Katadyn 2036000 Mini Water Microfilter User manual

Mini Water Microfilter
(Model #2036000)
Mini Replacement Cartridge
(Model #8013632)
GB DE FRA NL DK SWE NOR FIN IT ESP POR

Thank you for choosing a Katadyn portable water microfiltration system. The Katadyn Mini
Microfilter meets industry standards for reduction of bacteria (99.9999%) and protozoan
cysts like Legionella, Giardia and Cryptosporidium (99.99%). As the smallest and lightest
ceramic filter from Katadyn the Mini is ideal for light solo use during travel and dayhiking.
(Figure 11)
Output Barb
Ceramic Element
Housing
Base Cover
Measuring Gauge
Input Hose with Prefilter
Input Barb
(inside housing)
Pump Handle
ORing
Handle Collar
Pump Handle
English

Key Components
Float Output Hose
Input Hose
Prefilter
(Figure 21)
Product Setup
The Mini requires minimal set up. For best results, try out the Mini before first field use to familiar
ize yourself with its operation.
1) Connect Hoses
Remove the plastic caps from the input and output barbs; retain for storage. Connect input
hose (hose with prefilter) to input barb at base of pump housing. Connect out put hose to
out put barb on top of cartridge. Connect the EasyFill Bottle Adaptor to the end of the out
put hose. (Figures 11, 21, 22)
2) Flush System
Important: Before first use, flush system by pumping approximately 0.5 litres of water
through the unit to remove harmless ceramic dust. See following section on Normal
Operation on how to filter water.
Normal Operation
1) Place input hose in untreated water source. Adjust the float to keep prefilter off the bottom
and away from sediment.
2) Place the output hose into a clean water container*. (Figure 22)
3) Hold the filter vertically and begin pumping the handle in a slow, steady manner. Make sure
the input hose is not kinked.
X > Z
X > Z
Z
Z
X
X
-
(Figure 22) (Figure 23)
Output Barb
Measuring
Gauge
Ceramic
Element
GB

4) After filling water container with filtered water, remove output hose from container and
input hose from water source. Continue pumping to remove remaining water from pump
body.
5) Stow input hose inside pump body and store Mini inside the carry bag.
*Note: Before each use, flush and discard a small amount (5 – 10 strokes) of water to remove stale taste.
Field Performance Tips
The Katadyn Mini is designed to remove bacteria and protozoan cysts such as
Legionella, Giardia and Cryptosporidium. To extend ceramic life, always use the best
water source available. Keep the intake prefilter clean and off the bottom. In heavy sediment con
ditions, wrap a coffee filter or bandanna around the intake prefilter. Where possible, place untreat
ed water in container and wait for sediment to settle out until water appears clear  then filter from
water above the sediment.
Maintain your Katadyn water system to keep it operating smoothly.
1) If handle is hard to push:
Clogged filter pores. If the filter pores of the ceramic are clogged the ceramic needs to
be cleaned. Never use force when pumping. Remove the element by turning it counter
clockwise as far as it will go and lifting it from the housing. Regenerate the ceramic by
brushing under running water with the supplied cleaning pad until the light, original ceram
ic colour appears again. When reassembling hold output barb towards logo on pump hous
ing and turn clockwise as far as it will go while pushing down.
Lubricate pump handle oring. Silicone lubricant is provided with your new unit.
Remove handle collar and handle. (Figure 11) Clean excess buildup from black rubber o
ring on bottom of handle. Place a small amount of silicone lubricant all the way around the
oring. Reassemble.
2) If unit pumps easily, but no water flow:
Make sure prefilter is submerged.
Make sure that intake hose is not blocked or pinched.
Hold the filter vertically until water flows.
3) Prefilter: Rinse the prefilter in water to remove any particles that may be caught in the
strainer.
4) Storage: Your Katadyn water system comes with a carry bag for storage. To pre
vent the possibility of cross contamination, stow input hose inside pump body to
avoid contact with the output hose.

LongTerm Storage (After Your Trip Is Over)
Store the Mini filter as follows:
1) Remove ceramic filter and brush it under running water with the supplied cleaning pad.
Allow to airdry completely.
2) Put ceramic filter back into housing.
3) Grease orings with silicone lubricant provided.
4) Stow input hose inside pump body and store Mini inside the carry bag.
Note: When removing unit from longterm storage, flush the system with one litre of water
to remove any stale tasting water.
Ceramic Capacity
Ceramic capacity depends on water quality. The dirtier the water the more often you will have to
clean the element. This reduces the capacity of approx. 2’000 gallons (7’000 litres). If the gap of
the measuring gauge fits over the ceramic it is time to replace the filter. (Figure 23) Inspect the
ceramic for cracks after cleaning, if you dropped the filter or if you had freezing temperatures. If the
filter shows cracks it will no longer protect you from microorganisms.
Ceramic Installation
Replacement filter elements are available from the dealer where you purchased your Katadyn Mini.
1) Remove output hose from output barb. Remove the element by turning it counterclockwise
as far as it will go and lifting it from the housing.
2) Remove new ceramic element from packaging.
3) Insert new ceramic housing by holding output barb towards you and turning clockwise as far
as it will go while pushing down.
4) Reattach output hose to output barb.
5) Flush ceramic element by pumping and discarding the first litre.
GB

When You Travel Abroad, Camp or Backpack…
…you run a risk of illness ranging from the inconvenience and discomfort of diarrhoea to more
serious illnesses caused by protozoan cysts (i.e., Legionella, Giardia, Cryptosporidium), viruses
and bacteria.
The microorganisms that cause these diseases are often found in the food and water you consume.
Lakes, streams and the local water supply may be contaminated.
To minimize the risk of contracting these illnesses, we suggest that you consult with your physician,
state health department or travellers’ clinic 46 weeks before you depart.
And while you are travelling…
• Make sure that prepared food is thoroughly cooked.
• Select noncooked foods (fruits, nuts, etc.) that have intact shells or skins, and
clean your hands before peeling the food.
• Wash your hands with soap and water thoroughly and often, especially
before you eat. Filter all drinking water with your Katadyn Mini Water
Microfilter.
The Katadyn Mini Microfilter is an essential piece of outdoor equipment. For questions or sugges
tions, please contact us at [phone].
Limited Warranty
Your Katadyn Mini Microfilter is warranted for two (2) years from the date of purchase against
defects in materials and workmanship. Should your Katadyn Mini prove defective within one year
from the date of purchase, return it to the Katadyn retailer from whom it was purchased. If you
have any questions please contact Katadyn at [phone]. Katadyn, at its discretion, will
replace or repair the damaged item. Please retain your purchase receipt as proof of date pur
chased. This warranty gives you specific legal rights and you may have other legal rights which
vary from state to state.
Contact International:
Katadyn Products Inc.
Birkenweg 4
8304 Wallisellen / Switzerland
[email protected] / www.katadyn.ch