SNOWJOE sunjoe 24V-AJV-LTW-RM User manual
®
All rights reserved. Original instructions.
CORDLESS HIGH VOLUME INFLATOR KIT
24-VOLT MAX*| 1.3 Ah | INFLATION ADAPTERS
A Division of Snow Joe®, LLC Model 24V-AJV-LTW-RM Form No. SJ-24V-AJV-LTW-RM-880E-M-V1
R
OPERATOR’S MANUAL
© 2022 by Snow Joe , LLC SAVE THESE INSTRUCTIONS
1
IMPORTANT!
Safety Instructions
All Operators Must Read These
Instructions Before Use
Always follow these safety guidelines. Failure to do so may
result in serious bodily injury or death.
General Power Tool Safety
Warnings
m WARNING Read all safety warnings and all
instructions. Failure to follow the warnings and instructions
Save all warnings and instructions for future reference.
mDANGER! This indicates a hazardous situation, which,
if not followed, will result in serious injury or death.
mWARNING! This indicates a hazardous situation, which,
if not followed, could result in serious injury or death.
mCAUTION! This indicates a hazardous situation, which,
if not followed, could result in minor or moderate injury.
Work Area Safety
1. Keep work area clean and well-lit – Cluttered, dark
areas invite accidents.
2. Keep children, bystanders, and pets away – All
spectators, including pets, should be kept a safe distance
away from the work area.
3. Operate cordless high volume in an open area
at least 18 in. (45.7 cm) away from any wall or object
that could restrict the air to ventilation openings.
Electrical Safety
1. To reduce the risk of electrical shock, do not put
in water or other liquid. Do not place or store
appliance where it can fall or be pulled into a tub or sink.
2. Recharge only with the charger by the
manufacturer. A charger that is suitable for one type
another battery pack.
Personal Safety
1. Stay alert – Watch what you are doing. Use common
when you are tired,
drugs.
2. Dress properly – Do not wear loose clothing or jewelry.
They can get caught in moving parts. Loose clothes,
jewelry, or long hair can be caught in moving parts.
3. Avoid unintentional starting – Do not carry the cordless
4. Do not overreach – Keep proper footing and balance
at all times. Proper footing and balance enable better
situations.
5. Use safety equipment – Always wear eye protection.
Dusk mask, non-skid safety shoes, hard hat, or hearing
protection must be used for appropriate conditions.
6. Eye protection is required to guard against
fasteners and debris which could cause severe eye
injury.
7. Do no wear loose clothing or jewelry – Contain long
hair. Loose clothes, jewelry, or long hair can be drawn into
air vents.
8. Do not use on a ladder or unstable support – Stable
footing on a solid surface enables better control of the
cordless
9. Do not force the tool – It will perform better with less
likelihood of personal or mechanical injury if it is used at
the rate for which it was designed.
10. Release all pressures within the system slowly. Dust
and debris may be harmful.
11. Do not use cordless high volume if switch does
not turn it on or The cor
that cannot be controlled with the switch is dangerous
and must be repaired.
12. Disconnect battery pack from the cordless high
volume before making any adjustments,
changing accessories, or storing the cordless high
volume .Such preventive safety measures reduce
accidentally.
13. Store idle cordless high volume out of reach
of children or other untrained persons. Cordless high
users.
®
All rights reserved. Original instructions.
CORDLESS HIGH VOLUME INFLATOR KIT
24-VOLT MAX*| 1.3 Ah | INFLATION ADAPTERS
A Division of Snow Joe®, LLC
R
OPERATOR’S MANUAL
© 2022 by Snow Joe , LLC SAVE THESE INSTRUCTIONS
Model 24V-AJV-LTW-RM Form No. SJ-24V-AJV-LTW-RM-880E-M-V1
2
14. When battery pack is not in use, keep it away from metal
objects like: paper clips, coins, keys, nails, screws, or
other small metal objects that can make a connection
from one terminal to another. Shorting the battery terminals
[VNL[OLYTH`JH\ZLZWHYRZI\YUZVYHÄYL
15. Check for misalignment or binding of moving parts,
IYLHRHNLVMWHY[ZHUKHU`V[OLYJVUKP[PVU[OH[TH`HɈLJ[
[OLJVYKSLZZOPNO]VS\TLPUÅH[VYZVWLYH[PVU0MKHTHNLK
OH]L[OLJVYKSLZZOPNO]VS\TLPUÅH[VYZLY]PJLKILMVYL
using. Many accidents are caused by poorly maintained tools.
16. Use only accessories that are recommended by the
manufacturer for your model. Accessories that may be
Z\P[HISLMVYVULJVYKSLZZOPNO]VS\TLPUÅH[VYTH`JYLH[LH
risk of injury when used on another cordless high volume
PUÅH[VY
2LLW[OLJVYKSLZZOPNO]VS\TLPUÅH[VYHUKP[ZOHUKSLKY`
clean and free from oil and grease. Always use a clean cloth
^OLUJSLHUPUN5L]LY\ZLIYHRLÅ\PKNHZVSPULWL[YVSL\T
based products, or any strong solvents to clean your cordless
OPNO]VS\TLPUÅH[VY-VSSV^PUN[OPZY\SL^PSSYLK\JL[OLYPZRVM
loss of control and deterioration of the enclosure plastic.
5L]LYWVPU[HU`JVYKSLZZOPNO]VS\TLPUÅH[VY[V^HYK
yourself or others.
19. Do not exceed the pressure rating of any component in
the system.
:WLJPÄJ:HML[`>HYUPUNZ
for Cordless High volume
PUÅH[VY
2UV^`V\YJVYKSLZZOPNO]VS\TLPUÅH[VY¶Know how
to start and stop the tool. Be thoroughly familiar with
the controls.
2. Risk of bursting – Do not preset cordless high volume
PUÅH[VY[VYLZ\S[PUV\[W\[WYLZZ\YLNYLH[LY[OHUTHYRLK
TH_PT\TWYLZZ\YLVMP[LT[VILPUÅH[LK+VUV[\ZLH[
pressure greater than 0.65 PSI.
