Snorkel TB125J Owner's manual

October 2016
Part Number 0192647
MANUAL
REPAIR PARTS
Manufactured 07-05 and after
Models TB125J/T125J
Replaces 0191909 March 2014
0192216

GENERAL INFORMATION
GENERAL INFORMATION 1-1
REPAIR PARTS
CHASSIS HYDRAULIC INSTALLATION 2-1
AXLE INSTALLATION 2-2
EXTENDABLE AXLE 2-3
AXLE STOP INSTALLATION 2-4
STEERING INSTALLATION 2-5
TIRES AND WHEELS 2-6
GEAR HUB AUBURN 2-7
CHASSIS/TURNTABLE INSTALLATION 2-8
TURNTABLE ASSEMBLY KUBOTA V2403 TIER 4 FINAL FEBRUARY 2019 AND BEFORE 2-9
LIFT/SWING AND COUNTERWEIGHT INSTALLATION 2-10
SWING DRIVE 2-11
SWING DRIVE PERFECTION 2-12
FUEL TANK INSTALLATION DECEMBER 2008 AND BEFORE 2-13
FUEL TANK INSTALLATION JANUARY 2008 AND AFTER 2-14
HYDRAULIC OIL RESERVOIR ASSEMBLY 2-15
ENGINE TRAY ASSEMBLY 2-16
ENGINE SUB-ASSEMBLY KUBOTA 2-17
POWER UNIT ASSEMBLY 2-18
ENGINE CUMMINS 3.3 TURBO 85HP (REPLACEMENT PARTS) 2-19
V2403-CR TIER 4B KUBOTA ENGINE REPLACEMENT PARTS 2-20
V2403-M-T-E3B-KEA-2F KUBOTA ENGINE WITH RADIATOR REPLACEMENT PARTS 2-21
RADIATOR MOUNTING 2-22
ENGINE KUBOTA SUB ASSSEMBLY V2403 CR T4F 2-23
ENGINE KUBOTA V2403 CR TIER 4B DIESEL OXIDATION CATALYST MUFFLER 2-24
AIR CLEANER CUMMINS 2-25
AIR CLEANER 2-26
EXHAUST /AIR CLEANER INSTALLATION KUBOTA 2-27
COWLING INSTALL 2-28
BOOM ASSEMBLY 2-29
BOOM, ANGLE SENSOR ASSEMBLY 2-30
BOOM ASSEMBLY LENGTH SENSOR 2-31
BOOM/HOSE CARRIER 2-32
HOSE CARRIER ASSEMBLY 2-33
5FT JIB ASSEMBLY 2-34
PLATFORM MOUNTING 2-35
SNORKEL GUARD ASSEMBLY 2-36
LEGACY SNORKEL GUARD KIT 2-37
PLATFORM GATE 2-38
PLACARDS AND DECALS 2-39
HYDRAULICS

