Hussmann ESGMS User manual

Thermostat Bulb
Location
(Optional
Lights)
D
AC
B
P/N 0453555A
ESGMS
Data Sheet Set
P/N 0453555A
NSF®Certified
October 2005
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Note: Changed items have been underlined.
Item Part # Description Wiring Item #
FAN ASSEMBLIES AND THERMOSTATS
A. 0404551 Fan Motor, Ambient (120V) (1)
0404552 Fan Motor, Ambient (230V)
B. 0353949 Optional Adjustable (2)
Refrigeration Thermostat
Item Part # Description Wiring Item #
LAMPS AND BALLASTS
C. 0355716 Ballast, Electronic, 2 lamps
(120V) (3)
C. 0355398 Ballast, Electronic, 3 lamps
(120V) (4)
C. 0440215 Ballast, Electronic, 2 lamps
(230V 50-60 Hz) (3)
C. 0428652 Ballast, Electronic, 3 lamps
(230V 50-60 Hz) (4)
0385104 Ballast Transformer
(230V 50-60 Hz, per ballast)
D. Fluorescent Lamp (5)
Replace with like fixtures
We reserve the right to change or revise specifications
and product design in connection with any feature of
our products. Such changes do not entitle the buyer to
corresponding changes, improvements, additions or
replacements for equipment previously sold or shipped.

ESGMS Data Sheet2 of 6 HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Engineering
Plan Views
26 1/4
(667)
A
D
C
45 1/4
(1149)
29 3/8
(746)
35/8 (92)
E
33 1/4
(845)
Legs
Water Seal
C
L
Front
Refrigeration
Outlet
Electrical
B
Waste Outlet
Dimensions shown as in. and (mm).
Elite Straight Hinged Glass
Meat & Delicatessen
4 ft 6 ft 8 ft 12 ft
General
(A) Case Length (without ends or partitions) 48 1/4(1226) 72 3/8(1838) 96 3/8 (2448) 144 1/2(3670)
Maximum O/S dimension back to front (with bumper) 45 1/4(1149) 45 1/4(1149) 45 1/4(1149) 45 1/4(1149)
Back of case to front of front panel 33 1/4 (845) 33 1/4 (845) 33 1/4 (845) 33 1/4 (845)
RH end of case to outside edge of external support 1 5/8(41) 1 5/8(41) 1 5/8(41) 1 5/8(41)
Distance between edges of
external support and center support NA 28 1/2(724) 40 5/8 (1032) 40 5/8 (1032)
Distance between edges of center supports NA NA NA 44 (1118)
Distance between edges of external supports 37 (940) NA NA NA
Electrical Service (Electrical Field Wiring connection point)
(C) Length of electrical raceway 38 3/4 (984) 29 5/8 (752) 41 3/4 (1060) 41 3/4 (1060)
RH End of case to center of farthest knockout 10 3/8 (264) 10 (254) 10 3/8 (264) 10 1/4 (260)
Back of case to center of end knockout 3 5/8 (92) 3 5/8 (92) 3 5/8 (92) 3 5/8 (92)
(B) RH End of case to RH end of raceway 5 (127) 5 (127) 5 (127) 5 (127)
Waste Outlet
(D) RH End of case to the center of waste outlet 24 (610) 24 1/8 (613) 24 1/8 (613) 72 1/4 (1835)
LH End of case to the center of waste outlet 24 1/4 (616) 48 1/4 (1226) 72 1/4 (1835) 72 1/4 (1835)
Back O/S of case to center of waste outlet 26 1/4 (667) 26 1/4 (667) 26 1/4 (667) 26 1/4 (667)
Water Seal
Edge of water seal to center of waste outlet 4 (102) 4 (102) 4 (102) 4 (102)
Outside diameter of the drip pipe 1 1/2 (38) 1 1/2 (38) 1 1/2 (38) 1 1/2 (38)
(Field installed water seal outlets, tees, and connectors
are shipped with the merchandiser.)
Refrigeration Outlet
Back of case to center of refrigeration outlet 29 3/8 (746) 29 3/8 (746) 29 3/8 (746) 29 3/8 (746)
(E) RH end of case to center of refrigeration outlet 8 1/4 (210) 8 1/4 (210) 8 1/4 (210) 8 1/4 (210)

