Oase AquaMax Eco Premium4000 User manual

21461/05-13
AquaMax Eco Premium
4000/6000/8000/10000/12000/16000/20000
21461 GAW_AquaMax Eco Premium_end_. 23.05.13 14:57 Seite 2

2
22265_06-13_GA_Aquamax Eco Premi2 2 01.07.2013 10:48:48

3
22265_06-13_GA_Aquamax Eco Premi3 3 01.07.2013 10:48:49

4
22265_06-13_GA_Aquamax Eco Premi4 4 01.07.2013 10:48:50

10
- GB -
Translation of the original Operating Instructions
Information about these operating instructions
Welcome to OASE Living Water. You made a good choice with the purchase of this product AquaMax Eco Premium
4000/6000/8000/10000/12000/16000/20000.
Prior to commissioning the unit, please read the instructions of use carefully and fully familiarise yourself with the unit.
Ensure that all work on and with this unit is only carried out in accordance with these instructions.
Adhere to the safety information for the correct and safe use of the unit.
Keep these instructions in a safe place! Please also hand over the instructions when passing the unit on to a new
owner.
Symbols used in these instructions
The symbols used in this operating manual have the following meanings:
Risk of injury to persons due to dangerous electrical voltage
This symbol indicates an imminent danger, which can lead to death or severe injuries if the appropriate meas-
ures are not taken.
Risk of personal injury caused by a general source of danger
This symbol indicates an imminent danger, which can lead to death or severe injuries if the appropriate meas-
ures are not taken.
Important information for trouble-free operation.
Intended use
AquaMax Eco Premium 4000/6000/8000/10000/12000/16000/20000, in the following termed "unit", and all other parts
from the delivery scope may be used exclusively as follows:
−For pumping normal pond water for filters, waterfalls and water courses.
−Operation under observance of the technical data.
The following restrictions apply to the unit:
−Do not use in swimming ponds.
−Never use the unit to convey fluids other than water.
−Never run the unit without water.
−Do not use for commercial or industrial purposes.
−Do not use in conjunction with chemicals, foodstuff, easily flammable or explosive substances.
−Do not connect to the domestic water supply.
Safety information
Hazards to persons and assets may emanate from this unit if it is used in an improper manner or not in accordance
with its intended use, or if the safety instructions are ignored.
This unit can be used by children from the age of 8 and by persons
with physical, sensory or mental impairments or lack of experience
and knowledge, as long as they are supervised or instructed on how
to use the unit safely and are able to understand the potential haz-
ards. Do not allow children to play with the unit. Do not allow children
to clean or maintain the unit without close supervision.
Hazards encountered by the combination of water and electricity
−The combination of water and electricity can lead to death or severe injury from electrocution, if the unit is incorrectly
connected or misused.
−Prior to reaching into the water, always switch off the mains voltage to all units used in the water.
- GB -
22265_06-13_GA_Aquamax Eco Premi10 10 01.07.2013 10:48:50