HYDRAULIC EQUIPMENT-CHASSIS 3-1
DRIVE MOTOR WITH BRAKE 3-2
DRIVE CONTROL VALVE 3-3
SERIES PARALLEL PACKAGE RIGHT HAND 3-4
ANTI-CAVIATION VALVE SEPTEMBER 2015 AND BEFORE 3-5
ANTI-CAVIATION VALVE SUB-ASSEMBLY DECEMBER 2015 AND AFTER 3-6
ANTI-CAVIATION VALVE 3-7
STEER CUT OUT VALVE FOUR WHEEL DRIVE 3-8
DUAL SEQUENCE VALVE LEFT HAND 3-9
DUAL SEQUENCE VALVE FOUR WHEEL DRIVE RIGHT HAND 3-10
CAM VALVE 3-11
AXLE INTERLOCK 3-12
HIGH RANGE SPEED SELECTOR VALVE 3-13
AXLE JACKING CONTROL VALVE 3-14
HYDRAULIC EQUIPMENT TURNTABLE WITH HOSES MARCH 2017 AND BEFORE 3-15
TURNTABLE HYDRAULIC EQUIPMENT KU APRIL 2017 AND AFTER 3-16
CENTERPOST AND FITTINGS SUB ASSEMBLY 3-17
PUMP CONTROL VALVE ASSEMBLY 3-18
HYDRAULIC PUMP AND FITTINGS 3-19
EMERGENCY POWER UNIT LEFT HAND 3-20
EMERGENCY POWER UNIT RIGHT HAND 3-21
SHUTTLE VALVE ASSEMBLY 3-22
NON-PROPORTIONAL CONTROL VALVE ASSEMBLY FEBRUARY 2006 AND BEFORE 3-23
NON-PROPORTIONAL FOUR STATION VALVE 3-24
NON-PROPORTIONAL CONTROL VALVE ASSEMBLY MARCH 2006 AND AFTER 3-25
NON-PROP VALVE 3-26
PROPORTIONAL CONTROL VALVE ASSEMBLY MAY 2015 AND BEFORE 3-27
PROPORTIONAL VALVE MAY 2015 AND BEFORE 3-28
PROPORTION CONTROL VALVE ASSEMBLY WITH NEW JIB ONLY JUNE 2015 AND AFTER 3-29
PROPORTIONAL CONTROL VALVE JUNE 2015 AND AFTER 3-30
PRESSURE MANIFOLD 3-31
HYDRAULIC OIL RETURN FILTER 3-32
ACCUMULATOR CHARGED 3-33
BLOCKING VALVE 3-34
CHECK VALVE MANIFOLD 3-35
PLATFORM JIB SELECTOR VALVE ASSEMBLY 3-36
PLATFORM JIB SELECTOR VALVE 3-37
JACKING CYLINDER SUB ASSEMBLY 3-38
JACKING CYLINDER 3-39
LEVEL AND STEER CYLINDER ROSENBOOM 3-40
AXLE EXTEND CYLINDER 3-41
LIFT CYLINDER SUB-ASSEMBLY 3-42
MASTER LEVEL CYLINDER 3-43
EXTENSION CYLINDER ASSEMBLY 3-44
EXTENSION CYLINDER GBI 3-45

JIB CYLINDER HENGLI 3-46
JIB CYLINDER ROSENBOOM 3-47
MASTER LEVEL CYLINDER ROSENBOOM 3-48
SLAVE LEVEL CYLINDER ASSY 3-49
SLAVE LEVEL CYLINDER 3-50
PLATFORM SLIDING CYLINDER 3-51
DUAL HOLDING VALVE 3-52
MOTION CONTROL VALVE 3-53
PLATFORM ROTATOR ASSEMBLY 3-54
PLATFORM ROTATOR 3-55
ELECTRICAL
TURNTABLE ELECTRICAL CUMMINS AND KUBOTA 4-1
TURNTABLE WIRE ASSEMBLY 4-2
WIRE ASSEMBLY EMS PRIMARY 4-3
WIRE ASSEMBLY EMS BACK UP MARCH 2005 AND AFTER 4-4
WIRING BOX GROUND CONTROL ASSEMBLY 4-5
WIRING BOX PANEL SUB-ASSEMBLY KUBOTA 4-6
JUNCTION BOX ASSEMBLY 4-7
JUNCTION BOX PANEL ASSEMBLY 4-8
BOOM LIFT SWITCH 4-9
BOOM ELECTRICAL INSTALLATION 4-10
BOOM CALIBRATION SWITCH APRIL 2008 AND BEFORE 4-11
BOOM CALIBRATION SWITCH ASSEMBLY MAY 2008 AND AFTER 4-12
BOOM SPEED SWITCH MAY 2007 AND BEFORE 4-13
BOOM SPEED SWITCH ASSEMBLY JUNE 2007 AND AFTER 4-14
DRIVE SPEED SWITCH MAY 2007 AND BEFORE 4-15
DRIVE SPEED CUTOUT SWITCH SUB-ASSEMBLY JUNE 2007 AND AFTER 4-16
EXTEND CUT-OUT SWITCH 4-17
EXTEND CUTOUT SWITCH ASSEMBLY JUNE 2007 AND AFTER 4-18
PLATFORM/JIB SELECTOR - WIRE ASSEMBLY 4-19
SAFETY INTERLOCK WITH SLIDING PLATFORM 4-20
PLATFORM FOOT SWITCH ASSEMBLY 4-21
SNORKEL GUARD WIRING 4-22
UPPER CONTROL BOX ASSEMBLY 4-23
CONTROLLER DRIVE STEER 4-24
CONTROLLER EXTEND RETRACT 4-25
CONTROLLER LIFT SWING 4-26
CONTROLLER JIB ELEVATION 4-27
110V POWER TO PLATFORM INSTALLATION 4-28
OPTIONS
HYDRAULIC GENERATOR INSTALLATION 110V 5-1
HYDRAULIC AC GENERATOR SUB ASSEMBLY 110V 5-2
VALVE HYDRAULIC MOTOR FLOW CONTROL 5-3
AC GENERATOR VALVE 5-4

