Instruction Manual
XPP-5422B/G
THE XPP-5422B/G IS APPROVED FOR USE
Permissible Nightstick 5422 Flashlight/Floodlight
APPROVAL No. 20-A130001-0
TESTED FOR INTRINSIC SAFETY IN METHANE-AIR MIXTURES ONLY
WARNINGS:
CLASS I DIV 1 GRPS A-D T3
CLASS II & III DIV 1 GRPS E-G T135C
CLASS I ZONE 0 AEx ia IIC T3 Ga
CLASS I ZONE 0 Ex ia IIC T3 Ga
Ex ia op is I Ma
Ex ia op is IIC T3 Ga
Intertek ITS 13 ATEX27837X
IECEx ITS 16.0067X
-20ºC ≤ Tamb ≤ +40ºC
1.5V/Cell AA Alkaline
2575
ID 4003544
INTRINSICALLY SAFE
SECURITE INTRINSEQUE
I M 1 Ex ia op is I Ma
II 1 G Ex ia op is IIC T3 Ga
MSHA approved for use with three AA Duracell Type PC1500, Energizer
Type EN91, and Energizer Type L91 batteries only.
1)
Replace the batteries in fresh air only and replace all batteries at the
same time. Do not mix batteries from different manufacturers or of
different types.
2)
Energizer Lithium (Type L91) batteries are to be replaced by a qualified
technician only.
3)
The Model Nightstick 5422 must not be opened in areas where
permissibility is required.
4)
Conforms to:
ANSI/UL STD 913, ANSI/UL
60079-0, ANSI/UL 60079-11
ANSI/ISA 60079-26
Certified to:
CAN/CSA STD C22.2 No 157
CAN/CSA STD C22.2 No 60079-0
CAN/CSA STD C22.2 No 60079-11
CSA STD C22.2 No 25
INMETRO
Segurança
NCC
Ex ia op is I Ma
Ex ia op is IIC T3 Ga
(-20ºC ≤ Tamb ≤ +40ºC)
15.0286 X
WARNINGS - INTRINSICALLY SAFE
y
y
y
y
y
y
y
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
y
BATTERY INSTALLATION
WARNING: In order to maintain the XPP-5422B/G’s Intrinsically Safe rating,
the only AA batteries certied for use with this light are the Duracell PC1500,
Energizer EN91 or Energizer L91 batteries.
y
y
Warning: To prevent ignition of a hazardous atmosphere, do not remove the
lens bezel or the reector / battery carrier in the hazardous environment.
This task must ONLY be done in an area known to be non-hazardous.
y
y
y
y
y
y
y
OPERATION
THE XPP-5422B/G HAS FOUR SEPARATE LIGHTING MODES:
