IEI Technology PEMUX-XEW1 User manual

PEMUX-XEW1
Page i
User Manual
Full-Size CPU Card Supports LGA2066 Intel®Xeon®W CPU,
Intel® C422 Chipset, DDR4 RDIMM/LRDIMM, 10 GbE, RS-232,
USB 3.1 Gen1, SATA 6Gb/s, M.2, HD Audio and RoHS
Rev. 1.00 – February 19, 2019
MODEL:
PEMUX-XEW1

PEMUX-XEW1
Page ii
Revision
Date Version Changes
February 19, 2019 1.00 Initial release

PEMUX-XEW1
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

PEMUX-XEW1
Page iv
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.

PEMUX-XEW1
Page v
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 FEATURES................................................................................................................... 3
1.3 CONNECTORS ............................................................................................................. 4
1.4 DIMENSIONS............................................................................................................... 5
1.5 DATA FLOW................................................................................................................ 6
1.6 TECHNICAL SPECIFICATIONS ...................................................................................... 7
2 PACKING LIST............................................................................................................. 9
2.1ANTI-STATIC PRECAUTIONS...................................................................................... 10
2.2 UNPACKING PRECAUTIONS....................................................................................... 10
2.3 PACKING LIST............................................................................................................11
2.4 OPTIONAL ITEMS...................................................................................................... 12
3 CONNECTORS ........................................................................................................... 13
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 14
3.1.1 PEMUX-XEW1 Layout .................................................................................... 14
3.1.2 Peripheral Interface Connectors ..................................................................... 15
3.1.3 External Interface Panel Connectors............................................................... 15
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 16
3.2.1 +12V Power Connector................................................................................... 16
3.2.2 Audio Kit Connector ........................................................................................ 17
3.2.3 DDR4 DIMM Sockets ...................................................................................... 18
3.2.4 EC Debug Connector....................................................................................... 18
3.2.5 Fan Connector (CPU)...................................................................................... 19
3.2.6 Fan Connectors (System)................................................................................. 20
3.2.7 Front Panel Connector .................................................................................... 21
3.2.8 iRIS-2400 Module Slot..................................................................................... 22
3.2.9 M.2 2280 Slot, M-Key...................................................................................... 22
3.2.10 RS-232 Serial Ports........................................................................................ 24

PEMUX-XEW1
Page vi
3.2.11 Mini-SAS Connectors..................................................................................... 26
3.2.12 SPI Flash Connector...................................................................................... 27
3.2.13 SPI Flash Connector, EC............................................................................... 28
3.2.14 TPM Connector.............................................................................................. 29
3.2.15 USB 3.1 Gen 1 Connector.............................................................................. 30
3.2.16 USB DOM Connector.................................................................................... 31
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 32
3.3.1 10GbE LAN Connector.................................................................................... 32
3.3.2 USB 2.0 and GbE Combo Connector .............................................................. 33
3.3.3 USB 3.1 Gen 1 Connectors.............................................................................. 34
3.3.4 IPMI VGA Connector....................................................................................... 35
4 INSTALLATION ......................................................................................................... 36
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 37
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 37
4.3 SOCKET LGA2066 CPU INSTALLATION................................................................... 39
4.4 SOCKET LGA2066 COOLING KIT INSTALLATION ..................................................... 41
4.5 DIMM INSTALLATION.............................................................................................. 42
4.6 IRIS-2400 MODULE INSTALLATION (OPTIONAL)...................................................... 43
4.7 SYSTEM CONFIGURATION......................................................................................... 44
4.7.1 Clear CMOS Button......................................................................................... 44
4.7.2 Load Default Button......................................................................................... 45
4.7.3 Flash Descriptor Security Override Jumper.................................................... 45
4.8 SOFTWARE INSTALLATION ........................................................................................ 46
4.8.1 Driver Download ............................................................................................. 47
4.9 IPMI SETUP PROCEDURE ......................................................................................... 48
4.9.1 Managed System Hardware Setup ................................................................... 48
4.9.2 Using the IEI iMAN Web GUI.......................................................................... 49
5 BIOS.............................................................................................................................. 51
5.1 INTRODUCTION......................................................................................................... 52
5.1.1 Starting Setup................................................................................................... 52
5.1.2 Using Setup...................................................................................................... 52
5.1.3 Getting Help..................................................................................................... 53
5.1.4 Unable to Reboot after Configuration Changes.............................................. 53

