Pet Gear TL5927 User manual

INSTRUCTION MANUAL
TRAVEL LITE
“The Other Door®” Steel Crate
TL5927/TL5930/TL5936/TL5942
To see our full line of products, visit us online at: www.petgearinc.com
CUSTOMER SERVICE HELP DESK
[email protected]
Toll-Free 877-752-9123 - Eastern Standard Time 8am-3pm, Monday through Friday
For The ON-THE-GO Pet™

TRAVEL LITE–THE OTHER DOOR®STEEL CRATE • TL5927/TL5930/TL5936/TL5942
2
PARTS LIST
CRATE ASSEMBLY
Step 1. Remove the folded steel
crate from the carton so that plastic
base is on the bottom.
Unlatch the locking device located
on the side as shown in Figure A.
Crate
Locking
Device
2 Latches
Check that you have all the parts shown BEFORE assembling your product.
If any parts are missing, call Customer Service.
A.
2 Top Locks
(one on each side)

TRAVEL LITE–THE OTHER DOOR®STEEL CRATE • TL5927/TL5930/TL5936/TL5942 3
CRATE ASSEMBLY
B.
Step 2. Grab any wire on the top panel and turn it like the page of a book. This should look like Figure B.
Then grab the steel crate with both hands and pull upwards.
This will form the top and sides (shown in Figure C.)
Step 3. Reach in the crate and pull the end
panel forward (shown in Figure D) until it ts
into the clips on the ends of the side panels.
D.
C.
Step 4. To secure the end panel to the top panel, gently
pull forward on the end panel while pushing down on the
top panel.
Then, t the hooks over the end wire on the top (shown
in Figure E).
Step 5. Repeat Steps 4 and 5 with the other end panel.
To disassemble, reverse this process.
E.

TRAVEL LITE–THE OTHER DOOR®STEEL CRATE • TL5927/TL5930/TL5936/TL5942
4
TO USE THE TOP DOOR
Step 1. Stand beside the crate; the side
that is closest to the latches works best.
Lift up latches and slightly tilt them
towards each other at a 45 degree angle
(shown in Figure H).
Step 2. Pull latches towards you until
they are no longer touching the top
door.
Lift up on door to open.
Step 3. To close door, just reverse this
process.
TO USE “THE OTHER DOOR”
Step 1. To lock “The Other Door,” align latches with
their corresponding slots and push down on both
latches till you hear them click into the secure position
(shown in Figure F ).
Step 2. To open and put up “The Other Door,” press
the tabs inside the latches and pull up on latch (shown
in Figure G).
Swing door out and push into the top slot.
Step 3. To put door down, just reverse this process
(Step 2 then 1).
F.
G.
Secure/Latched Position
Unlatched Position
H.

TRAVEL LITE–THE OTHER DOOR®STEEL CRATE • TL5927/TL5930/TL5936/TL5942 5
AVOIDING SUFFOCATION HAZARDS
SETTING UP THE CRATE
Never use plastic shipping bags or other plastic lm as pad covers not sold and intended for that purpose.
They can cause suffocation. This product is not intended for commercial use.
THIS PRODUCT REQUIRES ADULT ASSEMBLY.
Be sure the crate is completely set up before use.
Always follow the instructions in the product instructions to set up the crate.
Before each use, inspect this product for damaged hardware, loose joints, missing parts, or sharp edges.
Do not use the crate if any parts are missing or broken.
Call PET GEAR at 1-877-752-9123 for replacement parts. Use only PET GEAR replacement parts.
Visit our website www.petgearinc.com to view or download the product instructions.
Do not substitute parts.
USING THE CRATE
Remove collar and leashes while using this product. The crate is for playing or sleeping.
When used for playing, never leave pet unattended and always keep pet in view. When used for
sleeping, you must still provide the supervision necessary for the continued safety of your pet.
Always keep the crate away from hazards in the area that may injure your pet.
DO NOT leave pet in product for prolonged periods of time.
DO NOT ATTEMPT TO MOVE CRATE WHEN YOUR PET IS INSIDE.

TRAVEL LITE–THE OTHER DOOR®STEEL CRATE • TL5927/TL5930/TL5936/TL5942
6
WARNING!
FOR PETS ONLY.
Not intended to be used as a restraining device for aggressive or dangerous animals that dig, chew or paw
aggressively. Do not leave your pet unattended. PET GEAR is not liable for any damage caused by aggressive,
destructive, immature or untrained animals. Do not use near an open or exposed ame. Failure to follow these
warnings and the instructions could result in serious injury or death.
REPLACEMENT PARTS
Use only PET GEAR replacement parts.
Please have your model number ready before calling.
You can also request parts: http://www.petgearinc.com/main.asp?sel=2
192 Sheldon Avenue∙West Rutland, VT∙05777∙877-752-9123∙www.petgearinc.com