Philips HTS3540/05 User manual

TABLE OF CONTENTS
Page
Service Manual
. Mechanical and Dismantling Instructions…………........................3-1
. Software Upgrades and Region Code Change..............................4-1
. Trouble Shooting Chart……………………………………………….5-1
. Wiring Diagram………………………………………..………..….….6-1
. Electrical Diagrams and Print-layouts..….…………………....….…7-1
. Set Mechanical Exploded view & Part list.…………………..….….8-1
©Copyright 2010 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in aretrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise
without the prior permission of Philips.
CLASS 1
LASER PRODUCT
PHILIPS
GB
Published by RY - BU AVM Printed in The Netherlands Subject to modification
. DFU Instruction..............................................................................2-1
. Revision List..................................................................................9-1
Home Theater DVD Player
HTS3540/05/12/51/93/98
3139 785
. Technical Specifications…………....………………………..............1- 3
. Safety Instruction, Warning & Notes….……………………....….....1- 4
. Location of PCB BdsÿVersion Variation and Repair Scenario Matrix..........1-2
35471
Version 1.1
1039

LOCATION OF PCB BOARDS：
Version Variation：
HTS3540
Type/Versions
Features /05 /12 /51 /93 /98
Output Power-1000W X X X X X
Voltage(220~240v) X X
Voltage(110~240v) X X
Voltage(220~230v) X
Repair Scenario Matrix：
HTS3540
Type/Versions
Board in used /05 /12 /51 /93 /98
Main Board C C C C C
Front Control Board C C C C C
Amplifier Board C C C C C
Power Board C C C C C
*Bd:Board Level Replacement
*C:Component Level Repair
1-2
MAIN BOARD
LOADER
AM BOARD
POWER BOARD
FRONT CONTROL
BOARD

Video
Signal system: PAL / NTSC•
HDMI output: 480i/576i, 480p/576p, 720p,•
1080i, 1080p
Audio
Sampling frequency:•
MP3: 32 kHz, 44.1 kHz, 48 kHz
•
WMA: 44.1 kHz, 48 kHz
•
Constant bit rate:•
MP3: 112 kbps - 320 kbps
•
WMA: 48 kbps - 192 kbps
•
Radio
Tuning range: FM 87.5-108 MHz (50 kHz)•
Signal-to-noise ratio: FM 50 dB•
Frequency response: FM 180 Hz-10 kHz /•
±6dB
USB
Compatibility: Hi-Speed USB (2.0)•
Class support: UMS (USB Mass Storage•
Class)
File system: FAT12, FAT16, FAT32•
Maximum memory support: < 160GB•
Main Unit
Power supply: 220-240V; ~50 Hz•
Power consumption: 100 W•
Standby power consumption: 0.9 W•
Dimensions (WxHxD): 360 x 58 x 320•
(mm)
Weight: 2.84 kg•
Subwoofer
Impedance: 4 ohm•
Speaker drivers: 165 mm (6.5”) woofer•
Frequency response: 40 Hz-150 kHz•
Dimensions (WxHxD): 120 x 307 x 369•
(mm)
Weight: 3.84 kg•
Cable length: 3 m•
Speakers
System: full range satellite•
Speaker impedance: 4 ohm (center), 8 ohm•
(Front/Rear)
Speaker drivers: 3” full range•
Frequency response: 150 Hz-20 kHz•
Dimensions (WxHxD):•
Center: 160.9 x 95 x 92 (mm)
•
Front/Rear: 254 x 1001.5 x 254 (mm)
•
Note
Specification and design are subject to change
•
without notice.
Region code
The type plate on the back or bottom of the
home theater shows which regions it supports
Playback media
DVD-Video, DVD+R/+RW, DVD-R/-RW, DVD+R
DL, CD-R/CD-RW,Audio CD,Video CD/SVCD,
Picture CD, MP3-CD,WMA-CD, DivX-CD, USB
storage device
File Format
Audio: .mp3, .wma•
Video: .divx, .divx ultra, .mpeg, .mpg, .wmv•
(simple profile)
Picture: .jpeg, .jpg•
Amplifier
Total output power: 1000 W RMS (30%•
THD)
Frequency response: 20 Hz-20 kHz / ±3dB•
Signal-to-noise ratio: > 65 dB (CCIR) /•
(A-weighted)
Input sensitivity:•
AUX: 1 mV
•
Country DVD
Europe, United Kingdom
Latin America
Australia, New Zealand
Russia, India
China
Asia Pacific, Taiwan, Korea
HTS3540/12
Product specifications
1-3

