Nokia NSW-1 Series User manual

Programmes After Market Services
Technical Documentation
Issue 4 Copyright  Nokia Mobile Phones. All Rights Reserved
SERVICE
MANUAL
[NMP Part No.0275398 + Update 0275410 + Update 0275431 +
Update 0275504]
NSW-1 Series Cellular Phones
NSW-1 Issue 4 03/01

Programmes After Market Services
Technical Documentation
Issue 4 Copyright  Nokia Mobile Phones. All Rights Reserved

Programmes After Market Services
Technical Documentation
Issue 4 Copyright  Nokia Mobile Phones. All Rights Reserved
Amendment Record Sheet
Amendment
No Date Inserted By Comments
10/98 Original
Issue 2 03/99 O Juntunen Introduction: 3 leaves
Issue 2 03/99 Service Tools: BTD3 dummy battery
added; amendment sheet updated;
repaginated.
Issue 3 11/99 J Watson Introduction: 3 leaves
Issue 3 12/99 J Watson Section 02: ACP-8 data added
Issue 3 11/99 J Watson Section 03: UT4S v.5.12 parts list
added; repaginated
Issue 3 11/99 J Watson Section 04: UE4S v.5.0 parts list added;
repaginated
Issue 3 11/99 J Watson Service SW: Wintesla v.5.30 replaced
by v.6.03; repaginated
Issue 3 11/99 J Watson Tuning Instructions: POS flash concept
added. Tuning target tolerance and test-
ing limits amended. Settings for spec-
trum analyzer added within 5.
Issue 3 11/99 J Watson Service Tools: XMS-3, FLS-2D,
SCH-5A, XRC-2 added; repaginated
Issue 3 11/99 J Watson Troubleshooting: Revised; repaginated
Issue 3 11/99 J Watson Nonserviceable Accessories: ACP-8,
XRC-2, DLR-3 RS232, HDC-9P added;
repaginated
Issue 4 04/01 J Fraser Introduction: 3 leaves
Issue 4 04/01 J Fraser Section 02: New variants and colors
added; repaginated
Issue 4 04/01 J Fraser Product Variants: NSW-1NX blue, grey,
SBC blue added; repaginated
Issue 4 04/01 J Fraser HFU-2 and LPS-1/2: Sections incorpo-
rated into Nonserviceable accessories
Issue 4 04/01 J Fraser Tuning: Information update; repaginate

Programmes After Market Services
Technical Documentation
Issue 4 Copyright  Nokia Mobile Phones. All Rights Reserved
NSW-1 Series Cellular Phones
Service Manual – Overall Manual Contents
Service Manual comprising
NSW-1 Series Transceiver booklet comprising
Chapter 1: Foreword
Chapter 2: General Information
Chapter 3: System Module UT4S
Chapter 4: UIF Module UE 4S
Chapter 5: Transceiver NSW-1 variants
Chapter 6: Service Software Instructions
Chapter 7: Tuning Instructions
Chapter 8: Service Tools
Chapter 9: Disassembly/Troubleshooting Instructions
Chapter 10: Non-serviceable Accessories
Chapter 11: CARK-64 Installation Guide
Chapter 12: CARK-91 Installation Guide

Programmes After Market Services
Technical Documentation
Issue 4 Copyright  Nokia Mobile Phones. All Rights Reserved
IMPORTANT
This document is intended for use by qualified service personnel only.
Company Policy
Our policy is of continuous development; details of all technical modifications will be
included with service bulletins.
While every endeavour has been made to ensure the accuracy of this document, some
errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Ltd
should be notified in writing.
Please state:
Title of the Document + Issue Number/Date of publication
Latest Amendment Number (if applicable)
Page(s) and/or Figure(s) in error
Please send to: Nokia Mobile Phones Ltd
PAMS Technical Documentation
PO Box 86
FIN-24101 SALO
Finland

Programmes After Market Services
Technical Documentation
Issue 4 Copyright  Nokia Mobile Phones. All Rights Reserved
Warnings and Cautions
Please refer to the phone's user guide for instructions relating to operation, care and
maintenance including important safety information. Note also the following:
Warnings:
1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH
ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING
SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN
AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/
MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC
SYSTEMS TO RF ENERGY.
2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY
TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS
(SERVICE STATIONS), BLASTING AREAS ETC.
3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING
CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF
INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR
THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY
QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO
INTERFERENCE.
Cautions:
1. Servicing and alignment must be undertaken by qualified personnel only.
2. Ensure all work is carried out at an anti-static workstation and that an
anti-static wrist strap is worn.
3. Ensure solder, wire, or foreign matter does not enter the telephone as
damage may result.
4. Use only approved components as specified in the parts list.
5. Ensure all components, modules screws and insulators are correctly
re-fitted after servicing and alignment. Ensure all cables and wires are
repositioned correctly.