Kenwood P-110 User manual

Deze download wordt u gratis aangeboden door Pick-upnaalden.nl
Web : www.pickupnaalden.com
Email : [email protected]
Facebook : www.facebook.com/pickupnaalden
Twitter : twitter.com/Pickupnaalden
Google+ : https://plus.google.com/+FCaris_pickupnaalden

STEREO AUTOMATIC TURNTABLE SYSTEM
P-110
SERVICE MANUAL
© 1998-7/B51-5453-00 (K/K) 3915
P-11098.12.1510:57 y[W 1

2
P-110
1. Speed adjustment
First, adjust the 33 RPM by 33 trimming pot. then the 45 RPM by
trimming pot in the motor from bottom case with the stroboscopic
disk.
1.
33rpm
MM.AMP
OFF
ON
33RPM
45RPM
ADJUSTMENT
Note : PCB figure is not available in this manual.
P-11098.12.1510:57 y[W 2

+B LINE
-B LINE
1u50
C7
+
R2
1K R3 470
2
3
8
4
1C6
+
3.3u50 R8 1K
100K
R18
4.7K
R1
100P
C2
390K
R6
33K
R5
2200P
C4 8200P C3
100K
R7
330
R4 10u25
C1
+
6
57
C8
100P
2200P
C10 C11
8200P
R14
390K33K
R13
C5
1u50
+
R9
1K
R11
470 3.3u50
C13
+1K
R16
4.7K
R10 R20
100K R17
100K
R19
100K
10u25330
R12 C9
+
ON
OFF
L IN
GND
R IN
Lch
Rch
220u16
C18
+
220u16
C17
+
10u25
C15
+
100
R21
0.022
C14
GND
IN OUT
T.F.
115
33 1/3
r.p.m
45
r.p.m
33 45 WHT
GND
+B
BLK
250mA
FUSE
1000u16
C16
+BLU
BLU
AC10.5V
BRN
BLU
AC CORD
RED +13.6V+13.6V
+13V +9V
+13.6V
+13.6V
+13.6V
+8.6V +8.6V +8.6V
+8.6V
+8.6V
100K
R15
L OUT
GND
R OUT
BLU
0V
240V
240V
115
T.F. BRN
BLU
100V
AC120V/240V
BRN AC CORD
GND LINE
SIGNAL LINE
+B
-B
M.M. AMP
(2/2)
SW1 OUTPUT
(PIN CORD)
M.M. AMP Lch
Rch
D5
D2 D1
D4 D3
SW3
SPEED
(SW)
SPEED ADJ.
SW2
POWER SW
(LEAF SW)
IC1
(1/2)
IC1
SW4
IC1 : NJM4558L
IC2 : NJM78L09A
D1-4 : 1N4002
M.M.
CARTRIDGE
IC2
MOTOR ASS'Y
TRANSFORMER AC POWER P.C.B.
P-110
POWER
EQ MM AMPLIFIER
AC POWER P.C.B.
TRANSFORMER
POWER
(OTHER)
(M) TYPE
8.6V
13.6V
9.0V13.0V
7
2
1 3 5
4
6
Y21-3360-00 P-110
CAUTION: For continued safety, replace safety critical components only with
manufacturer's recommended parts (refer to parts list). indicates safety critical
components. For continued protection against risk of fire, replace only with same type and
rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance
measurements shall be carried out (exposed parts are acceptably insulated from the
supply circuit) before the appliance is returned to the customer.
The DC voltage is an actual reading measured with a high
impedance type voltmeter at 33-1/3 r. p. m. mode. The
measurement value may vary depending on the measuring
instruments used or on the product.
NTM4558L NJM78L09A
ABDCE
P-11098.12.1510:57 y[W 3