Weight:•
Center: 0.77 kg
•
Front/Rear: 3.25 kg/each
•
Cable length:•
Center: 3 m
•
Front: 4 m
•
Rear: 10 m
•
Laser specification
Type: Semiconductor laser GaAIAs (CD)•
Wave length: 645 - 665 nm (DVD), 770 -•
800 nm (CD)
Output power: 6 mW (DVD), 7 mW•
(VCD/CD)
Beam divergence: 60 degrees.•
1-4

ǵǴDZDzǸǵȌ
ǜǽǵǹDzȄǭǺǵDz
ǢǭǽǭǷǿDzǽǵǾǿǵǷǵ ǵ DZǵǴǭǶǺ ǹǻǰȀǿ ǮȈǿȉ•
ǵǴǹDzǺDzǺȈ ǮDzǴ ǼǽDzDZǯǭǽǵǿDzǸȉǺǻǰǻ
ȀǯDzDZǻǹǸDzǺǵȌ.
ǗǻDZ ǽDzǰǵǻǺǭ
ǜǻDZDZDzǽdzǵǯǭDzǹȈDz ǽDzǰǵǻǺȈ ȀǷǭǴǭǺȈ ǯ ǿǭǮǸǵȄǷDz
Ǻǭ ǴǭDZǺDzǶ ǵǸǵ ǮǻǷǻǯǻǶ ǼǭǺDzǸǵ DZǻǹǭȅǺDzǰǻ
ǷǵǺǻǿDzǭǿǽǭ
ǜǻDZDZDzǽdzǵǯǭDzǹȈDz ǹDzDZǵǭǺǻǾǵǿDzǸǵ
DVD (ǯǵDZDzǻ), DVD+R/+RW, DVD-R/-RW,
DVD+R DL, CD-R/CD-RW, CD (ǭȀDZǵǻ), CD
(ǯǵDZDzǻ)/SVCD, CD (ǵǴǻǮǽǭdzDzǺǵȌ), MP3-CD,
WMA-CD, ǴǭǼǻǹǵǺǭȋȆǵDz USB-ȀǾǿǽǻǶǾǿǯǭ
ǡǻǽǹǭǿ ȁǭǶǸǻǯ
ǍȀDZǵǻ: .mp3, .wma•
ǏǵDZDzǻ: .divx, .divx ultra, .mpeg, .mpg, .wmv•
(ǼǽǻǾǿǻǶ ǼǽǻȁǵǸȉ)
ǕǴǻǮǽǭdzDzǺǵȌ: .jpeg, .jpg•
Страна
DVD
Европа, Великобритания
Латинская Америка
Австралия,
Новая Зеландия
Россия, Индия
Китай
Азиатско-тихоокеанский
регион, Тайвань, Корея
ǢǭǽǭǷǿDzǽǵǾǿǵǷǵ
HTS3540/51
1-5