11
- GB -
Correct electrical installation
−Electrical installations must meet the national regulations and may only be carried out by a qualified electrician.
−A person is regarded as a qualified electrician, if, due to his/her vocational education, knowledge and experience, he
or she is capable of and authorised to judge and carry out the work commissioned to him/her. This also includes the
recognition of possible hazards and the adherence to the pertinent regional and national standards, rules and regu-
lations.
−For your own safety, please consult a qualified electrician.
−The unit may only be connected when the electrical data of the unit and the power supply coincide. The unit data is
to be found on the unit type plate or on the packaging, or in this manual.
−Ensure that the unit is fused for a rated fault current of max. 30 mA by means of a fault current protection device.
−Extension cables and power distributors (e. g. outlet strips) must be suitable for outdoor use.
−Ensure that the power connection cable cross section is not smaller than that of the rubber sheath with the identifi-
cation H05RN-F. Extension cables must meet DIN VDE 0620.
−Protect the plug connections from moisture.
−Only plug the unit into a correctly fitted socket.
Safe operation
−Never operate the unit if either the electrical cables or the housing are defective!
−Do not carry or pull the unit by its electrical cable.
−Route cords/hoses/lines in a way that they are protected against damage, and ensure that they do not present a
tripping obstacle.
−Only open the unit housing or its attendant components, when this is explicitly required in the operating instructions.
−Only execute work on the unit that is described in this manual. If problems cannot be overcome, please contact an
authorised customer service point or, when in doubt, the manufacturer.
−Only use original spare parts and accessories for the unit.
−Never carry out technical modifications to the unit.
−The power connection cables cannot be replaced. When the cable is damaged, the unit or the component needs to
be disposed of.
−Only operate the unit if no persons are in the water!
−Keep the socket and power plug dry.
Important! The unit is equipped with a permanent magnet. The magnetic field may affect the function of pace-
makers.
Installation
The unit can be placed submerged or dry.
Always place the unit below water level.
Place the unit horizontally on the ground ensuring its stable position.
Connect the unit
Figure B
Recommendation for the use of the stepped hose adapter and hose connector:
AquaMax Eco Premium 4000/6000:
−Second inlet (1): Stepped hose adapter 25 to 38 mm (1 to 1½ ")
−Pump outlet (2): Hose connector 38 mm (1½ ") (alternative: stepped hose adapter 25 to 38 mm (1 to 1½ "))
AquaMax Eco Premium 8000/10000/12000/16000/20000:
−Second inlet (1): Stepped hose adapter 25 to 38 mm (1 to 1½ ")
−Pump outlet (2): Hose connector 50 mm (2 ") (alternative: stepped hose adapter 25 to 38 mm (1 to 1½ "))
Push the hose clip and the union nut over the hose. Fit the hose on the stepped hose adapter or hose connector and
secure with the hose clip.
Fit the stepped hose adapter or hose connector on the second inlet (1) or pump outlet (2) and hand-tighten the union
nut.
22265_06-13_GA_Aquamax Eco Premi11 11 01.07.2013 10:48:50

12
- GB -
Operate the unit with the pond filter.
Figure B
Connect the pump outlet (2) to the pond filter. Close the second inlet (1) with the screw cap.
Operate the unit with the satellite filter, or with the skimmer and pond filter.
Figure (C, D)
Connect the second inlet (1) to the satellite filter or skimmer. Connect the pump outlet (2) to the pond filter.
Set the inlet regulator
Figure (H)
Unlock the locking (9) (pull towards the inlet regulator) while pushing the inlet regulator (5) to the desired position (0 to
4).
−0: Second inlet closed. Water is only drawn in via the housing (strainer casings).
−1 to 3: Part of the water is drawn in via the housing (strainer casings), and part via the second inlet.
−4: The second inlet is fully open. Water is only drawn in via the second inlet.
Recommendation:
−When operating with the second inlet closed, turn the inlet regulator (5) to 0.
−When operating with the satellite filter or skimmer, turn the inlet regulator (5) to a position between 1 to 4.
Install the unit at a dry place
Figure (E, F)
Install the unit so that it is not exposed to direct sun radiation (max. 40 ºC).
Open the clips (3) and remove the strainer top casing.
Release the clamp (4) and take pump out of the bottom strainer casing. Pull suction adapter (6) and inlet regulator (5)
from the pump.
Remove screws provided for fastening the holder (7). Remove holder from the bottom strainer casing.
Plug the rubber feet (8) (part of the accessory kit) in the openings provided for this purpose on the bottom of the hol-
der (7).
Place the pump back into the holder (7) and fasten with the clamp (4).
Connect the suction and pressure line. The require assembly items are included in the accessory kit.
Start-up
Attention! The pump must never run dry.
Possible consequence: The pump will be destroyed.
Protective measure: Check the water level at regular intervals. Always place the unit below water level.
Attention! The installed temperature monitor automatically turns the pump off, if it is overloaded. The pump
automatically switches on again once the motor has cooled down. Risk of accident!
This is how to connect the power supply:
Switching on: Connect power plug to the socket. The unit switches on immediately when the power connection is
established.
Switching off: Disconnect the power plug.
Note:
A brand-new pump will only achieve its maximum capacity after several operating hours.
During start-up, the pump automatically undergoes a pre-programmed self-test of approx. two minutes (Environ-
mental Function Control (EFC)). The pump runs through various speeds and detects whether it runs dry (is blocked)
or is submerged. The pump switches off automatically after approx. 90 seconds if it runs dry (is blocked). The pump
automatically makes new attempts to start up at regular intervals. In the event of a malfunction, disconnect the power
supply and flood the pump or remove the obstacle. Following this, the unit can be restarted.
22265_06-13_GA_Aquamax Eco Premi12 12 01.07.2013 10:48:50

