Sunrise Medical BREEZY 600 SERIES Installation and operation manual

User
Instruction
Manual &
Warranty
Breezy Series Wheelchair
600 Series

930300 Rev. E

3930300 Rev. E
SUNRISE LISTENS
Thank you for choosing a Breezy wheelchair. We want to hear your questions or
comments about this manual, the safety and reliability of your chair, and the ser-
vice you receive from your supplier. Please feel free to write or call us at the
address and telephone number below:
SUNRISE MEDICAL (US) LLC
Customer Service Department
2842 Business Park Ave.
Fresno, CA 93727
[phone]
Be sure to return your warranty card, and let us know if you change your address.
This will allow us to keep you up to date with information about safety, new prod-
ucts and options to increase your use and enjoyment of this wheelchair. If you lose
your warranty card, call or write and we will gladly send you a new one.
FOR ANSWERS TO YOUR QUESTIONS
Your authorized supplier knows your wheelchair best, and can answer most of
your questions about chair safety, use and maintenance. For future reference,
fill in the following:
Supplier: _______________________________________________________________________________
Address: _______________________________________________________________________________
______________________________________________________________________________________
Telephone: _____________________________________________________________________________
Serial #: ________________________________________ Date/Purchased: ________________________
1 . I N T R O D U C T I O N

4
930300 Rev. E
I I . T A B L E O F C O N T E N T S
1. INTRODUCTION .................................................................................. 3
a. Sunrise Listens ...................................................................................... 3
11. TABLE OF CONTENTS ........................................................................ 4
III. YOUR C AIR AND ITS PARTS .......................................................... 6
IV. NOTICE - READ BEFORE USE .......................................................... 8
V. GENERAL WARNINGS .......................................................................... 9
A. Weight Limit ........................................................................................ 9
B. Getting to Know Your Chair ............................................................ 9
C.To Reduce The Risk of an Accident ................................................ 9
D. Safety Checklist .................................................................................. 10
E Changes & Adjustments .................................................................... 10
F. Environmental Conditions ................................................................ 10
G.Terrain .................................................................................................... 11
.Street Use ............................................................................................ 11
I. Motor Vehicle Safety .......................................................................... 11
J. When You Need elp ........................................................................ 12
VI. WARNINGS: FALLS & TIP-OVERS ...................................................... 13
A. Center of Balance .............................................................................. 13
B. Dressing or Changing Clothes ........................................................ 13
C.Obstacles .............................................................................................. 14
D. Reaching or Leaning .......................................................................... 14
E. Moving Backward ................................................................................ 15
F. Ramps, Slopes & Side ills ................................................................ 16
G.Transfers ................................................................................................ 17
.Curbs & Steps ...................................................................................... 18
I. Stairs ...................................................................................................... 18
J. Escalators .............................................................................................. 18
VII. WARNINGS: FOR SAFE USE ................................................................ 19
A. Descending a Curb or Single Step .................................................. 19
B. Climbing a Curb or Single Step ...................................................... 19
C.Climbing Stairs .................................................................................... 20
D. Descending Stairs ................................................................................ 20
E. Maintenance .......................................................................................... 20
VIII. WARNINGS: COMPONENTS & OPTIONS .................................... 22
A. Anti-Tip Tubes ...................................................................................... 22
B. Armrests .............................................................................................. 22
C.Cushion & Sling Seats ........................................................................ 22

