Infantino Fusion Manual

Fusion™
Flexible Position Carrier
Owners Manual
Instructions
This box contains: 1 - Carrier
Read all instructions before assembling and using your carrier. Failure to follow
each instruction can result in serious injury or death to your baby. Keep instructions
and review them before attempting new carrying positions.
8lbs - 32lbs (3.6kgs - 14.5kgs)
IMPORTANT!
KEEP INSTRUCTIONS FOR FUTURE USE.
Instruction manual available in additional languages at:
Manuel disponible en français chez:
www.infantino.com
2.
WARNING
FALL AND SUFFOCATION HAZARD
FALL HAZARD - Infants can fall through a wide leg opening or out of carrier.
 •Adjustlegopeningstotbaby’slegssnugly.
 •Beforeeachuse,makesureallfastenersaresecure.
 •Takespecialcarewhenleaningorwalking.
 •Neverbendatwaist;bendatknees.
 •Onlyusethiscarrierforbabiesbetween8lbs(3.6kgs)and32lbs(14.5kgs).
SUFFOCATION HAZARD-Infantsunder4monthscansuffocate
in this product if face is pressed tight against your body.
 •Donotstrapinfanttootightagainstyourbody.
 •Allowroomforheadmovement.
 •Keepinfant’sfacefreefromobstructionsatalltimes.
WARNING
• Followinstructionsforuse.Whenfasteningthecarrier,keeponehandonbabyatalltimes.
• Babymustfacetowardyouuntilhe/shecanholdtheirheaduprighttoavoidpossibleneckorbackinjury.
• Babymustbeabletosituponhis/herownbeforebeingworninthebackpackpositiontoavoid
possiblebackorneckinjury.
• NEVERusethewideseatpositionwhencarryingthebabyinthefacingoutposition.
• Prematureinfants,infantswithrespiratoryproblems,andinfantsunder4monthsareatgreatestrisk
of suffocation.
• NEVERuseasoftcarrierwhenbalanceormobilityisimpairedbecauseofexercise,sportingactivities,
drowsiness,ormedicalconditions.Itisintendedforusebyadultswhilewalkingorstandingonly.
• Your balance may be adversely affected by your movement and that of your baby.
• NEVERuseasoftcarrierwhileengaginginactivitiessuchascookingandcleaningwhichinvolvea
heatsourceorexposuretochemicals.
• NEVERwearasoftcarrierwhiledrivingorbeingapassengerinamotorvehicle.DONOTusethis
carrierasachildrestraintinamotorvehicle.Thistypeofcarrierwillnotproperlyrestrainyourbabyin
the event of a crash.
• NEVERleavebabyunattendedinthiscarrier.
• ALWAYSchecktoensurethatallbuckles,snaps,straps,andadjustmentsaresecurebeforeeach
use.Makesurebabyisproperlyplacedinthecarrier,includinglegplacement,beforeeachuse.
• Thisproductissubjecttowearandtearovertime.Checkforrippedseams,tornstrapsorfabricand
damaged fasteners before each use.
• NEVERleanagainstbaby.
• DONOTusethisproductifdeteriorationorproblemsaredetected.
• NEVERplacemorethanonechildinthiscarrier.
• DONOTwearmorethanonecarrieratatimeever.
• DONOTuseinshowers,poolsoranywaterenvironments.

