Powakaddy FW3 User manual

™ battery
™ Lithium Battery
OWNER’S MANUAL
PowaKaddy.com
Partner
PGA ® is a registered
trade mark of the
Professional Golfers’
Association Limited.

Please take a moment to register your new product.
You will be required to enter the serial numbers for the Trolley,
Battery and Charger. These are located on the individual items.
The serial number on the underside of the middle tube. See
image for reference.
*Terms and conditions apply. See powakaddy.com for details.
Scan to open the registration page
or visit: powakaddy.com/my-powakaddy
Don’t miss out!
Register now!
Plug ‘n’ Play Battery
2
IMPORTANT- you must fully charge your battery before using
your trolley. Always recharge your battery within 24 hrs of use.
Failure to do so could reduce the life of your battery. See Section
6 Battery Care, for detailed instructions.
Turn the battery on via the button located on the underside of
the battery. The LED light will illuminate green to indicate the
battery is switched on.
Your PowaKaddy trolley features an innovative Plug’n’Play™
battery system including sprung terminals and a locking feature
to maintain power connection over uneven terrain. Once your
battery is charged and trolley assembled, connect your battery as
shown.
1. Engage the front of the battery.
2. Press the front until the battery clips into position.
To remove the battery, depress the front latch and lift the front
of the battery out.
Note: The Lithium battery can be stored within the tray for
transportation. Please ensure you turn o the battery using
the power button on the underside of the battery. Leaving your
battery switched on could lead to your battery discharging or
trolley activating during transportation.
Thank you for purchasing the all new PowaKaddy. Please read the
following instructions carefully. Battery care is very important,
please refer to Sections 2 & 6 for detailed instructions.
When you receive your new PowaKaddy you will have the
following:
Product Warranty
1
1 x Trolley
1 x Battery
1 x Charger
2 x Wheels
1 x Instruction pack
BATTERY
ON

Fit the wheels by pressing the black release button and pushing
onto the axle until the clutch is engaged.
To open the frame, slide the main lock (highlighted blue) forward
to release the handle latch then lift the handle until both locks
click into place.
To fold, slide the same main lock towards the handle and fold the
top portion of the frame down before releasing the upper button
to fold the handle tube.
Your trolley will already be pre-set to run straight. If you nd
your trolley tracking to the left or right you can re-adjust this
by releasing the front wheel lever and rotating the adjustment
roller.
Rotate up to make your trolley track more to the LEFT and rotate
down to track more to the RIGHT.
Once you are happy the trolley is running straight re-apply the
lever to lock in position.
Unfold the Frame
3
1 2 3
Front Wheel Adjustment
4
Once your battery is connected your trolley is ready to use. The
control functions are detailed below.
Power Indicator:
Displays whether power is being
applied to the drive system.
The LED light will illuminate red on start up to indicate the motor
power condition as o. Press the yellow control dial in the centre
to power the motor on, the LED will illuminate Green. Press again
to turn the motor o; the LED will change back to Red.
Control Dial:
Rotate the central control dial to adjust the speed of the trolley
when the motor is powered on. Rotate the control clockwise to
increase the speed and counter-clockwise to decrease the speed.
Press to pause and resume your selected speed.
Controls Overview
5
Power Indicator

Please note: the STANDARD Lithium Battery is designed for
use over 18 holes and must always be fully charged before the
next round. Please follow charging instructions as outlined on
the following pages. We are aware that some golfers will try to
stretch these batteries to 27 holes. This may damage the overall
capacity of the battery and may result in an early failure. Playing
more than 18 holes with the battery can seriously shorten the
battery’s life and will invalidate the battery’s warranty.
Please note: In normal conditions the XL EXTENDED Lithium
Battery will do 36 Holes when used on a PowaKaddy product.
Conditions such as long or exceptionally hilly courses, wet ground
conditions and excessively heavy golf bags may reduce the range
of the trolley.
Charging Instructions
1. Plug the charger into the mains - the charger indicator light
will be green.
2. Connect the charger to the battery.
3. Power the battery on via the on/o button (the LED will
illuminate green). This will initiate the charging process – the
charger status light will turn from green to red.
4. Once the battery is fully charged, the charger status light will
be continuous green. At this point, remove the battery from
the charger and the charger from the outlet.
5. Turn o the battery by pressing the power button.
6. The charging process will take approximately 8 hours
depending on the extent of the discharge and battery
capacity. Avoid leaving your battery on charge for longer
than 12 hours.
Lithium Battery Safety
1. Never short circuit a battery. Keep it away from paper clips,
coins, keys and other small metal objects that can make a
connection between the terminals.
2. Do not splash or immerse in liquids.
3. Do not store or charge the battery in locations where the
temperatures may exceed below -10° (14° F) or above 40° C
(105° F) such as outdoor sheds or metal buildings in summer.
4. Only charge your PowaKaddy battery using the approved
charger supplied. Using another charger may damage the
battery or cause re.
5. Never use the battery if the casing or terminals are damaged.
6. There are no serviceable parts within the battery, DO NOT
ATTEMPT TO OPEN THE BATTERY or attempt a repair. RISK
OF ELECTRIC SHOCK OR FIRE.
Your PowaKaddy trolley is easy to maintain.
• Store your trolley inside
• Never jet wash or immerse in water. Clean the trolley using a sponge and warm water to remove mud, grass, and other debris.
• Occasionally remove the wheels and apply grease to the axles and wheels.
• Use approved PowaKaddy parts for repairs.
Your serial number can be found on the underside of the cental tube, please make a note for future reference.
Should you experience a problem with your PowaKaddy product, please visit www.powakaddy.com/support
7. The battery is a sealed unit. In the unlikely event liquid leaks
from the battery, do not touch the liquid as it may cause
irritation or burns.
Follow the following precautions:
• Skin contact – Wash with soap and water.
• Inhalation – Expose to fresh air and seek medical
advice.
• Eye contact – Immediately wash with water for at
least 15 minutes. Seek medical attention.
• Disposal – wear gloves to handle the battery and
dispose of immediately; contact your local council or
recycling centre.
8. Do not incinerate the battery even if damaged.
9. Only use a PowaKaddy Battery with a compatible PowaKaddy
Trolley. Use of the battery pack on other products may
create risk of injury or re.
Charging Safety
• Do not probe terminals with conductive objects.
• Only charge a PowaKaddy battery using the supplied
PowaKaddy charger. The charger and battery pack are
specically designed to work together.
• Only charge on a hard, at surface.
• The charger will get hot. Do not cover the battery or charger.
• Do not expose the charger to rain, frost, or snow.
• Do not use a charger if the plug, leads, contacts or casing is
damaged.
• Remove the plug with care, to not pull on the cord.
• Avoid using an extension cable.
BATTERY
ON
Battery Care
6
Maintainance
7