604
645
676 610
BM 651
612x2
671 640
790
613
603
630
644
685
618
619
615
605
672
SW2
652
601 680
665
601
602
650
P-110
650
660
SW3
661 642 617
670
674
673
616
654
677
643
611
647
791
641
753
ø3x10
ø3x12
ø3x10
ø3x5
ø3x10
ø2.6x8
: N47-3010-45
: N89-3012-46
: N89-3010-46
: N91-3005-46
: N91-3010-46
: N89-2008-46
: N09-3478-08
A
B
C
D
E
F
G
Dx2
A
A
E
E
F
D
E
C
720
C
E
Gx3
Bx2
B
Bx2
625
614
(BOTTOM VIEW)
626
624
B
4
EXPLODED VIEW
P-110
1
2
3
A
Parts with exploded view numbers larger than 700 are not supplied.
700
P-11098.12.1510:57 y[W 4

5
P-110
PARTS LIST
601 2B, 3B ✽A03-0297-08 CABINET
602 3B ✽A40-1052-08 BOTTOM PLATE
603 2B ✽A52-0351-08 MOTOR COVER
604 1B ✽A53-2083-08 DUST COVER ASSY
605 2A ✽A60-1566-08 PANEL ASSY
- B46-0093-53 WARRANTY CARD X
- B46-0191-03 WARRANTY CARD J
- B46-0310-03 WARRANTY CARD ET
-✽B60-4037-08 INSTRUCTION MANUAL(JPN) J
-✽B60-4038-08 INSTRUCTION MANUAL(ENG) KP
-✽B60-4039-08 INSTRUCTION MANUAL(FRN) KPE
-✽B60-4040-08 INSTRUCTION MANUAL(SPN) EM
-✽B60-4041-08 INSTRUCTION MANUAL(TWN) M
-✽B60-4043-08 INSTRUCTION MANUAL(GN/NT/IL) E
610 1A ✽D02-0139-08 TURNTABLE PLATTER ASSY
611 2B ✽D10-3838-08 RETURN LINK,PT5310803
612 1B ✽D10-3839-08 HINGE ASSY
613 2B ✽D10-3840-08 LEVER CUING
614 2B ✽D10-3841-08 CUING BASE
615 2A ✽D10-3842-08 WIPER REJECTION,PT5310901
616 3A ✽D10-3843-08 LINK RETURN ASSY
617 3A ✽D10-3844-08 RETURN LINK,PT5310802
618 2A ✽D13-1906-08 SUPER GEAR A
619 2A ✽D21-1925-08 SPINDLE SHAFT
BM 2A ✽D16-0724-08 BELT
624 1A E03-0115-05 AC ADAPTER M
625 3B E30-2649-08 AUDIO CORD
626 3B ✽E30-2896-08 AC POWER CORD KP
626 3B ✽E30-2897-08 AC POWER CORD E
626 3B ✽E30-2898-08 AC POWER CORD X
626 3B ✽E30-2899-08 AC POWER CORD T
626 3B ✽E30-2900-08 AC POWER CORD M
626 3B ✽E30-2901-08 AC POWER CORD J
630 2A ✽F07-1654-08 STYLUS COVER
640 2B ✽G01-4090-08 COMPRESSION SPRING,SP6711002
641 2B ✽G01-4091-08 COMPRESSION SPRING,SP5311005
642 3A ✽G01-4092-08 COMPRESSION SPRING,SP5310701
643 2A ✽G01-4093-08 COMPRESSION SPRING,K133-8
644 2A ✽G11-2425-08 MOTOR CUSHION
645 1A ✽G16-0924-08 TURNTABLE SHEET
647 2B ✽H20-0604-08 PROTECTION COVER
-✽H10-7521-08 POLYSTYRENE FOAMED FIXTURE(L) JKPEM
-✽H10-7522-08 POLYSTYRENE FOAMED FIXTURE(R) JKPEM
-✽H10-7523-08 POLYSTYRENE FOAMED FIXTURE(L) TX
-✽H10-7524-08 POLYSTYRENE FOAMED FIXTURE(R) TX
-✽H50-3145-08 ITEM CARTON CASE M
-✽H50-3146-08 ITEM CARTON CASE JKPE
-✽H50-3147-08 ITEM CARTON CASE TX