ǞǭǮǯȀȁDzǽ
ǞǻǼǽǻǿǵǯǸDzǺǵDz: 4 Ǜǹ•
ǍǷȀǾǿǵȄDzǾǷǵDz ǼǽDzǻǮǽǭǴǻǯǭǿDzǸǵ: 165 ǹǹ•
(6,5”) ǚǤ-DZǵǺǭǹǵǷ
ǤǭǾǿǻǿǺȈǶ ǻǿǷǸǵǷ: 40 ǐȃ-150 Ƿǐȃ•
ǝǭǴǹDzǽȈ (ǥxǏxǐ): 120 x 307 x 369 (ǹǹ)•
ǏDzǾ: 3,84 Ƿǰ•
ǑǸǵǺǭ ǷǭǮDzǸȌ: 3 ǹ•
ǑǵǺǭǹǵǷǵ
ǞǵǾǿDzǹǭ:ǾǭǿDzǸǸǵǿȈ ǼǻǸǺǻǰǻ DZǵǭǼǭǴǻǺǭ•
ǞǻǼǽǻǿǵǯǸDzǺǵDz DZǵǺǭǹǵǷǻǯ: 4 Ǜǹ•
(ȃDzǺǿǽǭǸȉǺȈǶ), 8 Ǜǹ (ȁǽǻǺǿǭǸȉǺȈǶ/
ǿȈǸǻǯǻǶ)
ǍǷȀǾǿǵȄDzǾǷǵDz ǼǽDzǻǮǽǭǴǻǯǭǿDzǸǵ:•
3-DZȋǶǹǻǯȈǶ DZǵǺǭǹǵǷ ǼǻǸǺǻǰǻ DZǵǭǼǭǴǻǺǭ
ǤǭǾǿǻǿǺȈǶ ǻǿǷǸǵǷ: 150 ǐȃ - 20 Ƿǐȃ•
ǝǭǴǹDzǽȈ:ǥX ǏX ǐ•
ǣDzǺǿǽǭǸȉǺȈǶ: 160,9 x 95 x 92 (ǹǹ)
•
ǡǽǻǺǿǭǸȉǺȈǶ/ǿȈǸǻǯǻǶ: 254 x 1001,5
•
x 254 (ǹǹ)
ǏDzǾ:•
ǣDzǺǿǽǭǸȉǺȈǶ: 0,77 Ƿǰ
•
ǡǽǻǺǿǭǸȉǺȈǶ/ǿȈǸǻǯǻǶ: 3,25 Ƿǰ•
(ǷǭdzDZȈǶ)
ǑǸǵǺǭ ǷǭǮDzǸȌ:•
ǣDzǺǿǽǭǸȉǺȈǶ: 3 ǹ
•
ǡǽǻǺǿǭǸȉǺȈǶ: 4 ǹ
•
ǟȈǸǻǯǻǶ: 10 ǹ
•
ǢǭǽǭǷǿDzǽǵǾǿǵǷǵ ǸǭǴDzǽǭ
ǟǵǼ:ǼǻǸȀǼǽǻǯǻDZǺǵǷǻǯȈǶ ǸǭǴDzǽ GaAIAs•
(CD)
ǑǸǵǺǭ ǯǻǸǺȈ: 645 – 665 Ǻǹ (DVD), 770 –•
800 Ǻǹ (CD)
ǏȈȂǻDZǺǭȌ ǹǻȆǺǻǾǿȉ: 6 ǙǏǿ (DVD), 7 ǙǏǿ•
(VCD/CD)
ǝǭǾǾDzǵǯǭǺǵDz ǸȀȄǭ: 60 ǰǽǭDZȀǾǻǯ.•
ǠǾǵǸǵǿDzǸȉ
ǛǮȆǭȌ ǯȈȂǻDZǺǭȌ ǹǻȆǺǻǾǿȉ: 1000 Ǐǿ•
(ǾǽDzDZǺDzǷǯǭDZǽǭǿǵȄǺǭȌ) (30 % THD)
ǤǭǾǿǻǿǺȈǶ ǻǿǷǸǵǷ: 20 ǐȃ-20 Ƿǐȃ / ±3 DZǎ•
ǛǿǺǻȅDzǺǵDz ǾǵǰǺǭǸ/ȅȀǹ: > 65 DZǎ (CCIR)/•