HYDRAULIC AC GENERATOR 220V 5-5
BEACON, DUAL AMBER 5-6
BLOCK HEATER CUMMINS 3.3 5-7
HYDRAULIC WARM UP 5-8
ISOLATION VALVE INSTALLATION 5-9
ALARM MOTION DRIVE ONLY 5-10
HEAD AND TAIL LIGHTS 5-11
PLATFORM WORK LIGHTS 5-12
MAINTENANCE
MAINTENANCE, TB125J 6-1
SCHEMATICS
TB125J ELECTRICAL SCHEMATIC CUMMINS A19058A 7-1
TB125J ELECTRICAL SCHEMATIC CUMMINS CE A19060A 7-2
TB125J HYDRAULIC SCHEMATIC A19059A 7-3
TB80 TB100J TB125J TB126J HYDRAULIC SCHEMATIC A11011B 7-4
TB125J TB126J HYDRAULIC SCHEMATIC 0191268A 7-5
TB125J TB126J ELECTRICAL SCHEMATIC A19035E CUMMINS 3.3 GLOW PLUG WIRING 7-6
A A
B B

The aerial platform is not electrically insulated. Death or serious injury will result from contact
with, or inadequate clearance from, an energized conductor.
Do not go closer than the Minimum Safe Approach Distance as dened by ANSI standards.
Regard all conductors as energized.
Allow for electrical wire sag and aerial platform sway.
If the platform, boom structure, or any part of the aerial platform contacts a high-voltage electrical
conductor, the entire machine can become electrically charged.
If that happens, remain on the machine and do not contact any other structure or object. This in-
cludes the ground, adjacent buildings, poles, and any other objects that are not part of the aerial
platform.
Such contact could make your body a conductor to the other object, creating an electrical shock
hazard resulting in death or serious injury.
Ifanaerialplatformisincontactwithanenergizedconductortheplatformoperatormustwarnground
personnelinthevicinitytostayaway.Theirbodiescanconductelectricitycreatinganelectricalshock
hazard resulting in death or serious injury.
Do not approach or leave the aerial platform until the electricity has been turned off.
Do not attempt to operate the lower controls when the platform, scissors structure, or any part of
the aerial platform is in contact with a high-voltage electrical conductor or if there is an immediate
danger of such contact.
Personnel on or near an aerial platform must be continuously aware of electrical hazards, recogniz-
ing that death or serious injury can result from contact with an energized conductor.
California
Proposition 65 Warning
Battery posts, terminals and related accessories contain lead
andleadcomponents,chemicalsknownto theStateof California
to cause cancer and birth defects or other reproductive harm.
Wash hands after handling.
California
Proposition 65 Warning
Diesel and gasoline engine exhaust and some of its constituents
areknown bythe StateofCalifornia tocause cancer,birth defects
or other reproductive harm.
© Snorkel International, Inc. – all rights reserved

