RAMFAN EX50Li User manual

San Diego |Luxembourg |Dubai |Ningbo | Singapore
FlowPath™Control
Owner's Manual
ALL PURPOSE-BATTERY VENTILATOR

2 3
PRIOR TO FIRST USE
1. OperateonACvoltage,85-264V,50/60Hz1Φ,forcharginganddischarging.
2. TheunitissuitableforuseonGroundFaultprotectedcircuits.
3. ShouldtheprovidedACconnectorbeunsuitable,replacewithdesiredconnector
 containingagroundingcircuit.Checkcontinuityfromgroundterminaltomotorshell.
4. PlacebatteriesintoholdersandconnecttoIP66connectors,Fullychargepriorto
 rstuse.
5. Thisfanisforemergencyserviceuse.Chargefullybetweenruns.Createacharging
 protocol.
6. Tocharge,turnthespeedcontrolfullytotheleft(OFF)andthenconnecttoACoutlet.
 Indicatorlightswillilluminate,andthengoo.Whenchargingcommences,indicator
 lightswillshowstateofcharge.Chargingshouldcompletein3-4hours,withthe
 indicatorlightsturninggreen.
7. ForDCoperationwithACdisconnected,holdthewakebuttonuntil
 indicatorlightscomeonshowingbatterystate.Advancespeedcontrol.
8. ForACoperation,advancespeedcontrol.
READ MANUAL BEFORE STARTING FOR THE FIRST TIME!
RAMFAN products are warranted against manufacture defect. Failure to
properly maintain product will invalidate warranty coverage. Please visit
www.euramco.com for warranty details.
CONTENTS
ThankyouforpurchasingtheRAMFAN®EX50Libatterypoweredmulti-purposeventilator
manufacturedintheUSAbyEuramcoGroup,Inc.
Formorethan30yearsEuramcoGrouphasbeenonthecuttingedgeofindustrial,re,
andmarineventilationproducts.Eachofourblower/exhausters,smokeejectors,PPV
&LSVfansandaccessoriesrepresentthenesttechnologiesavailable.Everyproductis
constructedtodemandingandexactspecicationsforquality,performance,andreliability.
Whenhumanlifedependsonhavingafanthatcandeliverclean,safeair,youhaveonly
onechoiceyoucantrust:RAMFAN.
Exploreourwebsiteandonlinecatalogatwww.euramco.comanddiscoverhowRAMFAN
canmakeadierenceintheeld!
Allproductinformationinthepublicationisbasedonthemostcurrentinformation
availableatthetimeofprinting.EuramcoGroup,Inc.reservestherighttomakechangesat
anytimewithoutnotice.
Unit Description ..............................................................................................................................4
Warning Labels & Safety Pecautions ........................................................................................5
Specications....................................................................................................................5
Main Interface ................................................................................................................................6
Plug Types ........................................................................................................................................7
Adjusting Angle ...............................................................................................................................8
Operational Modes ........................................................................................................................9
ACOperation....................................................................................................................9
DCOperation....................................................................................................................9
Connection of Battery Pack...................................................................................................9-10
Battery Operation Procedures............................................................................................11-12
RunTime.........................................................................................................................12
ChargingProcedure.......................................................................................................13
Fuel Gauge.....................................................................................................................................14
Battery Status Indicator Lights.................................................................................................15
BatteryPackProtection.................................................................................................15
Storage/TransportModes.............................................................................................16
HowtoActivate"Storage/TransportMode"..............................................................16
ACPowerCord...............................................................................................................17
OperatingLimitations....................................................................................................17
Lithium-Ion Battery Maintenance Guidelines........................................................................18
Overview.........................................................................................................................18
Storage............................................................................................................................18
Recommendation...........................................................................................................18
Maintenance and Disposal.........................................................................................................19
MaintenanceSchedule..................................................................................................20
Compatability..................................................................................................................21
Certication...................................................................................................................................22