3. ;VYLK\JL[OLYPZRVMLSLJ[YPJZOVJRKVUV[L_WVZL[VYHPU
Store indoors.
4. Inspect yearly for cracks, pin holes, or other
imperfections that could cause cordless high volume
PUÅH[VY[VILJVTL\UZHMLNever cut or drill holes in the
OPNO]VS\TLPUÅH[VY
5. Use the right appliance – Do not use the cordless high
]VS\TLPUÅH[VY for any applications other than those for
which it was intended.
6. Check for damaged parts – Before further use of the
cordless OPNO]VS\TLPUÅH[VY or air tool, all guards and
parts should be carefully checked to determine that it
will operate properly and perform its intended function.
Check for alignment of moving parts, binding of moving
parts, breakage of parts, mounting, and any other
JVUKP[PVU[OH[TH`HɈLJ[P[ZVWLYH[PVU(N\HYKVYV[OLY
part that is damaged should be properly repaired or
replaced. Contact the Snow Joe®+ Sun Joe®customer
service center at 1-866-SNOWJOE (1-866-766-9563) for
assistance.
7. Remove the battery – Remove the battery from the
cordless OPNO]VS\TLPUÅH[VY when it is not in use, before
servicing it, when changing accessories, and when
performing any other maintenance task.
8. Protect your lungs – Wear a face or dust mask if the
operation is dusty. Following this rule will reduce the risk
of serious personal injury.
9. +VUV[\ZLJVYKSLZZOPNO]VS\TLPUÅH[VYHZHIYLH[OPUN
device.
10. Never direct a jet of compressed air toward people or
animals. Take care not to blow dust and dirt towards
yourself or others. Following this rule will reduce the risk
of serious injury.
11. +VUV[\ZL[OPZJVYKSLZZOPNO]VS\TLPUÅH[VY[VZWYH`
chemicals. Your lungs can be damaged by inhaling
[V_PJM\TLZ
12. Always be aware that misuse and improper handling of
this cordless OPNO]VS\TLPUÅH[VY can cause injury to
yourself and others.
13. Do not continue to use a cordless OPNO]VS\TLPUÅH[VY that
leaks air or does not functions properly.
14. Always follow all safety rules recommended by the
THU\MHJ[\YLYVM`V\YJVYKSLZZOPNO]VS\TLPUÅH[VYPU
HKKP[PVU[VHSSZHML[`Y\SLZMVY[OLJVYKSLZZHPYPUÅH[VY
Following this rule will reduce the risk of serious personal
injury.
15. Do not crush, drop or damage battery pack. Do not use a
battery pack or charger that has been dropped or received
HZOHYWISV^(KHTHNLKIH[[LY`PZZ\IQLJ[[VL_WSVZPVU
Properly dispose of a dropped or damaged battery
immediately.
16. Do not charge battery tool in a damp or wet location.
Following this rule will reduce the risk of electric shock.
17. Inspect tool cords periodically and, if damages, have
repaired at your nearest authorized service center.
Constantly stay aware of cord location. Following this rule
^PSSYLK\JL[OLYPZRVMLSLJ[YPJZOVJRVYÄYL
mWARNING! Do not use this cordless high volume
PUÅH[VY^P[OV\[YLHKPUN[OPZPUZ[Y\J[PVUTHU\HS-VYPUKVVY\ZL
only.
Battery & Charger
Safety Instructions
We pay a great deal of attention to the design of every battery
pack to ensure that we supply you with batteries that are safe,
durable and have a high energy density. The battery cells have
a wide range of safety devices. Each individual cell is initially
formatted and its electrical characteristic curves are recorded.
;OPZKH[HPZ[OLU\ZLKL_JS\ZP]LS`[VILHISL[VHZZLTISL[OL
best possible battery packs.
Despite all the safety precautions, caution must always be
L_LYJPZLK^OLUOHUKSPUNIH[[LYPLZ;OLMVSSV^PUNWVPU[ZT\Z[
be obeyed at all times to ensure safe use. Safe use can only
be guaranteed if undamaged cells are used. Incorrect handling
of the battery pack can cause cell damage.
3
IMPORTANT!(UHS`ZLZJVUÄYT[OH[PUJVYYLJ[\ZLHUKWVVY
care of high-performance batteries are the main factors
YLZWVUZPISLMVYWLYZVUHSHUKVYWYVK\J[KHTHNL
mWARNING! Use only approved replacement batteries;
other batteries may damage the power tool and cause it to
malfunction, which can lead to serious personal injury.
mWARNING! Do not use a battery pack or appliance that
PZKHTHNLKVYTVKPÄLK+HTHNLKVYTVKPÄLKIH[[LYPLZTH`
L_OPIP[\UWYLKPJ[HISLILOH]PVYYLZ\S[PUNPUÄYLL_WSVZPVUVY
risk of injury.
Do not modify or attempt to repair the appliance or the battery
WHJRL_JLW[HZPUKPJH[LKPU[OLPUZ[Y\J[PVUZMVY\ZLHUKJHYL
/H]L`V\YIH[[LY`WHJRZLY]PJLKI`HX\HSPÄLKYLWHPYWLYZVU
using only identical replacement parts. This will ensure that the
safety of the battery pack is maintained.
mCAUTION! To reduce the risk of injury, charge the
iON+ 24V lithium-ion battery pack only in its designated
iON+ 24V lithium-ion charger. Other types of chargers present
YPZRVMÄYLWLYZVUHSPUQ\Y`HUKKHTHNL+VUV[^PYLHIH[[LY`
pack to a power supply plug or car cigarette lighter. Such
misuse will permanently disable or damage the battery pack.
Avoid dangerous environments – Do not charge the
battery pack in rain, snow or in damp or wet locations.