TB125J – 0192647 i
General Information
About This Manual
ThismanualcoversTB125Jaerialplatforms.Information
is included for machines that have been manufactured
toconformtoallapplicablerequirementsofthe following
organizations:
yAmerican National Standards Institute (ANSI)
yCanadian Standards Association (CSA)
yEuropean Committee for Standardization (CE)
Part pages include a drawing and a bill of material.
The bill of material lists the item number that is on the
drawing, the Snorkel part number, quantity used and a
description of the item.
Some callouts in the drawings may have a balloon with
two numbers. The top number is the item number and
the bottom number is the quantity of the item at that
location.
While Snorkel has attempted in every way to conrm that
all information in this manual is correct, improvements
are being constantly made to the machine that may not
be reected in this manual.
If you nd information in this manual that is not correct
or is confusing, you are urged to report your ndings to
Snorkel for our evaluation. Your input is important to us
and will be used in future printings of this manual.
This machine is covered by a limited warranty that spe-
cically identies items warrantied by Snorkel and those
items covered by original manufacturer's warranty. A
copy of the Snorkel Limited Warranty is located on the
inside of the back cover of this manual.
Repairs and Maintenance
Every person who maintains, inspects, tests or repairs
the machine must be qualied and authorized to do so.
ACaution
Do not modify this aerial platform without prior writ-
ten consent of Snorkel Engineering Department.
Modication may void the warranty, adversely affect
stability or affect the operational characteristics of
the aerial platform.
Abbreviations
The following abbreviations may be used in this man-
ual.
AC alternating current
ANSI American National Standards Institute
AR as required
CCA cold cranking amps
cm centimeter
DC direct current
ft feet
GFCI ground fault circuit interruptor
in inch
lbs pounds
mm millimeter
no number
NPT national pipe thread
psi pounds per square inch
qty quantity
rpm revolutions per minute
UL Underwriters Laboratories Inc.
Additional Information
All correspondence relative to this machine, such as eld
reports, discrepancy reports, requests for information,
etc., should be directed to:
Snorkel North America
P.O. Box 1160
St. Joseph, MO 64502-1160 USA
Phone: [phone]
Snorkel Europe
Vigo Centre
Birtley Road
Washington
Tyne & Wear
NE38 9DA
Phone: [phone]
http://www.snorkellifts.com

TB125J – 0192647
ii
Jib
Serial Number Placard
Above Lower Controls
Serial Number • Model Number
Platform Identication Placard
On Inside Front of Platform
Serial Number • Model Number
Upper Controls
Chassis
Wiring Box
Lower
Controls
Operator’s
Manual
Fuel Tank
Platform
Platform Foot Switch
Tip Boom
First Intermediate
Boom
Main Boom
Batteries
Battery Disconnect
Switch
Hydraulic Fluid Tank
and Filter
Engine
Emergency
Lowering Valve
Right Side
Left Side
Second Intermediate
Boom
LP Fuel Tank
Component Identication

TB125J – 0192647
Service and Parts Information
Ordering Parts
Whenplacinganorderforserviceorrepairparts,please
havethefollowingmachine information readilyavailable.
yModel number
ySerial number
ySnorkel part number
yDescription of part
yQuantity of parts required
yYour purchase order number
yAddress for order to ship to
yThe desired shipment method
If ordering parts off-line, the parts order form on the
following page may be mailed or faxed to the attention
of the Parts Department at the following location:
Snorkel North America
P.O. Box 1160
St. Joseph, MO 64502-1160 USA
Phone: [phone]
Parts Fax: [phone]
Snorkel Europe
Vigo Centre
Birtley Road
Washington
Tyne & Wear
NE38 9DA
Phone: [phone]
Parts Fax: [phone]
Attention: Parts Department
For your convenience, our electronic on-line ordering
system is accessible from the following Internet location:
http://www.snorkellifts.com
ANSI and OSHA Compliance
All owners and users of the aerial platform must read,
understand and comply with all applicable regulations.
UltimatecompliancetoOSHAregulationsistherespon-
sibility of the user and their employer.
ANSI publications clearly identify the responsibilities
of all personnel who may be involved with the aerial
platform. A reprint of the “Manual of Responsibilities
for Dealers, Owners, Users, Operators, Lessors and
Lessees of ANSI/SIA A92.5-2006 Boom-Supported
Elevating Work Platforms” is available from Snorkel
dealers or from the factory upon request.
Copies are also available from:
Scaffold IndustryAssociation, Inc.
P.O. Box 20574
Phoenix, AZ 85036-0574 USA
Manuals
Manuals are available from Snorkel to support any of
the machines that we produce.
The specic manuals for TB125J aerial platforms are
as follows:
TB125J – Operator’s Manual ANSI
Snorkel part number – 0192214
TB125J – Repair Parts Manual
Snorkel part number – 0192647
ANSI Manual of Respobsibilities
ANSI/SIAA92.5-2006
Snorkel part number – 0084053
Machine Information
Model Number:
Serial Number:
Date of Purchase:
Purchased From:
Snorkel Dealer or Distributor:
iii