4 5
Unit Description
TheEX50Liisamulti-purpose18"/46cmventilatorpoweredbybattery(s)or85-264Vsingle
phaseAC.TheexibleframecongurationallowsforPPV,SmokeEjectororductedblower
useinbothnormal,horizontalandhangingpositions.Thefancanbetiltedfrom0-34°
withintheframeinPPVmode.
Themotor,motorcontrollerandbatteriesarewater-resistant,IP66rated.
Themotorisavariable-speedBLDCmotorcontrolledbyamicroprocessorintegratedwith
apowersupply,dualbatterychargersandanLEDlightdriver.
TheEX50Liwillrunwithoneortwo40V6AhLi-ionbatterypacks.Eachpackyieldsabout
23minofoperationatfullpower.Extendedoperationisachievedbyreducingspeed.The
batteriesmaybeswappedduringoperation.
ACvoltagecanbeappliedwhilerunningonbatteriesandtheventilatorwillauto-switch
toACpower.Conversely,theACpowercanberemovedandtheunitwillauto-switchto
batterypower,ifsucientchargeremains.
Theintegratedbatterychargerswillchargeoneortwofullydischargedbatterypacksin
4hoursorless.
LEDscenelightsareintegratedintotheventilatorshroudand3-intensityinniteswitch
knobs:high,low,&o.Holdtochange.TheLEDknobselectsthescenelightsoutputlevelin
arow.ClockwiseProgression:OFullHalfO.
TheintegratedcontrollerisEMI-protectedtopreventinterferencewithradio
communication.
AsimpleControlPanelonthetopofcontrollercontrolsallfunctions.
Wtigmgexmsrw
LB9106
Hot Surface !
Do Not Touch
Heat Sink or Lights
12"
Warning Labels & Safety Precautions
Model EX50Li 18"/46 cm
Order# EL5500/EL5500-230
Motor 0.8Hp/0.6kW
Runtime@Max.Speed
DC:90minutes(fourbatterypacks)
DC:45minutes(twobatterypacks)
AC:Unlimited
PowerAC UniversalInput:85-264V1Φ,50/60HZ
BatterySystem 40VLithium-ion,432Wh,12Ah
IPRating
(Motor/BatterySystem/
Controller)
IP66/IP66/IP66
Dimensions(hxwxd) 22"x21"x12"in/56x53x30mm
Weight
withtwobatteries:54Ibs/25kg
withonebattery:50lbs/23kg
withoutbatteries:45lbs/20kg
OperatingTempRange -4°Fto105°F -20°Cto40°C
ChargeTempRange -32°Fto105°F -0°Cto40°C
Approvals AMCA
AMCAVeriedAirow
ACPowerSupply 9,635cfm(16,370m3/hr)
DCPowerSupply 10,120cfm(17,194m3/hr)
● Electricalshockhazard.Donotopen
 enclosures.
●DO NOT STARTwithsignsofvisible
 damage.
● Blowerisnotintendedforoperationin
 explosiveatmospheres.
● Wearearprotectionwhencloseby.
● Keepbodypartsandlooseobjectsaway
 fromintakeoffan.
● Donotmovewhilerunning.
● Operateandrepairbytrained
 personnelonly.
● Alwaysusegroundedplugandproperly
 groundACpowerreceptacle.
● Heatsinkbecomeshotduring
 operationandcharging.LEDlights
 becomehotduringuse.Donottouch.
● Usewithapproved,goodcondition
 extensioncordwithgroundconnector.
0-150 ft (0-50m) AWG 14 (2.5 mm2)
>150 ft (> 50m) AWG 12 (4 mm2)
Wire Gauge Requirements per ft (m)

