Insinger COMMANDER 18-5H User manual

❏ Pressure reduction valve
and line strainer
❏ Stainless steel steam coil
tank heat
❏ Steam booster
❏ Built-in electric booster
❏ Remote electric booster
❏ Security package
❏ Totally enclosed motor
❏ Door activated drain closer
❏ Plastic 20” x 20” racks
(plate or silver)
❏ 0.5, 2, 4, 6 minute wash timer
OPTIONAL ACCESSORY EQUIPMENT
STANDARD EQUIPMENT
Item #_____________
CSI - 11400
COMMANDER 18-5H
AUTOMATIC SINGLE TANK
DOOR TYPE WAREWASHER &
TRAY/UTENSIL WASHER
6245 State Road
Philadelphia, PA 19135-2996
215-624-4800
215-624-6966 FAX
800-344-4802
www.insingermachine.com
DESIGN
Automatic door type, single tank dishwasher with timed wash and
rinse cycle. Fully automatic operation with power on/off button. A
selector switch allows you to start the wash cycle with a manual
start button or by closing the door. Capacity is 60 - 20” X 20” racks
per hour, or 1500 dishes per hour. The 18-5H can also handle mixer
agitators, 18” X 26” sheet pans, utensils and mixing bowls up to
60 quarts! Designed for straight through operation. Corner model
available for right angle operation.
● Space saving compact design
● Door safety switch
● Detergent connection provision
● Fully automatic operation
● Single scrap screen design
● Non-proprietary commercially
available pump motor
● Easily removable pump
suction strainer
● Tank heat: 5KW electric
immersion heater or
steam injector (6KW corner)
● SureFireTM Start-Up and
Check-Out Service
● Vacuum breaker
● Capillary thermometer for wash
● In-line thermometer for final rinse
● Manual start button
● Selector switch
● Single point electrical connection:
motor, controls, heater and
built-in booster (only)
● Top-mounted NEMA 12
control panel
● “Easy Clean” front-mounted
wash tank
● Manifold cleanout brush
● Inspection door
● S/S frame, legs and feet
● S/S front panel
● Automatic tank fill
● Low water protection
● Override switch for deliming or
extended wash cycle
● Vent fan connection provision
● End caps/pipe plugs secured to
prevent loss

Note: For all rough in connections see Installation and Layout Detail Drawing.
SPECIFICATIONS
CONSTRUCTION - Hood and tank constructed of 16 gauge type 304 S/S. Hood unit of all welded seamless construction. S/S
frame, legs and feet. All internal castings are non-corrosive lead free nickel alloy or bronze.
DOORS - A front inspection/cleanout door and two simultaneously opening operating doors. Operating doors have fingertip
control, balanced by externally mounted springs. (Corner model available with 2 doors at right angles.) All doors have easy-glide
strips. Extra large die formed type 304 S/S doors ride in all S/S channels. A triple ply leading edge on the door channels made of
S/S.
PUMP - Centrifugal type “packless” pump with a brass petcock drain. Construction includes ceramic seal and a balanced cast
impeller on a precision ground stainless steel shaft. All working parts mounted as an assembly and removable as a unit without
disturbing pump housing. One 2 HP motor, standard horizontal C-face frame, drip proof, internally cooled with ball-bearing construction.
CONTROLS - Top-mounted control cabinet, NEMA 12 rated, housing motor controls and overload protection, transformer,
contactors and all dishwasher integral controls. All controls safe low voltage 24 VAC.
SPRAY SYSTEM - Wash and rinse spray systems made of type 304 stainless steel pipe threaded into cast hub
assemblies. Upper and lower wash and rinse spray assemblies are removable without the use of tools.
WASH - 2 power spinning wash arms above and 2 power spinning wash arms below. On top, each wash arm is designed with
8 nozzles (16 total). On the bottom, each wash arm is designed with 4 slots (8 total). The slots are precision milled for water
control and produce a fan spray.
FINAL RINSE - 2 power spinning rinse arms above and 2 power spinning rinse arms below. On top, each rinse arm is designed
with 2 nozzles (4 total). On the bottom, each rinse arm is designed with 4 nozzles (8 total). The nozzles produce a fan spray reduc-
ing water consumption, maximizing heat retention.
DRAIN - Drain valve externally controlled. Overflow assembly with skimmer cap is removable without use of tools for drain line
inspection. Heater protected by low water level control.
Capacity
per hour
Final rinse
consumption
at 20 psi min.
Exhaust hood
requirement Peak rate drain flow
Shipping
weight
Current draw
amps Steam Electric
w/o booster
Tank capacity Motor size Electric usage
Final rinse
peak flow
at 20 psi min.
60 racks
1500 dishes
75-150 meals
47 gals./hr.
0.8 gal./rack 9 gals./min. 600 lbs.
6.4 gals. 2 hp (wash)
5.0 kw wash tank (straight)
6.0 kw wash tank (corner)
13.5 kw b.i. booster 40 ° or 70 ° rise
6.0 kw rem. booster 40 ° rise
12. 0 kw rem. booster 70 ° rise
4.25 gals./min.
Steam consumption
at 20 psi min.
100 CFM
208/1/60 .......................13.7 ................... 37.7 ...........................95.7 ............................. 42.5 ..............................100.5
208/3/60 ........................ 8.0 ................... 21.9 ...........................59.4 ............................. 24.6 ................................62.1
240/1/60 .......................11.9 ................... 32.7 ...........................89.0 ............................. 36.9 ................................93.2
240/3/60 ........................ 7.2 ................... 19.2 ...........................51.7 ............................. 21.6 ................................54.1
380/3/50 ........................ 4.4 ................... 12.0 ...........................32.5 ............................. 13.6 ................................34.1
480/3/60 ........................ 3.6 ..................... 9.6 ...........................25.8 ............................. 10.8 ................................27.0
COMMANDER 18-5H
CSI - 11400
Electric w/
built-in booster
Electric w/o
booster - corner
Electric w/ built-in
booster - corner
3M 09/07 PRINTED IN USA
Information and specifications subject to change without notice
18 lbs./hr tank (straight)
22 lbs./hr tank (corner
24 lbs./hr booster 40° rise
43 lbs./hr booster 70° rise