Nokia IP1200 Series User manual

Nokia IP1200 Series
Security Platform
Installation Guide
Part No. N450897003 Rev B
Published May 2004

2 Nokia IP1200 Series Security Platform Installation Guide
COPYRIGHT
©2004 Nokia. All rights reserved.
Rights reserved under the copyright laws of the United States.
RESTRICTED RIGHTS LEGEND
Use, duplication, or disclosure by the United States Government is subject to restrictions as set
forth in subparagraph (c)(1)(ii) of the Rights in Technical Data and Computer Software clause at
DFARS 252.227-7013.
Notwithstanding any other license agreement that may pertain to, or accompany the delivery of,
this computer software, the rights of the United States Government regarding its use,
reproduction, and disclosure are as set forth in the Commercial Computer Software-Restricted
Rights clause at FAR 52.227-19.
IMPORTANT NOTE TO USERS
This software and hardware is provided by Nokia Inc. as is and any express or implied
warranties, including, but not limited to, implied warranties of merchantability and fitness for a
particular purpose are disclaimed. In no event shall Nokia, or its affiliates, subsidiaries or
suppliers be liable for any direct, indirect, incidental, special, exemplary, or consequential
damages (including, but not limited to, procurement of substitute goods or services; loss of use,
data, or profits; or business interruption) however caused and on any theory of liability, whether in
contract, strict liability, or tort (including negligence or otherwise) arising in any way out of the use
of this software, even if advised of the possibility of such damage.
Nokia reserves the right to make changes without further notice to any products herein.
TRADEMARKS
Nokia is a registered trademark of Nokia Corporation. Other products mentioned in this
document are trademarks or registered trademarks of their respective holders.
040113

Nokia IP1200 Series Security Platform Installation Guide 3
Nokia Contact Information
Corporate Headquarters
Regional Contact Information
Nokia Customer Support
Web Site http://www.nokia.com
Telephone [phone] or
1-650-625-2000
Fax [phone]
Mail
Address Nokia Inc. 313 Fairchild Drive
Mountain View, California
94043-2215 USA
Americas Nokia Inc.
313 Fairchild Drive
Mountain View, CA 94043-2215
USA
Tel: [phone]
Outside USA and Canada: [phone]
email: [e-mail]
Europe,
Middle East,
and Africa
Nokia House, Summit Avenue
Southwood, Farnborough
Hampshire GU14 ONG UK
Tel: UK: [phone]
Tel: France: [phone]
email: [e-mail]
Asia-Pacific 438B Alexandra Road
#07-00 Alexandra Technopark
Singapore 119968
Tel: [phone]
email: [e-mail]
Web Site: https://support.nokia.com/
Email: [e-mail]
Americas Europe
Voice: 1-888-361-5030 or
1-613-271-6721 Voice: [phone]
Fax: [phone] Fax: [phone]
Asia-Pacific
Voice: [phone]
Fax: [phone]
031014

4 Nokia IP1200 Series Security Platform Installation Guide

Nokia IP1200 Series Security Platform Installation Guide 5
Contents
About this Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
In This Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Conventions This Guide Uses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Notices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Text Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Related Documentation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
1 Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
About the Nokia IP1200 Series Security Platform . . . . . . . . . . . . . 19
Managing the Nokia IP1200 Series Security Platform . . . . . . . . . . 21
Nokia IP1200 Series Security Platform Overview . . . . . . . . . . . . . 23
Ethernet Management Ports . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
PMC Expansion Slots . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Console Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Serial (AUX) Port. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
System Status LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Hard Disk Drives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Disk Mirroring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Hard-Disk Drive Hot Swap Feature . . . . . . . . . . . . . . . . . . . . . 30
Hard-Disk Drive LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Supplies and Fan Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Power Supplies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Fan Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Site Requirements, Warnings, and Cautions . . . . . . . . . . . . . . . . . 36
Software Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

