San Jamar Saf-T-Wrap SW1218SC User manual

Saf-T-Wrap™Station
Portable Wrapping Station with Integrated Dating Label Dispenser
Cautions for Safety and Best Results
 •Althoughbladeisdesigndtohelppreventinjuries,partsmaybesharpandshouldbehandledwithcaution.
 •Donotloadlmorfoilwhilehangingonshelforonwall–alwaysloadonsecureatsurfacewithsuction
  cupsengaged.EnsurethatshelvingunitsaresecurebeforeplacingtheweightoftheSaf-T-Wrap™Station in
  placeorusing.
 •Whenusingonwireshelving,ensurefullengagementofhookstopreventinjuryandkeepanunobstructed
  pathtopreventaccidentallybeingknockedoffofshelf.
 •Topreventtipping–ensuresuctioncupsareengaged.
 •Donotplacedispenserunderheatlampornexttostoveoronhotsurface.
 •Whentransporting,ensurealllatchesandcoversarefullylatchedintheclosedpositionbeforecarrying,
  especiallyinaverticalorientation.
 •Whenloadinglmorfoil,usecautionwhenopening–theunitcoverwithdatinglabelstoragemaybe
  heavy–usecautionandsetcoverdowngentlyontablewhenreplacinglmorfoilrolls.
 •Intheeventoflm,foilordatinglabeljamming,ensureunitisonat,securesurfaceandopenunittoadjust;
  don’tforceittopreventinjury.
 •Useextremecarewhenreplacingbladesandcutterstoavoidinjury.
Replacement Parts and Accessories
ItemNumber Product Description
XSW1218-SC Saf-T-Wrap™StationSuctionCupKit (4)suctioncupsand(4)screws/washers
XSW1218-RC Saf-T-Wrap™StationRotationLabelCover Coverforlabelcompartment
XSW1218-CS Saf-T-Wrap™StationStorageCoverSet Leftandrightsidecovers
XSW1218-SR Saf-T-Wrap™StationSupportRod Supportrodassembledwith(2)endplugs
XSW1218-RD Saf-T-Wrap™StationRotationLabelDividersKit (7)dividers
XSW1218-RA Saf-T-Wrap™StationRollWidthAdaptorsKit (2) roll width adapters
XSW1218-SLIDE Saf-T-Wrap™StationReplacementSlideCutter (2)replacementcutters
XSW1218-RB Saf-T-Wrap™StationReplacementCuttingBlades (2)replacementblades
XSW1218-HB Saf-T-Wrap™StationWallMountingBracketKit (2)wallhangingbrackets(fastenersnotincluded)
101743RevA
SanJamar
ChefRevival
555 Koopman Lane
Elkhorn,Wisconsin 53121
USA
T: +1.262.723.6133
F: +1.262.723.4204
[e-mail]
SJCREurope
Schoorstraat 26A
Bus-1 B-2220 Heist op-den Berg
BELGIUM
T: [phone]
F: [phone]
[e-mail]
SJCRMéxico
Av. Universidad #1377-701
Colonia Axotla CP 01030
Del. Álvaro Obregón
MÉXICO, DF
T: [phone]
F: [phone]
[e-mail]
SJCRCanada
3300 Bloor Street West
CenterTower, 11th Floor,
Suite 3140
Toronto, ON M8X 2X3
CANADA
T: +1.416.760.7367
F: +1.416.207.2071
[e-mail]
Main Photo-
SW1218SC-Slide Cutter
Inset Photo-
SW1218 - Safety Blade

1. Opening Saf-T-Wrap
™
Station:
•Applyinwardpressuretolatchesandliftupwardtorelease.
2. Adjusting roll adaptors for size of roll
• Insertadaptorsinappropriateslotinbasetocenterroll.
(Note:Adaptorscanonlybeinstalledintoslotsinonedirection
 allowingtheadaptortofullyinsertintotheslot,otherwisetheroll
 extendstoohigh.Makesureendsoftubesareseatedinthecradle.)
• Note:if18”rollisused,noadaptorsarenecessary–storeadaptors
 inrearcenterpocketwhennotbeingused.
3. Loading and Dispensing film or foil
a.Inserttubethroughfoilorlm,seatrollandtubeintounitallowing
 thelmorfoiltounrollfromthetop(asshown)–makesure
 rollturnsfreely.
b.Unrollapprox12”oflm/foilforeasiestfeedingthroughdispensingslot,
 gatherendstogetherincentertofeedthroughcenter“EasyFeed”slot.
c.Closeandlatchunit.Pulloutafewinchesoflm/foiltostageonblade
 (SW1218)orslidecutter(SW1218SC)forrstuse.