13
- GB -
Aquamax Eco Premium 12000, Eco Premium 16000
Figure (G)
AquaMax Eco Premium 12000/16000/20000
With the SFC function activated, the pump automatically optimises the amount of water as well as the head height. It
reduces this head height to 50 %. The SFC allows the pump to adapt to the individual pond ecology throughout the
year, it supports the pond biology (winter mode, transition mode and summer mode) by temperature dependent water
circulation and saves energy. SFC does not function when installed dry. The SFC can be activated and deactivated by
means of the slide on the pump. When deactivated, the speed does not change temperature dependent and remains
on maximum throughout the year. If a skimmer, a satellite filter or an InScenio control unit (OASE accessories!) is
used, it might be recommendable to deactivate the SFC, depending on the unit.
The pump power can only be controlled by an OASE current management unit.
Remedy of faults
Malfunction Cause Remedy
No mains voltage Check mains voltageThe unit is not performing its suction function
Impeller blocked, pump running dry Clean pump housing, check supply lines for
blockages
Strainer casing or satellite filter clogged Clean
Hose blocked Clean or replace hose
Hose kinked Eliminate kink, replace hose if it is damaged
Excessive loss in the hoses due to friction Reduce hose length to reduce frictional loss
SFC reduces the water quantity Switch off the SFC
Insufficient capacity
AquaMax Eco Premium 12000/16000/20000:
Pump overload. The capacity is automatically
reduced to protect the pump.
−Clean the pump housing
−Reduce the ambient temperature (e.g. ensure
that the specified water temperature is ad-
hered to, avoid direct sunlight)
−Ensure adequate ventilation for dry installation
Strainer casing clogged Clean strainer casingUnit switches off after a short running period
Pump running dry −Check supply lines for blockages
−Vent hoses
−Check connections for leaks
Maintenance and cleaning
Attention! Dangerous electrical voltage.
Possible consequences: Death or severe injury.
Protective measures:
−Prior to reaching into the water, disconnect the power supply to all units used in the water.
−Disconnect the power plug prior to carrying out work on the unit.
Cleaning the unit
If necessary, clean the unit with clear water using a soft brush.
−Never use aggressive cleaning agents or chemical solutions. These could attack the housing surface or impair the
function.
−In the event of stubborn furring (calcium deposits), a common household cleaner free from vinegar and chlorine can
be used. Subsequently, clean the pump thoroughly using clear water.
Cleaning the pump
Figure (F)
Remove hoses from the unit. Open the clips (3) and remove the strainer top casing.
Release the clamp (4) and take the pump out of the bottom strainer casing. Pull the suction adapter (5) and regulator
(6) from the pump.
22265_06-13_GA_Aquamax Eco Premi13 13 01.07.2013 10:48:50