REFRIGERATION DATA
Note: This data is based on store temperature
and humidity that does not exceed 75°F and
55% R.H. Schedule defrost at night while
lights are off.
ESGMS
Discharge Air (°F) 27
Evaporator (°F) 22
Unit Sizing (°F) 20
Btu/hr/ft* ESGMS
Parallel 270
Conventional 290
*For all refrigeration equipment other than
Hussmann, use conventional Btu values.
DEFROST DATA
ESGMS
Frequency (hr) 24
Defrost Water (lb/ft/day) 0.5
(± 15% based on case configuration and
product loading).
ESGMS
OFFTIME (minutes) 90
Failsafe (minutes) 90
ELECTRIC OR GAS Not Recommended
CONVENTIONAL CONTROLS
Low Pressure Backup Control
ESGMS
CI/CO (Temp °F)** 15 / 5
Indoor Unit Only, Pressure Defrost
Termination (Temp °F)**
Not Recommended
**Use a Temperature Pressure Chart to
determine PSIG conversions.
PHYSICAL DATA
Merchandiser Drip Pipe (in.) 1 1/2
Merchandiser Liquid Line (in.) 3/8
Merchandiser Suction Line (in.) 5/8
Estimated Charge (lb)***
4 ft 0.8
6 ft 1.2
8 ft 1.5
12 ft 2.0
***This is an average for all refrigerant
types. Actual refrigerant charge may vary by
approximately half a pound.
Length Added to Lineup by:
Each End/Partition (in.) 1
3 of 6P/N 0453555A
24 3/4
(629)
8 1/4
(210)
22
(559)
52 1/8
(1324)
32 1/2
(826)
15 3/4
(400)
26 1/4
(667)
COIL
16 5/8
(422)
Electrical
Refrigeration
Outlet
FAN
27 1/4
(692)
ESGMS
12 1/2
(318)
4(102)
29 3/8
(746) 33 1/4
(845)
45 1/4
(1149)
12
(305)
20
(508)
Dimensions shown as in. and (mm).
Impact Elite ESGMS
Meat / Delicatessen
Elite Straight Hinged Glass, Gravity with Serpentine Coil, Single Display
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
NSF Certification
These merchandisers are manufactured to meet ANSI /National Sanitation
Foundation (NSF
®
) Standard #7 requirements.

ESGMS Data Sheet4 of 6
Impact Elite ESGMS
Meat / Delicatessen
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Electrical Data
Number of Fans 4 ft 6 ft 8 ft 12 ft
Refrigeration (120V 60hz) – 4W N/A
Ambient Air Wipe – 15W 1 2 2 3
Export Refrigeration (230V 50 hz ) – 4W N/A
Export Ambient Air Wipe – 15W 1 2 2 3
Amperes Watts
Merchandiser 4 ft 6 ft 8 ft 12 ft 4 ft 6 ft 8 ft 12 ft
Refrigeration Fans N/A
Ambient Air Wipe Fans
Standard (120V 60hz) 0.26 0.52 0.52 0.78 23 45 45 68
Energy Efficient(120V 60hz) N/A
Export: 230V 50 hz 0.15 0.30 0.30 0.45 25 50 50 75
Constant On Anti-sweat Heaters N/A
Cycling Anti-sweat Heaters N/A
Minimum Circuit Ampacity
With Standard Fans (120V 60hz) 0.46 0.72 0.72 0.98
With Energy Efficient Fans (120V 60hz) N/A
With Export Fans (230V 50 hz ) 0.35 0.50 0.50 0.65
Maximum Over Circuit Protection 120V 20
Maximum Over Circuit Protection 230V 15
Standard Lighting* (120V 60hz) 4 ft 6 ft 8 ft 12 ft 4 ft 6 ft 8 ft 12 ft
2 Row Canopy 0.49 0.98 0.98 1.42 59 118 118 171
Optional Lighting
1 Row Ledge 0.49 0.49 0.49 0.71 59 59 59 86
1 Row Rail 0.49 0.49 0.49 0.71 59 59 59 86
*230V lighting values are under review.

P/N 0453555A 5 of 6
R = Red G = Green BL = Blue LB = Light Blue DB = Dark Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
Ambient Fan
Wiring
Glass Air Wipe
Offtime Defrost
Fans
Electric Service Receptacle Receptacles
120V NEUTRAL
MAROON
BAND
120V POWER
W
B
G
N.E.C.
TAGS
MAROON
BAND
Refrigeration
Thermostat
To
Condensing Unit
}
(Field Installed)
2
BROWN BAND
Fans
BROWN BAND
120V POWER
120V NEUTRAL
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
Circled Numbers = Parts List Item Numbers
Grayed components in 12 foot models only.
1
4 ft case has 1 Fan
6 ft case has 2 Fans
8 ft case has 2 Fans
12 ft case has 3 Fans Light
Blue
Light Blue
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

ESGMS Data Sheet6 of 6
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
W
BG
Standard Lighting — 2 Row Canopy
Light Circuits
R = Red G = Green BL = Blue B = Black W = White
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
Circled Numbers = Parts List Item Numbers
Grayed components in 12 foot models only.
3
55
120V NEUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V POWER
ORANGE OR TAN
BAND
B
W
R
R
BL
BL
R
BL
R
R
BL
BL
R
BL
BL
B
GG
G
G
GGG
3
5
55 5
R
R
BL
BL
R
BL
BL
GGG
3
55 5
Optional Ledge Light Circuit
or
Optional Rail Light Circuit
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.