IEI Technology AFOLUX M Series User manual

AFL M Series LCD Monitor
Page i
IEI Technology Corp.
User Manual
MODEL:
AFOLUX M Series
7"~19" Multimedia Touch Monitor with Built-in Speakers,
VGA, Component, Composite, S-Video and DVI-D Input
IP 64 Protection
Rev. 1.12 – 10 March, 2011

AFL M Series LCD Monitor
Page ii
Revision
Date Version Changes
10 March, 2011 1.12 Updated Section 37.2 37-inch to 12.1-inch Driver
Installation and Configuration
29 September, 2009 1.11 Added screw torque warning
05 December, 2007 1.10 Added AFL-10M model information
Added USB touch screen feature to 7” to 12.1” models
Added USB touch screen models for 15” to 19” models
Added smartOSD function and smartOSD appendix
Added 7” to 12.1” model driver installation procedures
Added screen calibration procedures
30 June, 2007 1.00 Initial release

AFL M Series LCD Monitor
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
IBM PC is a registered trademark of International Business Machines Corporation. INTEL
is a registered trademark of INTEL Corporation. Other product names mentioned herein
are used for identification purposes only and may be trademarks and/or registered
trademarks of their respective owners.

AFL M Series LCD Monitor
Page iv
Manual Conventions
WARNING!
Warnings appear where overlooked details may cause damage to the equipment or result
in personal injury. Warnings should be taken seriously. Warnings are easy to recognize.
The word “warning” is written as “WARNING,” both capitalized and bold and is followed by
text. The text is the warning message. A warning message is shown below:
WARNING:
This is an example of a warning message. Failure to adhere to warning
messages may result in permanent damage to the AFL series monitor
or personal injury to the user. Please take warning messages seriously.
CAUTION!
Cautionary messages should also be heeded to help reduce the chance of losing data or
damaging the AFL series monitor. Cautions are easy to recognize. The word “caution” is
written as “CAUTION,” both capitalized and bold and is followed. The italicized text is the
cautionary message. A caution message is shown below:

AFL M Series LCD Monitor
Page v
CAUTION:
This is an example of a caution message. Failure to adhere to cautions
messages may result in permanent damage to the AFL series monitor.
Please take caution messages seriously.
NOTE:
These messages inform the reader of essential but non-critical information. These
messages should be read carefully as any directions or instructions contained therein can
help avoid making mistakes. Notes are easy to recognize. The word “note” is written as
“NOTE,” both capitalized and bold and is followed by text. The text is the cautionary
message. A note message is shown below:
NOTE:
This is an example of a note message. Notes should always be read.
Notes contain critical information about the AFL series monitor. Please
take note messages seriously.

AFL M Series LCD Monitor
Page vi
Packing List
NOTE:
If any of the components listed in the checklist below are missing,
please do not proceed with the installation. Contact the IEI reseller or
vendor you purchased the AFL M series from or contact an IEI sales
representative directly. To contact an IEI sales representative, please
send an email to 0[email protected].
The items listed below should all be included in the AFL M series package.
z1 x AFL M Series industrial LCD monitor
z1 x Power adapter
z1 x Power cord
z1 x DVI cable
z1 x VGAcable
z1 x Component cable
z1 x Audio cable
z1 x User manual and driver CD
z1 x Remote control
z1 x Screw set
z1 x Wire strain bands
z1 x Touch Panel RS-232 Cable / Touch Pen / Driver CD-ROM (T-R
models only)
z1 x Touch Panel USB Cable (for AFL-07M/T-R, AFL-08MH/T-R,
AFL-10M/T-R, and AFL-12M/T-R)
Images of the above items are shown in Chapter 383H383H5.3.3.

