Mercado Medic REAL 8100 PLUS EL Assembly instructions

19-05895-01
Created: 191125
Changed: 200528
Doc.no: 19-05895
Revision: 01
PDF versions of our operating and maintenance instructions with magnification options can be found on the website
mercado.se. There you will also find information about accessories that can be mounted on Mercado Medic's chairs as
well as any safety messages to the market, prescription support or recalls of products and accessories.
We reserve the right to make changes to this manual and its contents.
ASSEMBLY INSTRUCTIONS, INSTRUCTIONS FOR
USE AND CARE REAL 8100 PLUS EL
REAL®8100 PLUS EL
Sufficient competence to use this product safely is obtained by carefully
reading these instructions for use and care before using the chair.
TABLE OF CONTENTS
Assembly for use ..................3
Familiarise yourself with your
REAL8100PLUS EL ................3
Important safety information ........4
Cleaning & maintenance ............5
Instructions for disposal ............5
Symbols ..........................5
Warranty .........................6
User manual ......................6
Brake ............................ 6
Seat height. . . . . . . . . . . . . . . . . . . . . . . . 7
Seat tilt........................... 7
Backrest mechanism ............... 7
Armrest .......................... 8
Protractor with rotation release ...... 8
Charging.......................... 9

19-05895-01

19-05895-01
3
Armrest
Loosen the adjustment knobs for the height (1) and for
the width (2) of the armrest. Set the desired level in
height and width. Tighten all adjustment knobs (1 & 2).
Backrest mechanism
Install the backrest mechanism by inserting the back
pole into the back recliner (3) to the desired level.
Adjust the backrest and headrest using the controls (4).
Remember to tighten the adjustment knobs (4) after
adjusting.
FAMILIARISE YOURSELF WITH YOUR REAL8100PLUS EL
1. Adjust the armrests to a suitable height and lock the
armrest by turning the adjustment knob clockwise.
2. Fit the backrest tube in the intended bracket and
lock the adjustment knobs for the height adjustment
of the backrest.
3. Fit the brake lever in the intended bracket (left or
right side). Does not apply to electric brakes.
4. All adjustment knobs must be tightened before
sitting in the chair.
5. The brake on the chair must always be applied when
getting in and out of the chair. The brake must be
checked on a regular basis.
6. Charge the chair according to the enclosed
instructions before using it for the first time (applies
to electrical chairs).
7. The chair must not be used with the back and/or
armrests removed.
Checkpoints before use
For information on adjustments of all the parts of the
chair, see the chapter User manual on page 6-9.
ASSEMBLY FOR USE USER GUIDE
44
3
3
2
1
The chair is now ready for use! >>