14
- GB -
Figure (I)
AquaMax Eco Premium 4000/6000/8000/10000:
−Vigorously turn the pump housing counter-clockwise (bayonet lock) and remove together with O ring.
−Remove the screws, intermediate housing, O ring and impeller unit.
−Clean all parts in clear water with a brush.
−Check parts for damage and replace if necessary.
−Reassemble in the reverse order.
AquaMax Eco Premium 12000/16000:
−Remove the screws and pump housing.
−Pull off the impeller unit and flat seal.
Note: When pulling out the impeller unit, the journal bearing may come loose in the motor housing.
−Clean all parts in clear water with a brush.
−Check parts for damage and replace if necessary.
−Reassemble in the reverse order.
Note: Check that the journal bearing in the motor housing is correctly seated. If necessary, press the journal bearing
with the wide grooves at the front into the seat in the motor housing.
AquaMax Eco Premium 20000:
−Take out the screws and remove the two adapter plates, the pump housing with O ring and the intermediate hous-
ing.
−Pull off the impeller unit and flat seal.
Note: When pulling out the impeller unit, the journal bearing may come loose in the motor housing.
−Clean all parts in clear water with a brush.
−Check parts for damage and replace if necessary.
−Reassemble in the reverse order.
Note: Check that the journal bearing in the motor housing is correctly seated. If necessary, press the journal bearing
with the wide grooves at the front into the seat in the motor housing.
Disposal
Do not dispose of this unit with domestic waste! For disposal purposes, please use the return system provided.
Disable the unit beforehand by cutting off the cables.
Storage/Over-wintering
The unit is frost resistant to minus 20 °C. Should you store the unit outside of the pond, clean it thoroughly with a soft
brush and water, check it for damage, then store immersed in water or filled with water. Do not immerse the power plug
in water!
Repair
A damaged unit cannot be repaired and must be put out of operation. Dispose of the unit in accordance with the
regulations.
Wear parts
The impeller unit is a wearing part and does not fall under the warranty.
22265_06-13_GA_Aquamax Eco Premi14 14 01.07.2013 10:48:50

115
DE Typ Bemessungsspannung Leistungsaufname Förderleistung Wassersäule Tauchtiefe Gewicht Wassertemperatur GB Type Rated voltage Power consumption Max. flow rate Max. head height Immersion depth Weight Water temperature FR Type Tension de mesure Puissance absorbée Capacité de refoulement Colonne d'eau Profondeur d'immersion Poids Température de l’eau NL Type Dimensioneringsspanning Vermogensopname Pompcapaciteit Waterkolom Dompeldiepte Gewicht Watertemperatuur ES Tipo Tensión asignada Consumo de potencia Capacidad de elevación Columna de agua Profundidad de inmersión Peso Temperatura del agua PT Tipo Voltagem considerada Potência absorvida Débito Coluna de água Profundidade de imersão Peso Temperatura da água IT Tipo Tensione di taratura Potenza assorbita Portata Colonna d'acqua Profondità d'immersione Peso Temperatura dell'acqua DK Type Nominel spænding Effektforbrug Transportkapacitet Vandsøjle Bassindybde Vægt Vandtemperaturen NO Type Merkespenning Effektopptak Kapasitet Vannsøyle Nedsenkningsdybde Vekt Vanntemperatur SE Typ övre märkspänning Effekt Matningsprestanda Vattenpelare Doppningsdjup Vikt Vattentemperatur FI Tyyppi mitoitusjännite Ottoteho Syöttöteho Vesipylväs Upotussyvyys Paino Veden lämpötila HU Típus mért feszültség Teljesítményfelvétel Szállítási teljesítmény Vízoszlop Merülési mélység Súly Vízhőmérséklet PL Typ napięcie znamionowe Pobór mocy Wydajność pompowania Słup wody Głębokość zanurzenia Ciężar Temperatura wody CZ Typ domezovací napětí Příkon Dopravní výkon Vodní sloupec Hloubka ponoření Hmotnost Teplota vody SK Typ dimenzačné napätie Príkon Dopravný výkon Vodný stĺpec Hĺbka ponorenia Hmotnost’ Teplota vody SI Tip dimenzionirana napetost Poraba moči Črplana zmogljivost Vodni steber Potopna globina Teža Temperatura vode HR Tip gornji nazivni napon Potrošnja energije Protočni kapacitet Vodeni stup Dubina uranjanja Težina Temperatura vode RO Tip tensiunea măsuratăPutere consumatăDebit de pompare Coloanăde apăAdâncime de imersie Greutate Temperatura apei BG Тип номинално напрежение Потребявана мощност Дебит Воден стълб дълбочина на потапяне Тегло Температурата на водата UA Тип розрахункова напруга Споживання електроенергії Продуктивність Водяний стовп Глибина занурення Вага Температура води RU Тип расчетное напряжение Потребление мощности Производительность Водяной столб Глубина погружения Вес Температура воды CN 型号 设计电压 功耗 输送能力 水柱 潜水深度 重量 水温
4000 40 W max. 4000 l/h max. 3.3 m 6000 50 W max. 6000 l/h max. 3.7 m 8000 65 W max. 8000 l/h max. 4.1 m
10000 88 W max. 10000 l/h max. 4.7 m
5.3 kg
12000 110 W max. 12000 l/h max. 5.0 m 16000 145 W max. 15.600 l/h max. 5.2 m
5.4 kg
Aquamax Eco Premium
20000
~220-240 V, 50/60 Hz
180 W max. 19.500 l/h max. 5.4 m
max. 4 m
5.7 kg
+4 … +35 °C
22265_06-13_GA_Aquamax Eco Premi115 115 01.07.2013 10:48:54