Do not use the battery pack or charger in the presence of
L_WSVZP]LH[TVZWOLYLZNHZLV\ZM\TLZK\Z[VYÅHTTHISL
materials) because sparks may be generated when inserting
VYYLTV]PUN[OLIH[[LY`WHJR^OPJOJV\SKSLHK[VHÄYL
Charge in a well-ventilated area – Do not block the
charger vents. Keep them clear to allow for proper
]LU[PSH[PVU+VUV[HSSV^ZTVRPUNVYVWLUÅHTLZULHYH
JOHYNPUNIH[[LY`WHJR=LU[LKNHZLZTH`L_WSVKL
NOTE: The safe temperature range for the battery is
41°F – 105ºF (5°C – 40.5°C). Do not charge the battery
outside in freezing weather; charge it at room temperature.
Maintain charger cord – When unplugging the charger, pull
the plug, not the cord, from the receptacle to reduce the
risk of damage to the electrical plug and cord. Never carry
the charger by its cord or yank it by the cord to disconnect
it from the receptacle. Keep the cord away from heat, oil
and sharp edges. Make sure the cord will not be stepped
on, tripped over or subjected to damage or stress when the
charger is in use. Do not use the charger with a damaged
cord or plug. Replace a damaged charger immediately.
Do not use an extension cord unless it is absolutely
necessary – Using the wrong, damaged or improperly
^PYLKL_[LUZPVUJVYKWVZLZHYPZRVMÄYLHUKLSLJ[YPJZOVJR
0MHUL_[LUZPVUJVYKT\Z[IL\ZLKWS\N[OLJOHYNLYPU[VH
WYVWLYS`^PYLKNH\NLVYSHYNLYL_[LUZPVUJVYK^P[O[OL
female plug matching the male plug on the charger. Make
Z\YL[OH[[OLL_[LUZPVUJVYKPZPUNVVKLSLJ[YPJHSJVUKP[PVU
Charger (XZ2600-0450) is rated for 100 – 240 volt
AC only – The charger must be plugged into an
appropriate receptacle.
Use only recommended attachments – Use of an
attachment not recommended or sold by the battery
charger or battery pack manufacturer may result in risk
VMÄYLLSLJ[YPJZOVJRVYWLYZVUHSPUQ\Y`
Unplug charger when not in use – Make sure to remove
battery packs from unplugged chargers.
mWARNING! To reduce the risk of electric shock,
always unplug the charger before performing any cleaning or
THPU[LUHUJL+VUV[HSSV^^H[LY[VÅV^PU[V[OLJOHYNLY<ZL
a Ground Fault Circuit Interrupter (GFCI) to reduce
shock hazards.
Do not burn or incinerate battery packs – Battery packs
TH`L_WSVKLJH\ZPUNWLYZVUHSPUQ\Y`VYKHTHNL;V_PJ
fumes and materials are created when battery packs are
burned.
Do not crush, drop or damage battery packs – Do not
use the battery pack or charger if they have sustained a
sharp blow, been dropped, run over or have been damaged
in any way (i.e. pierced with a nail, hit with a hammer,
stepped on, etc.).
Do not disassemble – Incorrect reassembly may pose
HZLYPV\ZYPZRVMLSLJ[YPJZOVJRÄYLVYL_WVZ\YL[V[V_PJ
battery chemicals. If the battery or charger are damaged,
contact an authorized Snow Joe®+ Sun Joe®dealer or
call the Snow Joe®+ Sun Joe®customer service center at
1-866-SNOWJOE (1-866-766-9563) for assistance.
Battery chemicals cause serious burns – Never let a
damaged battery pack contact the skin, eyes or mouth.
If a damaged battery pack leaks battery chemicals, use
rubber or neoprene gloves to safely dispose of it. If skin
PZL_WVZLK[VIH[[LY`Å\PKZ^HZO[OLHɈLJ[LKHYLH^P[O
ZVHWHUK^H[LYHUKYPUZL^P[O]PULNHY0ML`LZHYLL_WVZLK
[VIH[[LY`JOLTPJHSZPTTLKPH[LS`Å\ZO^P[O^H[LYMVY
minutes and seek medical attention. Remove and dispose
of contaminated clothing.
Do not short circuit – When battery pack is not in use,
keep it away from other metal objects, like paper clips,
coins, keys, nails, screws or other small metal objects,
that can make a connection from one terminal to another.
Shorting the battery terminals together may cause burns
VYHÄYL
Store your battery pack and charger in a cool, dry
place – Do not store the battery pack or charger where
[LTWLYH[\YLZTH`L_JLLK¢-¢*Z\JOHZPU
direct sunlight or inside a vehicle or metal building
during the summer.
4
Information about the battery
1. The battery pack supplied with your cordless power tool is
only partially charged. The battery pack has to be charged
JVTWSL[LS`ILMVYL`V\\ZL[OL[VVSMVY[OLÄYZ[[PTL
2. For optimum battery performance, avoid low discharge
cycles by charging the battery pack frequently.
3. Store the battery pack in a cool place, ideally at 59°F
(15°C) and charged to at least 40%.
4. Lithium-ion batteries are subject to a natural aging
process. The battery pack must be replaced at the latest
when its capacity falls to just 80% of its capacity when
new. Weakened cells in an aged battery pack are no
longer capable of meeting the high power requirements
needed for the proper operation of your cordless high
]VS\TLPUÅH[VYHUK[OLYLMVYLWVZLHZHML[`YPZR
5. +VUV[[OYV^IH[[LY`WHJRZPU[VHUVWLUÄYLHZ[OPZWVZLZ
HYPZRVML_WSVZPVU
6. +VUV[PNUP[L[OLIH[[LY`WHJRVYL_WVZLP[[VÄYL
7. +VUV[L_OH\Z[P]LS`KPZJOHYNLIH[[LYPLZ,_OH\Z[P]L
discharge will damage the battery cells. The most
JVTTVUJH\ZLVML_OH\Z[P]LKPZJOHYNLPZSLUN[O`Z[VYHNL
or non-use of partially discharged batteries. Stop working
as soon as the performance of the battery falls noticeably
or the electronic protection system triggers. Place the
battery pack in storage only after it has been fully charged.