6 7
Main Interface
Number Symbol Indicate Function
1WakeButton/EmergencyStopButton
PressandholdWAKEbuttontostart.
2MaximumSpeed(DC)Button
PressMAXbuttonfor2seconds.
3LEDSceneLights
On,o,onhighoronlow.
4SpeedControl
Controlledoperationfrom0tofullspeed
5
BatteryStatusLEDLights
6
VentilatorStatusLEDLights
Seetablebelowfordetails.
MAX
MAX
L
R
BAT. FAULT
AC PWR
DC PWR
DC MAX
FAULT
NO PWR
STORAGE
MODE
LIGHTS
SPEED
Color Status Description
O NOPWR Poweriso
Green (Solid) ACPWR VentilatorisrunningonACPowerSupply
White (Solid) DCPWR VentilatorisrunningonDCPowerSupply
White (Flashing) DCMAX VentilatorisrunningonMaximumspeed-DC
PowerSupply
Red (Flashing) FAULT Faultontheventilator
Yellow (Flashing) STORAGEMODE Storage/TransportMode
L
R
BAT. FAULT
PUSH FOR
WAKE | STOP
LIGHTS
PUSH FOR
MAX
SPEED
AC PWR
DC PWR FAULT
NO PWR
STORAGE
MODE
DC MAX
Intellisense
TM
E3
MAX
MAX
12
34
5
6
Plug Types
TheEX50Liissuitableforworldwideapplications.Avoltageconverterisnotneeded.The
unitincludesasimpleremovablecordthatallowstheunittooperateupto250VAC:
Mainlyusedin Type Order#
NorthandCentralAmerica,Japan BEL-CUS-4762
France,Blegium,Germany,Austria,the
Netherlands(andmostEuropeancountries)
E/F EL-CEU-4762
UnitedKingdom,Ireland,Malta,Malaysiaand
Singapore
G EL-83070-4762
Australia,NewZealand,PapuaNewGuineaand
Argentina
I EL-84040-4762
China I EL-84640-4762
Ifitbecomesnecessarytouseapowercordwithanotherplugstandard,orderthepower
cordthatmatchestheelectricalrequirementsofthecountryorarea.Thephysicaladapter
fortheoutletisinterchangeableforuseindierentcountriesandallowsyoutoswapthe
cableyourselfintothesocket.
ThispageshowsaselectionofelectricplugswecancurrentlyoerfortheEX50Li.
Ifyouneedaspecialsolution,justinformyourlocalEuramcorepresentativeaboutthe
specic.

8 9
Connection of Battery Pack
DC Operation
• Plugtheventilatorconnectorcable(blue)intothebatteryconnector:
• Settheinstallationindexonthebatterywiththecable,liningupwiththecable
connector.
• Presstheconnectorlockandrotatethebluepiececlockwise(aquarterturntothe
right)inthemostcarefulwaypossible.
• Aligntheedgeofthebatterypackwithholderundertheredlinewhereitsays,“Align
batteryEX50Li”andrmlyslidethebatteryinthedirectionofthearrowasshownin
theillustrationuntilaloudclickisheard.
Operational Modes
• InputVoltage.90-250VAC,50/60Hz
• Theventilatoriscapableofoperatingseamlesslyincountriesthatsupplyelectricityat
either120VAC/60Hzor240VAC/50Hzwithoutmanualadjustmentsbytheuser.
• Operationoutoftheselimitscandamageelectricalcomponentsandwillvoidthe
warranty.
1.ConnectthefantoanACpowersource.
2.StatusLEDLightwillautomaticallyturngreen,displayingthestatus“Ventilatorisrunning
onACPowerSupply”.
3.StarttheventilatorbyusingtheSpeedControlknobtothedesiredspeed.
 Note:Youcankeepthebatteriesontheirlocationwithoutchargingthebattery.
 BatteryIndicatorLightswillturnobecausethereisnobatterycharging
 whenventilatorisrunningonAC.
4. Whenthefanispoweredo,StatusLEDLightwillautomaticallyturnoafter1hourand
thebatteryIndicatorLightswillredisplaybatterychargelevelofeachbatterypackdetected.
Theventilatorwillbeginchargingthebatterypacksafter60minutesofidletime.
5.BatteryPacksdonotchargewhileventilatorisrunning.
AC Operation
Adjusting Angle
Performthisproceduretoadjustthepositionoftheventilator.Useyourhand
tounscrewthetiltadjustmentknob,andthenlockitinplacefromabove,andheldinthe
inclinedpositionbytighteningtheknob.Fornegativetilt,usethenegativetiltbracket.This
providestiltup/downadjustment,from-10to+30degrees.
Forconnedspacerescueoperations,youcanplacetheventilatordirectlyontopofa
manhole.Tiltrangefrom-90to+90degrees.Notethatthosepositionscandirectairow
downwardorupward
Negative tilt bracket
(Accessory)
-10o
30o
Loosen
Tighten
Tilt adjustment knob

10 11
EX50Li
DATE 08/27/19
ITEM#
LABEL# LB9113
REVISION -
DIMS* 1.5748 x 2.25 in
MATERIAL MainStock: TEC4911 4Mil Vinyl Flex White TC Vinyl UL 50#SCK w/Permanent Adh
COLOR Black, Red
- Label Created 08/27/19
Revision Description Date
HISTORY - LB9113
Example of label placed on batter base