116
DE Staubdicht. Wasserdicht
bis 4 m Tiefe.
Mögliche Gefahren für
Personen mit Herz-
schrittmachern!
Vor direkter Sonnenein-
strahlung schützen.
Nicht mit normalem
Hausmüll entsorgen!
Achtung!
Lesen Sie die Ge-
brauchsanleitung
GB Dust tight. Submersible to
4 m depth.
Possible hazard for
persons wearing pace
makers!
Protect from direct sun
radiation.
Do not dispose of to-
gether with household
waste!
Attention!
Read the operating
instructions
FR Imperméable aux pous-
sières. Etanche à l'eau
jusqu'à une profondeur de
4 m.
Dangers possibles pour
des personnes ayant des
stimulateurs cardiaques !
Protéger contre les
rayons directs du soleil.
Ne pas recycler dans les
ordures ménagères !
Attention !
Lire la notice d'emploi
NL Stofdicht. Waterdicht tot
een diepte van 4 m.
Mogelijke gevaren voor
mensen met een pace-
maker!
Beschermen tegen direct
zonlicht.
Niet bij het normale
huisvuil doen!
Let op!
Lees de gebruiksaanwij-
zing
ES A prueba de polvo.
Impermeable al agua
hasta 4 m de profundidad.
Posibles peligros para las
personas con marcapa-
sos.
Protéjase contra la
radiación directa del sol.
¡No deseche el equipo en
la basura doméstica!
¡Atención!
Lea las instrucciones de
uso
PT À prova de pó. À prova de
água até 4 m de
profundidade.
Eventuais perigos para
pessoas com pace-
makers!
Proteger contra radiação
solar directa.
Não deitar ao lixo
doméstico!
Atenção!
Leia as instruções de
utilização
IT A tenuta di polvere.
Impermeabile all'acqua
fino a 4 m di profondità.
Possibili pericoli per
persone con pace-maker!
Proteggere contro i raggi
solari diretti.
Non smaltire con normali
rifiuti domestici!
Attenzione!
Leggete le istruzioni
d'uso!
DK Støvtæt. Vandtæt ned til 4 m
dybde. Mulig fare for personer
med pacemaker
Beskyt mod direkte sollys. Må ikke bortskaffes med det
almindelige
husholdningsaffald.
OBS!
Læs brugsanvisningen
NO Støvtett. Vanntett ned til 4
m dyp.
Kan være farlig for
personer med pacemaker!
Beskytt mot direkte sollys. Ikke kast i alminnelig
husholdningsavfall!
NB!
Les bruksanvisningen
SE Dammtät. Vattentät till 4
m djup.
Möjlig risk för personer
med pacemaker!
Skydda mot direkt sol-
strålning.
Får inte kastas i
hushållssoporna!
Varning!
Läs igenom
bruksanvisningen
FI Pölytiivis. Vesitiivis 4 m
syvyyteen asti
Mahdollinen vaara
sydämentahdistinta
käyttäville henkilöille!
Suojattava suoralta
auringonvalolta.
Älä hävitä laitetta taval-
lisen talousjätteen
kanssa!
Huomio!
Lue käyttöohje
HU Portömített. Vízálló 4 m-
es mélységig.
A készülék veszélyes
lehet szívritmus-
szabályozóval rendelkező
személyekre!
Óvja közvetlen napsugár-