8. Protect batteries and the tool from overloads. Overloads
will quickly result in overheating and cell damage inside
the battery housing even if this overheating is not
HWWHYLU[L_[LYUHSS`
9. Avoid damage and shocks. Immediately replace batteries
that have been dropped from a height of more than
MLL[TL[LYVY[OVZL[OH[OH]LILLUL_WVZLK[V]PVSLU[
shocks, even if the housing of the battery pack appears to
be undamaged. The battery cells inside the battery may
OH]LZ\ɈLYLKZLYPV\ZKHTHNL0UZ\JOPUZ[HUJLZ
please read the waste disposal information for proper
battery disposal.
10. 0M[OLIH[[LY`WHJRZ\ɈLYZV]LYSVHKPUNHUKV]LYOLH[PUN
[OLPU[LNYH[LKWYV[LJ[P]LJ\[VɈ^PSSZ^P[JOVɈ[OL
equipment for safety reasons.
IMPORTANT! +VUV[WYLZZ[OL656--Z^P[JOHU`TVYL
PM[OLWYV[LJ[P]LJ\[VɈOHZILLUHJ[P]H[LK;OPZTH`
damage the battery pack.
11. 9LJOHYNLVUS`^P[O[OLJOHYNLYZWLJPÄLKI`[OL
manufacturer. A charger that is suitable for one type of
IH[[LY`WHJRTH`JYLH[LHYPZRVMÄYL^OLU\ZLK^P[O
another battery pack.
12. <ZLHWWSPHUJLZVUS`^P[OZWLJPÄJHSS`KLZPNUH[LKIH[[LY`
packs. Use of any other battery packs may create a risk of
PUQ\Y`HUKÄYL
13. Under abusive conditions, liquid may be ejected from
the battery; avoid contact. If contact accidentally occurs,
Å\ZO^P[O^H[LY0MSPX\PKJVU[HJ[ZL`LZHKKP[PVUHSS`ZLLR
medical help. Liquid ejected from the battery may cause
irritation or burns.
14. Do not use a battery pack or appliance that is damaged
VYTVKPÄLK+HTHNLKVYTVKPÄLKIH[[LYPLZTH`L_OPIP[
\UWYLKPJ[HISLILOH]PVYYLZ\S[PUNPUÄYLL_WSVZPVUVYYPZR
of injury.
15. +VUV[L_WVZLHIH[[LY`WHJRVYHWWSPHUJL[VÄYLVY
L_JLZZP]L[LTWLYH[\YL,_WVZ\YL[VÄYLVY[LTWLYH[\YL
HIV]L¢-*TH`JH\ZLL_WSVZPVU
16. Follow all charging instructions and do not charge the
battery pack or appliance outside of the temperature
YHUNLZWLJPÄLKPU[OLPUZ[Y\J[PVUZ*OHYNPUNPTWYVWLYS`
VYH[[LTWLYH[\YLZV\[ZPKLVM[OLZWLJPÄLKYHUNLTH`
KHTHNL[OLIH[[LY`HUKPUJYLHZL[OLYPZRVMÄYL
Information about the charger and the
charging process
1. Please check the data marked on the rating plate of the
battery charger. Be sure to connect the battery charger
to a power supply with the voltage marked on the rating
WSH[L5L]LYJVUULJ[P[[VHKPɈLYLU[THPUZ]VS[HNL
2. Protect the battery charger and its cord from damage.
Keep the charger and its cord away from heat, oil and
sharp edges. Have damaged cords repaired without delay
I`HX\HSPÄLK[LJOUPJPHUH[HUH\[OVYPaLK:UV^1VL®+
Sun Joe®dealer or call the Snow Joe®+ Sun Joe®
customer service center at 1-866-SNOWJOE
(1-866-766-9563).
3. Electrical plugs must match the outlet. Never modify
the plug in any way. Do not use any adapter plugs with
NYV\UKLKHWWSPHUJLZ<UTVKPÄLKWS\NZHUKTH[JOPUN
outlets will reduce the risk of electric shock.
4. Keep the battery charger, battery pack(s) and the cordless
tool out of the reach of children.
5. Do not use the supplied battery charger to charge other
cordless tools.
6. During periods of heavy use, the battery pack will become
warm. Allow the battery pack to cool to room temperature
before inserting it into the charger to recharge.
7. +VUV[V]LYJOHYNLIH[[LYPLZ+VUV[L_JLLK[OLTH_PT\T
charging times. These charging times only apply to
discharged batteries. Frequent insertion of a charged or
partially charged battery pack will result in overcharging
and cell damage. Do not leave batteries in the charger for
days on end.
8. Never use or charge batteries if you suspect that it has
been more than 12 months since the last time they were
charged. There is a high probability that the battery pack
OHZHSYLHK`Z\ɈLYLKKHUNLYV\ZKHTHNLL_OH\Z[P]L
discharge).
9. Charging batteries at a temperature below 41°F (5°C) will
JH\ZLJOLTPJHSKHTHNL[V[OLJLSSZHUKTH`JH\ZLHÄYL
10. +VUV[\ZLIH[[LYPLZ[OH[OH]LILLUL_WVZLK[VOLH[
during the charging process, as the battery cells may have
Z\ɈLYLKKHUNLYV\ZKHTHNL
11. +VUV[\ZLIH[[LYPLZ[OH[OH]LZ\ɈLYLKJ\Y]H[\YLVY
deformation during the charging process or those that
L_OPIP[V[OLYH[`WPJHSZ`TW[VTZNHZZPUNOPZZPUN
cracking, etc.).
5
12. 5L]LYM\SS`KPZJOHYNL[OLIH[[LY`WHJRTH_PT\T
recommended depth of discharge is 80%). A complete
discharge of the battery pack will lead to premature aging
of the battery cells.