ALIGN
BATTERY
EX150Li

ALIGN
BATTERY
EX50Li
LB9113

ALIGN
BATTERY
EX150Li

ALIGN
BATTERY
EX50Li
LB9113
• Gentlypulluptheyellowhandletoremovethebatteryfromtheholder.
Battery Charger Warn Label
DATE 07/07/20
ITEM#
LABEL# LB9114
REVISION -
DIMS* 1.25 x .875 in
MATERIAL MainStock: TEC4911 4Mil Vinyl Flex White TC Vinyl UL 50#SCK w/Permanent Adh
COLOR Black
- Label Created 07/07/20
Revision Description Date
HISTORY - LB9114
LB9114
40V & 52V
battery packs
are NOT
interchangeable
Battery Operation Procedures
Pleasefullchargebatterybeforerstuse
UsingOneBattery
• TheEX50Liallowstheoptionofusingoneortwobatterypacks.
• Whenusingonebattery,simplyplugthebatteryintoeitheroneofthetwobattery
connectors(leftorright).
• Besuretosecuretheunusedbatteryconnectorbyplacingelectricaltapeoverthe
contacts.
• Whenthesystemispoweredusingonebattery,thebatteryindicatorlightbaron
controlpanelwillonlyemitlightforonebattery,whenthesystemispoweredon.
UsingTwoBatteries
• The EX50Li oers a true redundant dual battery system.
• Whenusingtwobatteriesofidenticalchargelevel,batteriesareconnectedinparallelto
increasesignicantlythetotalruntimeandairowperformance.
• Whenusingtwobatterypacks,eachpackfunctionsindependentlyandisisolated
fromtheothersothatifonepackshouldfail(opencircuit,short-circuit,orbecome
discharged)theotherbatterywillprovidepowertooperatethesystem.
• Whenusingdualbatteries,it’simportantthatbothbatteriesbeofthesamecharge
levelandideallyofthesameageandcondition.
• It’snormalforonebatterytodischargeslightlymorethantheother.Thisisthenature
ofatrulyredundantisolatedbatterysystem.
• Thebatterythathasthehighervoltagewilldischargeatafasterrate(untilitsvoltage
equalstheotherbattery).
• WerecommendthatusebothbatteriesontheSameStateofCharge(oratleastas
closeaspossible).Ifthisisnotpossible,thecontrollerwilleventuallybringbatteriesto
abalancedchargelevel.
• Tokeepbatterypackshealthyforlong-termuse,asimpleimplementationofcell-
balancing,internaltothebatterypack,includesaFETplacedinparallelwitheachcell
andcontrolledbyacomparatorforsimplevoltagebasedalgorithmsthatturn-onthe
bypassFETsduringtheonsetofvoltagedierences,controlledbyamicrocontroller
formorecomplexandeectivealgorithmsthatcanworkcontinuouslyregardlessof
variationsofvoltagedierences.