PEMUX-XEW1
Page vii
5.1.5 BIOS Menu Bar................................................................................................ 53
5.2 MAIN........................................................................................................................ 54
5.3ADVANCED............................................................................................................... 55
5.3.1 Trusted Computing........................................................................................... 56
5.3.2 ACPI Settings................................................................................................... 57
5.3.3 F81216AD Super IO Configuration................................................................. 58
5.3.3.1 Serial Port 1 Configuration....................................................................... 58
5.3.3.2 Serial Port 2 Configuration....................................................................... 59
5.3.4 iWDD H/W Monitor......................................................................................... 60
5.3.4.1 Smart Fan Mode Configuration................................................................ 61
5.3.5 RTC Wake Settings........................................................................................... 63
5.3.6 Serial Port Console Redirection ...................................................................... 64
5.3.6.1 Legacy Console Redirection Settings....................................................... 67
5.3.7 USB Configuration........................................................................................... 68
5.3.8 iEi Feature ....................................................................................................... 69
5.4 CHIPSET ................................................................................................................... 70
5.4.1 PCH-IO Configuration .................................................................................... 71
5.4.1.1 PCI Express Configuration....................................................................... 72
5.4.1.2 SATAAnd RST Configuration.................................................................. 74
5.4.1.3 HD Audio Configuration........................................................................... 76
5.5 SECURITY................................................................................................................. 77
5.6 BOOT........................................................................................................................ 78
5.7 SAVE &EXIT............................................................................................................ 80
5.8 SERVER MANAGEMENT............................................................................................ 81
5.8.1 System Event Log............................................................................................. 81
5.8.2 BMC Network Configuration........................................................................... 83
5.9 SOCKET CONFIGURATION......................................................................................... 84
5.9.1 Processor Configuration .................................................................................. 85
5.9.2 IIO Configuration ............................................................................................ 86
5.9.2.1 Socket0 Configuration.............................................................................. 87
5.9.2.1 Intel® VT for Directed I/O (VT-d) ........................................................... 87
A REGULATORY COMPLIANCE.............................................................................. 89
B PRODUCT DISPOSAL.............................................................................................. 91
C BIOS OPTIONS.......................................................................................................... 93

PEMUX-XEW1
Page viii
D WATCHDOG TIMER ................................................................................................ 96
E HAZARDOUS MATERIALS DISCLOSURE ......................................................... 99

PEMUX-XEW1
Page ix
List of Figures
Figure 1-1: PEMUX-XEW1..............................................................................................................2
Figure 1-2: Connectors ..................................................................................................................4
Figure 1-3: PEMUX-XEW1 Dimensions (mm)...............................................................................5
Figure 1-4: Data Flow Diagram......................................................................................................6
Figure 3-1: Peripheral Interface Connectors .............................................................................14
Figure 3-2: +12V Power Connector Pinout Location ................................................................16
Figure 3-3: Audio Connector Location.......................................................................................17
Figure 3-4: DDR4 DIMM Socket Locations.................................................................................18
Figure 3-5: EC Debug Connector Location................................................................................18
Figure 3-6: CPU Fan Connector Location..................................................................................19
Figure 3-7: System Fan Connector Locations...........................................................................20
Figure 3-8: Front Panel Connector Location .............................................................................21
Figure 3-9: iRIS-2400 Module Slot Location ..............................................................................22
Figure 3-10: M.2 2280 Slot Location ...........................................................................................23
Figure 3-11: RS-232 Serial Port Locations.................................................................................25
Figure 3-12: Mini-SAS Connector Locations.............................................................................26
Figure 3-13: SPI Flash Connector Location...............................................................................27
Figure 3-14: SPI EC Flash Connector Location.........................................................................28
Figure 3-15: TPM Connector Location........................................................................................29
Figure 3-16: USB 3.1 Gen 1 Connector Location ......................................................................30
Figure 3-17: USB DOM Connector Location..............................................................................31
Figure 3-18: External Peripheral Interface Connector..............................................................32
Figure 3-19: 10GbE LAN Connector ...........................................................................................33
Figure 3-20: 1GbE LAN Connector .............................................................................................34
Figure 3-21: IPMI VGA Connector...............................................................................................35
Figure 4-1: DIMM Installation.......................................................................................................42
Figure 4-2: iRIS-2400 Module Installation..................................................................................43
Figure 4-3: Clear CMOS Button Location...................................................................................44
Figure 4-4: Load Default Button Location..................................................................................45
Figure 4-5: Flash Descriptor Security Override Jumper Location ..........................................45