7YV[LJ[PVUMYVTLU]PYVUTLU[HSPUÅ\LUJLZ
1. Wear suitable work clothes. Wear safety goggles.
2. Protect your cordless tool and the battery charger from
moisture and rain. Moisture and rain can cause dangerous
cell damage.
3. Do not use the cordless tool or the battery charger near
]HWVYZHUKÅHTTHISLSPX\PKZ
4. Use the battery charger and cordless tools only in dry
conditions and at an ambient temperature of 41ºF – 105°F
(5°C – 40.5°C).
5. Do not keep the battery charger in places where the
temperature is liable to reach over 105°F (40.5°C). In
particular, do not leave the battery charger in a car that is
parked in the sunshine.
6. Protect batteries from overheating. Overloads,
V]LYJOHYNPUNHUKL_WVZ\YL[VKPYLJ[Z\USPNO[^PSSYLZ\S[
in overheating and cell damage. Never charge or work
with batteries that have been overheated – replace them
immediately, if possible.
7. Store the charger and your cordless tool only in dry
locations with an ambient temperature of 41ºF – 105°F
(5°C – 40.5°C). Store your lithium-ion battery pack in a
cool, dry place at a temperature of 77°F (25°C). Protect
the battery pack, charger and cordless tool from humidity
and direct sunlight. Only place fully charged batteries in
storage (charged to at least 40%).
8. Prevent the lithium-ion battery pack from freezing. Battery
packs that were stored below 32°F (0°C) for more than 60
minutes must be discarded.
9. When handling batteries, be wary of electrostatic charge.
Electrostatic discharges can damage the electronic
protection system and the battery cells. Avoid electrostatic
charging and never touch the battery poles.
6
Safety Symbols
The following table depicts and describes safety symbols that may appear on this product. Read, understand, and follow all
instructions on the machine before attempting to assemble and operate.
9,(+;/,67,9(;69:
MANUAL(S) – Read, understand,
and follow all instructions in the
user manual(s) before attempting
to assemble and operate.
SAFETY ALERT – Indicates a
precaution, a warning, or a danger.
WEAR EYE PROTECTION –
For protection against injury, wear
safety goggles.
Symbols SymbolsDescriptions Descriptions
HOT SURFACE – To reduce the
risk of injury or damage, avoid
contact with any hot surface.
Indoor use only. Only use battery
charger indoors.
WET CONDITIONS ALERT –
+VUV[L_WVZL[VYHPUVY\ZLPU
damp locations.
7
Know Your Cordless High Volume
adjustments. Save this manual for future reference.
*Initial no-load voltage, when fully charged, peaks at 24 volts; nominal voltage under typical load is 21.6 volts.
Technical Data
Motor............................................................................ 150 W
Battery Voltage*....................................................... 24 V D.C.
Battery Capacity........................................................... 1.3 Ah
Charger Input ................................................100 – 240 V AC,
........................................................................50/60 Hz, 0.4 A
Charger Output ................................... 26 V DC 450 mA
Charge Time Max ....................................................... 3 hours
Working Air Pressure Max ........................ 0.65 PSI, 0.04 BAR
..............................................................(
Air Pressure Max ....................................... 0.7 PSI, 0.05 BAR
Air Speed Max ....................................................... 188.8 MPH
Air Flow Max .............................................................. 36 CFM
.......................... 0.17 in (4.3 mm)
....................................................................... 0.19 in (4.8 mm)
2.3 lbs (1.03 kg)
.......................................................................... 0.5 in (13 mm)
Weight (with battery installed) .......................
1. Small Adapter
2. Medium Adapter
3. Large Adapter
4.
5.
6. ON/OFF Trigger
7. Battery Compartment
8. iON+ 24V lithium-ion charger
(XZ2600-0450)
9. Charger plug
10. Charge socket
11. Battery indicators
12. Push button for battery indicator
13. Push lock button
14. iON+ 24V lithium-ion battery
(24VBAT-LTW) featuring
exclusive EcoSharp®technology
111
12
13
14
8
9
10
2
7
3
4
5
6
8
Unpacking
Carton Contents
*VYKSLZZOPNO]VS\TLPUÅH[VY
0UÅH[PVUHKHW[LYZ_H[[HJOLK
P65=SP[OP\TPVUIH[[LY`
iON+ 24V lithium-ion charger
Manual with registration card
1. *HYLM\SS`YLTV]L[OLOPNO]VS\TLPUÅH[VYHUKJOLJR[V
see that all of the above items are supplied.
2. Inspect the product carefully to make sure no breakage or
KHTHNLVJJ\YYLKK\YPUNZOPWWPUN0M`V\ÄUKKHTHNLKVY
missing parts, DO NOT return the unit to the store. Please
call the Snow Joe®+ Sun Joe®customer service center at
1-866-SNOWJOE (1-866-766-9563).
NOTE: Do not discard the shipping carton and packaging
material until you are ready to use your new cordless
OPNO]VS\TLPUÅH[VY;OLWHJRHNPUNPZTHKLVMYLJ`JSHISL
materials. Properly dispose of these materials in
accordance with local regulations.
IMPORTANT! The equipment and packaging material are
not toys. Do not let children play with plastic bags, foils,
or small parts. These items can be swallowed and pose a
Z\ɈVJH[PVUYPZR
Battery Pack Operation
The equipment is powered by a lithium-ion battery. The battery
pack is completely sealed and maintenance free.
Battery Charge Level Indicator
The battery pack is equipped with a push button for checking
[OLJOHYNLSL]LS:PTWS`WYLZZ[OLW\ZOI\[[VU[VYLHKVɈ[OL
battery charge level from the LEDs of the battery indicator:
(SSSL]LSTVUP[VYPUN3,+ZHYLSP[!)H[[LY`JOHYNLSL]LS
is high.
SL]LSTVUP[VYPUN3,+ZHYLSP[!)H[[LY`JOHYNLSL]LSPZ
decreasing. Stop work as soon as possible.