650 3A ✽J02-1432-08 INSULATOR
651 2B ✽J91-0503-08 TONEARM ASSY
L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia
Y : PX(Far East, Hawaii) T : Europe E : Europe G : Germany V : China(Shanghai) J :
Y : AAFES(Europe) X : Australia Q:Russia H:Korea M : Other Areas indicates safety critical components.
L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia
Y : PX(Far East, Hawaii) T : Europe E : Europe G : Germany V : China(Shanghai) J :
Y : AAFES(Europe) X : Australia Q:Russia H:Korea M : Other Areas indicates safety critical components.
652 2B ✽J99-0807-08 ARM ELEVATION
654 2B ✽J19-5963-08 TONEARM REST ASSY TWP4003602
660 3A ✽K29-7463-08 KNOB,SPEED
661 3A ✽K29-7464-08 KNOB,REJECT
665 2B ✽L07-2645-08 POWER TRANSFORMER KP
665 2B ✽L07-2646-08 POWER TRANSFORMER XTE
665 2B ✽L07-2647-08 POWER TRANSFORMER M
665 2B ✽L07-2648-08 POWER TRANSFORMER J
670 3A ✽N14-0201-08 NUT
671 2B ✽N19-1469-08 WASHER WS143205P
672 2A ✽N19-1470-08 WASHER WS127705P
673 3A ✽N19-1471-08 WASHER WS1843151Z
674 3A ✽N19-1472-08 SPRING WASHER WS0704091Z
676 1A ✽N29-0291-08 E RING
677 2A ✽N29-0292-08 CSB RING CSB74
G2A✽N09-3478-08 SCREW, MOTOR
SW2 3B ✽S74-0085-08 LEAF SWITCH,POWER,SW11403
SW3 3A ✽S68-0110-08 PUSH SWITCH,SPEED,SW12203
SW4 ✽S62-0082-08 SLIDE SWITCH,VOLTAGE,SWEV12 M
680 2B ✽T42-0928-08 MOTOR ASSY
685 1A ✽W01-0959-08 EP ADAPTER
C1 CE04KW1E100M ELECTRO 10UF 25WV
C2 CK45FB1H101K CERAMIC 100PF K
C3 CQ92FM1H822J MYLAR 8200PF J
C4 CQ92FM1H222J MYLAR 2200PF J
C5 CE04KW1H010M ELECTRO 1.0UF 50WV
C6 CE04KW1H3R3M ELECTRO 3.3UF 50WV
C7 CE04KW1H010M ELECTRO 1.0UF 50WV
C8 CK45FB1H101K CERAMIC 100PF K
C9 CE04KW1E100M ELECTRO 10UF 25WV
C10 CQ92FM1H222J MYLAR 2200PF J
C11 CQ92FM1H822J MYLAR 8200PF J
C13 CE04KW1H3R3M ELECTRO 3.3UF 50WV
C14 CK45FB1H223K CERAMIC 0.022UF K
C15 CE04KW1E100M ELECTRO 10UF 25WV
C16 CE04KW1C102M ELECTRO 1000UF 16WV
C17, 18 CE04KW1C221M ELECTRO 220UF 16WV
FUSE ✽F53-0175-08 FUSE,250MA
- J13-0075-08 FUSE CLIP
SW1 ✽S74-0086-08 SLIDE SWITCH,EQ SW,SWSBE2210
D1~5 1N4002 DIODE
IC1 NJM4558L IC(OP AMP X2)
IC2 NJM78L09A IC(VOLTAGE REGULATOR/ +9V)
✽New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert. 2
Ref. No Add-
ress
New
Parts
Parts No. Description Desti-
nation Re-
marks
✽New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert. 1
Ref. No Add-
ress
New
Parts
Parts No. Description Desti-
nation Re-
marks
P-110
EQ AMP
P-11098.12.1510:57 y[W 5