ǾǽDzDZǺDzǯǴǯDzȅDzǺǺǻDz
ǏȂǻDZǺǭȌ ȄȀǯǾǿǯǵǿDzǸȉǺǻǾǿȉ:•
AUX: 1 ǹǏ
•
ǏǵDZDzǻ
ǞǵǾǿDzǹǭ ǾǵǰǺǭǸǭ: PAL/NTSC•
ǏȈȂǻDZ HDMI: 480i/576i, 480p/576p, 720p,•
1080i, 1080p
ǍȀDZǵǻ
ǤǭǾǿǻǿǭ ǯȈǮǻǽǷǵ:•
MP3: 32 Ƿǐȃ; 44,1 Ƿǐȃ; 48 Ƿǐȃ
•
WMA: 44,1 Ƿǐȃ, 48 Ƿǐȃ
•
ǜǻǾǿǻȌǺǺǭȌ ǾǷǻǽǻǾǿȉ ǼDzǽDzDZǭȄǵ DZǭǺǺȈȂ:•
MP3: 112 ǗǮǵǿ/Ǿ– 320 ǷǮǵǿ/Ǿ
•
WMA: 48 ǗǮǵǿ/Ǿ– 192 ǷǮǵǿ/Ǿ
•
ǝǭDZǵǻ
ǤǭǾǿǻǿǺȈǶ DZǵǭǼǭǴǻǺ: FM 87,5 – 108 Ǚǐȃ•
(50/100 Ƿǐȃ)
ǛǿǺǻȅDzǺǵDz ǾǵǰǺǭǸ/ȅȀǹ: FM 50 DZǎ•
ǤǭǾǿǻǿǺȈǶ ǻǿǷǸǵǷ: FM 180 ǐȃ ~•
10 Ƿǐȃ/±6 DZǎ
USB
ǞǻǯǹDzǾǿǵǹǻǾǿȉ:ǯȈǾǻǷǻǾǷǻǽǻǾǿǺǻǶ•
ǵǺǿDzǽȁDzǶǾ USB (2.0)
ǜǻDZDZDzǽdzǷǭ ǷǸǭǾǾǭ: UMS (ǷǸǭǾǾ•
ǴǭǼǻǹǵǺǭȋȆǵȂ ȀǾǿǽǻǶǾǿǯ USB)
ǡǭǶǸǻǯǭȌ ǾǵǾǿDzǹǭ: FAT12, FAT16, FAT32•
ǙǭǷǾǵǹǭǸȉǺȈǶ ǼǻDZDZDzǽdzǵǯǭDzǹȈǶ ǻǮȇDzǹ•
ǼǭǹȌǿǵ: < 160 ǐǎ
ǛǾǺǻǯǺǻDz ȀǾǿǽǻǶǾǿǯǻ
ǕǾǿǻȄǺǵǷ ǼǵǿǭǺǵȌ:•
ǘǭǿǵǺǾǷǭȌ ǍǹDzǽǵǷǭ/ǍǴǵǭǿǾǷǻ-
•
ǟǵȂǻǻǷDzǭǺǾǷǵǶ ǽDzǰǵǻǺ/ǕǺDZǵȌ: 110-
240 Ǐ; ~50-60 ǐȃ;
ǗǵǿǭǶ: 220-230 Ǐ, ~50-60 ǐȃ
•
ǝǻǾǾǵȌ: 230 Ǐ, ~50 ǐȃ
•
ǜǻǿǽDzǮǸȌDzǹǭȌ ǹǻȆǺǻǾǿȉ: 100 Ǐǿ•
ǪǺDzǽǰǻǼǻǿǽDzǮǸDzǺǵDz ǯ ǽDzdzǵǹDz ǻdzǵDZǭǺǵȌ:•
0,9 Ǐǿ
ǝǭǴǹDzǽȈ (ǥxǏxǐ): 360 x 58 x 320 (ǹǹ)•
ǏDzǾ: 2,84 Ƿǰ•
1-6