SL]LSTVUP[VYPUN3,+PZSP[!)H[[LY`PZÅH[:[VW^VYR
IMMEDIATELY and charge the battery. Otherwise the
battery’s service life will be greatly shortened.
NOTE: If the charge level button does not appear to be
working, insert the charger and charge as needed.
NOTE: Immediately after using the battery pack, the charge
level button may display a lower charge than it will if checked
a few minutes later. The battery cells “recover” some of their
charge after resting.
Charger Operation
mWARNING! Charge only iON+ 24V lithium-ion battery
packs with its compatible iON+ 24V lithium-ion charger. Other
types of batteries may cause personal injury and damage.
;VYLK\JL[OLYPZRVMLSLJ[YPJZOVJRKVUV[HSSV^^H[LY[VÅV^
PU[V[OLJOHYNLYZ(*+*WS\N
When to Charge the iON+
24VBAT-LTW Lithium-iON Battery
NOTE: The iON+ 24VBAT-LTW lithium-iON battery packs do
not develop a "memory" when charged after only a partial
discharge. Therefore, it is not necessary to run down the
battery pack before inserting the charger plug.
<ZL[OLIH[[LY`PUKPJH[VYSPNO[Z[VKL[LYTPUL^OLU[VJOHYNL
your iON+ 24VBAT-LTW lithium-iON battery pack.
@V\JHU[VWVɈ`V\YIH[[LY`WHJRZJOHYNLILMVYLZ[HY[PUN
a big job or after a long day of use.
Charging the Battery
1. Push the push lock button on the battery to pull the
battery pack out from the battery compartment (Fig. 1).
2. Check that the mains voltage is the same as that marked
on the rating plate of the battery charger. Then, plug the
charger adapter into an appropriate AC power outlet.
Connect the charger plug into the charge socket of the
battery to start charging (Fig. 2).
Charge level button
The battery is at 30% capacity
and requires charging
The battery is at 60% capacity
and requires charging soon
The battery is at full capacity
Light IndicatorsLights
Fig. 1
Push lock
button
9
3. ;OLIH[[LY`^PSS[HRLHWWYV_PTH[LS`OV\YZ[VJOHYNL
The battery indicator LEDs will twinkle and illuminate one
by one during the charging process. Unplug the charger
immediately when the 3 LEDs are all illuminated.
mCAUTION! FIRE HAZARD. When disconnecting the
charger from the battery, be sure to unplug the charger from
[OLV\[SL[ÄYZ[[OLUKPZJVUULJ[[OLJOHYNLYMYVT[OLIH[[LY`
mWARNING! ;OPZJOHYNLYKVLZUV[H\[VTH[PJHSS`[\YUVɈ
when the battery is fully charged. Please take care not to leave
[OLIH[[LY`WS\NNLKPU[V[OLJOHYNLY:^P[JOVɈVY\UWS\N[OL
charger at the mains when charging is complete.
4. Timely recharging of the battery will help prolong the
battery's life. You must recharge the battery pack when
you notice a drop in the equipment's power.
IMPORTANT! Never allow the battery pack to become fully
discharged as this will cause irreversible damage to the
battery.
Assembly
;OPZOPNO]VS\TLPUÅH[VYYLX\PYLZUVHZZLTIS`PUVYKLY[VIL
\ZLK(U`VM[OL[OYLLHKWH[LYZTH`IL\ZLKMVYZWLJPÄJ[HZRZ
Attaching the Adapters
;OPZOPNO]VS\TLPUÅH[VYPZLX\PWWLK^P[O[OYLLPUÅH[VY
adapters. It is recommended to leave them connected, as
disconnecting the adapters may make them easier to lose.
1. ;VH[[HJOHUHKHW[LY[V[OLPUÅH[VYLUKHSPNU[OLUV[JOLZ
VU[OLOPNO]VS\TLPUÅH[VYUVaaSL^P[O[OLZSV[ZVU[OL
adapter of your choice and slide together. Twist the
adapter to lock into place (Fig. 3).
2. ;VH[[HJOHUHKHW[LY[V[OLKLÅH[VYLUKZPTWS`ZUHW[OL
adapter into place (Fig. 4).
Operation
mWARNING! Do not use any attachments or accessories
not recommended by the manufacturer of this high
]VS\TLPUÅH[VY;OL\ZLVMH[[HJOTLU[ZVYHJJLZZVYPLZUV[
recommended can result in serious personal injury.
mWARNING! ;OLOPNO]VS\TLPUÅH[VYPZJHWHISLVM
PUÅH[PUN[V7:0)(9;VH]VPKV]LYPUÅH[PVUJHYLM\SS`
MVSSV^PUZ[Y\J[PVUZVUP[LTZ[VILPUÅH[LK5L]LYL_JLLK
recommended pressures.
mCAUTION! +VUV[SLH]LP[LTZ[VILPUÅH[LK\UH[[LUKLK
^OPSLOPNO]VS\TLPUÅH[VYPZPU\ZL;OLZLP[LTZJHUI\YZ[HUK
could cause serious injury.
Fig. 2
Battery
indicators
Fig. 3
Notch
Slot
Fig. 4
10
Adapter Functions (Fig. 5)
;OLZTHSSHKHW[LY0.17 in) can be used on smaller air
]HS]LZ[VPUÅH[LP[LTZSPRLILHJOIHSSZJOPSKYLUZ[V`Z
HUKWVVSPUÅH[HISLZ;OLHKHW[LYJHUIL\ZLK[VKLÅH[L
vacuum compression bags.
;OLTLKP\THKHW[LY PUPZPKLHSMVYPUÅH[PUNHUK
KLÅH[PUNHPYTH[YLZZLZPUÅH[HISLWVVSZHUKYHM[Z
;OLSHYNLHKHW[LYPUPZPKLHSMVYOPNO]VS\TLPUÅH[HISLZ
like bounce houses and boats.
Starting + Stopping
1. Slide the battery into the battery compartment until it
clicks to lock it into position (Fig. 6).
