SUMMIT LIFTS Summit User manual

18505 E. 163rd St.
Lake Winnebago, MO 64034
Phone [phone]
E-mail [email protected]
www. summitlifts.com
Toll Free Phone [phone]
Summit Lifts, Inc.
TROUBLE SHOOTING YOUR LIFT
These tips might save you a service call. Make sure
you remove power from the lift before attempting any
of the following items.
1. Lift not running, steel cable not tight.
A “slack cable” safety device stops the lift from running if any slack is
sensed in the cable. To reset the device, do the following: Remove the
round plastic hole cover in the side of the lift facing uphill. Insert the
handcrank tube onto the pulley and turn clockwise until the cable is fully
wound tightly on the drum and the lift begins coming up the track. A loud
click will occur indicating the safety device has been reset. The lift should
now run.
If the lift is not all the way at the bottom of the track, an alternative method
for resetting the slack cable device may be used. Half way between the
lift and top of the track, grasp the steel cable and lift it straight up in the air
(as if you were pulling on a bow string) until you are holding the weight of
the lift. Slowly lower the cable back down to the track, the lift will travel
down the track and the cable will now be tight.
2. Lift all the way at top of track— unit won’t run.
The lift hit the final limit switch—meaning it has run too far up. Remove
the round plastic hole cover in the side of the lift facing uphill. Insert the
handcrank tube onto the pulley and turn counter-clockwise 4-5 turns until
the lift moves down the track about 1”. Slide the final limit actuator (metal
tab sticking up off the track) down until it touches the lift. The lift should
now run. Lower the top switch cam about 1/2” to keep problem from
recurring.
•Warranty Details
•Proper Use of Your Lift
•Ideas to Keep Your Lift Problem Free
•Safety Tips
•Troubleshooting Problems
SUMMIT LIFTS, INC.
OWNER’S MANUAL
Date: May 2007
Summit® Stairway Lift
“Taking you to new heights…”
NOTE:
IT IS IMPORTANT THIS ENTIRE MANUAL BE
READ AND UNDERSTOOD BEFORE ATTEMPTING
TO OPERATE THIS LIFT. IF THERE IS ANYTHING IN
THIS MANUAL YOU DO NOT UNDERSTAND
CLEARLY, CONTACT YOUR DEALER FOR CLARIFI-
CATION BEFORE YOU OPERATE THIS LIFT, OR
CALL US TOLL FREE AT 866-378-6648 BEFORE
YOU OPERATE THIS LIFT.

CUSTOMER INFORMATION SHEET
Page 2
Date Purchased
Dealer
Address
Phone
Contact
Serial number of lift
If warranty work or service is needed, your dealer
will need the data above to receive factory infor-
mation or order parts for this lift.
CONGRATULATIONS!
You have purchased the most trouble free
stairway lift on the market today. It is our hope
this lift will allow you the independence you
desire in your day to day life. Because of the
trust you have placed in us we wanted to take
this moment to say thank you.
Page 7
LIMITED WARRANTY DETAILS
Summit Lifts, Inc, 18505 E. 163rd St., Lake Winnebago, MO 64034,
warrants to the original purchaser of a stairway lift manufactured by us
to be free from defects in material and workmanship for a 3-year period
on all component parts of the lift, and a 5-year period on the motor and
gear.
Exceptions to this Limited Warranty are:
• Damage resulting from improper installation or operation.
• Negligence, alterations, abuse or misuse of the equipment.
• Fire, flood, acts of God.
• Torn or dirty upholstery.
• Shipping damage
• Parts used that are not supplied by Summit Lifts, Inc.
• Batteries are warranted for a 1-year period
• Labor fees for installation work or service calls
No warranty is extended, express or implied, whether of merchantability
or fitness for a particular purpose, after expiration of 3 years from the
date of original purchase of the unit. Summit Lifts, Inc. and its dealers
shall not be liable for any consequential, special or incidental damages
arising out of the purchase or use of the unit or resulting from the
breach of this Limited Warranty, or any implied warranty. The limit of
liability of Summit Lifts, Inc. and its dealer hereunder shall be the unit’s
purchase price.
Some states do not allow limitations on how long an implied warranty
lasts or the exclusion or limitation of incidental or consequential dam-
ages, or legal remedies, so these above limitations may not apply to
you. All warranty claims must be reported to the dealer from whom the
lift was purchased as they have responsibility for handling your warranty
claim. The dealer is to contact the Service Department of Summit Lifts,
Inc. and provide the serial number of the lift along with a description of
the events leading to the warranty claim. Dealers may charge for labor,
service, travel, or other associated costs to make repairs, and such
charges are not covered by this Limited Warranty. It is permissible to
have any repairs or replacement work done as a result of any defects in
material and workmanship by someone other than the Dealer under this
Limited Warranty. However, the Limited Warranty does not cover any
charges or expenses assessed by any such other person or company
performing such repairs or replacement work. All parts used to replace
defective materials must be genuine Summit Lifts, Inc. parts to be cov-
ered by this Limited Warranty.
This Limited Warranty gives you specific legal rights, and you may have
other rights which vary from state to state.

