IEI Technology KINO-KBN-i2 User manual

KINO-KBN-i2
Page I
User Manual
KINO-KBN-i2
MODEL:
Mini-ITX SBC with AMD® G-Series SoC Processor,
DDR3, VGA/HDMI, Dual GbE, USB 3.0,Dual Mini PCIe,
SATA 6Gb/s, Audio and RoHS
Rev. 1.02 - December 3, 2015
CPU Card

KINO-KBN-i2
Page II
Revision
Date Version Changes
December 3, 2015 1.02 Added a note regarding how to use USB 3.0 ports for Windows 7 OS
installation in Section 3.3.2.
March 12, 2014 1.01 Added chassis intrusion connector (CHASSIS1)
Added IPMI LED connector (ID_BT_FP1)
November 20, 2013 1.00 Initial release

KINO-KBN-i2
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

KINO-KBN-i2
Page IV
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any
directions or instructions contained therein can help avoid making
mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

KINO-KBN-i2
Page V
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 MODEL VARIATIONS ................................................................................................... 2
1.3 FEATURES................................................................................................................... 3
1.4 CONNECTORS ............................................................................................................. 4
1.5 DIMENSIONS............................................................................................................... 5
1.6 DATA FLOW................................................................................................................ 6
1.7 TECHNICAL SPECIFICATIONS ...................................................................................... 7
2 UNPACKING................................................................................................................. 9
2.1ANTI-STATIC PRECAUTIONS...................................................................................... 10
2.2 UNPACKING PRECAUTIONS....................................................................................... 10
2.3 PACKING LIST............................................................................................................11
2.4 OPTIONAL ITEMS...................................................................................................... 12
3 CONNECTORS ........................................................................................................... 13
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 14
3.1.1 KINO-KBN-i2 Layout ...................................................................................... 14
3.1.2 Peripheral Interface Connectors ..................................................................... 15
3.1.3 External Interface Panel Connectors............................................................... 16
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 17
3.2.1 AT/ATX Mode Select Switch............................................................................. 17
3.2.2 Battery Connector............................................................................................ 18
3.2.3 Chassis Intrusion Connector............................................................................ 19
3.2.4 Clear CMOS Button......................................................................................... 19
3.2.5 CPU Fan Connector........................................................................................ 20
3.2.6 CPU Power Connector.................................................................................... 21
3.2.7 DDR3 SO-DIMM Slots .................................................................................... 22
3.2.8 Digital I/O Connector...................................................................................... 23
3.2.9 EC Debug Connector....................................................................................... 24
3.2.10 Front Panel Connector .................................................................................. 25

KINO-KBN-i2
Page VI
3.2.11 IPMI LED Connector..................................................................................... 26
3.2.12 IPMI Slot........................................................................................................ 27
3.2.13 Keyboard/Mouse Connector .......................................................................... 30
3.2.14 LAN LED Connector...................................................................................... 31
3.2.15 PCIe x4 Slot ................................................................................................... 32
3.2.16 PCIe Mini Card Slot ...................................................................................... 34
3.2.17 RS-232 Serial Port Connector....................................................................... 37
3.2.18 RS-422/485 Serial Port Connector................................................................ 38
3.2.19 SATA 6Gb/s Drive Connector ........................................................................ 39
3.2.20 SATA Power Connector.................................................................................. 39
3.2.21 SD Card Slot .................................................................................................. 40
3.2.22 SMBUS Connector......................................................................................... 41
3.2.23 S/PDIF Connector ......................................................................................... 42
3.2.24 SPI Flash Connector...................................................................................... 43
3.2.25 System Fan Connector................................................................................... 44
3.2.26 TPM Connector.............................................................................................. 45
3.2.27 USB Connector .............................................................................................. 46
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 48
3.3.1 Audio Connector .............................................................................................. 48
3.3.2 Ethernet and USB Connectors......................................................................... 49
3.3.3 HDMI Connector............................................................................................. 51
3.3.4 Power Connector............................................................................................. 52
3.3.5 Serial Port Connector (COM1) ....................................................................... 52
3.3.6 VGA Connector................................................................................................ 53
4 INSTALLATION ......................................................................................................... 54
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 55
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 55
4.2.1 SO-DIMM Installation..................................................................................... 57
4.2.2 IPMI Module Installation (Optional)............................................................... 58
4.3 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 59
4.3.1 SATA Drive Connection ................................................................................... 59
4.3.2 Single RS-232 Cable........................................................................................ 60
4.4 IPMI SETUP PROCEDURE ......................................................................................... 61
4.4.1 Managed System Hardware Setup ................................................................... 61