2. Select and assemble the appropriate adapter for the job.
Insert the nozzle of the adapter into the air port on the
VIQLJ[`V\^PZO[VPUÅH[LHUKKLÅH[L-PN
3. ;V[\YU[OLOPNO]VS\TLPUÅH[VY65WYLZZ[OL656--
[YPNNLYVUJL;VZ[VWWYLZZ[OL656--I\[[VUVUJLTVYL
(Fig. 7).
4. >OLU[OLP[LTPZM\SS`PUÅH[LKVYKLÅH[LK[\YU[OL\UP[VɈ
remove it from the air port, and close the port.
NOTE: :PUJLTVZ[OPNO]VS\TLPUÅH[HISLZYLX\PYL]LY`SV^
WYLZZ\YL[OPZPUÅH[VYKVLZUV[OH]LHUHPYWYLZZ\YLNH\NLP[PZ
KLZPNULK[VPUÅH[L[V[OLJVYYLJ[MLLS
Storage
1. ,_HTPUL[OLJVYKSLZZOPNO]VS\TLPUÅH[VY[OVYV\NOS`MVY
worn, loose, or damaged parts. Should you need to repair
or replace a part, contact an authorized Snow Joe®+
Sun Joe®dealer or call the Snow Joe®+ Sun Joe®
customer service center at 1-866-SNOWJOE
(1-866-766-9563) for assistance.
2. 9LTV]L[OLIH[[LY`MYVT[OLJVYKSLZZOPNO]VS\TLPUÅH[VY
before storing.
3. :[VYL[OLOPNO]VS\TLPUÅH[VYPUHKY`^LSS]LU[PSH[LK
place that is inaccessible to children. Keep away from
corrosive agents.
Cleaning And Maintenance
mWARNING! +VUV[H[HU`[PTLSL[IYHRLÅ\PKZ
gasoline, petroleum based products, penetrating oils, etc.,
come in contact with plastic parts. Chemicals can damage,
weaken or destroy plastic which can result in serious personal
injury.
Cleaning
2LLW[OL]LU[PSH[PVUZSV[ZVM[OLTHJOPULJSLHU[VWYL]LU[
overheating of the engine.
9LN\SHYS`JSLHU[OLTHJOPULOV\ZPUN^P[OHZVM[JSV[O
preferably after each use. Keep the ventilation slots free
from dust and dirt.
0M[OLKPY[KVLZUV[JVTLVɈ\ZLHZVM[JSV[OTVPZ[LULK^P[O
soapy water.
5L]LY\ZLZVS]LU[ZZ\JOHZWL[YVSHSJVOVSHTTVUPH^H[LY
etc. These solvents may damage the plastic parts.
Large adapter
Small adapter Medium
adapter
Fig. 5
Fig. 6
Battery
Battery
compartment
Fig. 7
ON/OFF trigger
11
Maintenance
Our machines have been designed to operate over a long
period of time with a minimum of maintenance. Continuous
satisfactory operation depends upon proper machine care and
regular cleaning.
NOTE: Snow Joe®+ Sun Joe®will not be held responsible for
any damage or injuries caused by repair of the high volume
Spare parts may be ordered online at sunjoe.com or via phone
by contacting the Snow Joe®+ Sun Joe®customer service
center at 1-866-SNOWJOE (1-866-766-9563).
Avoid using solvents when cleaning plastic parts. Most plastics
are susceptible to damage from various types of commercial
solvents and may be damaged by their use. Use clean cloths
to remove dirt, dust, oil, grease, etc.
Disposal
Should your appliance need replacement after extended
use, do not dispose of it with the household refuse, but in an
environmentally safe way.
Waste produced by electrical machine items should
not be handled like normal household rubbish. Please
recycle where recycle facilities exist. Check with your
local authority or retailer for recycling advice.
Troubleshooting
•
battery and make sure it is charged.
•If the battery does not charge, check the charger adapter
and the charger adapter cable are connected correctly.
Remove the battery pack and allow it to cool down to room
temperature.
•If there is no pressure, check the adapter and make sure it
•
sure you are using the correct adapter. Clean the adapter
Battery Caution + Disposal
Always dispose of your battery pack according to federal,
state, and local regulations. Contact a recycling agency in your
area for recycling locations.
mCAUTION! Even discharged battery packs contain
some energy. Before disposing, use electrical tape to cover
the terminals to prevent the battery pack from shorting, which
mWARNING! To reduce the risk of injury or explosion,
never burn or incinerate a battery pack even if it is damaged,
dead, or completely discharged. When burned, toxic fumes
and materials are emitted into the surrounding atmosphere.
1. Batteries vary according to device. Consult your manual
2. Install only new batteries of the same type in your product
(where applicable).
3. Failure to insert batteries in the correct polarity, as
indicated in the battery compartment or manual, may
shorten the life of the batteries or cause batteries to leak.
4. Do not mix old and new batteries.
5. Do not mix Alkaline, Standard (Carbon-Zinc), or
Rechargeable (Nickel Cadmium, Nickel Metal Hydride, or
Lithium-Ion) batteries.
6.
may explode.
7. Batteries should be recycled or disposed of as per state
and local guidelines.
Service + Support
•
injury.
•
replacement parts. Follow instructions in the cleaning and
maintenance section of this manual. Use of unauthorized
parts or failure to follow maintenance instructions may
create a risk of shock or injury.
•If your Sun Joe®
service or maintenance, please call the Snow Joe®+ Sun
Joe®customer service center at 1-866-SNOWJOE
(1-866-766-9563).
Model + Serial Numbers
When contacting the company or reordering parts, you will
need to provide the model and serial numbers of your product.
of your cordless compressor. Copy these numbers into the
space provided below.