SAFETY TIPS
Page 6
• Have the dealer adjust the footrest and seat back
height so it fits you properly.
• Operate the lift while the dealer is present. Be
sure you are comfortable with mounting and dis-
mounting the lift at each landing. The seat height
should be set so it is as easy as possible to get
on and off the lift.
• Make sure you understand how the swivel seat
works and locks into the various positions.
• Keep your feet centered on the footrest while
traveling up and down the stairs. Never dangle
your feet off the footrest while riding the lift.
• Use the armrests to assist you getting on and off
the lift.
• Sit all the way back in the seat while operating
the lift and always fasten your seat belt.
• Never operate the lift while standing up.
• Stop the unit by releasing the control switch if
anyone begins walking up or down the stairs. Do
not proceed until the staircase has been cleared.
• Keep the landings at each end of the staircase
free of any obstructions (children’s toys, etc.)
• Do not carry pets or children on your lap while
riding the lift. The lift is designed for use by one
person at a time.
Page 3
TABLE OF CONTENTS
Customer Information Sheet 2
Table of Contents 3
Using Your Stairway Lift
4
Keeping Your Stairway Lift Trouble-Free 5
Cleaning - Maintenance Instructions 5
Safety Tips 6
Limited Warranty Details 7
Troubleshooting
8
Other notes __________________________________
_____________________________________________
_____________________________________________
_____________________________________________
_____________________________________________

USING YOUR STAIRWAY LIFT
TROUBLE FREE
Page 4
OPERATING THE LIFT
Before you attempt to use your Summit Stairway Lift, ask your dealer to
demonstrate the features and operation of the lift. The dealer should
show you how to use all of the following items:
Power Indicator Light - AC powered units - This small green light at the
top of the track indicates power is on to the unit. If it is not lit, the unit will
not run. This is generally the result of a blown circuit breaker. The circuit
breaker is located under the light and is resettable.
Charger Light - Battery powered units - This small light located on the
charger gives you a constant picture of the charger’s operation. A green
light indicates the batteries are completely charged. A reddish/orange light
indicates the charger is charging the batteries. Should there be no
light—or the light is continually flashing, contact the factory.
Unit Control Switch - This is a rocker switch located on the front of the
arm rest. It must be pushed and held during the entire travel of the lift.
Pushing one side moves the lift up, the other side moves the lift down.
The lift will automatically stop when it reaches the end of the track or any-
time you release the control.
Swivel Seat - The seat swivels at the top and bottom landings to facilitate
getting on and off the lift. To swivel the seat, pull up on the handle on
either side of the seat and use your body to turn the seat in the direction
desired. Make sure the seat locks before attempting to mount or dis-
mount the lift. Returning the seat to its forward, locked position be-
fore operating the lift is very important. A safety switch under the
seat prevents the lift from moving unless the seat is forward and
locked in place.
Seat Belt - A seat belt is provided to keep you firmly in the chair during
the travel of the lift. Never operate the lift until the seat belt is fas-
tened securely around your waist.
Obstructions - Always check the stairway and track to make sure there
are no obstructions before traveling up or down the stairs. Never operate
the lift if anything or anyone is on the stairway. The footrest is
equipped with a sensor to stop the lift if it should strike anything. If this
happens, push the unit control the opposite direction to move away from
the obstruction.
Landing Controls - A remote control is provided at the top and bottom of
the stairs. Pressing the control will bring the lift to you. The lift will stop
automatically when it reaches the end of the track. It will also stop if you
release the control.
This lift will provide you years of service when used
correctly. Make sure you understand each of the
features listed below prior to using your stairway lift.
Page 5
KEEPING YOUR STAIRWAY LIFT
TROUBLE FREE AND SAFE
CLEANING YOUR STAIRWAY LIFT
• Keep the track and unit clean & free from dust and dirt
• Make sure the stairs & track are free from obstructions
• Do not attempt to service or work on the lift yourself
without consulting the factory first.
• Do not carry children or pets on your lap while riding
the lift. It is intended for use by one person at a time.
• Call your dealer if you have any questions or concerns
• Make sure the outlet being used provides 110 volts and
is grounded properly
• Do not allow children to play on the lift
• Never stand up while on the lift or attempt to operate
the lift while standing
• Always make sure the swivel is in the locked position
before mounting or dismounting the lift
• Unplug the lift prior to cleaning any portion of the lift.
• At least twice a year, use a general household cleaner
to clean any portion of the track and unit
• Use a general upholstery cleaner (or leather cleaner if
you have leather upholstery) to clean the seat cushions,
arm rests and seat back.
IMPORTANT
Track Lubrication: Every 2-4 months, wipe out the inside
of the track channels. Apply a thin coat of light body gen-
eral purpose grease (lithium) to the vertical surfaces of the
track channel where the chassis wheels roll.
MAINTENANCE TO YOUR LIFT