5930300 Rev. E
1 I . T A B L E O F C O N T E N T S
D. Fasteners .............................................................................................. 23
E. Footrests ................................................................................................ 23
F. Pneumatic Tires .................................................................................. 23
G.Positioning Belts .................................................................................. 24
. Power Drive ...................................................................................... 24
I. Push andles ........................................................................................ 24
J. Quick-Release Axles .......................................................................... 25
K. Rear Axles ............................................................................................ 25
L. Rear Wheel Locks .............................................................................. 25
M.Modified Seat Systems ...................................................................... 26
N.Upholstery Fabric .............................................................................. 26
IX. C AIR BASICS ........................................................................................ 27
A. To Mount & Remove Rear Wheels ................................................ 27
B. To Fold & Unfold Chair .................................................................... 28
X. SET-UP AND ADJUSTMENTS .............................................................. 29
A. Set-up .................................................................................................... 29
B Tools ...................................................................................................... 29
C.To Find and Correct a Problem........................................................ 30
D. Anti-Tip Tubes ...................................................................................... 30
E. Standard & Low Front Seat eights .............................................. 32
F. Caster Forks ........................................................................................ 33
G.Rear Wheel Locks .............................................................................. 34
.Flip-Back Armrests .............................................................................. 35
I. Flip-Back eight Adjustable Armrests ............................................ 35
J. Swing-Away angers & Footrests ................................................ 36
K. Articulating Legrest & Elevating Legrest ...................................... 37
L. Caster Plates ...................................................................................... 37
M.Caster Mounting ................................................................................ 38
N.Backrest .............................................................................................. 38
XI. TROUBLES OOTING .......................................................................... 40
X11. MAINTENANCE .................................................................................... 41
XIII. SUNRISE LIMITED WARRANTY ........................................................ 43

6
930300 Rev. E
I I I . Y O U R C A I R A N D I T S P A R T S
1. Flip-back armrest
2. Padded seat sling
3. Swing-away footrest
4. Crossbrace
5. Flip-up composite footplate
6. Caster housing dust cover
7. Caster housing
8. Caster fork
9. Caster wheel
10. 8” (203 mm) polyurethane
caster tire
11. Push handle backrest tube
12. Backrest
13. 24” (540 mm) low-profile
polyurethane tire
14. 6-spoke mag wheel
15. Composite handrim
16. Step-tube
(not shown)
17. Threaded axle
18. Swing-away release latch
19. Anti-tip tube (optional)
BREEZY 600
1
2
3
4
5
6
7
8
9
11
12
13
10
14
15
17
18
19

7930300 Rev. E
I I I . Y O U R C A I R A N D I T S P A R T S
Weight
28 lbs. (12.7 kg)
Adjustments
1” (25 mm) Vertical Axle- Adjustment,
2- ole Fork Footrest Extension
Adjustment, Adjustable Caster
ousing, Backrest Adjustment
Colors
Blue, Silver Texture, Forest Green
Frame Dimensions
Seat Width - Std
14”, 15”, 16”, 17”, 18”, 19”, 20”
(356 mm, 381 mm, 406 mm, 432 mm,
457 mm, 483 mm, 508 mm)
Seat Depth
14”, 15”, 16”, 17”, 18”
(356 mm, 381 mm, 406 mm, 432 mm,
457 mm)
Backrest
16” - 19” (406 mm - 483 mm)
angers
60o, 70o, 90o
ELR, ALR
Footplates
Std - composite with heel loop
Opt - 90o Flip up
Ext. tubes - short, med., long
Casters
5”, 6”, 8” (127 mm, 157 mm, 203 mm)
Polyurethane & pneumatic
1 1/2” & 3/4” (38 mm & 19 mm)
caster fork stem
Axles/Axle Plate
Std - Offset Fixed
Opt - Quick-Release
Anti-Tip Tubes
Opt - Rear Anti-Tip Tubes
Rear Wheels
Type - mag
Sizes - 20”, 22”, 24”
Tires - Polyurethane
Pneumatic
andrims
Std - composite, aluminum
Opt - plastic-coated
Projections andrims
Opt - 8,12 vertical or oblique
Wheel Locks
Std - igh push-to-lock, igh pull-
to-lock,
Opt - 6” (152 mm) extension
handles, grade aids
All features may not be available with
some chair setups or in conjunction
with another chair feature. Please
consult your authorized supplier for
more information.