PEMUX-XEW1
Page x
Figure 4-6: IEI Resource Download Center................................................................................46
Figure 4-7: IEI iMAN Web Address..............................................................................................49
Figure 4-8: IEI iMAN Web GUI......................................................................................................50

PEMUX-XEW1
Page xi
List of Tables
Table 1-1: PEMUX-XEW1 Specifications......................................................................................8
Table 2-1: Packing List.................................................................................................................11
Table 2-2: Optional Items.............................................................................................................12
Table 3-1: Peripheral Interface Connectors...............................................................................15
Table 3-2: External Peripheral Connectors................................................................................15
Table 3-3: +12V Power Connector Pinouts................................................................................16
Table 3-4: Audio Connector Pinouts ..........................................................................................17
Table 3-5: EC Debug Connector Pinouts...................................................................................19
Table 3-6: CPU Fan Connector Pinouts......................................................................................20
Table 3-7: System Fan Connector Pinouts................................................................................20
Table 3-8: Front Panel Connector Pinouts.................................................................................21
Table 3-9: M.2 2280 Connector Pinouts......................................................................................24
Table 3-10: RS-232 Serial Port Pinouts ......................................................................................25
Table 3-11: SPI Flash Connector Pinouts..................................................................................27
Table 3-12: SPI EC Flash Connector Pinouts ............................................................................28
Table 3-13: TPM Connector Pinouts...........................................................................................29
Table 3-14: USB 3.1 Gen 1 Connector Pinouts..........................................................................30
Table 3-15: USB DOM Connector Pinouts .................................................................................31
Table 3-16: 10GbE LAN Pinouts..................................................................................................32
Table 3-17: USB 2.0 Port Pinouts................................................................................................33
Table 3-18: 1GbE LAN Connector Pinouts.................................................................................33
Table 3-19: 1GbE LAN Connector LEDs.....................................................................................34
Table 3-20: USB 3.1 Gen 1 Port Pinouts.....................................................................................34
Table 3-21: IPMI VGA Connector Pinouts ..................................................................................35
Table 4-1: Flash Descriptor Security Override Jumper Settings.............................................45
Table 5-1: BIOS Navigation Keys................................................................................................53

