Philips Lightolier IS-PTS7 User manual

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
3&"%"/%6/%&345"/%5)&4&*/4536$5*0/4#&'03&130$&&%*/(
3&5"*/5)&4&*/4536$5*0/4'03."*/5&/"/$&3&'&3&/$&
5IJTmYUVSFJTJOUFOEFEGPSJOTUBMMBUJPOJOBDDPSEBODFXJUIUIF/BUJPOBM&MFDUSJDBM$PEFBOEMPDBMSFHVMBUJPOT
5PBTTVSFGVMMDPNQMJBODFXJUIMPDBMDPEFTBOESFHVMBUJPOTDIFDLXJUIZPVSMPDBMFMFDUSJDBMJOTQFDUPSCFGPSF
JOTUBMMBUJPO5PQSFWFOUFMFDUSJDBMTIPDLUVSOPGGFMFDUSJDJUZBUFMFDUSJDBMQBOFMCFGPSFQSPDFFEJOH
%0/05*/45"--5)*44:45&.*/"8&503%".1-0$"5*0/
%0/05&/&3(*;&"/:5)*/(05)&35)"/5)&'*9563&4*/5)&4:45&.
$0/53"$503*43&410/4*#-&'03"%&26"5&-:3&*/'03$*/(8"--"/%$&*-*/(504611035'*9563&
8&*()5
Cross Section
Ceiling Tile
Wall
9”
Ceiling Opening
+1/8“
-0“
9”- 7/32”
7”-1/16”
11”-1/4”

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
Note: Cartons are Shipped with the Following Components (Fig. 1)
Note: Facing wall, normal sequence of hanging fixtures is from left to right. Beginning with the longest fixture first and decreasing in fixture
length to the right with the tele-fixture last.
SAMPLE PART LIST
Figure 1
Left hand
&OE1MBUF
%FBE&OE
Wire Set
&MFDUSJDBM)BSOFTT
:PLF4QBDFS
2VJDL$POOFDUPST 3JHIU)BOE&OE1MBUF
5FMFTDPQJOH
5FMF'JYUVSF
$FJMJOH5SJN
Aligner Spline
Standard
'JYUVSF
Standard
'JYUVSF
&OE1MBUF4QMJOF
Reflectors
300.4*%&
-PVWFST
8"--4*%&
Standard Fixture
'JYUVSF
-PVWFS
3FnFDUPS
1BSUT#BH
 4DSFXT
 /VUT
 4QMJOF
 :PLFTQBDFS
Inside/Outside Corner
$PSOFS
-PVWFS
3FnFDUPS
&MFDUSJDBMIBSOFTT
End Plate Kit
-FGUIBOEFOEQMBUF
3JHIUIBOEFOEQMBUF
%FBEFOEXJSFTFU
1MVH#VUUPO
4DSFXT/VUT8BTIFST
&OEQMBUFTQMJOF
Tele-Fixture
'JYUVSF
-PVWFS
3FnFDUPS
1BSUT#BH
 4DSFXT
 /VUT
 4QMJOF
 :PLFTQBDFS
 %FBEFOEXJSFTFU
 )PMFQMVH
 $VUUJOHKJH

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
3FNPWFBMMSFnFDUPSTBOEMPVWFSTGSPNUIFmYUVSFTCFGPSFJOTUBMMBUJPO1.
"UUBDIUIFMFGUIBOEFOEQMBUFUPUIFmSTUmYUVSFUPCFJOTUBMMFEXJUITDSFXTOVUTXBTIFSTBOEFOEQMBUFTQMJOF2.
)BOHUIFmYUVSFGSPNTVQQPSUXJSFTCZPUIFSTBOEMFWFMXJUIDFJMJOHMJOF3.
*OTFSUnBOHFUSJNBMJHOFSTQMJOF
3FNPWFOVUGSPNBEKVTUBCMFXBMMCSBDLFU
3FQFBUTUFQXJUIUIFOFYUmYUVSFBOEKPJOZPLFTXJUITDSFXTOVUTBOEZPLFTQBDFS'JOHFSUJHIUFOPOMZ6.
4MJEFnBOHFUSJNBMJHOFSTQMJOFJOUPBEKBDFOUmYUVSFBOEUJHIUFOTFDVSFMZ7.
3FQFBUGPSUIFSFNBJOEFSPGUIFTUBOEBSEmYUVSFT
1SFQBSFUFMFmYUVSF
Fasten right hand end plate as in step 2.10.
STRAIGHT RUN INSTALLATION
Figure 2
&OE1MBUF4QMJOF
"EKVTUBCMF
8BMM#SBDLFU
-FGU)BOE&OE1MBUF
Washer
'MBOHF5SJN
Aligner Spline
Standard
'JYUVSF
:PLF4QBDFS
Screw
:PLF
:PLF4QBDFS
Screw
/VU
/VU
8"--4*%&