TB125J – 0192647
Parts Order Form
Date:
Company:
Address:
Contact Name:
Phone Number:
Fax Number:
Account Number:
Purchase Order Number:
Model Number:
Serial Number:
Ship To:
Shipping Method:
Part Number Description Quantity
Note: Backordered parts will be shipped as soon as available using the same shipping method as the original
order unless otherwise indicated below.
Ship complete order only. Do not backorder parts.
Ship all available parts and disposition of backordered parts.
Other instructions as specied:
Fill out completely and fax attention Parts Department to:
Snorkel USA 1-785-989-3077
Snorkel Europe [phone]
iv

REPAIRPARTS
TB125J PARTS MANUAL CHASSIS HYDRAULIC INSTALLATION
CHASSIS HYDRAULIC INSTALLATION Tue Mar 23 02:55:53 UTC 2021 2-1

TB125J PARTS MANUAL CHASSIS HYDRAULIC INSTALLATION
CHASSIS HYDRAULIC INSTALLATION Tue Mar 23 02:55:53 UTC 2021 2-1

アイテム 部品番号 名前 数量 UOM
- A19074AB CHASSISHYDRAULIC
INSTLLATIONMAY2017AND
AFTER
EA
1 0111291 CONTROLVALVESUB-
ASSEMBLY A/R EA
2 0111292 JACKINGCYLINDERSUB-ASSY 1 EA
3 6010222 CAMVALVE 3 EA
4 0111290 SHUTTLEVALVESUB-ASSEMBLY A/R EA
5 0111273 ANTI-CAVVALVESUB-
ASSEMBLY-L.H A/R EA
6 0111344 HIGHRNGSPDSELVALVESUB-
ASSEMBLY A/R EA
7 0111264 DRIVEVALVESUB-ASSEMBLY A/R EA
8 0110495 BASEPLATECAMVALVE 3 EA
9 0110590 TUBECLAMP-BARW/BONDED
RUBBER 1 EA
10 5034203 FTGELB90UN-6S-6SSTL 1 EA
11 5036705 FTGTEESWVLRUN-6S-6SSTL 2 EA
12 5034505 FTGELB90BHD-12S-12SSTL-PH
12 1 EA
13 5070026 CAPWHEELSERVICE- 2 EA
15 5569880 SCREWMACHSKTHD10-24X
.625 12 EA
16 5560654 WSHRLOCK#10SPLITTYPE 12 EA
17 0111305 GUARD 1 EA
18 5035408 FTGTEEBHDRUN-12S-12SSTL 3 EA
19 970319 BLTHEXHD.313-182.50GR5 6 EA
20 987109 WSHRLOCK.313 6 EA
21 984089 NUTHEX.313-18 2 EA
22 972469 BLTFLSKTHD.375-16X1.00
GR 2 EA
23 970426 BLTHHD.375-16X.875 9 EA
24 970469 HHDBLT.375-16X1.00GR5 8 EA
TB125J PARTS MANUAL CHASSIS HYDRAULIC INSTALLATION
CHASSIS HYDRAULIC INSTALLATION Tue Mar 23 02:55:53 UTC 2021 2-1