8
930300 Rev. D
I V. N O T I C E — R E A D B E F O R E U S E
A. C OOSE T E RIG T C AIR & SAFETY OPTIONS
Sunrise provides a choice of many wheelchair styles to meet the needs of the
wheelchair rider. owever, final selection of the type of wheelchair, options and
adjustments rests solely with you and your health care advisor. Choosing the
best chair and set-up for your safety depends on such things as:
1. Your disability, strength, balance and coordination.
2. The types of hazards you must overcome in daily use (where you live and
work, and other places you are likely to use your chair).
3. The need for options for your safety and comfort (such as anti-tip tubes,
positioning belts, or special seating systems).
B. REVIEW T IS MANUAL OFTEN
Before using this chair you, and each person who may assist you, should
read this entire manual and make sure to follow all instructions. Review the
warnings often, until they are second nature to you.
C. WARNINGS
The word “WARNING” refers to a hazard or unsafe practice that may cause
severe injury or death to you or to other persons. The “Warnings” are in four
main sections, as follows:
1. V — GENERAL WARNINGS
ere you will find a safety checklist and a summary of risks you need to be
aware of before you ride this chair.
2. VI — WARNINGS — FALLS & TIP-OVERS
ere you will learn how to avoid a fall or tip-over while you perform daily
activities in your chair.
3. VII — WARNINGS — FOR SAFE USE
ERE YOU WILL LEARN ABOUT PRACTICES FOR T E SAFE USE OF
YOUR C AIR
4. VIII — WARNINGS — COMPONENTS & OPTIONS
ere you will learn about the components of your chair and options you can
select for safety. Consult your authorized supplier and your health care advisor
to help you choose the best set-up and options for safe use.
Note: Where they apply, you will also find “Warnings” in other sections of this manual.
eed all warnings in this section. If you fail to do so a fall, tip-over or loss of control may
occur and cause severe injury to the rider or others.

9930300 Rev. D
V . G E N E R A L W A R N I N G S
A. WEIG T LIMIT
NEVER exceed the weight limit of 250 pounds (113.6 kilograms), for combined
weight of rider and items carried. If you do exceed the limit, damage to your
chair, a fall, tip-over or loss of control may occur and cause severe injury to the
rider or others.
B. GETTING TO KNOW YOUR C AIR
Every wheelchair is different. Take the time to learn the feel of this chair
before you begin riding. Start slowly, with easy, smooth strokes. If you are used
to a different chair, you may use too much force and tip over. If you use too
much force, damage to your chair, a fall, tip-over or loss of control may occur
and cause severe injury to the rider or others.
C. TO REDUCE T E RISK OF AN ACCIDENT
1. BEFORE riding, you should be trained in the safe use of this chair by your
health care advisor.
2. Practice bending, reaching and transfers until you know the limit of your
ability. ave someone help you until you know what can cause a fall or
tip-over and how to avoid doing so.
3. Be aware that you must develop your own methods for safe use best
suited to your level of function and ability.
4. NEVER try a new maneuver on your own until you are sure you can
do it safely.
5. Get to know the areas where you plan to use your chair. Look for
hazards and learn how to avoid them.
6. Use anti-tip tubes unless you are a skilled rider of this chair and are sure
you are not at risk to tip over.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.

10
930300 Rev. D
D. SAFETY C ECKLIST
Before Each Use Of Your Chair:
1. Make sure the chair rolls easily and that all parts work smoothly. Check
for noise, vibration, or a change in ease of use. (They may indicate low tire
pressure, loose fasteners, or damage to your chair).
2. Repair any problem. Your authorized supplier can help you find and correct
the problem.
3. Check to see that both quick-release rear axles are locked. When locked,
the axle button will “pop out” fully. If not locked, the wheel may come off
and cause you to fall.
4. If your chair has anti-tip tubes, lock them in place.
Note: See “Anti-Tip Tubes” (Section VIII) for times you should not use them.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss
of control may occur and cause severe injury to the rider or others.
E. C ANGES & ADJUSTMENTS
1. If you modify or adjust this chair, it may increase the risk of a tip-over UNLESS
you make other changes as well.
2. Consult your authorized supplier BEFORE you modify or adjust your chair.
3. We recommend that you use anti-tip tubes until you adapt to the change, and
are sure you are not at risk to tip over.
4. Unauthorized modifications or use of parts not supplied or approved by Sunrise
may change the chair structure. This will void the warranty and may cause a
safety hazard.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
F. ENVIRONMENTAL CONDITIONS
1. Use extra care if you must ride your chair on a wet or slick surface. If you are
in doubt, ask for help.
2. Contact with water or excess moisture may cause your chair to rust or
corrode. This could cause your chair to fail.
a. Do not use your chair in a shower, pool or other body of water. The chair
tubing and parts are not water-tight and may rust or corrode from the inside.
b. Avoid excess moisture (for example, do not leave your chair in a damp
bathroom while taking a shower).
c. Dry your chair as soon as you can if it gets wet, or if you use water to
clean it.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
V . G E N E R A L W A R N I N G S