Record the following numbers from the housing or handle of your
new product: Model #:
Serial #:
2 4 V -AJV - L T W - R M
12
Optional Accessories
mWARNING! ALWAYS use only authorized Snow Joe®+ Sun Joe®replacement parts and accessories. NEVER use
YLWSHJLTLU[WHY[ZVYHJJLZZVYPLZ[OH[HYLUV[PU[LUKLKMVY\ZL^P[O[OPZJVYKSLZZOPNO]VS\TLPUÅH[VY*VU[HJ[:UV^1VL®+
Sun Joe®if you are unsure whether it is safe to use a particular replacement part or accessory with your cordless high volume
PUÅH[VY;OL\ZLVMHU`V[OLYH[[HJOTLU[VYHJJLZZVY`JHUILKHUNLYV\ZHUKJV\SKJH\ZLPUQ\Y`VYTLJOHUPJHSKHTHNL
NOTE: Accessories are subject to change without any obligation on the part of Snow Joe®+ Sun Joe®to provide notice of such
changes. Accessories can be ordered online at sunjoe.com or via phone by contacting the Snow Joe®+ Sun Joe®customer
service center at 1-866-SNOWJOE (1-866-766-9563).
Accessories Item Model
iON+ 24V 1.3 Ah Lithium-Ion Battery 24VBAT-LTW
iON+ 24V 2.0 Ah Lithium-Ion Battery 24VBAT-LTE
iON+ 24V 4.0 Ah Lithium-Ion Battery 24VBAT
iON+ 24V Lithium-Ion Battery Quick Charger 24VCHRG-QC
1
2
3
4
13
NOTES
SNOW JOE®+ SUN JOE®REFURBISHED GOODS WARRANTY
GENERAL CONDITIONS:
Snow Joe®+ Sun Joe®operating under Snow Joe®, LLC warrants
this refurbished product to the original purchaser for 90 days
against defects in material or workmanship when used for normal
residential purposes. If a replacement part or product is needed,
it will be sent free of charge to the original purchaser except as
noted below.
The duration of this warranty applies only if the product is put to
SHUVRQDOXVHDURXQGWKHKRXVHKROG,WLVWKHRZQHU·VUHVSRQVLELOLW\
to correctly perform all maintenance and minor adjustments
H[SODLQHGLQWKHRZQHU·VPDQXDO
HOW TO OBTAIN YOUR REPLACEMENT PART OR PRODUCT:
To obtain a replacement part or product, please visit
instructions. Please be sure to register your unit beforehand
to speed up this process. Certain products may require a serial
QXPEHU W\SLFDOO\ IRXQG RQ WKH GHFDO DIÀ[HG WR WKH KRXVLQJ
or guard of your product. All products require a valid proof
of purchase.
EXCLUSIONS:
• Wearing parts like belts, augers, chains and tines are
not covered under this warranty. Wearing parts can be
purchased at snowjoe.com or by calling 1-866-SNOWJOE
(1-866-766-9563).
• Batteries are covered in full for 90-days from the date of
purchase.
Snow Joe®+ Sun Joe®may from time to time change the design of
its products. Nothing contained in this warranty shall be construed
as obligating Snow Joe®+ Sun Joe®to incorporate such design
changes into previously manufactured products, nor shall such
changes be construed as an admission that previous designs
were defective.
This warranty is intended to cover product defects only.
Snow Joe®, LLC is not liable for indirect, incidental or
consequential damages in connection with the use or misuse of
the Snow Joe®+ Sun Joe®products covered by this warranty.
This warranty does not cover any cost or expense incurred
by the purchaser in providing substitute equipment or service
during reasonable periods of malfunction or non-use of this product
while waiting for a replacement part or unit under this warranty.
Some states do not allow exclusions of incidental or consequential
damages so the above exclusions may not apply in all states. This
ZDUUDQW\PD\JLYH\RXVSHFLÀFOHJDOULJKWVLQ\RXUVWDWH
HOW TO REACH US:
:H·UHKHUHWRKHOS0RQGD\WKURXJK)ULGD\IURP$0WR30(67
DQG 6DWXUGD\ DQG 6XQGD\ $0 WR 30 <RX FDQ UHDFK XV DW
1-866-SNOWJOE (1 866-766-9563), online at snowjoe.com, via
EXPORTS:
Customers who have purchased Snow Joe®+ Sun Joe®
products exported from the United States and Canada should
contact their Snow Joe®+ Sun Joe®distributor (dealer) to obtain
information applicable to your country, province or state. If for
DQ\ UHDVRQ \RX DUH QRW VDWLVÀHG ZLWK WKH GLVWULEXWRU·V VHUYLFH
RU LI \RX KDYH GLIÀFXOW\ REWDLQLQJ ZDUUDQW\ LQIRUPDWLRQ FRQWDFW
your Snow Joe®+ Sun Joe®seller. If in the event your efforts are
unsatisfactory, please reach out to us directly.
14
sunjoe.com
Table of contents
Other SNOWJOE Power Tools manuals
SNOWJOE
SNOWJOE SUNJOE ION GTS4001C User manual
SNOWJOE
SNOWJOE 323E-RM User manual
SNOWJOE
SNOWJOE sunjoe24V-HG100 User manual
SNOWJOE
SNOWJOE sunjoe 24V-DDK-LTX-PNK User manual
SNOWJOE
SNOWJOE Sunjoe 24V-HG100-CT User manual
SNOWJOE
SNOWJOE sunjoe 24V-CSSHRP-LTE-RM User manual
SNOWJOE
SNOWJOE SJBLZD-LED User manual
SNOWJOE
SNOWJOE 323E User manual
SNOWJOE
SNOWJOE AUTOJOE ATJ-AIR1-HYB User manual
SNOWJOE
SNOWJOE sunjoe 24V-CSSHRP-CT-RM User manual
Popular Power Tools manuals by other brands
TOX PRESSOTECHNIK
TOX PRESSOTECHNIK FinePress ZFS Original operating instructions
Laguna Tools
Laguna Tools DAKE 1 instruction manual
Makita
Makita 6907D instruction manual
Optimum
Optimum Optimill MH 20V operating manual
Smith Flow Control
Smith Flow Control SFC-EDE manual
EINHELL
EINHELL BT-CD 18/1 Original operating instructions