アイテム 部品番号 名前 数量 UOM
25 987119 WSHRLOCK.375 17 EA
26 986299 WASHER,FLAT,.375STANDARD,
PLATED 15 EA
27 984109 NUTHEX.375-16 8 EA
28 5560693 BLTSKTHD.750-101.75-
$C075C 4 EA
29 987179 WSHRLOCK.750 4 EA
30 5035303 FTGELB90STRTHD-4B-4SSTL 6 EA
31 0112030 SPCR.1251.003.00STLSP 2 EA
32 5075203 -FTGPLHEXHD-4BSTL 6 EA
33 0111492 VALVE A/R EA
34 0111535 RHSERIESPKGVALVE4X4 A/R EA
35 0111536 VALVE A/R EA
38 5037008 ADAPTER90°ELBOWSWIVEL-
12JIC 1 EA
40 987099 WSHRLOCK.250 4 EA
41 986019 WSHRFLAT.250 4 EA
43 0111530 VALVE A/R EA
44 0111528 VALVE A/R EA
Not
Shown 5035708 FTGELB45STRTHD-12B-12SSTL 1 EA
Not
Shown 5560033 .375-16UNCHEXLOCKNUT 2 EA
50 970169 BOLTHEXHD.250-202.00GR5 2 EA
51 969979 BLTHEXHD.250-20X4.50GR5 2 EA
101 0111282 HOSE-12-12S-12S190100R2 3 EA
102 0111283 HOSE-12-12S-12S142100R2 1 EA
103 0040276 HOSE-4-4S-4S20.5100R1 3 EA
104 0111285 HOSE-12-10S-10S36100R2 1 EA
105 0090402 HOSE-6-6S-6S108100R2(SEE
PAGE2) 2 EA
106 0100270 HOSE-4-6S-6S108100R1 2 EA
TB125J PARTS MANUAL CHASSIS HYDRAULIC INSTALLATION
CHASSIS HYDRAULIC INSTALLATION Tue Mar 23 02:55:53 UTC 2021 2-1

アイテム 部品番号 名前 数量 UOM
107 0070779 HOSE-4-6S-6S23.75100R1 2 EA
108 0080386 HOSE-4-4S-4S70100R1 1 EA
109 0080359 HOSE-4-4S-6S23.5100R1 1 EA
110 0070781 HOSE-4-6S-6S52100R1 1 EA
111 0070782 HOSE-4-6S-6S66100R1 1 EA
112 0070780 HOSE-4-6S-6S36100R1 2 EA
113 0070771 HOSE-4-4S-4S77100R1 2 EA
114 0070773 HOSE-4-6S-6S13.5100R1 3 EA
115 0020276 HOSE-6-6S-6S27.625100R2 1 EA
117 0080939 HOSE-12-12S45-12S31.5100R2 1 EA
118 0323885 HOSE-12-10S-12S37100R2 1 EA
119 0323804 HOSE-12-12S-12S24100R2 2 EA
120 0080524 HOSE-12-12S-12S30100R2-30 4 EA
121 0110171 HOSE-12-12S-12S44100R2 3 EA
122 0111286 HOSE-6-6S-6S84100R2 1 EA
123 0100491 HOSE-4-4S-4S150100R1 2 EA
124 0110173 HOSE-12-12S-12S41100R2 4 EA
125 0081080 HOSE-6-6S-6S65100R2 1 EA
126 0020280 HOSE-4-4S-4S23.5(SEEPAGE
2) 6 EA
127 0111346 HOSE-4-4S-4S133100R1 1 EA
128 0100278 HOSE-4-4S-4S43100R1 1 EA
129 0070768 1/4I.D.HOSEASSY 1 EA
130 0070911 HOSE-4-4S-4S62100R1 1 EA
131 5080015 LASTCHANCEFILTER 8 EA
132 0070783 HOSE-4-6S-6S76.5100R1 2 EA
133 0070765 HOSE-4-4S-4S29100R1 1 EA
134 0073040 HOSE-8-8S-8S28100R2 2 EA
135 0070792 HOSE-8-8S-8S32100R2 1 EA
136 0090299 HOSE-4-6S-6S43100R1 1 EA
TB125J PARTS MANUAL CHASSIS HYDRAULIC INSTALLATION
CHASSIS HYDRAULIC INSTALLATION Tue Mar 23 02:55:53 UTC 2021 2-1

アイテム 部品番号 名前 数量 UOM
137 0020424 HOSE-8-8S-8S30100R2 1 EA
140 970469 HHDBLT.375-16X1.00GR5 2 EA
141 986299 WASHER,FLAT,.375STANDARD,
PLATED 4 EA
142 5560033 .375-16UNCHEXLOCKNUT 2 EA
TB125J PARTS MANUAL CHASSIS HYDRAULIC INSTALLATION
CHASSIS HYDRAULIC INSTALLATION Tue Mar 23 02:55:53 UTC 2021 2-1

