Raypak HI DELTA 1802B User manual

Catalog No.: 6000.342B Effective: 8-15-08 Replaces: 3-1-07
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor/Outdoor: MBTUH Input:
Sealed Combustion Chamber
100% Factory Fire Tested
Efficiency: 85%
Minimum Non-condensing Inlet Temperature: 105°F
Thermal Shock Proof Heat Exchanger
Limited Twenty-year Thermal Shock Warranty
Limited Five-year Heat Exchanger Warranty
Diagnostic Center with Fault History
PolyTuf Powder Coated Cabinet
No Combustible Floor Shield Required
Fan-assisted
Non-ferrous Bypass
Patented Burner Security Blanket
Heat Exchanger
Bronze Headers
ASME Inspected and Stamped
160 PSIG Working Pressure
National Board Approved
Cupro Nickel Finned Tubing
ASME Steel Tube Sheet
Silicone High Temp O-Rings
125 PSIG ASME Pressure Relief Valve
Temperature and Pressure Gauge
Water Connections
Left – Standard
Right – Option A-6
Bronze Pump, 120V, 60Hz
Non-ferrous Pool Bypass
Controls
120V, 60Hz, 1∅Power Supply
120/24V 60Hz Transformer
100% Shut-off/Lockout
Hot Surface Ignition Systems (2)
Remote Flame Sensors (2)
High Limit Control, Auto Reset
On/Off Power Switch
Manual Shut-off, Front-mounted
Flow Switch
Blocked Vent Pressure Switch
Combustion Air Proving Switches
Economaster Pump Time Delay
Poolstat
Gas Train
Gas Pressure Regulators
Safety Shut-off Valves
Firing Control Valves
On/Off Firing
Low Gas Pressure Switch, Manual
Fuel
Natural Gas
Propane Gas
Design Certified ANSI Z21.56/
CSA 4.7
Burner
Ultra-low NOx:
Less than 30 PPM
Construction
Indoor/Outdoor Construction
Enclosed Front Controls
Venting
Vent Location
Top – Standard
Rear – Option D-14
Vent Termination Cap
Outdoor – Option D-11
Indoor, Horizontal –
Option D-15
Indoor, Vertical (by others)
Combustion Air
In-Line Filter Kit (TruSeal
only) – Option D-17
Air Intake Elbow –
Option D-16
Options
C-6 Ignition Module, Manual Reset
D-21 TruSeal™ Direct Vent
Right Side
Left Side (Model 1802B
Only)
F-10 Low Water Cut-off, Remote
Probe
S-2 Dual High Gas Pressure
Switches, Manual Reset
X-1 SureRack Kit, Zone III and IV
X-2 SureRack Add-on, Zone IV
Y-241 Temperature Controller,
1-4 Stages
Regulatory Agency Requirements
G-1 CSD-1
Hi Delta®- Type P
Commercial Pool Heaters
Models 1802B-2342B
L
W

Catalog No.: 6000.342B Effective: 8-15-08 Replaces: 3-1-07
Hi Delta – Type P
Models 1802B-2342B Model
Raypak, Inc.  2151 Eastman Avenue, Oxnard, CA 93030  [phone]  Fax [phone]  www.raypak.com
RATE OF FLOW AND PRESSURE DROP
Max. Flow Min. Flow
Model GPM ∆
∆∆
∆P (ft) ∆
∆∆
∆T GPM ∆
∆∆
∆P (ft) ∆
∆∆
∆T
1802B 132 18.7 23 102 11.2 30
2002B 132 19.2 26 113 14.0 30
2072B 132 19.2 27 117 15.1 30
2342B 132 21.0 30 132 21.0 30
MBTUH A K T W Amp Draw
Model Input Output Width Heater w/ Pump
Pump
Pump
HP
Shipping
Weight (Lbs.)
1802B 1800 1530 91-1/8 14 10 28-1/8 21 12 3/4 1350
2002B 1999 1699 102-1/2 14 10 31-15/16 24 12 1 1450
2072B 2070 1760 102-1/2 14 10 31-15/16 24 12 1 1450
2342B 2340 1989 113-7/8 16 10 35-11/16 24 12 1-1/2 1520
Dimensions are in inches.
Ratings shown are for elevations up to 5,000 feet and for natural or propane gas.
For installation at elevations over 5,000 feet, please contact manufacturer.