surface
hazards.
• Cross railroad tracks at a right angle.
• Be careful when riding on soft road edges, gravel, sand
and uneven surfaces. Ride slowly and avoid quick turns
when riding on these surfaces.
• Never hitch onto other vehicles.
• Do not “stunt” ride or race in traic.
• Do not weave in and out of traic or swerve from side to
side.
• A crash can put extraordinary stress on your Instinct’s
components, possibly causing them to fatigue
prematurely. Components suering from stress fatigue can
fail suddenly, causing loss of control, or serious injury.
CAUTION: RIDING IN WET WEATHER
Brakes do not work as well under wet conditions as they do
when dry. It is recommended that you do not ride your
Instinct in wet weather, as there are electronic
components of your Instinct that may be damaged if
exposed to water.
If you are riding your bicycle in low-visibility conditions, the
Instinct’s reectors will provide some visibility. It is highly
recommended that you wear bright, reective clothing to
increase your visibility.
• Wet conditions will require a longer distance to
stop. Brake earlier and avoid sudden stops when
riding in wet conditions.
WARNING

9
Think about safety when you ride. You can prevent many
accidents if you think about safety. Below is a helpful
checklist for Instinct riders.
SAFETY CHECKLIST
• Check your Instinct before every ride, making sure
brakes are operating eectively and everything is in good
working condition.
• Do not ride “no hands.” Always keep both hands rmly
on the handlebars.
• Do not ride “double” with more than one rider on the
seat.
• Avoid riding in large groups, as this can force you to ride
too close to other riders, making it diicult to see other
vehicles and road hazards.
• Do not ride above your skill level. Ensure you have had
enough practice with all functions and features of your
Instinct.
• Do not ride too fast - with increased speed comes
increased risk. If you are moving at a higher speed, small
bumps can turn into large impacts, leading to a higher risk
of injury if an accident occurs.
• Do not ride with loose objects attached to the
handlebars or other parts of the Instinct.
• Do not ride your Instinct with any pets leashed to your
bicycle.
• Never carry other riders or packages as they may
obstruct vision or proper control of your Instinct.
When you ride in low-visibility conditions such as
fog, dusk, or night, you might be diicult to see,
which could lead to a collision. Wear bright,
reective clothing when riding in poor lighting
conditions.
WARNING

10
There may be additional risk to injury if you use your
Instinct incorrectly. This includes, but is not limited
to:
• Jumping your Instinct
• Riding over debris or obstacles
• Performing stunts
• Riding in o-road terrain
• Riding fast
• Racing other riders
• Riding in unusual manner
The aforementioned examples add stress to each
part of your Instinct and can lead to long term
damage of the Instinct. Damage to your Instinct
can lead to an accident or increase your risk of
injury. To decrease your risk of injury, operate your
Instinct correctly.
WARNING
• Do not ride while intoxicated or while taking medications
which can make you drowsy and/or impair your
judgment.
• When approaching a turn or descent, decrease your
speed.
• Do not abuse your Instinct. Always look ahead to avoid
and anticipate any upcoming obstacles. The distance of
any upcoming obstacles will vary according to your
speed.
• Use caution when you encounter road obstacles. If you
are going fast, even a small obstacle can create a
signicant impact to both you and your Instinct. If you are
unsure about your ability to safely ride over an obstacle, it
is best to either ride around it, or stop your Instinct,
dismount, and walk your Instinct around the obstacle.
• The natural tendency of riders is to move where they are
looking. Avoid focusing on obstacles, even if you are trying
to avoid them. Instead, focus on the part of the road
where you want to go.

11
CARE & MAINTENANCE
• Do not expose the Instinct to liquid, moisture, or humidity
to avoid damage to the electrical system.
• Do not use abrasive cleaning solvents to clean the
Instinct.
• Do not expose the Instinct to extremely high or low
temperatures as this will shorten the life of the electrical
system, destroy the battery, and/or distort certain plastic
parts.
• Do not dispose of the Instinct in a re as it may explode
or combust.
• Do not expose the Instinct to contact with sharp objects
as this will cause scratches and damage.
• Do not let the Instinct fall from high places, as doing so
may damage the internal circuitry.
• Do not attempt to disassemble the Instinct.
• Use only the charging cable provided by Hover-1.
• Ensure the bicycle chain is well lubricated for optimal
performance.
• To minimize tire wear and for maximum riding safety,
comfort and handling, maintain recommended tire air
pressure which can be found on the side wall of all tires.
Use a reliable tire air pressure gauge to check for proper
ination before every ride. At the same time, inspect tires
for excessive wear and cracks. Replace tires if necessary.
Avoid using water or other liquids for cleaning. If
water or other liquids enter the bicycle, it will cause
permanent damage to the electrical system.
WARNING