REPAIRPARTS
TB125J PARTS MANUAL AXLE INSTALLATION
AXLE INSTALLATION Tue Mar 23 02:55:54 UTC 2021 2-2

アイテム 部品番号 名前 数量 UOM
- 0190782C AXLEINSTALLATION EA
1 0110283 POWERWHEEL 2 EA
2 6030037 VRDRIVEMTRW/BRAKEVON
RUDEN 2 EA
3 0190969 ENDFLANGE-RH 2 EA
4 0190968 ENDFLANGE-LH 2 EA
5 0190713 HOSECARRIERTUBE
WELDMENT 2 EA
6 0190709 CYLINDERASSEMBLY
EXTENDINGAXLES- 1 EA
7 0110261 WLDMTPINAXLEEXTCYLDR 1 EA
8 0110260 WLDMTPINAXLEEXTCYL 1 EA
9 0080293 SLIDEPAD 4 EA
10 0070030 SHIM(NOTE5)(.030) A/R EA
11 0072567 SPCR2.005.88.063 A/R EA
12 0090141 SHIM(.090) A/R EA
13 5065707 FTGADPTRSTRTHD-6B-6SSTL-
PH 2 EA
14 5035305 FTGELB90STRTHD-6S-6SSTL 2 EA
15 5037005 TERMFEMF.I..25016/14 1 EA
16 0191362 WLDMTAXLETUBERH4X4 A/R EA
17 0191363 WLDMTAXLETUBELH4X4 A/R EA
18 0110731 STOPBAR 8 EA
19 5035319 FTGELB90STRTHD-16B-12SSTL 2 EA
20 5035303 FTGELB90STRTHD-4B-4SSTL 2 EA
21 7110159 O-RING5.00ID5.19OD.09470D 2 EA
22 5560245 Bolt 4 EA
23 5560099 BLTSKTHD.625-111.75HEX
LKG 16 EA
24 987159 WSHRLOCK.625 4 EA
25 5560169 WSHRFLATHARD.625SP 14 EA
26 0111362 WLDMTPIN1.0020.81GRIP 1 EA
TB125J PARTS MANUAL AXLE INSTALLATION
AXLE INSTALLATION Tue Mar 23 02:55:54 UTC 2021 2-2

アイテム 部品番号 名前 数量 UOM
27 5580002 PINSNAPPER 1 EA
28 0110594 RTNRLOCKPINAXLES 1 EA
29 970049 BLTHEXHD.250-201.00GR5-
GRADE5PLT-SAMEAS970189 2 EA
30 5560004 NUTLKG.250-20 2 EA
31 5560679 M.SCR3/8-165/8SOC.CAD 12 EA
32 5561555 BLTBTNHD.313-18.50- 2 EA
33 987109 WSHRLOCK.313 2 EA
34 5560676 BLTHEXHD.750-10X3.50GR8 16 EA
35 5560170 WSHRFLATHARD.750SP 32 EA
36 5560035 NUTHEXLKG.750-10 16 EA
37 971309 BLTHEXHD.625-11X2.00GR5
ZP 2 EA
39 5560036 NUTHEXLKG.625-11 2 EA
40 0111303 SLPAD1.6314.75.750SP 1 EA
41 0111304 SLPAD2.6314.75.750SP 1 EA
42 5093030 CLPCUSH2.50VINYLCOATED 1 EA
43 5037008 ADAPTER90°ELBOWSWIVEL-
12JIC 2 EA
44 5065715 FTGADPTRSTRTHD-16B-12S
STL-B 2 EA
45 0190972 WLDMTPAD 4 EA
46 5093013 CLPCUSH2.00VINYLCOATED 1 EA
47 970489 BLTHEXHD.375-161.50GR5-
PL 2 EA
48 5560033 .375-16UNCHEXLOCKNUT 2 EA
49 984449 NUTHEXJAM.625-11 16 EA
TB125J PARTS MANUAL AXLE INSTALLATION
AXLE INSTALLATION Tue Mar 23 02:55:54 UTC 2021 2-2

REPAIRPARTS
TB125J PARTS MANUAL EXTENDABLE AXLE
EXTENDABLE AXLE Tue Mar 23 02:55:54 UTC 2021 2-3