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
STRAIGHT RUN INSTALLATION (CONT’D)
3FNPWFUIFCMBOLDIBOOFMTBOETPDLFUTUSBQTPOUIFMBTUIBOHJOHmYUVSFCFGPSFUFMFTDPQJOHNPEFM11.
)BOHUIFUFMFmYUVSFXJUIBMMUIFDIBOOFMTTUJMMSFNPWFEPSMPPTF5IFTPDLFUTUSBQTPOPOMZUIFMJHIUUFMF12.
mYUVSFDBOCFSFQMBDF
'PSMJHIUSVOTDVUUIFCMBOLDIBOOFMTPOUIFMBTUIBOHJOHmYUVSFOFYUUPUIFUFMFmYUVSF13.
8JUIUIFmYUVSFTMFWFMBOEKPJOFEBUUIFZPLFTMJEFUIFBEKVTUBCMFXBMMCSBDLFUBHBJOTUUIFXBMMBOETFDVSFXJUI
BQQSPQSJBUFIBSEXBSFCZPUIFST'JH
5JHIUFOBMMTDSFXTKPJOJOHUIFZPLFTBOEUSJNT%POPUPWFSUJHIUFO
For Runs Ending in 3 or 4 Foot Fixtures before
Telescoping Model
4MJEFTPDLFUDIBOOFMJOwPOUIFmYUVSFOFYUUPUA.
IFMBTUIBOHJOHmYUVSF
$VUUIFCMBOLDIBOOFMUPUIFNFBTVSFEMFOHUIB.
'JH"
3FQMBDFBMMDIBOOFMTBOETPDLFUTUSBQTPOUIF$
UFMFBOEMBTUmYUVSF
For Runs NOT Ending in 3 or 4 Foot Fixtures before
Telescoping Model
$VUCMBOLDIBOOFMUPNFBTVSFEMFOHUI'JH#A.
3FQMBDFBMMDIBOOFMTBOETPDLFUTUSBQTPOUIFB.
UFMFBOEMBTUmYUVSF
Figure 3A
Figure 3B
Side
Wall
¾'JYUVSF
¾'JYUVSF
5FMF'JYUVSF
5FMF'JYUVSF
'JYUVSF
Lamp
w
w
.FBTVSF
UP$VU
$IBOOFMTPOUFMFSFWFSTFE-PDLJOHUISV
mYUVSFUPXBSETXBMM
$IBOOFMTPOUFMF/05SFWFSTFE-PDLJOH
UISVmYUVSFUPXBSETXBMM
#MBOL$IBOOFM$PWFS
#MBOL$IBOOFM
$PWFS
Lamp Lamp
.FBTVSF
UP$VU #MBOL
$IBOOFM
$PWFS
Side
Wall

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
STRAIGHT RUN INSTALLATION (CONT’D)
4UBHHFSTPDLFUDIBOOFMTGSPNSJHIUUPMFGUMPPLJOHJOUPmYUVSF'PSMJHIUTFF'JH#'PSMJHIUTFF'JH16.
$POOFDUBMMmYUVSFTXJUIRVJDLDPOOFDUPSTBOETOBQnFYDPOOFDUPSJOUPCBMMBTUCPY'JH'JH'PSUFMF17.
mYUVSFDPOOFDUJPOSFNPWFFMFDUSJDBMIBSOFTTGSPNTUBOEBSEmYUVSF-FBWFFOPVHIXJSFUPDPOOFDUUPUIF
IBSOFTTPGUIFUFMFmYUVSFBOEDPOOFDUJOUPUIFCBMMBTUCPYPGUIFTUBOEBSEmYUVSF1PXFSDBOCFCSPVHIUJOUP
UIFSVOUISPVHIBOZCBMMBTUCPY
*OTUBMMUIFSFnFDUPSTCZTUBSUJOHGSPNUIFMFGUBOEDPOUJOVJOHUPUIFSJHIUVOUJMUIFMBTUSFnFDUPSJTJOTUBMMFE5IF
MBTUSFnFDUPSNBZOFFEUPCFDVU
*OTUBMMUIFMBNQTCZPUIFSTBOEUIFOUIFMPVWFSTUIFTBNFXBZUIFSFnFDUPSTXFSFJOTUBMMFE5IFMBTUMPVWFS
NBZOFFEUPCFDVU
"EKVTUBCMF8BMM#SBDLFU Wall
'JYUVSF 'JYUVSF'JYUVSF 5FMF Figure 4
'JYUVSF
w 0WFSMBQ5ZQF
Slide Lower Lamps
Figure 5
3JHIU)BOE$PSOFS
2VJDL$POOFDUPST
2VJDL$POOFDUPST
$POOFDUXJUI8JSFOVUT
5FMF .FBTVSF
-FGU)BOE$PSOFS
'JYUVSF 'JYUVSF 5FMF
Figure 7
%FBE&OE$POOFDUPST
'MFY$POOFDUPST
)PMF1MVH
4UBOEBSE'JYUVSF 5FMF'JYUVSF
2VJDL$POOFDUPST
&MFDUSJDBM)BSOFTT
Figure 6

