Korenix JetBox 9462-w User manual











JetBox9462‐w
UserManual
Hardware

www.korenixembedded.com















Copyright©2010KorenixTechnologyCo.,Ltd.
Allrightsreserved.
Reproductionwithoutpermissionisprohibited.

Informationprovidedinthismanualisintendedtobeaccurateandreliable.However,
theoriginalmanufacturerassumesnoresponsibilityforitsuse,orforany
infringementsupontherightsofthirdpartiesthatmayresultfromitsuse.
Thematerialinthisdocumentisforproductinformationonlyandissubjectto
changewithoutnotice.Whilereasonableeffortshavebeenmadeinthepreparation
ofthisdocumenttoassureitsaccuracy,Korenixassumesnoliabilitiesresultingfrom
errorsoromissionsinthisdocument,orfromtheuseoftheinformationcontained
herein.
Korenixreservestherighttomakechangesintheproductdesignwithoutnoticeto
itsusers.


KorenixisaregisteredtrademarkofKorenixTechnologyCo.,Ltd.
Allothertrademarksorregisteredmarksinthemanualbelongtotheirrespective
manufacturers.


TheadvantageofadoptingKorenixJetBoxseriesisready‐to‐use.Korenixisdevoted
toimprovetheusabilityofembeddedcomputerinindustrialdomain.Besides
operatingsystem,Korenixprovidesdevicedrivers,protocolstacks,systemutilities,
supportingservicesanddaemonstomakesystemintegrationsimple.Further,
Korenixprovidesapplicationdevelopmenttoolkitsforuserstobuilduptheirown
applicationseasily.

ThestylishJetBox9400seriesisanindustriallayer‐3routerwithLinuxcomputing.It
isagatewaytoconnectdifferentnetworkgroups(Ethernet,fieldbus,serialorIO
control)inacomplexnetworkingarchitectureandmanageperipheralsatthe

front‐endsitethroughitsLinuxprogramsorJavaapplications.Itisreliable(network
redundancy,systemrecovery)androbust(passivecooling,protectedagainstthe
dustsandspills,shock&vibrationresistance)toadoptinsevereindustrialvertical
markets,suchastransportation,substation,orhazardousenvironment.

FeatureJetBox9462‐w
ProcessorIntelXscaleIXP435667MHzRISC‐based
Fanless
Systemmemory128MBDDR2RAM
Systemflash32MB
Ethernet10/100Base‐TxRJ45connectorx5
StorageSDcardslotx1
CFcardslotx1
MobileslotminiPCIex1
SIMx1
SerialportRS232/422/485x4(DB37connector)withlong
distanceterminationswitches(internal),default
RS232
USBUSB2.0x3(Host)
USBSupportingdevicesUSBflash,wirelessdongle
DigitalIO8DIO(default8DI),DIorDOisdefinedbycustomers
Consoleport3‐pinheader(RS232interface)
LEDperEthernetport(on
theport)
Link/Activity(Greenon/Greenblinking)
FullDuplex/Collision(Yellowon/Yellowblinking)
LEDperunitPoweron/offx1(Greenon/off)
ResetButtonx1
HWWatchdogtimerGeneratesatime‐outsystemreset,1sec
PowersupplyDC12~48V
PowerConsumption25W
OSsupportEmbeddedLinux2.6.20
ConstructionRuggedAluminumAlloyChassis,IP31protection
ColorSilver
MountingWallmount
Dimensions66.5(H)x250(W)x106.3(D)mm
NetWeight1.07kg

OperatingTemp.‐40~176℉(‐40~80℃)**,5to95%RH
StorageTemp.‐40~176℉(‐40~80℃),5to95%RH
RegulationFCCclassA,CE,UL*
EN55022classA
EN55024
EN61000‐3‐2,3
EN61000‐4‐2,3,4,5,6,8,11
IEC60950
IEC61373*(Railway)
EN50155*(Railway)
EN50121‐4*(Railway)
NEMATS2*(trafficcontrol)
ShockIEC60068‐2‐27(50gpeakacceleration)
VibrationIEC60068‐2‐6(5g/10~150Hz/operating)
MTBFgreaterthan200,000hours@25℃
Warranty5years

*Optional
**SafetyinformationforUL:
‐ MaximumSurroundingAirTemperature65℃
‐ ForuseinPollutionDegree2Environment

JetBox9462‐wappearance
 
JetBox9462‐wmechanicaloutline



TheJetBoxcomeswithaPhoenixconnectorthatcarriesa12~48VDCexternalpower
input.

