Nokia Rh-109 User manual

Nokia Customer Care

Service Manual

RH-109 (Nokia 1606Arte; L3&4)

Mobile Terminal

Part No: (Issue 2)

COMPANY CONFIDENTIAL

RH-109

Amendment Record Sheet

Amendment No Date Inserted By Comments

Issue 1 2008.05.13 Michelle Wang Initial draft

Issue 2 2008.07.17 Michelle Wang Updated version

Page ii COMPANY CONFIDENTIAL Issue 1

RH-109

Copyright

Reproduction, transfer, distribution or storage of part or all of the contents in this document in any form without

the prior written permission of Nokia is prohibited.

Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of Nokia

Corporation. Other product and company names mentioned herein may be trademarks or tradenames of their

respective owners.

Nokia operates a policy of continuous development. Nokia reserves the right to make changes and

improvements to any of the products described in this document without prior notice.

Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental,

consequential or indirect damages howsoever caused.

The contents of this document are provided "as is". Except as required by applicable law, no warranties of any

kind, either express or implied, including, but not limited to, the implied warranties of merchantability and

fitness for a particular purpose, are made in relation to the accuracy, reliability or contents of this document.

Nokia reserves the right to revise this document or withdraw it at any time without prior notice.

The availability of particular products may vary by region.

IMPORTANT

This document is intended for use by qualified service personnel only.

Issue 1 COMPANY CONFIDENTIAL Page iii

RH-109

Warnings and Cautions

Warnings and cautions

Warnings

zIF THE DEVICE CAN BE INSTALLED IN A VEHICLE, CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH

ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT

CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/

MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.

zTHE PRODUCT MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES, FOR

EXAMPLE, PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.

zOPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH

THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE

MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO

BE SUBJECT TO INTERFERENCE.

zBEFORE MAKING ANY TEST CONNECTIONS, MAKE SURE YOU HAVE SWITCHED OFF ALL EQUIPMENT.

Cautions

zServicing and alignment must be undertaken by qualified personnel only.

zEnsure all work is carried out at an anti-static workstation and that an anti-static wrist strap is worn.

zEnsure solder, wire, or foreign matter does not enter the telephone as damage may result.

zUse only approved components as specified in the parts list.

zEnsure all components, modules, screws and insulators are correctly re-fitted after servicing and alignment.

zEnsure all cables and wires are repositioned correctly.

zNever test a mobile phone WCDMA transmitter with full Tx power, if there is no possibility to perform the

measurements in a good performance RF-shielded room. Even low power WCDMA transmitters may disturb

nearby WCDMA networks and cause problems to 3G cellular phone communication in a wide area.

zDuring testing never activate the GSM or WCDMA transmitter without a proper antenna load, otherwise GSM

or WCDMA PA may be damaged.

Page iv COMPANY CONFIDENTIAL Issue 1

RH-109

For your safety

QUALIFIED SERVICE

Only qualified personnel may install or repair phone equipment.

ACCESSORIES AND BATTERIES

Use only approved accessories and batteries. Do not connect incompatible products.

CONNECTION TO OTHER DEVICES

When connecting to any other device, read its user’s guide for detailed safety instructions. Do not connect

incompatible products.

Issue 1 COMPANY CONFIDENTIAL Page v

RH-109

Care and Maintenance

Care and maintenance

zThis product is of superior design and craftsmanship and should be treated with care. The suggestions

below will help you to fulfill any warranty obligations and to enjoy this product for many years.

zKeep the phone and all its parts and accessories out of the reach of small children.

zKeep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that

will corrode electronic circuits.

zDo not use or store the phone in dusty, dirty areas. Its moving parts can be damaged.

zDo not store the phone in hot areas. High temperatures can shorten the life of electronic devices, damage

batteries, and warp or melt certain plastics.

zDo not store the phone in cold areas. When it warms up (to its normal temperature), moisture can form

inside, which may damage electronic circuit boards.

zDo not drop, knock or shake the phone. Rough handling can break internal circuit boards.

zDo not use harsh chemicals, cleaning solvents, or strong detergents to clean the phone.

zDo not paint the phone. Paint can clog the moving parts and prevent proper operation.

zUse only the supplied or an approved replacement antenna. Unauthorized antennas, modifications or

attachments could damage the phone and may violate regulations governing radio devices.

All of the above suggestions apply equally to the product, battery, charger or any accessory.

Page vi COMPANY CONFIDENTIAL Issue 1

RH-109

ESD protection

Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the

phone.

Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced

without ESD protection if the product is otherwise ready for use.

To replace the covers ESD protection must be applied.

All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity

discharge.

All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any

ESD Protected Area (EPA).

Every repair action involving opening the product or handling the product components must be done under ESD

protection.

ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area.

For more information and local requirements about ESD protection and ESD Protected Area, contact your local

Nokia After Market Services representative.

Issue 1 COMPANY CONFIDENTIAL Page vii

RH-109

Battery information

Note: A new battery's full performance is achieved only after two or three complete charge and

discharge cycles!

The battery can be charged and discharged hundreds of times but it will eventually wear out. When the

operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery.

Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers

approved by the manufacturer. Unplug the charger when not in use. Do not leave the battery connected to a

charger for longer than a week, since overcharging may shorten its lifetime. If left unused a fully charged battery

will discharge itself over time.

Temperature extremes can affect the ability of your battery to charge.