V . G E N E R A L W A R N I N G S
G. TERRAIN
1. Your chair is designed for use on firm, even surfaces such as concrete,
asphalt and indoor floors and carpeting.
2. Do not operate your chair in sand, loose soil or over rough terrain.
This may damage wheels or axles, or loosen fasteners of your chair.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
. STREET USE
In most states, wheelchairs are not legal for use on public roads. Be alert to the
danger of motor vehicles on roads or in parking lots.
1. At night, or when lighting is poor, use reflective tape on your chair
and clothing.
2. Due to your low position, it may be hard for drivers to see you. Make eye con-
tact with drivers before you go forward. When in doubt, yield until you are
sure it is safe.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
I. MOTOR VE ICLE SAFETY
Breezy wheelchairs do not meet federal standards for motor vehicle seating.
1. NEVER let anyone sit in this chair while in a moving vehicle.
a. ALWAYS move the rider to an approved vehicle seat.
b. ALWAYS secure the rider with proper motor vehicle restraints.
2. In an accident or sudden stop the rider may be thrown from the chair.
Wheelchair seat belts will not prevent this, and further injury may result
from the belts or straps.
3. NEVER transport this chair in the front seat of a vehicle. It may shift and
interfere with the driver.
4. ALWAYS secure this chair so that it cannot roll or shift.
5. Do not use any chair that has been involved in a motor vehicle accident.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
11 930300 Rev. D

12
930300 Rev. D
V . G E N E R A L W A R N I N G S
J. W EN YOU NEED ELP
For The Rider:
Make sure that each person who helps you reads and follows all warnings and
instructions that apply.
For Attendants:
1. Work with the rider’s doctor, nurse or therapist to learn safe methods
best suited to your abilities and those of the rider.
2. Tell the rider what you plan to do, and explain what you expect the rider
to do. This will put the rider at ease and reduce the risk of an accident.
3. Make sure the chair has push handles. They provide secure points for
you to hold the rear of the chair to prevent a fall or tip-over. Check to
make sure push handle grips will not rotate or slip off.
4. To prevent injury to your back, use good posture and proper body
mechanics. When you lift or support the rider or tilt the chair, bend your
knees slightly and keep your back as upright and straight as you can.
5. Remind the rider to lean back when you tilt the chair backward.
6. When you descend a curb or single step, slowly lower the chair in one
easy movement. Do not let the chair drop the last few inches to the
ground. This may damage the chair or injure the rider.
7. To avoid tripping, unlock and rotate anti-tip tubes up, out of the way.
ALWAYS lock the rear wheels and lock anti-tip tubes in place if you
must leave the rider alone, even for a moment. This will reduce the risk
of a tip over or loss of control of the chair.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss
of control may occur and cause severe injury to the rider or others.

13 930300 Rev. D
V I . W A R N I N G S : F A L L S & T I P - O V E R S
A. CENTER OF BALANCE
The point where this chair will tip forward, back, or to the side depends on its
center of balance and stability. ow your chair is set up, the options you select
and the changes you make may affect the risk of a fall or tip-over.
1. The Most Important Adjustments Are:
a. The position of the rear wheels. The more you move the rear wheels
forward, the more likely your chair will tip over backward.
2. The Center Of Balance Is Also Affected By:
a. A change in the set-up of your chair, including:
• The distance between the rear wheels.
• The amount of rear wheel camber.
• The seat height and seat angle.
• Backrest angle.
b. A change in your body position, posture or weight distribution.
c. Riding your chair on a ramp or slope.
d. The use of a back pack or other options, and the amount of added weight.
3. To Reduce The Risk Of An Accident:
a. Consult your doctor, nurse or therapist to find out what axle and
caster position is best for you.
b. Consult your authorized supplier BEFORE you modify or adjust this
chair. Be aware that you may need to make other changes to correct
the center of balance.
c. ave someone help you until you know the balance points of your
chair and how to avoid a tip-over.
d. Use anti-tip tubes.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss
of control may occur and cause severe injury to the rider or others.
B. DRESSING OR C ANGING CLOT ES
Your weight may shift if you dress or change clothes while seated in this chair.
To reduce the risk of a fall or tip-over:
1. Rotate the front casters until they are as far forward as possible.
This makes the chair more stable.
2. Lock anti-tip tubes in place. (If your chair does not have anti-tip tubes,
back it up against a wall and lock both rear wheels).
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.