Pin Power Signal Name
1VCC
2 GND

‐UseCopperConductorsOnly,Tightento4.5lbin
‐Thewiregaugetotheterminalblockshouldbeintherange
between12~28AWG



Thisswitchisusedtoturnthesystempoweronoroff.



TheLEDindicatorsshowtheirActive/Linkstatus(Greenblinking/Greenon)and
Col/Fdxstatus(Yellowon/blinking).


ThisLEDindicatorisusedtoindicatethepoweron/offstatus.
Poweron/off:Greenon/off


StandardRJ‐45jacksockets.

Pin 10/100 Base-T Signal Name
1RX+
2RX-
3TX+
4
5
6TX-
7
8



USBtype“A”femaleconnectorsforUSBperipherals

PinUSBSignalName
1VCC
2DATA‐

3DATA+
4GND



TheJetBoxprovidesoneConsoleport3‐pinconnectorfordebuguse.

Console
1TXD
2RXD
3GND



ThisbuttonisusedtoresettheCPUcausingthesystemrebootorresettothefactory
default.
Press3secondsforsystemreboot.
Press7secondstoresettheJetBoxtothefactorydefault.


ThissocketisusedforthetypeI/IICFCardandreservedforsystemextension.


ThissocketisusedforaSDCardandisfortheusers’applications.Thereisaexternal
blankettocovertheSDcardslot.




TheJetBoxsupports8digitalchannelsanduserscanconfigurethemasdigital
outputsordigitalinputs.Followingistheconnectorpinassignments.(Thedefault
settingisdigitalinput)


Digitalinput
Belowfiguresshow2waystousedigitalinputfunction.Thedigitalinputchannels
cansupportmax.5V.
Dryconnectfordigitalinput

Wetconnectfordigitalinput

DigitalOutput
Belowfigureshowshowtousedigitaloutputfunction.Thedigitaloutputchannels
cansupportmax.3.3V.





TheJetBoxisavailablewithGSM/GPRS/EDGE/3G/HSDPA/HSUPAmoduleviaits
internalminiPCIeconnector(thesignalisthesameasUSBsignal)

PinSignalnameDescriptionInput/OutputActive
State
VoltageLevels
MinTypMax
1NCNo connect
2VCC3.3 V supplyInputPower3.003.303.60
3NCNo connect
4GNDGroundGNDGND
5NCNo connect
6NCNo connect
7NCNo connect
8USIM_PWRUSIM VCC supply Output (1.8 V)Power1.601.801.90
Output (3.0 V)2.703.003.30
9GNDGroundGNDGND
10USIM_DATAUSIM I/O pinInput High (1.8 V)Low1.202.10
Input Low (1.8 V)0.000.63
Output High (1.8
V)
1.301.802.10
Output Low (1.8 V) 0.000.30
Input High (3.0 V)1.953.30
Input Low (3.0 V)0.001.05
Output High (3.0
V)
2.103.003.30
Output Low (3.0 V) 0.000.40
11NCNo connect
12USIM_CLKUSIM clockOutput High (1.8
V)
High1.301.802.10
Output Low (1.8 V) 0.000.47

PinSignalnameDescriptionInput/OutputActive
State
VoltageLevels
MinTypMax
Output High (3.0
V)
1.903.003.30
Output Low (3.0 V) 0.000.60
13NCNo connect
14USIM_RESETUSIM resetOutput High (1.8
V)
Low1.301.802.10
Output Low (1.8 V) 0.000.47
Output High (3.0
V)
2.203.003.30
Output Low (3.0 V) 0.000.70
15GNDGroundGNDGND
16NCNo connect
17NCNo connect
18GNDGroundGNDGND
19NCNo connect
20W_DISABLE#Wireless disableInput HighLow2.303.303.60
Input Low 0.90
21GNDGroundGNDGND
22NCNo connect
23NCNo connect
24VCC3.3 V supplyInputPower3.003.303.60
25NCNo connect
26GNDGroundGNDGND
27GNDGroundGNDGND
28NCNo connect
29GNDGroundGNDGND
30NCNo connect
31NCNo connect
32NCNo connect
33NCNo connect
34GNDGroundGNDGND
35GNDGroundGNDGND
36USB_D-USB data
negative(Low/Full
Input High2.003.003.60
Input Low0.002.00