For good operation times with Li-Ion batteries, discharge the battery from time to time by leaving the product

switched on until it turns itself off (or by using the battery discharge facility of any approved accessory available

for the product). Do not attempt to discharge the battery by any other means.

Use the battery only for its intended purpose.

Never use any charger or battery which is damaged.

Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object (coin, clip or pen)

causes direct connection of the + and - terminals of the battery (metal strips on the battery) for example when

you carry a spare battery in your pocket or purse. Short-circuiting the terminals may damage the battery

or the connecting object.

Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions, will reduce the

capacity and lifetime of the battery. Always try to keep the battery between 15°C and 25°C (59°F and 77°F). A

phone with a hot or cold battery may temporarily not work, even when the battery is fully charged.

Batteries' performance is particularly limited in temperatures well below freezing.

Do not dispose of batteries in a fire!

Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste.

Page viii COMPANY CONFIDENTIAL Issue 1

RH-109

Company Policy

Our policy is of continuous development; details of all technical modifications will be included with service

bulletins.

While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any

errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/e-mail.

Please state:

zTitle of the Document + Issue Number/Date of publication

zLatest Amendment Number (if applicable)

zPage(S) and/or Figure(s) in error

Please send to:

NOKIA CORPORATION

Nokia Mobile Phones Business Group

Nokia Customer Care

PO Box 86

FIN-24101 SALO

Finland

E-mail: Servic[email protected]om

Issue 1 COMPANY CONFIDENTIAL Page ix

RH-109

Company Policy

(This page left intentionally blank.)

Page x COMPANY CONFIDENTIAL Issue 1

RH-109

Nokia 1606Arte Service Manual Structure

1. General information

2. Service Devices and Service Concepts

3. BB Troubleshooting and Manual Tuning Guide

4. RF Troubleshooting

5. System Module Description

Glossary

Issue 1 COMPANY CONFIDENTIAL Page xi

RH-109

Nokia 1606Arte Service Manual Structure

(This page left intentionally blank.)

Page xii COMPANY CONFIDENTIAL Issue 1

Nokia Customer Care

1 – General information

Issue 1 COMPANY CONFIDENTIAL Page 1-1

RH-109

General information

(This page left intentionally blank.)

Page 1-2 COMPANY CONFIDENTIAL Issue 1

RH-109

General information

Table of Contents

Product selection…………………………………………………………………………………………………………………………………….…..1-5

Phone features……………………………………………………………………………………………………………………………….……….…..1-5

User interface and software features……………………………………………………………………………………………….……….…..1-6

Accessories……………………………………………………………………………………………….…………………………………………….…..1-6

Technical specifications……………………………….…………………………………………….…………………………………………….…..1-6

General specifications…………………………….…………………………………………….…………………………………………….…..1-6

Battery endurance…………………………………….………………………………………….…………………………………………….…..1-6

List of Figures

Figure 1 RH-109 (Nokia 1606Arte) product picture…………………………………………………………………………………….…..1-5

Issue 1 COMPANY CONFIDENTIAL Page 1-3

RH-109

General information

(This page left intentionally blank.)

Page 1-4 COMPANY CONFIDENTIAL Issue 1

RH-109

General information

Product selection

Rh-109 (Nokia 1606) is a CDMA200 triple band phone, supporting CDMA2000 1Xrtt /Cell/PCS/AWS bands.

Figure 1 RH-109 (Nokia 1606Arte) product picture

Phone features

Display and keypad features

z1.77” 128x160 pixel, 262k true color internal display

z0.97” 96x32 pixel, white monochrome external display

z5-way , navi-key (4 way scroll and center key, call and end keys with intelligent key light+)

Hardware features

zMicro USB port for charging and data transfer (USB 2.0+)

z2.5 phi dedicate headset

zInternal vibrator and antenna

zInternal 512Mb memory

zTorch feature in power on/off

zSupport E911

RF features

zCDMA2000 1Xrtt: Cell/PCS/AWS

zAGPS/SGPS: E911 feature only

Issue 1 COMPANY CONFIDENTIAL Page 1-5

RH-109

General information

User interface and software features

Selection of software applications and services

z3GPP streaming / downloading videq

zThemes (wallpapers, icons, colors+

zMusic Player supporting MP3,Midi, QCELP and EVRC

zOMA DRM 1.0

zOMA MMS 1.2, MMS Conformance 3.0, AMR and SMIL

zOMA Client Provisioning v1.3

zMP3 ringing tones, true tones and MIDI ringing, alert and gaming tones with support of 64 polyphone

zHTTP 1.1/WAP2.0

zNokia PC Suite

Accessories

Sales package contents

zNokia 1606 phone

zNokia Battery BL-4B

zNokia Charger: AC-6,

zUser Guide

Technical specifications

General specifications

Unit Dimension(mm) Weight(g) Volume(cc)

Transceiver with BL-4B 700mA

Li-Ion battery pack

85x45x16.5 76 48

Battery endurance

Battery NMP Talk time NMP Standby time

BL-4B 700mAh Li-Ion battery Up to 3.5 hours 10 days

Note: The variation in operation times will occur depending on network parameters, phone setting and usage.

Page 1-6 COMPANY CONFIDENTIAL Issue 1

RH-109

General information

(This page left intentionally blank.)

Issue 1 COMPANY CONFIDENTIAL Page 1-7

Nokia Customer Care

2 – Service Devices and

Service Concepts

Issue 1 COMPANY CONFIDENTIAL Page 2-1

Nokia RH-109 User manual

Popular Cell Phone manuals by other brands