Fusion™Carrier Position Options
3.
For Safe and Secure Carrying:
If you are new to babywearing or are using a new carrier style, there are denitely some things you need to
know before placing your baby in the carrier. Here are some important Do’s and Don’ts for proper use of your
carrier. Please be sure to review this manual in its entirety for all safety information.
• Practice before you start. Be sure to try out your carrier before you put baby in the rst time.
• Check regularly that baby’s chin is positioned upwardly and never pressed into his/her chest.
• Don’t overdress your baby. Your closeness and body heat along with the carrier fabric will help to keep
them warm.
• TIP: Small children have poor temperature regulation, so check baby’s abdomen, forehead and neck
frequently.
• Check your baby’s legs often to make sure they are warm and blood circulates freely. Should the calves
and feet appear to be a slightly different color, shift baby in the carrier.
• If baby falls asleep or starts to fuss in the facing-out position you should switch to the facing-in position or
remove them from the carrier entirely.
Position: Facing-In with
Narrow Seat
Facing-In with
Wide Seat
Facing-Out with
Narrow Seat
Backpack with
Wide Seat
Age: For babies 8 lbs
to 15 lbs
For babies 15 lbs
to 32 lbs
Baby is able to
hold their head
up on their own
Baby is able to fully
sit up on their own.
Tips: Until your child is
able to hold his/
her head upright,
this is the correct
position.
When the baby
is positioned
correctly, you
should be able to
tilt forward slightly
and kiss the top
of your child’s
head.
The wide seat
allows a larger
baby to ride in a
seated position
with his/her
legs wrapping
around you. This
is a comfortable
position for
the child and it
provides better
weight distribution
for you.
Never use the
wide seat when
baby is facing-out.
This position
allows your baby
to visually explore
their surroundings
while maintaining
close contact with
you.
This position
requires assistance
from a second
person.
Wearing the carrier
closer to your body
and higher up
on your back will
minimize stress
to your back and
shoulders from
prolonged use.
Instructions: see pg. 6 see pg. 9 see pg. 12 see pg. 14
4.
Helpful Hints:
• Facing-In Position - Baby Facing Toward You - Until your child is able to hold his/her
head upright, this is the correct position. It affords your baby lots of close physical contact
and attention, while leaving your hands free. In this position, you can entertain and bond
with your newborn by talking, touching, playing or just making eye-contact.
• Facing-Out Position - Baby Facing Away From You - Once your child is able to hold
his/her head up, your baby is ready for a new adventure. This position allows him/her to
visually explore their surroundings while maintaining close contact with you. Always use
the narrow seat position when carrying in the baby facing-out position.
• Backpack Position - Child Facing Towards You - When your little one can fully sit up
on his/her own, putting them on your back allows you to carry the child comfortably for
longer periods of time. In this position your baby is free to check out what is going on
around them and still know that you are right there.
What seat position should I use?
• For Facing-In Position, smaller babies, 8 lbs to 15 lbs, use the narrow seat. Larger
babies and children use the wide seat. The wide seat allows a larger child to ride in a
comfortable seated position with their legs wrapping around you.
• For Facing-Out Position, always use the narrow seat.
• For Backpack Assisted Position, always use the wide seat.
How do I know if my baby is at the right height when Carrier is worn in the front?
•You should be able to tilt forward slightly and kiss the top of your child’s head.
• When placing your baby in or taking them out of the carrier, sitting down will make
the procedure easier. Until you are familiar with the placement of baby, it is also
recommended to do so over a soft surface.
• It is best to limit the use of your carrier to 10-20 minutes until you and your baby are both
completely comfortable in it together.
• Wearing the carrier closer to your body and higher up on your back (or chest when worn
in the front position) will minimize stress to your back and shoulders from prolonged use.
Care Instructions:
Machine wash cold, separately, on gentle cycle with mild detergent. DO NOT bleach. Wipe
clean with a cloth or sponge between machine washings. Drip dry only. DO NOT iron.

Shoulder Straps
Head Support Snap
Head Support
Conversion Button
for Wide Seat
Conversion Button
for Narrow Seat
Conversion Flap
Leg Straps
Waist Belt & Buckle
Tuck-Away Loops
Tidy Loop
Chest/Back Buckle
Side Closure Buckle
Leg Opening
Head Support Buckle & Strap
Shoulder Strap Adjuster
Leg Strap Button
Shoulder Straps
Head Support Snap
Head Support
Conversion Button
for Wide Seat
Conversion Button
for Narrow Seat
Conversion Flap
Leg Straps
Waist Belt & Buckle
Tuck-Away Loops
Tidy Loop
Chest/Back Buckle
Side Closure Buckle
Leg Opening
Head Support Buckle & Strap
Shoulder Strap Adjuster
Leg Strap Button
5.
Carrier Body Front:
Refer to these parts when reading the instructions.
Carrier Body Back:
6.
1Carrier use for an Infant:
Facing-In Position with Narrow Seat
This position is for babies 8 lbs to 15 lbs.
* IMPORTANT! Your baby must face toward you until he/she is able to hold their head upright.
* When using this carrier in the Facing-In Position, you should t it to the user before placing
the baby in the carrier.
* Keep one hand on the baby until all the buckles and straps are properly fastened.
* NOTE: The carrier parts in bold can be found on the carrier illustrations.
1. Adjust the conversion aps to the narrow seat position
by folding the ap upward and fastening the button
hole over the conversion button on the front of the
carrier body.
2. Unfasten the chest/back buckle and waist belt & buckle.
Hold the carrier so the grey interior of the shoulder
straps and waist belt face you. (The straps should form
a “V”)
3. Place your arms through the shoulder straps making
sure the grey fabric rests on your shoulders.