P-110
SPECIFICATIONS
14-6,Dogenzaka 1-chome, Shibuya-ku, Tokyo, 150-8501 Japan
KENWOOD SERVICE CORPORATION
P.O BOX 22745, 2201 East Dominguez St., Long Beach, CA 90801-5745, U.S.A.
KENWOOD ELECTRONICS CANADA INC.
6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8
KENWOOD ELECTRONICS LATIN AMERICA S.A.
P.OBOX55-2791,Piso 6plaza Chase,Cl. 47y Aquilinode laGuardia Panama,Republic dePanama
KENWOOD ELECTRONICS BRASIL LTDA.
Av Indianópolis, 628, 04062-001 Planalto Paullsta São Paulo-SP-Brasil
KENWOOD ELECTRONICS U.K. LIMITED
KENWOOD House, Dwight Road, Watford, Herts., WD1 8EB., United Kingdom
KENWOOD ELECTRONICS BELGUM N.V.
Meachelsesteenweg 418, B-1930 Zaventem, Belgium
KENWOOD ELECTRONICS DEUTSCHLAND GMBH
Rembrücker Str. 15, 63150 Heusenstamm, Germany
KENWOOD ELECTRONICS FRANCE S.A.
13 Boulevard Ney, 75018 Paris, France
KENWOOD ELECTRONICS ITALIA S.p.A.
Via G. Sirtori, 7/9 20129, Milano, ltaly
KENWOOD IBÉRICA S.A.
Bolivia, 239-08020 Barcelona, Spain
KENWOOD ELECTRONICS AUSTRALIA PTY. LTD.
(A.C.N. 001499 074)
P.O Box 504, 8 Figtree Drive, Australia Centre, Homebush, N.S.W. 2140, Australia
KENWOOD & LEE ELECTRONICS, LTD.
Unit 3712-3724, Level 37, Tower 1, Metroplaza, 223 Hing Fong Road, Kwai Fong N.T., Hong Kong
KENWOOD ELECTRONICS GULF FZE
P.O.Box 61318, Jebel Ali, Dubai, U.A.E.
KENWOOD ELECTRONICS SINGAPORE PTE LTD.
No. 1 Genting Lane #02-02, KENWOOD Building, Singapore, 349544
KENWOOD ELECTRONICS (MALAYSIA) SDN BHD.
#4.01 Level 4, Wisma Academy Lot 4A, Jalan 19/1 46300 Petaling Jaya Selangor Darul Ehsan
Malaysia
KENWOOD ELECTRONICS (THAILAND) CO., LTD.
573/111 Soi Ramkhamhaeng 39, Ramkhamhaeng Road, Wangthonglang, Bangkapi, Bankok
10301 Thailand
Note:
Component and circuit are subject to modification to insure best
operation under differing local conditions. This manual is based on
Europe (E) standard, and provides information on regional circuit
modification through use of alternate schematic diagrams, and
information on regional component variations through use of parts
list.
Motor and turntable
Drive system..................................................... Belt-drive system
Motor .................................................................... DC servo motor
Turntable platter............................................... 29.5 cm diameter
Speeds ......................................... 2 speeds; 33-1/3 and 45 rpm.
Wow & flutter .................................... Less than 0.05 % (WRMS)
S/N (rumble) ................................................. DIN : 65 dB (DIN B)
Tonearm
Type.................................................. Integrated straight tonearm
Effective arm length........................................ 215 mm (8-7/16")
Cartridge
Type.................................................................................. MM type
Stylus................................................. N-76 with 0.6 mill diamond
Frequency response .......................................... 20 Hz to 20 kHz
Output voltage............................... 2.5 mV (1kHz, 3.54 cm/sec.)
Equalizer amplifier
Output voltage
(RIAA EQ ON)....................... 200 mV (1kHz, 3.54 cm/sec.)
General
Power consumption ................................................................ 4 W
Dimensions ............................................. W: 400 mm (15-3/4")
H : 103 mm (4-1/16")
D : 380 mm (14-15/16")
Weight (net) .............................................................. 3.0 kg (6,6lb)
Note:
KENWOOD follows a policy of continuous advancements. For
this reason specifications may be changed without notice.
P-11098.12.1510:57 y[W 6