PinSignalnameDescriptionInput/OutputActive
State
VoltageLevels
MinTypMax
speed)Output High 2.803.303.60
Output Low  0.30
USB data
negative(High
speed)
Input High0.300.44
Input Low0.000.01
Output High 0.360.380.44
Output Low 0.000.01
37GNDGroundGNDGND
38USB_D+USB data
positive(Low/Full
speed)
Input High2.003.003.60
Input Low0.002.00
Output High 2.803.303.60
Output Low  0.30
USB data
positive(High
speed)
Input High0.300.44
Input Low0.000.01
Output High 0.360.380.44
Output Low 0.000.01
39VCC3.3 V supplyInputPower3.003.303.60
40GNDGroundGNDGND
41VCC3.3 V supplyInputPower3.003.303.60
42LED_WWAN#LED driverTri-state
Output Low 0.000.45
43GNDGroundGNDGND
44NCNo connect
45NCNo connect
46NCNo connect
47NCNo connect
48NCNo connect
49NCNo connect
50GNDGroundGNDGND
51NCNo connect
52VCC3.3 V supplyInputPower3.003.303.60




TheSIMconnectorisusedforaSIMcardofmobilenetworkservice.Itis
accompaniedwiththeminiPCIemobilemodule.

PinSignal
name
Descripti
on
8USIM_PWRUSIM VCC
supply
10USIM_DAT
A
USIM I/O
pin
12USIM_CLKUSIM clock
14USIM_RES
ET
USIM reset
20W_DISABL
E#
Wireless
disable
36USB_D-USB data
negative
37GNDGround
38USB_D+USB data
positive
42LED_WWA
N#
LED driver
2,24,39,41,52VCC3.3 V
supply
4,9,15,18,21,26,27,29,34,35,37,40,43,50GNDGround
1,3,5,6,7,11,13,16,17,19,22,23,25,28,30,31,32,33,44,45,46,4
7,48,49,51
NC No connect


TheJetBoxprovides4‐portserialdeviceserver(DB37connector),supportingTCP
server/clientandpairedTCPmodes.


PinFunction PinFunction
1NC20RI2
2DCD221DTR2
3GND22DSR2
4CTS223RTS2
5RXD224TXD2
6RI325DCD3
7DTR326GND
8DSR327CTS3
9RTS328RXD3
10TXD329RI1
11DCD130DTR1
12GND31DSR1
13CTS132RTS1
14RXD133TXD1
15RI034DCD0
16DTR035GND
17DSR036CTS0
18RTS037RXD0
19TXD0

OptionalAccessories
Serialcable:
CM37M9x4‐604‐portmaleDB37tomaleDB9connectioncable,60cm
DB9RS‐232RS‐422RS‐485RS485
Pin(4‐wire)(2‐wire)
1DCDTxD‐(A)TxD‐(A)Data‐(A)
2RxDTxD+(B)TxD+(B)Data+(B)
3TxDRxD+(B)RxD+(B)
4DTRRxD‐(A)RxD‐(A)
5GNDGNDGNDGND
6DSRRTS‐(A)
7RTSRTS+(B)
8CTSCTS+(B)
9CTS‐(A)
Serialcable:

CM37M25x4‐604‐portmaleDB37tomaleDB25connectioncable,60cm

DB25RS‐232RS‐422RS‐485RS485
Pin(4‐wire)(2‐wire)
2TxDRxD+(B)RxD+(B)
3RxDTxD+(B)TxD+(B)Data+(B)
4RTSRTS+(B)
5CTSCTS+(B)
6DSRRTS‐(A)
7GNDGNDGNDGND
8DCDTxD‐(A)TxD‐(A)Data‐(A)
20DTRRxD‐(A)RxD‐(A)
22CTS‐(A)


ThefollowingfigureshowsthememoryarchitectureoftheJetBox.

32MBFlash

Thereis32MByteofFlashROMfortheBootLoaderprogram.

128MBDDR2RAM
TheJetBoxsupports128MBofDDR2SDRAM.TheDDR2SDRAMisarrangedforLinux
2.6ObjectStoreandapplications.

UserscanentertheJetBoxLinuxenvironmentviatheusername:rootandno
passwordisrequired.

login:root
password:(none)

KorenixTechnologyCo.,Ltd.
Businessservice:[email protected],[email protected]
Customerservice:[email protected]
WebSite:http://www.korenixembedded.com,http://www.korenix.com