12 13
• WhenACisdisconnectedandSpeedControliso(speed=0),thecontrollerand
battery(s)willenterasleepmodetoconservethebatterypowerafter60minutesofno
activity.
• Towaketheventilator,pushandholdWAKE|STOPButtononControlPanel.
BatteryStatusLEDLightwillshowwhitesolidforthestatus.Theunitwillreturnto
sleepmodeifnotusedwithin10minutes.
• Theventilatorstartsatthelowerspeed=0.Speedwillvaryby11levels-from11
(highest)to0(o).Turnclockwisetoincreasespeed.Atlevel11(thehighest),ifkeep
turningthecontrolknobclockwise,thespeedwillnotchange,itwillstayathighest
speedallthetime.Toslowdown,turncounterclockwise.
• Ifyouwanttoincreasethespeed,pushandholdtheMAXButtonVentilator
StatusLEDLightwillashwhiteforthestatus.Rememberthatthiswillonlyworkwhen
2batteriesareconnectedtotheventilatorandwhenitisoperatingexclusivelyonDC
currentsource(battery).
• Theventilatorwilloperateononeortwobatterypack(s).Iftwobatterypacksareused
simultaneously,theydischargeevenly.
• ToSTOPtheventilator,pushandholdWAKE|STOPButtononControlPanel.
BatteryStatusLEDLightwillbeunlit.
• Battery(s)maybeswappedforchargedbatteriesatanytime.
• Reducerunspeedtominimumrequiredtoincreaseruntime.
Battery Operation Procedures
MAX
MAX
MAX
Run Time
Runtimereferstohowlongtheventilatoronbatterypowerwilllastunderagivenload.
Wewillassumebothbatterieshavefullchargebeforehandandalso100%eciency(Read
"FactorsthataectBatteryLife"section):
2 Batteries Speed Level Knob
Atmaximumspeed 45minutes 11
AtmaximumspeedandDCMax
buttonactivated
30minutes Maxbuttonactivated MAX
Makesurethebatterypackisconnectcorrectlyintotheventilator,asdescribedabovein
“Connection of Battery Pack”.
• Thenextstepistoleavetheventilatoro.Duringcharging,thebatteryindicatorlights
willash.Thebatterychargelevelcanberecognizedbythenumberoflightsthatare
constantlylit.
• IfbothbatteriesandACareconnected,thebatterieswillbeginchargingafter60
minutesofidletime.Ifonlyonesinglebatteryisconnect,thebatterywillbegin
chargingafter120minutesofidletime.
• Indicatorlightswillshowchargestateduringcharging.Chargingshouldcompletein
about5hours,withtheBatteryStatusIndicatorlightsturninggreenandalltheve
FuelGaugelightsonthebatteryturningred.ShouldtheSpeedControlbeturned
counterclockwiseonduringthecharge,chargingwillstop,andtheventilatorwillstart.
Chargingwillbeginagainafter15minofidletime.
• Afterchargingiscomplete,thechargerswillmaintainthebattery(s)bykeepingthe
ventilatorconnectedtoAC.
• Whilecharging,thebatterystatusLEDlightswillstrobe,aswellasthebatterycharge
indicatorstatuslightslocatedonthebatteryitself.Thebatterieswillbedisconnected
attheendoftheirchargeautomatically.Attheendofcharging,thecurrentpoweris
displayedfor5minutesandthenlightswillbeturnedo.
• IfalltheFuelGaugelightsareashing,thisindicatesanerrorcondition.
Charging Procedure

14 15
The Fuel Gauge
TheBatteryFuelGaugeprovidesbatterystatusinformationusingveredLEDs.
PresstheFuelGaugebuttontodisplaythelights.Thefuelgaugelightswillremainlitfor
approximatelyveseconds.
ThenumbersrepresenteachLEDandthegridishowthey'relaidout:
12345
FuelGaugeLights Diagnosis Solution
LEDs1-5:RedSolid RemainingRunTime ContinueWorking
LED1:RedFlashing
LEDs2-5:O
Lessthan13%runtimeleft ChargePack
LEDs1-5:RedFlashing BatteryTemperaturetoo
high
AllowBatterytoCool
Lessthan13%ifbottomlightisashing
35-55%56-76% 77-99% 100%
14-34%
Battery Status Indicator Lights
Onthecontrolpanelthereare2setsoflights:onthetopsideofthebatterylightsindicate
thechargelevelinthebatteryattachedtotheleftsideoftheventilator,onthebottomside
ofthebatterylightsindicatethechargelevelinthebatteryattachedtotherightsideofthe
ventilator.
Ifthebatteryischarging,thegreenindicatorlightswillhorizontallyscrollfromleft-to-right,
turningsolidgreenwhenthebatteryisfullycharged.
Iftheventilatorisrunningonbatterypower,theestimatedremainingbatterytimeis
shown.
Ifallthelightsashred,thisindicatesthatthebatteryhasfailedandthebatterymustbe
replaced.
Battery Pack Protection
• Toprotectitselffromdamageandextenditslife,thebatterypack'sintelligentcircuit
monitorscurrentdrawandtemperature.Inextremesituations,thebatterypackwill
turnOFFtheventilatorifthecurrentdrawbecomestoohigh.Allthefuelgaugelights
willash.
• Underextremecircumstances,theinternaltemperatureofthebatterycouldbecome
toohigh.Ifthishappens,thefuelgaugelightswillashinanalternatingpatternand
thetoolwillnotrun.
• Whileabatteryundergoesachargecycle,itstemperaturerises.Topreventgrid
corrosionandeventualbatteryfailure,allowthebatterytocooldowninbetween
charginganddischarging.
L
R
BAT. FAULT
PUSH FOR
WAKE | STOP
LIGHTS
PUSH FOR
MAX
SPEED
AC PWR
DC PWR FAULT
NO PWR
STORAGE
MODE
DC MAX
Intellisense
TM
E3

