Katadyn Exstream User manual

DIRECTIONS FOR USE
It is a violation of Federal law to use this product in a
manner inconsistent with its labeling.
For short term or limited emergency use only and not
recommended for longterm or routine community
supply application.
For Use Directions See Exstream Personal Water
Purification System Owner’s Manual.
PRECAUTIONARY STATEMENTS
Hazards to Humans & Domestic Animals
CAUTION: This cartridge contains PentaPure® penta
iodide resin. Persons with allergies to iodine, thyroid
problems and pregnant women should consult their
doctor before using this device, because small
amounts of iodine may remain in the treated water.
This device is intended for short term, limited or
emergency use only and is not intended for long
term use.
Print No 8013663/0
®
Active Ingredient:
Iodine*...................................46%
Inert Ingredients.......................54%
*Bound to polystyrene divinyl benzene quarternary
ammonium anion exchange resin.
Keep Out of Reach of Children
CAUTION
See Owner’s Manual for Additional
Precautionary Statements
Net Contents: 1 cartridge (2.8oz.)
Distributed by:
Katadyn North America
9850 51st Ave N.
Minneapolis, MN 55442
1 800 755 6701
EPA Reg. No. 35917372228 EPA Est. 35917MN1
For use with the Katadyn Exstream water purification system as a microbiological
water purifier. Not intended for brackish or salt water.
ViruStat
ViruStat
Microbial Water Purification Cartridge

EXSTREAM
PERSONAL WATER PURIFIER
®
Print No. 8011869/1
Manufactured by:
Katadyn Products Inc.
CH-8304 Wallisellen
Switzerland
Distributed by:
Katadyn North America
9850 51st Ave. N.
Minneapolis, MN 55442
1 [phone]
www.katadyn.com
EPA Reg. No. 35917-3-72228
EPA Est. No. 39444CHE01
Art. No. 8013555
EXSTREAM
PERSONAL WATER PURIFIER
REPLACEMENT CARTRIDGE
VIRUSTAT
Replacement Cartridge
Ersatzfilterkartusche
Cartouche de rechange
Filterpatron
Filterpatronen
Reserve filter
Patruunan
1 x
1 x
1 x
For use in Katadyn Exstream and
Exstream XR Personal Water Bottle
Purifiers.
NET CONTENTS:
1 Virustat Microbial Water Purification
Cartridge consisting of Iodinated Resin
Cell, One-Micron Cyst Filter and Carbon
Prefilter
It is a violation of Federal law to use this
product in a manner inconistent with its
labeling. For short term, limited, or
emergency use only. Not recommended
for long-term or routine community water
supply applications.
For use and directions, see Katadyn
Exstream and Exstream XR owner’s
manual.
®
TM
®
ULTRALIGHT SERIES

(2) (3) (4) (5)
Katadyn Exstream® personal water purification systems eliminate the need to carry or locate
safe water, whether you are hiking, traveling or in an emergency situation. Only Katadyn
Exstream personal water bottle purifiers place the advanced technology of an EPA-registered
microbial purification cartridge into a standard water bottle. The result is a personal
hydration system that provides anti-microbial protection against cysts, bacteria and viruses.
When To Use
Katadyn Exstream personal water bottle purifiers are designed for use with untreated fresh
water sources, such as lakes, rivers and streams. They also provide protection against
waterborne pathogens that may still be present in the tap water of many foreign countries.
Exstream systems are also effective in emergencies, such as floods, hurricanes, earthquakes
or any time service from a municipal water treatment plant fails.
Katadyn Exstream personal water bottle purifiers provide a convenient alternative to pump-
style water purifiers. Because they are designed for personal use, Exstream systems are not
suitable for situations when large volumes of water must be treated.
How They Work
Katadyn Exstream personal water purification systems utilize a multi-stage, modular system.