7.
5. Fasten the waist belt around your waist and pull the
strap to tighten.
*NOTE: People with longer torsos may nd a higher belt
position more comfortable (closer to the navel); shorter
people may wish to wear the belt more on the hips.
6. Fasten the side closure buckle on one side. You will
hear a ‘click’ when the buckle is secure. This step will
create a leg opening on the closed side.
7. With the carrier open on one side and the baby facing
you, carefully slide the baby into the carrier by tting
his/her leg through the leg opening on the closed side
of the carrier.
*IMPORTANT! Keep one hand on the baby until all buckles
and straps are properly fastened.
*Make sure your baby’s leg goes through the leg opening
on the closed side of the carrier.
4. With the shoulder straps in place, reach behind your
back to connect the chest/back buckle. If you need
assistance, have another person fasten the buckle.
Pull the strap to tighten.
8.
8. While supporting the baby with one hand, fasten the
other side closure buckle. You will hear a ‘click’ when
the buckle is secure.
9. Support the baby’s head by attaching the two head
support buckles above each arm. You will hear a ‘click’
when the buckle is secure. Adjust the size of the head
support by pulling both of the head support straps.
*IMPORTANT! Always make sure there is enough room
around your baby’s face to provide a clear source of air.
10. Attach the leg strap to the leg strap button on BOTH
SIDES of the carrier.
*IMPORTANT! For babies between 8-11 lbs, the leg straps
must be attached to make the leg opening smaller and to
avoid a potential falling hazard.
*NOTE: For babies over 11 lbs or 5 kgs, this step is
unnecessary. When leg straps are not in use, fold them
under the tuck-away loops.

9.
11. To adjust how high the baby rides on your chest, lift the
baby slightly and pull the shoulder strap adjuster, rst on
one strap, then on the other. When the baby is properly
positioned, you should be able to tilt your head forward
and kiss the top of your baby’s head.
*NOTE: Wearing the carrier closer to your body and higher
up on your chest will minimize stress to your back and
shoulders from prolonged use.
2Carrier use for an Older Baby:
Facing-In Position with Wide Seat
This position is for babies 15 lbs to 32 lbs.
* IMPORTANT! Your baby must face toward you until he/she is able to hold their head upright.
* When using this carrier in the Facing-In Position, please t it to the user before placing the
baby in the carrier.
* Keep one hand on the baby until all the buckles and straps are properly fastened.
* NOTE: The carrier parts in bold can be found on the carrier illustrations.
1. To adjust the conversion aps for the wide seat position,
fold under the corner of the ap and attach the button
hole over the conversion button on the waist belt.
10.
2. Unfasten the chest/back buckle and waist belt buckle.
Hold the carrier so the grey interior of the shoulder
straps and waist belt face you. (The straps should
form a “V”)
3. Place your arms through the shoulder straps making
sure the grey fabric rests on your shoulders.
4. With the shoulder straps in place, reach behind your
back to connect the chest/back buckle. If you need
assistance, have another person fasten the buckle.
Pull the strap to tighten.
5. Fasten the waist belt around your waist and pull the
strap to tighten.
*NOTE: People with longer torsos may nd a higher belt
position more comfortable (closer to the navel); shorter
people may wish to wear the belt more on the hips.

11.
6. Fasten the side closure buckle on one side. You will
hear a ‘click’ when the buckle is secure. This step will
create a leg opening on the closed side.
7. With the carrier open on one side and the baby facing
you, carefully slide the baby into the carrier by tting
his/her leg through the leg opening on the closed
side of the carrier.
*IMPORTANT! Keep one hand on the baby until all buckles
and straps are properly fastened.
*Make sure your baby’s leg goes through the leg opening
on the closed side of the carrier.
8. While supporting the baby with one hand, fasten the
other side closure buckle. You will hear a ‘click’ when
the buckle is secure.
9. Support the baby’s head by attaching the two head
support buckles above each arm. You will hear a ‘click’
when the buckle is secure. Adjust the size of the head
support by pulling both of the head support straps.
12.
10. To adjust how high the baby rides on your chest, lift the
baby slightly and pull the shoulder strap adjuster, rst on
one strap, then on the other. When the baby is properly
positioned, you should be able to tilt your head forward
and kiss the top of your baby’s head.
3Carrier use for an Older Baby:
Facing-Out Position with Narrow Seat
Once your baby is able to hold his/her head up, your child is ready for
the Facing-Out Position.
* WARNING! Your baby must face toward you until he/she is able to hold their head upright.
* WARNING! Never use the wide seat position when carrying the baby in the Facing-Out Position.
* When the baby is carried in the Facing-Out Position, the attachment of the leg strap is
UNNECESSARY, regardless of the weight of the child.
* NOTE: The carrier parts in bold can be found on the carrier illustrations.
1. Repeat steps 1-6 of 1Carrier Use for an Infant:
Facing-In Position with a Narrow Seat. (See page 6)
2. Fold down the head support and fasten the head
support snap to the carrier body.
3. With the carrier open on one side and the baby facing
away from you, carefully slide the baby into the carrier
by tting his/her leg through the leg opening on the
closed side of the carrier.
*IMPORTANT! Keep one hand on the baby until all buckles
and straps are properly fastened.
*Make sure your baby’s leg goes through the leg opening
on the closed side of the carrier.