14
930300 Rev. D
V I . W A R N I N G S : F A L L S & T I P - O V E R S
C. OBSTACLES
Obstacles and road hazards (such as potholes and broken pavement) can
damage your chair and may cause a fall, tip-over or loss of control.
To avoid these risks:
1. Keep a lookout for danger – scan the area well ahead of your chair
as you ride.
2. Make sure the floor areas where you live and work are level and
free of obstacles.
3. Remove or cover threshold strips between rooms.
4. Install a ramp at entry or exit doors. Make sure there is not a drop off at
the bottom of the ramp.
5. To elp Correct Your Center Of Balance:
a. Lean your upper body FORWARD slightly as you go UP over an obstacle.
b. Press your upper body BACKWARD as you go DOWN from a higher
to a lower level.
6. If your chair has anti-tip tubes, lock them in place before you go UP
over an obstacle.
7. Keep both of your hands on the handrims as you go over an obstacle.
8. Never push or pull on an object (such as furniture or a doorjamb) to
propel your chair.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
D. REAC ING OR LEANING
If you reach or lean it will affect the center of balance of your chair. This may
cause you to fall or tip over. When in doubt, ask for help or use a device to
extend your reach.
1. NEVER reach or lean if you must shift your weight sideways or rise up
off the seat.
2. NEVER reach or lean if you must move forward in your seat to do so.
Always keep your buttocks in contact with the backrest.
3. NEVER reach with both hands (you may not be able to catch yourself
to prevent a fall if the chair tips).
4. NEVER reach or lean to the rear unless your chair has anti-tip tubes
locked in place.

15 930300 Rev. D
V I . W A R N I N G S : F A L L S & T I P - O V E R S
5. DO NOT reach or lean over the top of the seat back. This may damage
one or both backrest tubes and cause you to fall.
6. If You Must Reach Or Lean:
a. Do not lock the rear wheels. This creates a tip point and makes a fall
or tip-over more likely.
b. Do not put pressure on the footrests.
Note: Leaning forward puts pressure on the footrests and may cause the chair to tip if
you lean too far.
c. Move your chair as close as you can to the object you wish to reach.
d. Do not try to pick up an object from the floor by reaching down
between your knees. You are less likely to tip if you reach to the side
of your chair.
e. Rotate the front casters until they are as far forward as possible. This
makes the chair more stable.
Note: To do this: Move your chair past the object you want to reach, then back up
alongside it. Backing up will rotate the casters forward.
f. Firmly grasp a rear wheel or an armrest with one hand. This will help
to prevent a fall if the chair tips.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of control
may occur and cause severe injury to the rider or others
E. MOVING BACKWARD
Use extra care when you move your chair backward. Your chair is most stable
when you propel yourself forward. You may lose control or tip over if one of
the rear wheels hits an object and stops rolling.
1. PROPEL YOUR C AIR SLOWLY AND SMOOT LY.
2. IF YOUR C AIR AS ANTI-TIP TUBES, MAKE SURE TO LOCK
T EM IN PLACE.
3. Stop often and check to be sure your path is clear.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.