6 Nokia IP1200 Series Security Platform Installation Guide
2 Performing the Initial Configuration . . . . . . . . . . . . . . . . . . . . . 39
Using a Console Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Connecting Power and Turning the Power On. . . . . . . . . . . . . . . . 42
Performing the Initial Configuration . . . . . . . . . . . . . . . . . . . . . . . . 44
Connecting Network Interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Using Nokia Network Voyager to Manage Your Security Platform 47
Accessing Nokia Network Voyager Reference Information. . . . . 48
Nokia Network Voyager Reference Guide . . . . . . . . . . . . . . . . 49
Nokia Network Voyager Inline Help . . . . . . . . . . . . . . . . . . . . . 49
Using Nokia Network Voyager to Monitor a Nokia IP1200 Series
Security Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Using the Command-Line Interface to Manage Your Security
Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Using Nokia Horizon Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
3 Installing the Nokia IP1200 Series Security Platform . . . . . . . 53
Rack Mounting the Security Platform. . . . . . . . . . . . . . . . . . . . . . . 53
Before You Begin. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
4 Installing and Replacing Network Interface Cards . . . . . . . . . 61
Removing, Installing, and Replacing NICs. . . . . . . . . . . . . . . . . . . 62
Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Configuring and Activating Interfaces . . . . . . . . . . . . . . . . . . . . . . 70
Monitoring Network Interface Cards. . . . . . . . . . . . . . . . . . . . . . . . 71
5 Connecting PMC Network Interface Cards . . . . . . . . . . . . . . . . 73
Four-Port and Dual-Port 10/100 Ethernet NICs. . . . . . . . . . . . . . . 75
10/100 Ethernet NIC Features . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Ethernet NIC Connectors and Cables. . . . . . . . . . . . . . . . . . . . . 77
Dual-Port Fiber-Optic Gigabit Ethernet NIC. . . . . . . . . . . . . . . . . . 78
Fiber-Optic Gigabit Ethernet NIC Features. . . . . . . . . . . . . . . . . 79

Nokia IP1200 Series Security Platform Installation Guide 7
Fiber-Optic Gigabit Ethernet NIC Connectors and Cables . . . . . 80
Dual-Port Copper Gigabit Ethernet NIC. . . . . . . . . . . . . . . . . . . . . 80
Performance Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Copper Gigabit Ethernet NIC Features. . . . . . . . . . . . . . . . . . . . 81
Dual-Port Copper Gigabit Ethernet NIC Connectors and Cables 82
Single-Port ISDN S/T NIC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Single-Port ISDN S/T NIC Features . . . . . . . . . . . . . . . . . . . . . . 86
ISDN NIC Connectors and Cables . . . . . . . . . . . . . . . . . . . . . . . 86
Single-Port V.35 or X.21 NIC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Single-Port V.35 or X.21 NIC Features . . . . . . . . . . . . . . . . . . . . 88
V.35 and X.21 NIC Connectors and Cables . . . . . . . . . . . . . . . . 89
Single-Port T1 NIC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Connectors and Cables. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Single-Port E1 NIC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Connectors and Cables. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
6 Using the Boot Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Variables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Viewing the Variables and Other System Parameters . . . . . . . 101
printenv. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
sysinfo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
ls. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Setting the Variables. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
setenv. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
unsetenv. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
set-defaults. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
setalias . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
unsetalias . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Other commands. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
halt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106

8 Nokia IP1200 Series Security Platform Installation Guide
help. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Booting the System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Using the Boot Manager to Install Nokia IPSO . . . . . . . . . . . . . . 107
Protecting the Boot Manager with a Password . . . . . . . . . . . . . . 108
Installing the Boot Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Upgrading the Boot Manager. . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
7 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111
General Troubleshooting Information. . . . . . . . . . . . . . . . . . . . . . 111
8 Installing and Replacing Other Components . . . . . . . . . . . . . 119
Replacing a Hard Disk Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Disk Mirroring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Hard Disk Drive Hot Swap Feature. . . . . . . . . . . . . . . . . . . . . . 121
Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Removing and Replacing a Hard Disk Drive . . . . . . . . . . . . . 122
Replacing or Upgrading Memory . . . . . . . . . . . . . . . . . . . . . . . . . 128
Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Installing a Nokia Encryption Accelerator Card . . . . . . . . . . . . . . 134
Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Configuring Software to Use Hardware Acceleration . . . . . . . . 139
Installing a Fan Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Installing or Replacing a Power Supply . . . . . . . . . . . . . . . . . . . . 141
Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 143
Monitoring the Nokia IP1200 Series Security Platform Power
Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
A Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Space Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146

Nokia IP1200 Series Security Platform Installation Guide 9
B Compliance Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Declaration of Conformity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
Compliance Statements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
FCC Notice (US) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Equipment Attachment Regulations (Canada). . . . . . . . . . . . . . . 152
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 153

10 Nokia IP1200 Series Security Platform Installation Guide