AFL M Series LCD Monitor
Page vii
Table of Contents
1H1H1 INTRODUCTION.......................................................................................................... 384H384H1
2H2H1.1AFLMSERIES LCD MONITOR OVERVIEW ................................................................ 385H385H3
3H3H1.1.1 Added Features .................................................................................................. 386H386H3
4H4H1.1.2 Standard Features.............................................................................................. 387H387H3
5H5H1.1.3 IEI smartOSD..................................................................................................... 388H388H4
6H6H1.1.4 Model Variations................................................................................................ 389H389H4
7H7H1.2 EXTERNAL OVERVIEW................................................................................................ 390H390H5
8H8H1.2.1 Front View.......................................................................................................... 391H391H5
9H9H1.2.2 Rear View........................................................................................................... 392H392H6
10H10H1.3 SERIES SPECIFICATIONS.............................................................................................. 393H393H7
11H11H1.4 CERTIFICATIONS ......................................................................................................... 394H394H8
12H12H2 MECHANICAL OVERVIEW...................................................................................... 395H395H9
13H13H2.1 INTRODUCTION......................................................................................................... 396H396H10
14H14H2.2 FRONT VIEW ............................................................................................................ 397H397H10
15H15H2.3 BOTTOM PANEL........................................................................................................ 398H398H12
16H16H2.3.1 AFL-07M/08MH/10M/12M Connectors.......................................................... 399H399H12
17H17H2.3.2 AFL-15M/17M/19M Connectors...................................................................... 400H400H12
18H18H2.4 PHYSICAL DIMENSIONS............................................................................................ 401H401H13
19H19H2.4.1 General Physical Dimensions.......................................................................... 402H402H13
20H20H2.4.2 AFL-07M Physical Dimensions....................................................................... 403H403H15
21H21H2.4.3 AFL-08MH Physical Dimensions.................................................................... 404H404H16
22H22H2.4.4 AFL-10M Physical Dimensions....................................................................... 405H405H17
23H23H2.4.5 AFL-12M Physical Dimensions....................................................................... 406H406H18
24H24H2.4.6 AFL-15M Physical Dimensions....................................................................... 407H407H19
25H25H2.4.7 AFL-17M Physical Dimensions....................................................................... 408H408H20
26H26H2.4.8 AFL-19M Physical Dimensions....................................................................... 409H409H21
27H27H2.5 MOUNTING KITS ...................................................................................................... 410H410H22
28H28H2.6 MOUNTING OPTIONS................................................................................................ 411H411H22
29H29H2.6.1 Panel Mounting................................................................................................ 412H412H22
30H30H2.6.2 Rack and Cabinet Mounting ............................................................................ 413H413H23