* Do not load film or foilwhileunitishangingonshelformountedonwall.
4. Loading and Dispensing dating rotation labels
• Opendatinglabelcover.
• Determinesizeandnumberofrollstoload(Note:dividersallowrange
ofwidthsfrom¾”upto2¼”andcapacityupto(11)1”rolls.)
  a. Positiondividerstoholdpreferredrollcongurationsecurely
   inplace.
  b. Referringtothediagramonendsofinteriorofdatinglabelarea,
   positionrollstodispenseasshown–feedstripsoflabelsthrough
   slottedcoverasshownindiagram.
• Closeandsnapcovershut
  c. Todispense:pullendofstriptoselfpeellabelsasshown
  d. Manuallytearremainingstripbackingasneededtonotimpede
   foil/lmdispensing.
5. Loading and UsingTool Storage:
• Pushsidetabstoopencover;pressdownsecurelytolatch.
6. Replacing Blade/Slide Cutter
Overtime,thebladeorslidecutteronyourSaf-T-Wrap
™
Stationwillbecome
dullorsoiledandneedreplacing.Carefullylifttheblade/cutteroffoftheSaf-
T-Wrap
™
Stationanddiscard.Toinstallanewblade/cutter,lineuptheunder-
sideoftheblade/cutterwiththeblade/slidecutterrailbetweenthetwotabs
andpushsecurelyintoplace.
 Thebladeandslidecuttersareinterchangeable,providingmaximumexibility.
7. Transporting
Makesureallstorageanddatinglabeldoorsareclosedbeforetransporting.
Dualhandlesmakeitpossibletotrasportusingonehand.
Saf-T-Wrap™Station Instructions
1.
2.
3. a. b.
c.
5.
Versatile Options for Use
 •Countertop,TableTop
  Formaximumstability,ensuresuctioncupsaresecurelyengagedonthesurfacebeforeuse.
 •HangingonWireShelving
Theintegratedhookfeatureinthebackoftheunitallowssecurehanginganduseonstandardwireshelves. 
  Simplyhangtheunitontheshelfensuringhooksengagetightlywiththeshelf.
ThankyouforpurchasingSanJamar’sSaf-T-Wrap™Station,aportablewrappingstationwithintegrateddating
labeldispenser.Pleasetakeamomenttoreviewthekeyfeaturesandinstructionsforuse.
Capacity: Foil/Film:width-12"upto181/2",length-standard2,000'foodservicerollsorupto5.1"diameter
Dating Labels: 31/4"max.diameter,21/4"maxrollwidth
Instructions For Use
Getting Started:
•PleasecleanandsanitizeyourSaf-T-Wrap™Stationbeforerstuse.
 •ReadentireInstructionsincludingCautions for Safety and Best Results.
 •Pleaseensureallusersofthisproductareproperlytrainedoninstructionsforuse;
  retainthisinstructionsheetforfuturereferenceandtraining.
Cleaning
 •Saf-T-Wrap™Stationisdishwashersafeandshouldbecleanedbeforerstuse,thenasneededtoensuresanitaryuse.
 •Beforewashing,ensurealltools,datinglabelsandlm/foilrollsareremoved.
 •Yourunithasdrainholesonthebottomtoensurecompletedrainingofwash,rinseandsanitizewater.
 •Alwaysensureunitiscompletelydrybeforeloadingrollsandtoolsaswellasgeneraluse.
Saf-T-Wrap™Station
onwireshelving
Saf-T-Wrap™Stationmountedonwall
usingbrackets
•WallMountingfastenersarenot
includedwiththeWallBrackets.
Makesuretoselectfastenersand
wallanchorssuitableforthewall
typeyouwillbemountingto,andare
capableofsupportingaweightofat
least20lbsperbracket.
CONTENTS
(7)RotationLabel
RollDividers
SW1218-RD
(2)RollWidth
Adaptors
SW1218-RA
(1)Saf-T-Wrap™Station (1)SupportRod
SW1218-SR
(2)WallMounting
Brackets
SW1218-HB
4.
c.
a. b.
d.
SW1218-(4)totalBlades,(1)installed,
orSW1218SC(1)SlideCutter,installed
or
6.
7.