zástól.
A készüléket nem a
normál háztartási szemét-
tel együtt kell megsemmi-
síteni!
Figyelem!
Olvassa el a használati
útmutatót
PL Pyłoszczelny.
Wodoszczelny do 4 m
głębokości.
Możliwość wystąpienia
zagrożeńdla osób ze
stymulatorami
Chronićprzed bezpoś-
rednim nasłonecznieniem.
Nie wyrzucaćwraz ze
śmieciami domowymi!
Uwaga!
Przeczytaćinstrukcję
użytkowania!
CZ Prachotěsný. Vodotěsný
do hloubky 4 m.
Možná nebezpečí pro
osoby s kardiostimulátory!
Chránit před přímým
slunečním zářením.
Nelikvidovat v normálním
komunálním odpadu!
Pozor!
Přečtěte Návod k použití!
SK Prachotesný. Vodotesný
do hĺbky 4 m.
Možné nebezpečenstvo
pre osoby
s kardiostimulátormi!
Chránit’ pred priamym
slnečným žiarením.
Nelikvidovaťv normálnom
komunálnom odpade!
Pozor!
Prečítajte si Návod
na použitie
SI Ne prepušča prahu. Ne
prepušča vode do
globinen 4 m.
Obstaja nevarnost za ljudi
s srčnim spodbujevalni-
kom!
Zaščitite pred neposred-
nimi sončnimi žarki.
Ne zavrzite skupaj z
gospodinjskimi odpadki!
Pozor!
Preberite navodila za
uporabo!
HR Ne propušta prašinu. Ne
propušta vodu do 4 m
dubine.
Moguće opasnosti za
nositelje elektrostimulato-
ra!
Zaštitite od izravnog
sunčevog zračenja.
Nemojte ga bacati u
običan kućni otpad!
Pažnja!
Pročitajte upute za
upotrebu!
RO Etanşla praf. Etanşla
apă, pânăla o adâncime
de 4 m.
Posibile pericole pentru
persoane cu by-pass
cardiac !
Protejaţi împotriva razelor
directe ale soarelui.
Nu aruncaţi în gunoiul
menajer !
Atenţie !
Citiţi instrucţiunile de
utilizare !
BG Защитено от прах.
Водоустойчив до
дълбочина 4 м.
Възможен риск за хора с
пейс-мейкъри!
Да се пази от слънчеви
лъчи.
Не изхвърляйте заедно
собикновения
домакински боклук!
Внимание!
Прочетете упътването
UA Пилонепроникний.
Водонепроникний до 4
м.
Небезпека для осіб з
кардіостимулятором
Пристрій повинен бути
захищений від прямого
сонячного
випромінювання.
Не викидайте разом із
побутовим сміттям!
Увага!
Читайте інструкцію.
RU Пыленепрониц.
Водонепрониц. на
глубине до 4 м.
Возможная опасность
для лиц с
кардиостимулятором!
Защищать от прямого
воздействия солнечных
лучей.
Не утилизировать
вместе сдомашним
мусором!
Внимание!
Прочитайте инструкцию
по использованию
CN 防尘。至 4 米深防水。 可能对带有心脏起搏器人
员有危险!
防止阳光直射。
不要与普通的家庭垃圾一
起丢弃!
注意!
请阅读使用说明书。
22265_06-13_GA_Aquamax Eco Premi116 116 01.07.2013 10:48:54

117
22265_06-13_GA_Aquamax Eco Premi117 117 01.07.2013 10:48:54

118
22265_06-13_GA_Aquamax Eco Premi118 118 01.07.2013 10:48:54

119
22265_06-13_GA_Aquamax Eco Premi119 119 01.07.2013 10:48:55

22265/06-13
22265_06-13_GA_Aquamax Eco Premi120 120 01.07.2013 10:48:55