13.
4. While supporting the baby with one hand, fasten the
other side closure buckle. You will hear a ‘click’ when
the buckle is secure.
5. Attach both head support buckles, making sure that the
head support area remains folded down. You will hear a
‘click’ when the buckle is secure. Adjust the size of the
head support area by pulling both of the head support
straps.
6. To adjust how high the baby rides on your chest, lift the
baby slightly and pull the shoulder strap adjuster, rst on
one strap, then on the other. When the baby is properly
positioned, you should be able to tilt your head forward
and kiss the top of your baby’s head.
*The baby should NEVER be leaning forward in the carrier.
*NOTE: The arms of smaller babies should be positioned
below the head support buckles. Larger babies’ arms
should be above the buckles, and rest comfortably over the
folded-down head support.
14.
4Carrier use for an Older Baby:
Backpack Position with Wide Seat - Assisted
Once your baby is fully able to sit up on their own, your child is ready for the
Backpack Position.
* STOP! First time users, DO NOT attempt to use the carrier in the Backpack Position without
the assistance of a second person. We highly recommend always using the assistance of a
second person.
* IMPORTANT! The baby MUST be able to sit up on his or her own before being worn in the
backpack position.
* NOTE: The carrier parts in bold can be found on the carrier illustrations.
1. To adjust the conversion aps for the wide seat position,
fold under the corner of the ap and attach the button
hole over the conversion button on the waist belt.
2. Place your arms through the straps like you are putting on
a jacket. The carrier should be hanging down behind you.
3. Connect the chest/back buckle. You will hear a ‘click’
when the buckle is secure. Pull the strap to tighten.

15.
4. Fasten the waist belt around your waist and pull the
strap to tighten.
*NOTE: Persons with longer torsos may nd a higher belt
position more comfortable (closer to the navel); shorter
people may wish to wear the belt more on the hips.
5. With assistance from a partner, place the child gently
on your back like you are giving them a piggyback ride.
Your child’s legs should wrap around your waist and
their arms should be on your shoulders.
*NOTE: It is helpful to lean forward slightly to help keep the
child in a high position on your back.
*Your child should be supported by a partner at all times.
6. While the second person is supporting the child, bring
the carrier body up over the child’s back.
7. Once the carrier body is up, the second person will
secure it closed by attaching the side closure buckles
and then the head support buckles. You will hear a ‘click’
when secure.
16.
10. Once all buckles are secured and tightened, the second
person may release their support of the child.
*NOTE: It is helpful to reach around and provide added
support for the child by placing your hand under the child’s
bottom while carrier body is being secured.
8. Once all buckles are fastened, adjust the head support
by pulling the head support straps.
9. To adjust how high the baby rides on your back, lift the
baby slightly and pull the shoulder strap adjuster, rst on
one strap, then on the other.
*NOTE: Wearing the carrier closer to your body and higher
up on your back will minimize stress to your back and
shoulders from prolonged use.

Removing Baby from the Carrier:
Backpack Position - Assisted
* IMPORTANT! When releasing the baby from the carrier, keep at least one hand on the baby at all times.
1. With assistance from your partner, reverse steps 2-9 of 4Carrier use for an
Older Baby:Backpack Position with Wide Seat - Assisted. (See page 14)
2. With baby supported at all times, your partner will release the two head support
buckles, then both side closure buckles. Your partner will then lift the child from
your back.
Removing Baby from the Carrier:
Backpack Position - Unassisted
* IMPORTANT! NEVER lean against the child. ALWAYS make sure there is enough room around your
child’s face to provide a clear source of air.
* IMPORTANT! When releasing the baby from the carrier, keep at least one hand on the baby at all times.
1. For removal by yourself, sit down slowly and carefully in a secure corner seat such
as a sofa.
2. Gently ease baby back and unbuckle the chest strap and waist belt.
3. Remove the shoulder straps and slowly remove baby from your back.
4. Remove baby from carrier by unfastening both head support buckles and side
closure buckles.
Removing the Child from the Carrier:
Front Position, Facing-In/Out
* IMPORTANT! When releasing the baby from the carrier, keep at least one hand on the baby at all times.
1. Keeping one hand securely on the baby, release the two head support buckles.
2. Still keeping one hand on your baby, release the side closure buckle on one side.
Put one hand on your baby inside the carrier, holding him/her to your chest.
3. Release the side closure buckle on the other side of the carrier. With both hands, lift
your baby and place him/her in a safe location.
4. You can now remove the carrier from your body.
17. 18.

© 2013 Infantino, LLC
4920 Carroll Canyon Road, Suite 200 | San Diego, CA 92121 USA
www.infantino.com
Complies with safety requirements of ASTM F2236-13
Designed with in California
BEFORE USING THIS CARRIER: Review and save the Instruction Manual for future reference. Please call Infantino at
1-800-840-4916 (for US or Canada) with any questions or visit our website www.infantino.com. Made in China.
1023201319.