KINO-KBN-i2
Page VII
4.4.2 Using the IEI iMAN Web GUI.......................................................................... 61
5 BIOS.............................................................................................................................. 64
5.1 INTRODUCTION......................................................................................................... 65
5.1.1 Starting Setup................................................................................................... 65
5.1.2 Using Setup...................................................................................................... 65
5.1.3 Getting Help..................................................................................................... 66
5.1.4 Unable to Reboot after Configuration Changes.............................................. 66
5.1.5 BIOS Menu Bar................................................................................................ 66
5.2 MAIN........................................................................................................................ 67
5.3ADVANCED............................................................................................................... 68
5.3.1 ACPI Settings................................................................................................... 68
5.3.2 RTC Wake Settings........................................................................................... 69
5.3.3 Trusted Computing........................................................................................... 71
5.3.4 CPU Configuration.......................................................................................... 72
5.3.5 IDE Configuration........................................................................................... 73
5.3.6 USB Configuration........................................................................................... 74
5.3.7 F81866 Super IO Configuration...................................................................... 75
5.3.7.1 Serial Port n Configuration....................................................................... 76
5.3.8 F81866 H/W Monitor....................................................................................... 81
5.3.8.1 Smart Fan Mode Configuration................................................................ 82
5.3.9 Serial Port Console Redirection ...................................................................... 83
5.3.9.1 Console Redirection Settings.................................................................... 84
5.4 CHIPSET ................................................................................................................... 87
5.4.1 GFX Configuration.......................................................................................... 87
5.4.2 South Bridge Configuration............................................................................. 88
5.4.3 North Bridge Configuration............................................................................. 90
5.5 BOOT........................................................................................................................ 91
5.6 SECURITY................................................................................................................. 93
5.7 SAVE &EXIT............................................................................................................ 93
A REGULATORY COMPLIANCE.............................................................................. 95
B BIOS MENU OPTIONS............................................................................................. 97
C TERMINOLOGY ..................................................................................................... 100
D DIGITAL I/O INTERFACE..................................................................................... 105

KINO-KBN-i2
Page VIII
D.1 INTRODUCTION...................................................................................................... 106
D.2ASSEMBLY LANGUAGE SAMPLE 1.......................................................................... 107
D.3ASSEMBLY LANGUAGE SAMPLE 2.......................................................................... 107
E WATCHDOG TIMER............................................................................................... 108
F HAZARDOUS MATERIALS DISCLOSURE.........................................................111
F.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS ROHS
COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY.................................................112

KINO-KBN-i2
Page IX
List of Figures
Figure 1-1: KINO-KBN-i2................................................................................................................2
Figure 1-2: Connectors ..................................................................................................................4
Figure 1-3: Dimensions (mm)........................................................................................................5
Figure 1-4: Data Flow Diagram......................................................................................................6
Figure 3-1: Connector and Jumper Locations...........................................................................14
Figure 3-2: AT/ATX Mode Select Switch Location ....................................................................17
Figure 3-3: Battery Connector Location.....................................................................................18
Figure 3-4: Chassis Intrusion Connector Location...................................................................19
Figure 3-5: Clear CMOS Button Location...................................................................................20
Figure 3-6: CPU Fan Connector Locations................................................................................21
Figure 3-7: CPU Power Connector Location..............................................................................22
Figure 3-8: DDR3 SO-DIMM Slot Location .................................................................................23
Figure 3-9: Digital I/O Connector Location ................................................................................24
Figure 3-10: EC Debug Connector Location..............................................................................25
Figure 3-11: Front Panel Connector Location ...........................................................................26
Figure 3-12: IPMI LED Connector Location ...............................................................................27
Figure 3-13: IPMI Slot Location...................................................................................................28
Figure 3-14: Keyboard/Mouse Connector Location..................................................................31
Figure 3-15: LAN LED Connector Location ...............................................................................32
Figure 3-16: PCIe x4 Slot Location .............................................................................................33
Figure 3-17: PCIe Mini Card Slot Location.................................................................................35
Figure 3-18: RS-232 Serial Port Connector Location................................................................37
Figure 3-19: RS-422/485 Connector Location............................................................................38
Figure 3-20: SATA 6Gb/s Drive Connector Location................................................................39
Figure 3-21: SATA Power Connector Location .........................................................................40
Figure 3-22: SD Card Slot Location............................................................................................41
Figure 3-23: SMBus Connector Location...................................................................................42
Figure 3-24: S/PDIF Connector Location ...................................................................................43
Figure 3-25: SPI Flash Connector Location...............................................................................44
Figure 3-26: System Fan Connector Locations.........................................................................45
Figure 3-27: TPM Connector Location........................................................................................46