19-05895-01
4
IMPORTANT SAFETY INFORMATION
The REAL 8100 PLUS EL chair has replaceable components, accessories and functions with setting options for individual
customisation. The chair must only be used by the person for whom, and for the purpose for which, it is intended. The
chair is intended for indoor use only and must not be used outdoors. The chair must not be exposed to extreme cold or
heat, prolonged sunlight or other radiation. The chair must not be exposed to water, other fluids or chemicals.
Warning! Metal surfaces may become very hot if they are exposed to direct sunshine.
Read this manual carefully before using the chair for the first time.
• REAL8100PLUS EL can affect and be affected by
equipment in its immediate vicinity that generates
electromagnetic fields; e.g alarm systems, power
generators. Mobile phones and similar equipment
can also interfere with the control system. Mercado
Medic AB recommends that such equipment should
not be stored any closer than 3.3 m(~10 ft) from the
chair.
• REAL8100PLUSEL has an electric lifting
mechanism that can lift a person high enough to
cause a risk of falling. If a person cannot get out
of the chair from its highest position, then the
seat height should never be set to higher than
the position at which your feet touch the ground.
The only exception to this is cases where you can
summon help via alarm or telephone.
• NOTE! The electrical functions on
REAL8100PLUSEL chairs may be used for
maximum 10% of the time, maximum 2 minutes
every 20 minutes. The electronics in the chair
measure the activity and shut down the electrical
functions if this limit is exceeded.
• Only electrical equipment from Mercado Medic AB
may be used on the REAL8100PLUSEL.
• Warning! Do not plug any accessory, other than
those supplied by Mercado Medic AB, into the
control system’s contacts.
• The chair must be operated with care. Before
moving off or operating the chair, consideration
must be given to the surroundings. Any pets or
children in the area could be easily run into. The
chair must only be used to sit on and should not be
regarded as a toy by either children or adults.
• REAL8100PLUSEL is approved for transportation/
storage at temperatures of between -25°C and
+60°C(-13°F and 140°F) and up to 90% non-
condensing relative humidity.
• Max user weight, REAL8100PLUSEL 150 kg
(330lbs).
• The REAL 8100 PLUS EL should not be used on any
incline greater than 5 degrees. If the chair is used or
the brake is applied at steeper inclines, it may begin
to slide which may cause the chair to fall over.
• If shipped, the chair must be transported in the
intended cardboard box on a pallet.
• If the chair is transported by car, it must be
strapped in place using straps over both the frame
and the seat, and it should be set to the lowest
possible seat height.
• The chair is tested and approved for use between
+5°C and +40°C(41°F and 104°F) and 15 to 90%,
non-condensing humidity. If the chair has been
stored in an environment outside these limits, the
chair must be left to acclimatise before use in order
to ensure that it can be used safely.
• Repairs and other technical measures may only be
carried out by personnel authorised by EMP Living
LLC.
• Maximum height 2000m(~6500 ft) above sea level.
• The REAL8100PLUSEL must not be moved when
the seat is in the raised position.
• Expected service-life ten (10) years.
• REAL8100PLUSEL can be supplemented with a
variety of accessories. Only accessories supplied
by Mercado Medic should be used. All accessories
must be fitted so that there is no risk of small parts
coming loose. All the cables must be secured with
cable ties to minimise the risk for strangulation.
• Mercado Medic armrests, seats, backrests
and other parts intended for skin contact are
in compliance with the EU Regulation (EC) No
1907/2006 concerning the Registration, Evaluation,
Authorisation and Restriction of Chemicals (REACH).

19-05895-01
5
CLEANING & MAINTENANCE
SYMBOLS
• The chair should be wiped down and kept clean
from dust and dirt.
• The chair should be washed using a disinfectant
with PH 7–12 (concentrated), with the exception of
the padding.
• Artificial leather has to be washed with soapy water
or alternatively wiped off with an alcohol solution;
e.g. disinfectant.
• Leather upholstery requires a little extra
maintenance;
- Spills must be wiped up immediately with a
damp cloth, never use strong cleaning agents.
- Prevent upholstery from coming into contact
with personal care products, such as make-up,
hair gel etc.
- Do not allow pets on leather furniture, their
claws may scratch the leather.
- Avoid direct and prolonged exposure to sunlight,
it may fade the leather in the long run.
• Seat, backrest and other upholstery are not
manufactured in sealed materials for functional
reasons. When reconditioning, upholstery should be
replaced for hygienic reasons.
• The electric lift mechanism should be checked
regularly for dust, dirt and stability: Raise the seat
to its highest position. Clean with a cloth. Do not use
any water or solvents. Then lubricate the cylinder
using a thin layer of Teflon or silicone-based grease.
8-12
6-7
1–4
Combustible:
• Seat
• Back
• Armrest
• Headrest
• Other padded parts sold by Mercado Medic AB
Electronic waste:
• Motors
• Cables
• Control system
Metal:
• Frame
• Electric lifting mechanism
• Gas pistons
• Gas springs
• Seat frame
• Back recliner
• U-bars and armrest mechanism
• Other metal parts in products sold by Mercado
Medic AB
Note! The battery has to be sorted separately.
INSTRUCTIONS FOR DISPOSAL
1. Seat height up/down.
2. Back tilt forwards/
backwards.
3. Back recliner
forwards/
backwards.
4. Activate/release
brake
5. Risk of crushing.
Any risks marked.
6. Warning: Read the
manual before use.
7. Charge connector.
8. Separation of
source materials
9. The product is part
of a recycling rocess.
10. Product classified as
type B applied part
in accordance with
IEC60601-1.
11. Max user weight
12. Time in use for
electrical functions
24VDC