AFL M Series LCD Monitor
Page viii
31H31H2.6.3 Wall Mounting.................................................................................................. 414H414H23
32H32H2.6.4 Monitor Arm or Stand Mounting...................................................................... 415H415H24
33H33H3 LCD AND TOUCH PANEL SPECIFICATIONS ..................................................... 416H416H25
34H34H3.1 LCD SPECIFICATIONS............................................................................................... 417H417H26
35H35H3.1.1 LCD Overview ................................................................................................. 418H418H26
36H36H3.1.2 AFL-07M LCD Specifications.......................................................................... 419H419H26
37H37H3.1.3 AFL-08MH LCD Specifications....................................................................... 420H420H27
38H38H3.1.4 AFL-10M LCD Specifications.......................................................................... 421H421H28
39H39H3.1.5 AFL-12M LCD Specifications.......................................................................... 422H422H29
40H40H3.1.6 AFL-15M LCD Specifications.......................................................................... 423H423H30
41H41H3.1.7 AFL-17M LCD Specifications.......................................................................... 424H424H31
42H42H3.1.8 AFL-19M LCD Specifications.......................................................................... 425H425H32
43H43H3.2 OPTIONAL TOUCH PANELS ....................................................................................... 426H426H33
44H44H3.2.1 Touch Panel Models......................................................................................... 427H427H33
45H45H3.2.2 Touch Panel Dimensions.................................................................................. 428H428H34
46H46H3.2.3 Touch Panel Specifications.............................................................................. 429H429H35
47H47H3.2.4 Touch Panel RS-232 Controller Specifications................................................ 430H430H36
48H48H3.2.5 Touch Panel USB Controller Specifications.................................................... 431H431H37
49H49H3.3 POWER ADAPTERS.................................................................................................... 432H432H38
50H50H4 AD BOARD................................................................................................................... 433H433H39
51H51H4.1AV-9962AD BOARD OVERVIEW.............................................................................. 434H434H40
52H52H4.1.1 AV-9962 AD Board Connectors ....................................................................... 435H435H41
53H53H4.1.2 AV-9962 AD Board Layout............................................................................... 436H436H42
54H54H4.1.3 AV-9962 Peripheral Interface Connectors....................................................... 437H437H42
55H55H4.1.4 AV-9962 Rear Panel Connectors ..................................................................... 438H438H43
56H56H4.1.5 AV-9962 On-board Jumpers............................................................................. 439H439H43
57H57H4.2AV-9962 INTERNAL PERIPHERAL CONNECTORS ....................................................... 440H440H44
58H58H4.2.1 Audio Output Connector.................................................................................. 441H441H44
59H59H4.2.2 Auto-Dimming Connector................................................................................ 442H442H45
60H60H4.2.3 Debug Port Connector..................................................................................... 443H443H46
61H61H4.2.4 OSD and LED Connector ................................................................................ 444H444H47
62H62H4.2.5 LED Indicator and Remote Sensor Connector ................................................ 445H445H48
63H63H4.2.6 Backlight Inverter Interface Connector........................................................... 446H446H49

AFL M Series LCD Monitor
Page ix
64H64H4.2.7 IR Sensor Connector........................................................................................ 447H447H50
65H65H4.2.8 LVDS Signal Output Connector (AFL-08MH/10M/12M only)........................ 448H448H51
66H66H4.2.9 Power Output Connector................................................................................. 449H449H52
67H67H4.2.10 Remote Control Connector ............................................................................ 450H450H53
68H68H4.2.11 TTL Signal Output Connector (AFL-07M Model Only)................................. 451H451H54
69H69H4.2.12 Touch Panel Connector.................................................................................. 452H452H55
70H70H4.3AV-9962 ON-BOARD JUMPERS ................................................................................. 453H453H57
71H71H4.3.1 LCD Panel Voltage Select Jumper................................................................... 454H454H58
72H72H4.3.2 Touch Screen Select Jumper............................................................................. 455H455H58
73H73H4.4AV-9962 EXTERNAL (REAR PANEL)CONNECTORS................................................... 456H456H59
74H74H4.4.1 Audio Jack........................................................................................................ 457H457H59
75H75H4.4.2 Component Video Connector ........................................................................... 458H458H60
76H76H4.4.3 Composite Video Connector............................................................................. 459H459H61
77H77H4.4.4 DC 12V Connector........................................................................................... 460H460H61
78H78H4.4.5 RS-232 Touch Panel Connector....................................................................... 461H461H62
79H79H4.4.6 S-Video Connector ........................................................................................... 462H462H62
80H80H4.4.7 USB Touch Panel Connector ........................................................................... 463H463H63
81H81H4.4.8 VGA Connector................................................................................................ 464H464H64
82H82H4.5AV-6962AD BOARD OVERVIEW.............................................................................. 465H465H65
83H83H4.5.1 AV-6962 AD Board Connectors ....................................................................... 466H466H66
84H84H4.5.2 AV-6962 AD Board Layout............................................................................... 467H467H67
85H85H4.5.3 AV-6962 Peripheral Interface Connectors....................................................... 468H468H68
86H86H4.5.4 AV-6962 Rear Panel Connectors ..................................................................... 469H469H68
87H87H4.5.5 AV-6962 On-board Jumpers............................................................................. 470H470H69
88H88H4.6AV-6962 INTERNAL PERIPHERAL CONNECTORS ....................................................... 471H471H70
89H89H4.6.1 Audio Output Connector.................................................................................. 472H472H70
90H90H4.6.2 Auto-Dimming Connector................................................................................ 473H473H71
91H91H4.6.3 Debug Port Connector..................................................................................... 474H474H71
92H92H4.6.4 Backlight Inverter Interface Connector........................................................... 475H475H72
93H93H4.6.5 IR Sensor Connector........................................................................................ 476H476H73
94H94H4.6.6 LVDS Signal Output Connector....................................................................... 477H477H74
95H95H4.6.7 OSD and LED Connector ................................................................................ 478H478H75
96H96H4.6.8 Power Input Connector.................................................................................... 479H479H76
97H97H4.6.9 Power Output Connector................................................................................. 480H480H77
98H98H4.6.10 Remote Control Connector ............................................................................ 481H481H78