KINO-KBN-i2
Page X
Figure 3-28: USB Connector Locations......................................................................................47
Figure 3-29: External Peripheral Interface Connector..............................................................48
Figure 3-30: Audio Connector.....................................................................................................48
Figure 3-31: LAN Connector........................................................................................................49
Figure 3-32: Serial Port Pinout Locations..................................................................................53
Figure 3-33: VGA Connector .......................................................................................................53
Figure 4-1: SO-DIMM Installation................................................................................................57
Figure 4-2: IPMI Module Installation...........................................................................................58
Figure 4-2: SATA Drive Cable Connection.................................................................................59
Figure 4-3: Single RS-232 Cable Installation .............................................................................60
Figure 4-5: IEI iMAN Web Address..............................................................................................62
Figure 4-6: IEI iMAN Web GUI......................................................................................................62

KINO-KBN-i2
Page XI
List of Tables
Table 1-1: KINO-KBN-i2 Model Variations....................................................................................2
Table 1-2: Technical Specifications..............................................................................................8
Table 3-1: Peripheral Interface Connectors...............................................................................16
Table 3-2: Rear Panel Connectors..............................................................................................16
Table 3-3: AT/ATX Mode Select Switch Settings.......................................................................17
Table 3-4: Battery Connector Pinouts........................................................................................18
Table 3-5: Chassis Intrusion Connector Pinouts......................................................................19
Table 3-6: Clear CMOS Button Settings.....................................................................................20
Table 3-7: CPU Fan Connector Pinouts......................................................................................21
Table 3-8: CPU Power Connector Pinouts.................................................................................22
Table 3-9: Digital I/O Connector Pinouts....................................................................................24
Table 3-10: EC Debug Connector Pinouts .................................................................................25
Table 3-11: Front Panel Connector Pinouts...............................................................................26
Table 3-12: IPMI LED Connector Pinouts...................................................................................27
Table 3-13: IPMI Slot Pinouts ......................................................................................................30
Table 3-14: Keyboard/Mouse Connector Pinouts .....................................................................31
Table 3-15: LAN LED Connector Pinouts...................................................................................32
Table 3-16: PCIe x4 Slot Pinouts.................................................................................................34
Table 3-17: PCIe Mini Card Slot Pinouts (M_PCIE1) .................................................................36
Table 3-18: PCIe Mini Card Slot Pinouts (M_PCIE2) .................................................................37
Table 3-19: RS-232 Serial Port Connector Pinouts...................................................................38
Table 3-20: RS-422/485 Connector Pinouts ...............................................................................38
Table 3-21: SATA Power Connector Pinouts.............................................................................40
Table 3-22: SMBus Connector Pinouts ......................................................................................42
Table 3-23: S/PDIF Connector Pinouts.......................................................................................43
Table 3-24: SPI Flash Connector Pinouts (SPI1).......................................................................44
Table 3-25: SPI Flash Connector Pinouts (SPI2).......................................................................44
Table 3-26: System Fan Connector Pinouts ..............................................................................45
Table 3-27: TPM Connector Pinouts...........................................................................................46
Table 3-28: USB Connector Pinouts...........................................................................................47
Table 3-29: LAN1_USB2 Connector Pinouts .............................................................................50