16 17
Storage/Transport Modes
Lithium-ioncellmanufacturersrecommendthatbatterycellsbestoredat30%state
ofcharge(SoC)forbestlong-termhealthandstability.Further,IATA(InternationalAir
TransportAssociation)DangerousGoodsRegulations(DGR)statethatalllithium-ion
batteriesmustnotexceed30%SoCattimeofshipment.
RAMFANbattery-poweredfansbuiltwithIntellisenseTME3controllersareequipped
withintegrated“Storage/TransportMode”tomakeiteasytocomplywithstorage
recommendationsandtransportregulationsbyautomaticallydischarginginstalledbattery
pack(s)to30%SoC.
1.PressandholdboththeWAKE|STOPandtheMAXbuttons,togetherfor8seconds,
untilthestatusLEDlightchangestoyellowashing.
2.Onceactivated,fanwillautomaticallyturnatlowRPMuntilbatterypackreaches30%
SoC.Once30%SoCreached,fanwillturno.
Storage/TransportModecanbeinterruptedbyturningSpeedControlatanytimeduring
theoperation.
Storage/TransportModecanbeengagedwitheitherone(1)ortwo(2)batterypacks
installedonthefan.
ACpowermustbedisconnectedforStorage/TransportModetobeactivated.
How to activate "Storage/Transport Mode"
L
R
BAT. FAULT
PUSH FOR
WAKE | STOP
LIGHTS
PUSH FOR
MAX
SPEED
AC PWR
DC PWR FAULT
NO PWR
STORAGE
MODE
DC MAX
Intellisense
TM
E3
MAX
MAX
AC Power Cord
CORD
STORAGE
ThisbatteryfanwasdesignedtoreplacecordedACfans,optimizingcordlessoperations.AC
powercordisdesignedtoberemovablefortheconvenienceofthoseuserswhochooseto
operatecordless.
ACpowerconnectorisa”Push-Pull”lockingsystemwheretheouter(blue)slidemustbe
pulledback,inlinewiththecable,tosecurelyengageconnector.
• WhenACpowerisneeded,push(blue)connectoronto(black)inletonfancontroller.
Checkthatitissecurelyengaged.
• WhendisconnectingACpowercordfromfan,pullbackon(blue)slidetodisengage
andgentlyremove.Storeinmarkedframepositionwhennotinuse.
Pulltheplugoutitself,neverbythecordorbywigglingitoutoftheoutlet.
RAMFANlithium-ionbatterypacksaredesignedtooperateinawiderangeof
temperatures.Duetothechemistryoflithiumionbatterycells,dierentoperationallimits
applytodischargeandchargefunctionality.
• Temperaturerange(discharge):-20oCto+45oC(-4oFto+113oF)
• Temperaturerange(charge):0oCto+40oC(32oFto104oF)
A“coldsoaked”batterymaynotpowerafanorbeabletotakeacharge.Ifthisoccurs,
warmupcoldbatteryatroomtemperature20oC(68oF)andtryagain.
Operating Limitations