PEMUX-XEW1
Page xii
BIOS Menus
BIOS Menu 1: Main.......................................................................................................................54
BIOS Menu 2: Advanced..............................................................................................................55
BIOS Menu 3: Trusted Computing..............................................................................................56
BIOS Menu 4: ACPI Settings .......................................................................................................57
BIOS Menu 5: F81216AD Super IO Configuration.....................................................................58
BIOS Menu 6: Serial Port 1 Configuration Menu.......................................................................58
BIOS Menu 7: Serial Port 2 Configuration Menu.......................................................................59
BIOS Menu 8: iWDD H/W Monitor ...............................................................................................60
BIOS Menu 9: Smart Fan Mode Configuration ..........................................................................61
BIOS Menu 10: RTC Wake Settings............................................................................................63
BIOS Menu 11: Serial Port Console Redirection.......................................................................64
BIOS Menu 12: Legacy Console Redirection Settings .............................................................67
BIOS Menu 13: USB Configuration.............................................................................................68
BIOS Menu 14: iEi Feature...........................................................................................................69
BIOS Menu 15: Chipset................................................................................................................70
BIOS Menu 16: PCH-IO Configuration........................................................................................71
BIOS Menu 17: PCI Express Configuration ...............................................................................72
BIOS Menu 18: PCIEX4 Slot.........................................................................................................72
BIOS Menu 19: SATA And RST Configuration...........................................................................74
BIOS Menu 20: HD Audio Configuration....................................................................................76
BIOS Menu 21: Security...............................................................................................................77
BIOS Menu 22: Boot.....................................................................................................................78
BIOS Menu 23: Save & Exit..........................................................................................................80
BIOS Menu 24: Server Management...........................................................................................81
BIOS Menu 25: System Event Log..............................................................................................82
BIOS Menu 26: BMC Network Configuration.............................................................................83
BIOS Menu 27: Socket Configuration.........................................................................................84
BIOS Menu 28: Processor Configuration...................................................................................85
BIOS Menu 29: IIO Configuration................................................................................................86
BIOS Menu 30: Socket0 Configuration.......................................................................................87

PEMUX-XEW1
Page xiii
BIOS Menu 31: Intel® VT for Directed I/O (VT-d).......................................................................87

PEMUX-XEW1
Page 1
Chapter
1
1 Introduction

PEMUX-XEW1
Page 2
1.1 Introduction
Figure 1-1: PEMUX-XEW1
The PEMUX-XEW1 is a full-size CPU card that can provide up to 56-lane PCIe signal to
the backplane. It accepts a Socket LGA2066 Intel®Xeon®W processor and supports four
288-pin 2666MHz dual-channel ECC DDR4 RDIMM/LRDIMM modules up to 256 GB.
The PEMUX-XEW1 provides one 10GbE interface through the Aquantia AQC107
controller (with NCSI support) and one 1GbE through the Intel® I210AT PCIe controller.
The integrated Intel® C422 chipset supports eight SATA 6Gb/s drives with RAID function.
Four USB 3.1 Gen 1 and two one USB 2.0 on the rear panel, two USB 3.1 Gen 1 by an
internal box header, two RS-232, one USB DOM pin header and one M.2 M-key slot
provide flexible expansion options. High Definition Audio (HDA) support ensures HDA
devices can be easily implemented on the PEMUX-XEW1.

PEMUX-XEW1
Page 3
1.2 Features
The PEMUX-XEW1 motherboard features are listed below:
Full-size CPU card supports up to 56-lane PCIe link to the backplane
Supports PCI Express Generation 3.0
LGA2066 Intel®Xeon®W processor family supported
Intel®C422 chipset
Four 288-pin 2666 MHz dual-channel ECC DDR4 RDIMMs/LRDIMMs support
up to 256 GB of memory
One 10GbE port, and one 1GbE port with NCSI support
One M.2 2280 M-key slot for SSD
Two Mini-SAS ports support 8 SATA 6Gb/s connectors with RAID
Four USB 3.1 Gen 1 ports on the rear I/O
Two USB 3.1 Gen 1 ports via internal box header
Two USB 2.0 via external Type A connectors
Two RS-232 serial ports
TPM V2.0 hardware security function supported by TPM module
High Definition Audio
RoHS compliant

PEMUX-XEW1
Page 4
1.3 Connectors
The connectors on the PEMUX-XEW1 are shown in the figure below.
Figure 1-2: Connectors

PEMUX-XEW1
Page 5
1.4 Dimensions
The main dimensions of the PEMUX-XEW1 are shown in the diagram below.
Figure 1-3: PEMUX-XEW1 Dimensions (mm)

PEMUX-XEW1
Page 6
1.5 Data Flow
Figure 1-4 shows the data flow between the system chipset, the CPU and other
components installed on the motherboard.
Figure 1-4: Data Flow Diagram