KINO-KBN-i2
Page XII
Table 3-30: LAN2_USB2 Connector Pinouts .............................................................................50
Table 3-31: HDMI Connector Pinouts .........................................................................................52
Table 3-32: Power Connector Pinouts........................................................................................52
Table 3-33: Serial Port Pinouts....................................................................................................53
Table 3-34: VGA Connector Pinouts...........................................................................................53
Table 5-1: BIOS Navigation Keys................................................................................................66

KINO-KBN-i2
Page XIII
List of BIOS Menus
BIOS Menu 1: Main.......................................................................................................................67
BIOS Menu 2: Advanced..............................................................................................................68
BIOS Menu 3: ACPI Configuration..............................................................................................69
BIOS Menu 4: RTC Wake Settings..............................................................................................70
BIOS Menu 5: Trusted Computing..............................................................................................71
BIOS Menu 6: CPU Configuration...............................................................................................72
BIOS Menu 7: IDE Configuration.................................................................................................73
BIOS Menu 8: USB Configuration...............................................................................................74
BIOS Menu 9: Super IO Configuration........................................................................................75
BIOS Menu 10: Serial Port n Configuration Menu.....................................................................76
BIOS Menu 11: Hardware Health Configuration........................................................................81
BIOS Menu 12: FAN 1 Configuration..........................................................................................82
BIOS Menu 13: Serial Port Console Redirection.......................................................................84
BIOS Menu 14: Console Redirection Settings...........................................................................85
BIOS Menu 15: Chipset................................................................................................................87
BIOS Menu 16: GFX Configuration.............................................................................................88
BIOS Menu 17: South Bridge Configuration..............................................................................89
BIOS Menu 18: North Bridge Configuration ..............................................................................90
BIOS Menu 19: Boot.....................................................................................................................91
BIOS Menu 20: Security...............................................................................................................93
BIOS Menu 21:Exit........................................................................................................................94

KINO-KBN-i2
Page 1
1 Introduction
Chapter
1

KINO-KBN-i2
Page 2
1.1 Introduction
Figure 1-1: KINO-KBN-i2
The KINO-KBN-i2 Mini-ITX motherboard is an AMD® G-Series SoC processor platform. It
supports two 1600/1333 MHz DDR3 SO-DIMM modules up to 8.0 GB.
The KINO-KBN-i2 includes a VGA connector and two HDMI connectors. Expansion and
I/O include two USB 3.0 connectors on the rear panel, two USB 2.0 connectors on the rear
panel, two USB 2.0 connectors by pin header and two SATA 6Gb/s connectors. Serial
device connectivity is provided by three internal RS-232 connectors, one external RS-232
connector and one internal RS-422/485 connector. Two RJ-45 Ethernet connectors
provide the system with smooth connections to an external LAN.
1.2 Model Variations
The model variations of the KINO-KBN-i2 Series are listed below.
Model No. SoC
KINO-KBN-i2-4151-R10 AMD® G-Series GX-415GA, 15W, 1.5GHz
KINO-KBN-i2-2101-R10 AMD® G-Series GX-210HA, 9W, 1.0GHz
KINO-KBN-i2-4201-R10 AMD® G-Series GX-420CA, 25W, 2.0GHz
KINO-KBN-i2-2171-R10 AMD® G-Series GX-217GA, 15W, 1.65GHz
Table 1-1: KINO-KBN-i2 Model Variations

KINO-KBN-i2
Page 3
1.3 Features
Some of the KINO-KBN-i2 motherboard features are listed below:
Mini-ITX form factor with AMD® G-Series SoC processor supports DDR3
1600/1333 MHz memory
12V only single voltage design forAT/ATX power
Dual independent display by VGAand dual HDMI
Support dual PCIe Mini card slot with mSATA, wireless card and DOM
capabilities
IPMI 2.0 support by IPMI-01-R101 module card
IEI One Key Recovery solution allows you to create rapid OS backup and
recovery

KINO-KBN-i2
Page 4
1.4 Connectors
The connectors on the KINO-KBN-i2 are shown in the figure below.
Figure 1-2: Connectors

KINO-KBN-i2
Page 5
1.5 Dimensions
The dimensions of the board are listed below:
Figure 1-3: Dimensions (mm)

KINO-KBN-i2
Page 6
1.6 Data Flow
Figure 1-4 shows the data flow between the system chipset, the CPU and other
components installed on the motherboard.
Figure 1-4: Data Flow Diagram