AFL M Series LCD Monitor
Page x
99H99H4.6.11 RS-232 Serial Port Connector........................................................................ 482H482H79
100H100H4.6.12 USB Connector .............................................................................................. 483H483H80
101H101H4.7AV-6962 ON-BOARD JUMPERS ................................................................................. 484H484H81
102H102H4.7.1 LCD Panel Voltage Select Jumper................................................................... 485H485H82
103H103H4.8AV-6962 EXTERNAL (REAR PANEL)CONNECTORS................................................... 486H486H83
104H104H4.8.1 Audio Jack........................................................................................................ 487H487H83
105H105H4.8.2 Component Video Connector ........................................................................... 488H488H84
106H106H4.8.3 Composite Video Connector............................................................................. 489H489H85
107H107H4.8.4 Digital Input Connector................................................................................... 490H490H86
108H108H4.8.5 DC 12V Connector........................................................................................... 491H491H87
109H109H4.8.6 RS-232 Touch Panel Connector....................................................................... 492H492H87
110H110H4.8.7 S-Video Connector ........................................................................................... 493H493H88
111H111H4.8.8 USB Touch Panel Connector ........................................................................... 494H494H89
112H112H4.8.9 VGA Connector................................................................................................ 495H495H89
113H113H5 INSTALLATION ......................................................................................................... 496H496H91
114H114H5.1 I ............................................................................................................................... 497H497H91
115H115H5.2 NSTALLATION PRECAUTIONS .................................................................................... 498H498H92
116H116H5.3 UNPACKING.............................................................................................................. 499H499H93
117H117H5.3.1 Packaging ........................................................................................................ 500H500H93
118H118H5.3.2 Unpacking Procedure ...................................................................................... 501H501H93
119H119H5.3.3 Packing List ..................................................................................................... 502H502H94
120H120H5.4 PRE-INSTALLATION PREPARATION ............................................................................ 503H503H96
121H121H5.4.1 Tools................................................................................................................. 504H504H96
122H122H5.5 CONNECTORS ........................................................................................................... 505H505H96
123H123H5.5.1 VGA Connector................................................................................................ 506H506H96
124H124H5.5.2 12V Power Connector...................................................................................... 507H507H97
125H125H5.5.3 DVI-D Connector (AFL-15M/17M/19M Models Only)................................... 508H508H97
126H126H5.5.4 Optional RS-232 Touch Panel Connector........................................................ 509H509H98
127H127H5.5.5 Optional USB Touch Panel Connector............................................................ 510H510H99
128H128H5.6 MOUNTING THE AFLSERIES INDUSTRIAL MONITOR................................................ 511H511H99
129H129H5.6.1 Mounting Kits................................................................................................. 512H512H100
130H130H5.6.2 Panel Mounting.............................................................................................. 513H513H100
131H131H5.6.2.1 Standard Panel Mounting........................................................................ 514H514H100
132H132H5.6.3 Wall Mounting................................................................................................ 515H515H103