At the heart of the system is the ViruStat® microbial water purification cartridge. The
ViruStat® uses PentaPure® penta-iodide resin to kill over 99.9999% of waterborne
bacteria, such as Klebsiella terrigena, and 99.99% of viruses, such as Poliovirus type 1 and
Rotavirus Strain SA-11. The ViruStat employs a patented ion-release technology that
dramatically reduces residual iodine, and a special layer of coconut-carbon that further
minimizes any residue. The ViruStat cartridge is preceded by a replaceable 1-micron filter
that removes more than 99.9% of pathogenic cysts, such as Giardia. A Prefilter is installed
below the cyst filter to remove sediment and organic contaminants.
Please read the following instructions carefully for maximum performance from your Katadyn
Exstream personal water purification system. Failure to follow the instructions found in this
guide may result in unsafe drinking water.
Key Components
ViruStat
Cyst Filter
Carbon Prefilter
Bottle
Important Notes
1. In order to be purified, water must pass through the ViruStat® cartridge. The flow rate
is slower than an ordinary sports water bottle in order to ensure complete purification.
2. New and stored units must be preconditioned. See section on Preconditioning the
System.
3. Squeeze and sip using continuous pressure. Do not pump. You will notice a 2-4 sec
ond pause after squeezing, like using a long straw, before water flows.
4. Always hold bottle upright when drinking. Water will not pass through the cartridge if
bottle is upside down or at an angle.
Product Set-Up
1. Rinse inside of bottle
2. Flush Prefilter
Attach Carbon Prefilter to Bottle Cap. Fill bottle with tap water. Install Bottle Cap on bottle
and tighten. Squeeze bottle firmly with both hands until 1/2 bottle of water has been run
through the system. Remove Bottle Cap.
3. Assemble the cartridge
Remove the red label from the top of the Virustat (Figure 2). Attach
the Cyst Filter to the bottom of the ViruStat and the Prefilter to the
bottom of the Cyst Filter. Gently twist each component while pushing
it on. Make sure ALL O-rings and components are fully seated and
assembled. The cartridge must be assembled in this way to ensure
purification in all water conditions. Firmly twist and push the car-
tridge into the bottle cap (Figure 3).
1. Prime - Fill the bottle with water to the fill line (indicated on outside of bottle). Insert car-
tridge/bottle cap into bottle. Turn bottle cap clockwise until tight. Squeeze bottle firmly with
both hands to start water flow. Repeat until two bottles of water have been run through the
system. While priming, keep bottle as full as possible. Flow rate will improve once the sys-
tem is fully primed.
2. Again, fill the bottle with water to the fill line. Insert cartridge/bottle cap into bottle. Turn
bottle cap clockwise until tight. Allow to sit for two hours prior to use.
1. Fill the bottle with water to the fill line (Figure 4). Remember, the clearer the water, the
longer the Cyst and Prefilter will last.
2. Insert cartridge/bottle cap into bottle.
Turn bottle cap clockwise until tight.
3. Open bite valve. Note: The bite valve has two
positions. Pull the bite valve out to open. Push
it in to close (Figure 5). Do not remove bite valve.
4. Hold the bottle upright when drinking. Squeeze and
sip using continuous pressure.
Open
Closed
Thank you for choosing a Katadyn Exstream
Personal Water Purification System Pre-Condition the System - (before each use)
Normal Operation (After Pre-Conditioning)
Figure 1
Figure 2
Figure 3 Figure 5
Figure 4
Bite Valve
IMPORTANT!
Remove Safety Seal!
Fill Line
Bottle Cap
8014248_0 Manual Exstream New.qxd 3/10/2004 9:52 AM Page 1

(6) (7) Print No: 8014248/0
The ViruStat® microbial purification cartridge is for use with the Exstream or Exstream XR
personal portable water purification system as a microbiological water purifier. Each
replaceable ViruStat microbial purification cartridge will treat up to 100 liters (26 gallons)
of water.