specifications
Note
Specification and design are subject to change
•
without notice.
Region code
The type plate on the back or bottom of the
home theater shows which regions it supports
Playback media
DVD-Video, DVD+R/+RW, DVD-R/-RW, DVD+R
DL, CD-R/CD-RW, Audio CD,Video CD/SVCD,
Picture CD, MP3-CD,WMA-CD, DivX-CD, USB
storage device
File Format
Audio: .mp3, .wma•
Video: .divx, .divx ultra, .mpeg, .mpg, .wmv•
(simple profile)
Picture: .jpeg, .jpg•
Amplifier
Total output power: 1000 W RMS (30% THD)•
Frequency response: 20 Hz-20 kHz / ±3dB•
Signal-to-noise ratio: > 65 dB (CCIR) /•
(A-weighted)
Input sensitivity:•
AUX: 1 mV
•
Country DVD
Europe, United Kingdom
Latin America
Australia, New Zealand
Russia, India
China
Asia Pacific, Taiwan, Korea
HTS3540/93/98
Product
1-7

Speakers
System: full range satellite•
Speaker impedance: 4 ohm (center), 8 ohm•
(Front/Rear)
Speaker drivers: 3” full range•
Frequency response: 150 Hz-20 kHz•
Dimensions (WxHxD):•
Center: 160.9 x 95 x 92 (mm)
•
Front/Rear: 254 x 1001.5 x 254 (mm)
•
Weight:•
Center: 0.77 kg
•
Front/Rear: 3.25 kg/each
•
Cable length:•
Center: 3 m
•
Front: 4 m
•
Rear: 10 m
•
Laser specification
Type: Semiconductor laser GaAIAs (CD)•
Wave length: 645 - 665 nm (DVD), 770 -•
800 nm (CD)
Output power: 6 mW (DVD), 7 mW•
(VCD/CD)
Beam divergence: 60 degrees.•
Video
Signal system: PAL / NTSC•
HDMI output: 480i/576i, 480p/576p, 720p,•
1080i, 1080p
Audio
Sampling frequency:•
MP3: 32 kHz, 44.1 kHz, 48 kHz
•
WMA: 44.1 kHz, 48 kHz
•
Constant bit rate:•
MP3: 112 kbps - 320 kbps
•
WMA: 48 kbps - 192 kbps
•
Radio
Tuning range: FM 87.5-108 MHz (50/100•
kHz)
Signal-to-noise ratio: FM 50 dB•
Frequency response: FM 180 Hz ~ 10 kHz•
/ ±6dB
USB
Compatibility: Hi-Speed USB (2.0)•
Class support: UMS (USB Mass Storage•
Class)
File system: FAT12, FAT16, FAT32•
Maximum memory support: < 160GB•
Main Unit
Power supply:•
Latin America/Asia Pacific/India: 110-
•
240V, ~50-60Hz
China: 220-230V, ~50-60Hz
•
Russia: 230V, ~50Hz
•
Power consumption: 100 W•
Standby power consumption: 0.9 W•
Dimensions (WxHxD): 360 x 58 x 320•
(mm)
Weight: 2.84 kg•
Subwoofer
Impedance: 4 ohm•
Speaker drivers: 165 mm (6.5”) woofer•
Frequency response: 40 Hz-150 kHz•
Dimensions (WxHxD): 120 x 307 x 369•
(mm)
Weight: 3.84 kg•
Cable length: 3 m•
1-8

Safety instruction
1. General safety
Safety regulations require that during a repair:
. Connect the unit to the mains via an isolation transformer.
. Replace safety components indicated by the symbol ,
only by components identical to the original ones. Any
other component substitution (other than original type)
may increase risk of fire or electrical shock hazard.
Safety regulations require that after a repair, you must
return the unit in its original condition. Pay, in particular,
attention to the following points:
. Route the wires/cables correctly, and fix them with the
mounted cable clamps.
. Check the insulation of the mains lead for external
damage.
. Check the electrical DC resistance between the mains
plug and the secondary side:
1) Unplug the mains cord, and connect a wire between
the two pins of the mains plug.
2) Set the mains switch the “on” position (keep the
mains cord unplug).
3) Measure the resistance value between the mains
plug and the front panel, controls, and chassis
bottom.
4) Repair or correct unit when the resistance
measurement is less than 1M
¡
.
5) Verify this, before you return the unit to the
customer/user (ref. UL-standard no. 1492).
6) Switch the unit “off”, and remove the wire between
the two pins of the mains plug.
2.Laser safety
This unit employs a laser. Only qualified service personnel
may remove the cover, or attempt to service this device
(due to possible eye injury).
Laser device unit
Type :SemiconductorlaserGaAlAs
Wavelength : 650nm (DVD)
: 780nm (VCD/CD)
Output power : 7mW (DVD)
:10mW(DVD/CD)
Beam divergence: 60 degree
Note: Use of controls or adjustments or performance of
procedure other than those specified herein, may result in
hazardous radiation exposure. Avoid direct exposure to
beam.
Safet
y
instruction, Warnin
g
& Notes
1-9

Warning
1.General
. All ICs and many other semiconductors are susceptible to
electrostatic discharges (ESD). Careless handing during
repair can reduce life drastically. Make sure that, during
repair, you are at the same potential as the mass of the
set by a wristband with resistance. Keep components and
tools at this same potential. Available ESD protection
equipment:
1) Complete kit ESD3 (small tablemat, wristband,
connection box, extension cable and earth cable)
4822 310 10671.
2) Wristband tester 4822 344 13999.
. Be careful during measurements in the live voltage
section. The primary side of the power supply , including
the heat sink, carries live mains voltage when you
connect the player to the mains (even when the player is
“off”!). It is possible to touch copper tracks and/or
components in this unshielded primary area, when you
service the player. Service personnel must take
precautions to prevent touching this area or components
in this area. A “lighting stroke” and a stripe-marked
printing on the printed wiring board, indicate the primary
side of the power supply.
. Never replace modules, or components, while the unit is
“on”.
2. Laser
. The use of optical instruments with this product, will
increase eye hazard.
. Only qualified service personnel may remove the cover
or attempt to service this device, due to possible eye
injury.
. Repair handing should take place as much as possible
with a disc loaded inside the player.
. Text below is placed inside the unit, on the laser cover
shield:
Notes: Manufactured under licence from Dolby
Laboratories. The double-D symbol is trademarks of Dolby
Laboratories, Inc. All rights reserved.
CAUTION: VISIBLE AND INVISIBLE LASER
RADIATION WHEN OPEN, AVOID EXPOSURE
TO BEAM.
1-10