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
.FBTVSFUIFEJTUBODFGSPNUIFXBMMUPUIFMBTUIBOHJOHmYUVSF'JH1.
3FNPWFUIFXBMMBOEDFJMJOHUSJNGSPNUIFmYUVSFBOEDVUUIFNUPUIFNFBTVSFEMFOHUIVTJOHUIFDVUUJOHKJH2.
'JH'JH5IFTPDLFUDIBOOFMTUSBQTNVTUCFSFNPWFECFGPSFUIFUSJN'JH
(Note: To stagger the lamps, the blank channel on both the tele-fixture and the fixture before the tele-fixture may have to be measured
to cut as shown in Fig. 3A and Fig. 3B on page 4)
(Note: The over all length of the tele-fixture plus the right hand end plate must match the distance between the last
hanging fixture and the wall.)
TELE-FIXTURE PREPARATION - ONE LIGHT RUN
For 1 Light 36” Tele-Fixture
3FNPWFUIFTPDLFUDIBOOFMTUSBQT'JHBOEA.
SFNPWFUIFDIBOOFMTGSPNUIFIPVTJOH
4RVFF[FBOESFNPWFUIFTQMJUCVTIJOHBOETMJEFB.
UIFTPDLFUXJSFTUPUIFCPUUPNIPMF'JH
3FQMBDFUIFCVTIJOHJOUPOFXMPDBUJPO
$VUCMBOLDIBOOFMUPUIFTBNFMFOHUIBTUIFXBMM$
and ceiling trim.
For 1 Light 48” Tele-Fixture
$VUUIFCMBOLDIBOOFMwMFTTUIBOUIFMFOHUIPGA.
the wall and ceiling trim.
(PUPQBHFTUFQB.
Figure 9
#BMMBTU#PY 5FMF'JYUVSFBTTIJQQFE
#MBOL$IBOOFM
4QMJU#VTIJOH
#PUUPN)PMF
4PDLFU8JSF
4PDLFU8JSJOH)PMFT
Figure 8
:PLF
-PXFS4PDLFU$IBOOFM $VU0GG4FF
/PUFi%w
-BNQ4PDLFU'MVTIXJUI&OE
:PLF
Straps Removed
#BMMBTU#PY
6QQFS4PDLFU$IBOOFM
-BNQ4PDLFU'MVTIXJUI&OE
&OE1MBUF4JEF
(Note: When the tele-fixture follows a 3 foot or 4 foot fixtures, the socket channel and the blank channel must be reversed.)