Changing the Cyst Filter
When water flow becomes restricted, use the following steps to change the Cyst Filter:
a. Remove the Cartridge/Bottle Cap from the bottle.
b. Remove the Cyst Filter from the bottom of the ViruStat cartridge and the Prefilter from
the bottom of the Cyst Filter.
c. Gently twist and push the new Cyst Filter onto the ViruStat cartridge (see figure 1).
d. Gently twist and push the Prefilter onto the Cyst Filter.
f. Put Cartridge/Bottle Cap back on bottle.
Changing the ViruStat Microbial Purification Cartridge
After 100 liters (26 gallons) use the following steps to change the ViruStat® cartridge.
a. Remove the Cartridge/Bottle Cap from the bottle.
b. Remove the ViruStat microbial purification cartridge with cyst filter and prefilter from
the cap. Discard cartridge components in trash receptacle.
c. Flush Prefilter (see step 2 of product set-up on page 4).
d. Assemble the Cartridge (see step 3 of product set-up on page 4).
e. Follow the Pre-Conditioning procedure on Page 5.
Cartridge Installation
Wash and dry the inside of the Exstream bottle thoroughly before using and regularly
during heavy periods of use. If using with safe water and without the ViruStat® cartridge,
the bottle must be completely disinfected to prevent contamination from previous contact
with contaminated water. Your Exstream bottle and cap are dishwasher safe (without the
cartridge). Do NOT use soap to clean the ViruStat cartridge, the cyst filter or the Prefilter.
Before storage, remove excess water from the ViruStat cartridge by disassembling all three
components. Shake out excess water. Allow the components to dry thoroughly and store
them in a cool, dry place or in a refrigerator (not the freezer section). Do NOT allow the
ViruStat to freeze with water in the cartridge. Wash and dry bottle. Store bottle empty
(without the ViruStat cartridge, Cyst Filter or Prefilter installed) with the cap on. Wash well
and follow conditioning instructions before resuming use. Replace a used Cyst Filter when
taking the Exstream system out of prolonged storage.
Do NOT use with carbonated or flavored beverages, as they may damage the ViruStat
microbial purification cartridge.
IMPORTANT
Please refer to the Important Notes and the Product Set-Up before using.
Cleaning And Storage
Your Katadyn Exstream Personal Water Purifier is warranted for one (1) year from the date
of purchase against defects in materials and workmanship. Should your Katadyn Exstream
Personal Water Purifier prove defective with one year from the date of purchase, return it
to the Katadyn retailer from whom it was purchased. If you do not receive a satisfactory
resolution, contact Katadyn Customer Relations at 1-800-755-6701 for service assistance.
Katadyn, at it's discretion, will replace or repair the damaged item. Please retain purchase
receipt as proof of date purchased. This warranty gives you specific legal rights and you
may have other legal rights which vary from state to state.
Limited Warranty
Exstream Water Bottle Purifier
Exstream XR Water Bottle Purifier
ViruStat®Replacement Cartridge
(Model # 8011555)
Hazards to Humans & Domestic Animals
CAUTION
This cartridge contains PentaPure® penta-iodide resin. Persons with allergies to iodine,
thyroid problems and pregnant women should consult their doctor before using this device,
because small amounts of iodine may remain in the treated water.
This device is intended for short term, limited or emergency use only and is not intended for
long term use.
Under the rigid U.S. EPA Guide Standard and Protocol for Testing Microbial Water Purifiers,
the Exstream system's long-lasting, replaceable ViruStat microbial purification cartridge,
killed or removed:
o More than 99.9999% of waterborne bacteria (Klebsiella terrigena)
o More than 99.99% of waterborne viruses (Poliovirus type 1 and Rotavirus Strain
SA-11)
o More than 99.9% of waterborne protozoa (Giardia)
o Bad tastes and odors.
Precautionary Statements
Contact North America:
Katadyn North America
9850 51st Avenue North
Minneapolis, MN 55442 / USA
1-800-755-6701
[email protected] / www.katadyn.com
Contact International:
Katadyn Products, Inc.
Birkenweg 4
8304 Wallisellen / Switzerland
[email protected] / www.katadyn.ch
8014248_0 Manual Exstream New.qxd 3/10/2004 9:52 AM Page 2