18 19
Batterypacksdorequireroutinemaintenanceandcaretomaximizetheirusefullifeand
maintainwarrantycoverage.Readandfollowtheguidelinesinthismanualtosafelyuse
yourlithium-ionbatterypacksandachievebatterylifespan.
Lithium-Ion Battery Maintenance Guidelines
Accordingtoleadingcellmanufacturers(LG,Samsung,Panasonic),theestimatedlifeofa
lithium-ionbatteryis500chargecycles.Whenstatingapproximateusefullifeofabattery
inunitsof“chargecycles,”cellmanufacturersdenethisasthepointwherethebattery
capacity(Ah)isreducedto80%oforiginal.Thismeansbatteryisnot“dead”after500
chargecycles,butruntimeissignicantlyreduced,andreplacementshouldbeconsidered.
Partialdischargeoflithium-ionbatteriesisne.Thereisno“memoryeect”andthebattery
doesnotneedperiodicfulldischargecyclestoprolonglife.
Overview
Storage
Whenstoring,removebatterypacksfromfanandstoreinadryandcoollocation.Avoid
extremetemperatures.
• RecommendedStorageTemperature:5oC to 20oC(41oFto68oF)
• Maximumrelativehumidityduringstorage:90%RH
NOTE:allbatteriesself-dischargeduringstorage.Highertemperature(>20oC or 68oF)reduce
thebatterystoragelife.
Lithium-ionbatteriesshouldbestoredinachargedstate,ideallyaround30%stateof
charge(SoC).See“Storage/TransportMode”sectionofthismanualforeasydischarging
stepstofollowbeforestoringbatterypacks.
Long-term(>6months)storageofbatterypacksisnotrecommended.Whenabatterypack
hasbeenunusedfor6months,checkthechargestatusandeitherchargeordisposeofthe
batteryasappropriate.
Recommendations
• Batterypackswilllastsignicantlylongerwhenruninpairs(twobatterypacksperfan)
asthereis50%lessdischargecurrentperpack.
• Aswithanyequipment,batterieswillwearoutfasterwithheavyuse.Depthof
Discharge(DoD)determinesthecyclecountofthebattery.Thesmallerthedischarge
(lowDoD),thelessstressisenactedonthechemistryofthebatteryandthelongerthe
batterywillultimatelylast.Ideally,operatorsshouldavoidfulldischargesandcharge
thebatteryaftereveryuse.
• Partialdischargeoflithium-ionbatteriesisne.Thereisno“memoryeect”andthe
batterydoesnotneedperiodicfulldischargecyclestoprolonglife.Battery(s)willneed
tobereplacedastheyage.
Maintenance and Disposal
• DONOTdisassembletheventilatorformaintenancereasons.
• DonotloosenscrewsoncontrolboxwithoutcontactingEuramcocustomerservice.
Theyaretorquedtoasettingtoachievewatertightness.Cleanventilatorperiodically
toremoveaccumulateddustorparticlesfromventilatorguards.
• Assemblyscrewsaretorquedtoaspeciedvaluetoachievewatertightness.
Completelyunravelpowercordandplaceunitonaat,stablesurface.Cleanventilator
periodicallytoremoveaccumulateddustorparticlesfromventilatorguards,impeller
bladeandheatsinkinrearofcontroller(ribbed).Useonlybiodegradabledetergents.If
powerwashing,avoidcontrollerhousingespeciallygasketsandcontrolpanel.
• Contactfactoryforreplacementpartsandinstallationinstructions.Toorderspare
partscallEuramcoGroup+1.619.670.9590 or [email protected]
• Alwaysdisposeofyourbatterypackaccordingtofederal,stateandlocalregulations.
• Evendischargedbatteriescontainsomeenergy.Beforedisposingof,useelectricaltape
tocovertheterminalstopreventthebatterypackfromshortcircuit.
• Properlydisposeofbatterypackswhennecessary.Contactyourlocalhazardous
materialse-wastecollectiondepartmentfordetailsorproperdisposalofrechargeable
batteries.

20 21
MAINTENANCE SCHEDULE
REGULAR SERVICE PERIOD
Perform at every indicated month or operating
hour interval, whichever comes first.
ITEM
Each use Every 3
months
Every 6
months
Every year
Fan Inlet/Outlet
Gaurds
Visual Check •
Clean •(1)
Impeller Visual Check •
Clean •(1)
Control Box
Gaskets
Visual Check •(2)
Replace if necessary •(3)
Electrical Cables Check •
Rubber Feet Check •
Battery Packs:
Gaskets Visual Check •(2)
Replace if necessary •(3)
Electrical
Connector/USB
Connector
Visual Check •(2)
Internal Diagnostics Plug into USB if equipped •(3)
(1) Clean more frequently when used in high-sediment areas.
(2) Check immediately if dropped, or damage may affect water ingress protection.
(3) These items should be serviced by your RAMFAN servicing dealer, unless you have the proper
tools and are mechanically proficient. Refer to RAMFAN service manual for service procedures.
Failure to follow this maintenance schedule could result in non-warrantable failures.
Maintenance Schedule
Batterypacksshouldbeinspectedregularlyformechanicaldamage.
• Dropping,oranyotherheavyimpact,maycompromisewateringressprotection.
Quicklyinspectforobviousdamageaftereveryuse.Ifdamageisnoted,contact
AuthorizedServiceCenterforinspection,testing,andmaintenance.
• Damagetogasketmaycompromisewateringressprotection,increasingriskofpack
failure.
• Donotstoreinsamecompartmentwithcombustibleorhighlyammablematerialas
gasolineanddieseloil.
• Liquiddamageisnotcoveredunderwarranty.
Compatibility
Date Version Serial Number
(last 5 numbers) Update
08/2017 1.1 77091andhigher
Shroudincludesquickconnectwiring
harnessneededforeldinstallsofintegrated
mister.Note:Previousversionsoffan(last5
numbersofserialnumberare≤77090are
ineligibleformisterupgrade.
Accessories
1. External Battery Charger
 Chargebatteriesonreapparatus
 Order#R2C-5500DC
 Chargebatteriesatrestation
 Order#R2C-5500AC
 Order#R2C-5500AC230
2. Swappable 40V Li-Ion Battery Pack
 SpareBattery(recommendordering2)
 Order#R2-360-AH-U
3. Vehicle Mount Kit
 Custommountthatperfectlytsfan
 Order#EL600K
4. EX50Li Mister
Order#EL8111
5. Mister Adapters
DoubleFemaleNH1"Adapters
Order#WF20-0252
1"BSPTOSTORZ
 Order#GX-8020
6. Convert to a Smoke Ejector
 DoorBarandHangarKit
 Order#EL7095K
 HangerKit(ifyoualreadyowndoorbar)
 Order#EL8095
7. Convert to Con˜ned Space Rescue Fan
18”/46cmduct(16.4’/5mlength)
Order#FDT-185MSR
18”/46cmduct(32.8'/10mlength)
Order#FDT-181MSR
8. Shoulder Strap
Order#EL6013