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
.FBTVSFUIFEJTUBODFGSPNUIFXBMMUPUIFMBTUIBOHJOHmYUVSF'JH1.
3FNPWFUIFXBMMBOEDFJMJOHUSJNGSPNUIFmYUVSFBOEDVUUIFNUPUIFNFBTVSFEMFOHUIVTJOHUIFDVUUJOHKJH2.
'JH'JH5IFTPDLFUDIBOOFMTUSBQTNVTUCFSFNPWFECFGPSFUIFUSJN'JH
4MJEFUIFUFMFmYUVSFUPHFUIFSwTNBMMFSUIBOUIFDVUXBMMBOEDFJMJOHUSJN3.
1VTIUIFMBNQTPDLFUTnVTIXJUIUIFFOEPGUIFmYUVSF
$VUPGGUIFFYQPTFEFYDFTTGSPNUIFVQQFSTPDLFUDIBOOFM
5PTUBHHFSUIFMBNQTQVTIJOUIFMPXFSTPDLFUDIBOOFMwBOEDVUPGUIFFYDFTT6.
3FQMBDFUIFXBMMBOEDFJMJOHUSJNCZESJMMJOHBOZwEJBNFUFSIPMFTUIBUXFSFDVUPGGBOESFJOTUBMMJOHUIF7.
TDSFXT
(Note: The over all length of the tele-fixture plus the right hand end plate must match the distance between the last
hanging fixture and the wall.)
Figure 10
4VTQFOTJPO8JSF
-FGU)BOE&OE1MBUF
)BOHJOH'JYUVSFT .FBTVSFGPS
5FMF'JYUVSF &OE1MBUF'MBOHF
WallWall
3JHIU)BOE&OE1MBUF
Figure 11
)BDLTBX
8BMM5SJN
Figure 13
4PDLFU$IBOOFM4USBQ1FS'JYUVSF
4PDLFU
$IBOOFMT
$FJMJOH5SJN
Screw
TELE-FIXTURE PREPARATION - TWO LIGHT RUN
Figure 12
)BDLTBX
$FJMJOH5SJN
$VUUJOH+JH

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
PATTERN RUN INSTALLATION
*OTUBMMBMMDPSOFSTmSTU1.
*OTUBMMBMMTUBOEBSEmYUVSFT2.
*OTUBMMUFMFmYUVSFT3.
.BLFFMFDUSJDBMDPOOFDUJPOTUZQJDBMUPTUSBJHIUSVO
Starting from left to right facing the wall, install the reflectors.
*OTUBMMUIFMBNQT6.
*OTUBMMUIFMPVWFST'JH7.
Note: Read straight run installation instructions before installing pattern run.
Note: Do not fasten fixtures to the wall with the adjustable mounting brackets until all fixtures, corners and tele-fixtures are installed.
:PLF
8JSFXBZ$IBOOFM
$FJMJOH5JMF
-PVWFSJO1MBDF
Faceted Reflector
-PVWFS*OTFSUFE
"EKVTUBCMF
8BMM#SBDLFU
#BMMBTU#PY
)PVTJOH
Figure 14

"JSQPSU3PBE'BMM3JWFS."tt'BY
We reserve the right to change details of design, materials and finish.
XXXMJHIUPMJFSDPN½1IJMJQT(SPVQt
Lighting Systems IS-PTS7
1BHFPG *OTUSVDUJPO4IFFUGPS"TTFNCMZBOE*OTUBMMBUJPOPG154
#
RELAMPING PROCEDURE
Louver RemovalStep 1.
5PSFNPWFMPVWFSQVTIMPVWFSVQBOETMJEFUPXBSE
SPPNTJEF"-PVWFSXJMMEJTFOHBHFPOXBMMTJEF#
BOEFYQPTFJOOFSmYUVSFGPSSFMBNQJOH
Relamping
Step 2.
3FQMBDFMBNQCZSPUBUJOHMBNQVOUJMQJOTPGMBNQ
EJTFOHBHFGSPNTPDLFUT5IFOTMJEFUPXBSEXBMMUP
JOTUBMMOFXMBNQBMJHOMBNQQJOTXJUITPDLFUQVTI
UPXBSESPPNTJEFSPUBUFVOUJMSFTJTUBODFJTGFMUCZ
TPDLFUTQSJOHT
Louver Installation
Step 3.
-JGUMPVWFSVQBOEJOUPmYUVSFBUSPPNTJEFXJUICPUUPN
PGMPVWFSBCPWFUSJNnBOHF4XJOHPQQPTJUFTJEFPG
MPVWFSVQVOUJMJUIJUTSFnFDUPSUIFOTMJEFUPXBSEXBMM
BOEMFUMPVWFSESPQEPXO
Test - LOUVER MUST BE LEVELED
Step 4.
5PUFTUMPVWFSTMJEFMPVWFSUPXBSEXBMMTJEFUIFO
TMJEFJUCBDLUPXBSETSPPNTJEF*OFJUIFSDBTFMPVWFS
TIPVMEOPUGBMMPVU.BLFTVSFUIBUMPVWFSSBJMJTSFTUJOH
DPNQMFUFMZnBUBTJO'JHVSFOPU'JHVSF-PVWFS
3BJMTTIPVMEOPUPWFSMBQPOBOPUIFS
Wall Side
Room Side
" #
Reflector
5SJN'MBOHF
.VTU#FPO
5IJT-FEHF -PVWFS
Figure 15
Figure 16
:FT
Figure 17
No
Figure 18
Flange
-PVWFS
Figure 19