12
Users who disassemble the Instinct without
permission will void the warranty.
WARNING
ITEM
Battery
Appearance
Tires
Brakes
Axles
Front Fork
RATE
Daily
Weekly
Weekly
Weekly
Monthly
Monthly
MAINTENANCE NEEDED
Check if battery is fully
charged before riding.
Wash the outer surface
area of your Instinct to
remove dirt and dust
Make sure tires are properly
inated
Make sure brakes function
fully when you clench the
brake handles
Check and tighten screws
on the front and rear axles
Tighten the screw on the
front fork and handle bar
MAINTENANCE TIPS

13
Maintain the battery pack as instructed in this operation
manual. Failure to follow these instructions may result in
damage to your battery pack and may require battery
pack replacement:
• Fully recharge the battery pack when the battery
pack shows a low charge on the controller. The battery
pack LED lights up red and beeps to alert the rider to
charge the battery.
• Only charge the battery pack with the charging
cable provided by Hover-1.
• Do not connect or attach the battery pack to a power
supply plug or directly to a car’s cigarette lighter.
• Handle your battery pack with care. Do not drop or
impact the battery pack. Mishandling of the battery
pack could lead to severe damage or over-heating. In
an extremely rare case, a battery pack that has been
severely impacted or otherwise mishandled could
potentially catch re. If you suspect damage to your
battery pack, contact the customer support team for
assistance.
• If not in use for an extended period of time, charge the
battery pack at least once every 2 months.
• When the battery pack is not in use, store it with a 100%
charge in a dry, cool place, between 5°C and 25°C,
preferably 5-10°C. Do not store it in places where
temperatures get higher than +25°C or lower than 5°C.
Avoid extreme temperature changes.
• Do not place the battery pack near a re, or into
direct sunlight. Heating the device and/or the battery
can cause additional heating, breaking, or ignition of
the battery inside the device.
• Do not continue charging the battery pack if it does
not recharge within the specied charging time. Doing
so may cause the battery to become hot, rupture, or
ignite.
BATTERY CARE

To preserve natural resources, please recycle or dispose
of the battery pack properly. This product contains
lithium batteries. Local, state, or federal laws may
prohibit disposal of lithium batteries in ordinary trash.
Consult your local waste authority for information
regarding available recycling and/or disposal options.
• Do not attempt to modify, change, or disassemble your
battery pack/charger.
• Do not allow any liquids on or inside the battery
pack/charger.
• Do not use your Instinct if the battery pack begins to
emit odor, overheats, or begins to leak.
• Do not touch any leaking materials or breathe fumes
emitted.
• Do not allow children and animals to touch the battery
pack.
• The battery pack contains dangerous substances, do
not open the battery pack, or insert anything into the
battery pack.
• Please only use the charging cable provided by Hover-1.
• Do not attempt to charge the Instinct if the battery pack
has discharge or emits any substances. In that case,
immediately distance yourself from the battery pack in
case of re or explosion.
• Lithium batteries are considered to be hazardous
materials. Please follow all local, state and federal laws in
regards to recycling, handling and disposing of lithium
batteries.
• Do not expose the battery/charger to extreme
weather conditions.
14
Failure to follow the safety precautions listed below
could lead to serious bodily injury and/or death.
WARNING

15
SEEK IMMEDIATE MEDICAL ATTENTION IF YOU ARE
EXPOSED TO ANY SUBSTANCE THAT IS EMITTED FROM
THE BATTERY PACK.
WARNING
• Do not operate the battery pack/charger if
damaged.
• Do not use the battery/charger for any use other than
its intended purpose.
• Do not use any third party or unauthorized battery
pack/charger on your Instinct.

16
Hover-1 Instinct (H1-EBGR)
264 lbs (120 kg)
Up to 15 mph (24 km/h)
Up to 40 miles (65 km)
15°
Magnetic speed sensor
Aluminum
Suspension fork
Front & rear disc brake
26 in.660.6 mm
Min:40 psi Max:65 psi
350W brushless DC motor
Up to 5 hours
Lithium-ion
36 V
10 Ah
AC 100-240V, 50/60 Hz
37.47 lbs (17 kg)
Model:
Max Load:
Max Speed:
Max Distance Range:
Max Incline Angle:
Sensor:
Frame:
Fork:
Brake Type:
Tire Size:
Tire Pressure:
Motor:
Charge Time:
Battery Type:
Battery Voltage:
Battery Capacity:
Power Requirement:
Net Weight:
NOTE: Max speed and max distance may vary
depending on, but not limited to: user load, terrain of
road, operation temperature, driving habits and
environmental temperatures.
SPECIFICATIONS