Rhima RR190 EVO User manual

Operator’s Manual
RR190, RR250, RR280 EVO
Rack Conveyor Washers
Australia Tel: [phone] | New Zealand Tel: [phone] | Singapore Tel: [phone]

INSTRUCTION MANUAL FOR DISHWASHERS
●The appliance must be connected to water and electrical supplies by qualified
tradespersons only and according to local regulations.
●The appliance must be used by adults only. Do not let children play with, or operate
this machine.
●Only persons trained to use this dishwasher are permitted to operate it.
●This appliance has been designed to wash food preparation and eating utensils. It has
NOT been designed to wash objects soiled with petrol, paint, remnants of steel or iron,
corrosive chemical products such as acids, alkalis, or solvents or any item that cannot be
immersed in water.
●Do not open the appliance door(s) while the appliance is operating. The appliance has
a safety device which stops operation if a door is accidentally opened.
●After using the appliance, isolate the electric and water supply.
●Do not attempt to repair the appliance. Repairs made by unqualified persons may cause
further damage and will void warranty.
●Repairs and servicing of this appliance must be carried out by Rhima personnel only.
GENERAL INSTRUCTIONS
It is important to keep this instruction manual near the appliance for
future consultation.
If the appliance is sold or transferred to another user, make sure this
manual remains with the appliance so that the new owner is informed
about the warnings and operation of the appliance. These instructions
are given for safety reasons and they must be read carefully before
installing or using the appliance.
IMPORTANT CUSTOMER INFORMATION
●To request a service, detergents or rinse additive contact your local Rhima Service centre
below:
Australia: 1300 347 944
New Zealand: 0800 902 054
Singapore: [phone]
2

ELECTRICAL INSTALLATION
The Australian installation shall be in accordance with The Plumbing Code of Australia (PCA).
This appliance should be connected to a hot water supply (Max 65°C ) for in accordance
with Australian Standard AS/NZS 3500.1. for optimum performance.
The water supply pressure should be a minimum 200 kPa at all times and flow rate should
be at least 15 litres per minute. A static pressure higher than 600 kPa (73.5 psi) requires a
pressure reducing valve upstream of the supply line. If water pressure is below 200 kPa,
the use of a rinse booster pump is recommended.
This appliance is designed to drain to a tundish. Waste connection to a spigot is not
recommended and may cause draining issues.
The drainpipe should withstand 70°C (158°F) in continuous duty conditions.
The grey water drain hose must have a fixed watertight seal above the tundish in
accordance with the Australian Standard AS/NZS 3500.2.
A DIAGRAM SHOWING THE CORRECT METHOD OF WASTE INSTALLATION IN ACCORDANCE
WITH THE AUSTRALIAN STANDARD AS/NZS 3500.2 IS BELOW
PLUMBING INSTALLATION
This appliance must be connected to an earthed 3-phase electrical switched outlet of an
appropriate rating.
VENTILATION
Use extractor fans to guarantee a minimum ventilation of 500 m³/h. Increase the
ventilation rate to 1500 m³/h if the machine is equipped with drying system. It is suggested
to position the extractor fans close to the machine entry and exit and in correspondence
to the heat recovery fans.
3

4

5

STAND-BY
BOILER TEMP
Available options
6

, Page 5
, Page 5
FUNCTIONING OF THE MACHINE
SIGNALS AND ALARMS
7

DETERGENTS
Dishes and cutlery loading
8

MAINTENANCE
9

10

11

End washing operations
12

1
3

MAINTENANCE
14

FREE THE OUTLET
READY TO START
E7 WASH1 PUMP
Extraordinary Maintenance - Heat Recovery wih heat pump optional
1
5

the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
16

Rhima Service Department
the Rhima Service Department to clean the
the filter.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
1
7

the Rhima Service Department.
Rhima Service Department
the Rhima Service Department.
the Rhima Service Department to connect
the machine separately.
the Rhima Service Department to check the
security devices.
the Rhima Service Department.
the overflow/drain
pipe.
Overflow/drain pipe positioned
incorrectly
the Rhima Service Department.
Rhima Service Department.
Rhima Service Department.
the overflow/drain pipe.
18

the Rhima
Service Department to
the Rhima Service Department.
the Rhima
Service Department to
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
the Rhima Service Department.
Rhima Service Department
contact the Rhima Service Department to clean the Heat
contact the Rhima Service Department to clean the Heat
Contact the Rhima Service Department
Contact the Rhima Service Department
contact the Rhima Service Department to clean the Heat
Contact the Rhima Service Department
1
9

Version 1.0
Australia Tel: [phone]
New Zealand Tel: [phone]
Singapore Tel: [phone]
DETERGENTS
To request detergents or rinse additive contact your local Rhima Service centre
below:
Australia: 1300 347 944
New Zealand: 0800 902 054
Singapore: [phone]
Superwash
10L Drum
For all other washing