22
iesr
WWW.EURAMCO.COM PROUDLY MADE IN CALIFORNIA
FlowPath™ Control
Euramco Safety Inc.
certifies that the
portable PPV
Blowers shown here
are licensed to bear
the AMCA SEAL.
Euramco Safety Inc. certies that the Portable PPV Blower
shown below is licensed to bear the AMCA Seal. The ratings
shown are based on tests and procedures in accordance with
AMCA Publication 211 and comply with the AMCA Certied
Ratings Program.
Why We Use AMCA
AMCA, The Air Movement and Control Association International,
has been in existence for nearly 80 years and is the world’s only
recognized authority for the development of standards and
measurement of air movement.
Our commitment to AMCA Certication is your veriable assurance that every RAMFAN PPV
Turbo Blower will perform exactly as specied.
Performance certied is for installation type A - Free inlet, Free oulet.
Performance ratings do not include the eects of appurtenances (accessories).
RAMFAN’s re ghting PPV Series outperforms larger blowers in their class with their precision
balanced TurboForce Impellers that maximize airow. These PPV blowers have proven to be eective
in controlling airborne contaminates, replacing interior air, removing heat and supplementing xed
ventilation systems. By pressurizing properly and controlling the resultant ow path, these changes
occur very rapidly. This is accomplished by using these specialized blowers with the power and velocity
to pressurize the interior of a structure or building.
SPECIFICATIONS AND PERFORMANCE RATINGS
2746 Via Orange Way | Spring Valley, CA 91978 USA | [phone] | [phone]
August 2019
AMCA
Euramco Safety Inc.
certifies that the
portable PPV
Blowers shown here
are licensed to bear
the AMCA SEAL.
MODEL SIZE HP DIMENSION (HxWxD) MOTOR
MFG/MODEL NOWEIGHT RPM SETBACK ANGLE AIRFLOW @ FULL SPEED
POWER
SUPPLY
in cm in cm lbs kg ft m tilt cfm m³/hr
EX150Li 18 46 1.8 23x21x19 58x53x48 Euramco EM-E1020 58 26 3550 16 4.9 11˚ 11,896 20,211 AC
EX150Li 18 46 1.8 23x21x19 58x53x48 Euramco EM-E1020 58 26 3600 16 4.9 11˚ 12,377 21,029 DC

SM-EX50LIREVH
080621
USA
2746ViaOrangeWay
SpringValley,CA91978USA
TollFree:(800)472-6326
Phone:+1(619)670-9590
Fax:+1(619)670-7345
[email protected]
LUXEMBOURG
1RueEdmondReuter,
5326Contern,Luxembourg
Phone:[phone]
Fax:[phone]
[email protected]
MIDDLE EAST – UAE
JebelAliFTZ,Dubai
Phone:+1(619)670-9590x114
Fax:+1(619)670-7345
[email protected]
CHINA
A11,No.1JinxiRoad
Qingshuipu,Zhenhai,Zhejiang
Ningbo,China315221
Phone:[phone]
Fax:[phone]
[email protected]
MADE IN THE USA
Use with all
US Firefighting
literature