16
930300 Rev. D
V I . W A R N I N G S : F A L L S & T I P - O V E R S
F. RAMPS, SLOPES & SIDE ILLS
Riding on a slope, which includes a ramp or side hill, will change the center of
balance of your chair. Your chair is less stable when it is at an angle. Anti-tip tubes
may not prevent a fall or tip-over.
1. Do not use your chair on a slope steeper than 10%. (A 10% slope means: one
foot in elevation for every ten feet of slope length.)
2. Always go as straight up and as straight down as you can. (Do not “cut the
corner” on a slope or ramp.)
3. Do not turn or change direction on a slope.
4. Always stay in the CENTER of the ramp. Make sure ramp is wide enough that
you are not at risk that a wheel may fall over the edge.
5. Do not stop on a steep slope. If you stop, you may lose control of your chair.
6. NEVER use rear wheel locks to try to slow or stop your chair. This is likely
to cause your chair to veer out of control.
7. Beware Of:
a. Wet or slippery surfaces.
b. A change in grade on a slope (or a lip, bump or depression). These may
cause a fall or tip-over.
c. A drop-off at the bottom of a slope. A drop-off of as small as 3/4 inch can
stop a front caster and cause the chair to tip forward.
8. To Reduce The Risk Of A Fall Or Tip-Over:
a. Lean or press your body UP ILL. This will help adjust for the change in the
center of balance caused by the slope or side hill.
b. Keep pressure on the handrims to control your speed on a down slope.
If you go too fast you may lose control.
c. Ask for help any time you are in doubt.
9. Ramps At ome & Work - For your safety, ramps at home and work must
meet all legal requirements for your area. We recommend:
a. Width. At least four feet wide.
b. Guardrails. To reduce the risk of a fall, sides of ramp must have guardrails
(or raised borders at least three inches high).
c. Slope. Not more than a 10% grade.
d. Surface. Flat and even, with a thin carpet or other non-skid material.
(Make sure there is no lip, bump or depression.)
e. Bracing. Ramp must be STURDY. You may need bracing so ramp does not
“bow” when you ride on it.
f. Avoid A Drop Off. You may need a section at the top or bottom to smooth
out the transition.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.

17 930300 Rev. D
V I . W A R N I N G S : F A L L S & T I P - O V E R S
G. TRANSFER
It is dangerous to transfer on your own. It requires good balance and agility.
Be aware that there is a point during every transfer when the wheelchair seat
is not below you. To Avoid A Fall:
1. Work with your health care advisor to learn safe methods.
a. Learn how to position your body and how to support yourself during
a transfer.
b. ave someone help you until you know how to do a safe transfer on
your own.
2. Lock the rear wheels before you transfer. This keeps the rear wheels
from rolling.
Note: This will NOT keep your chair from sliding away from you or tipping.
3. Make sure to keep pneumatic tires properly inflated. Low tire pressure
may allow the rear wheel locks to slip.
4. Move your chair as close as you can to the seat you are transferring to.
If possible, use a transfer board.
5. Rotate the front casters until they are as far forward as possible.
6. If you can, remove or swing footrests out of the way.
a. Make sure your feet do not catch in the space between the footrests.
b. Avoid putting weight on the footrests as this may cause the chair to tip.
7. Make sure armrests are out of the way and do not interfere.
8. Transfer as far back onto the seat surface as you can. This will reduce the
risk that the chair will tip or move away from you.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.

18
930300 Rev. D
V I . W A R N I N G S : F A L L S & T I P - O V E R S
. CURBS & STEPS
1. Each person who helps you should read and follow the warnings
“For Safe Use” (Section VII).
2. Do not try to climb or descend a curb or step alone UNLESS you
are a skilled rider of this chair and:
a. You can safely do a “wheelie”; and
b. You are sure you have the strength and balance to do so.
3. Unlock and rotate anti-tip tubes up, out of the way, so they do
not interfere.
4. Do not try to climb a high curb or step (more than 4 inches high)
UNLESS you have help. Doing so may cause your chair to exceed its
balance point and tip over.
5. Go straight up and straight down a curb or step. If you climb or descend
at an angle, a fall or tip-over is likely.
6. Be aware that the impact of dropping down from a curb or step can
damage your chair or loosen fasteners.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
I. STAIRS
1. NEVER use this chair on stairs UNLESS you have someone to help you.
Doing so is likely to cause a fall or tip-over.
2. Persons who help you should read and follow the warnings
“For Attendants” (p. 16), and the “For Safe Use” (Section VII).
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
J. ESCALATORS
NEVER use this chair on an escalator, even with an attendant. If you do, a fall
or tip-over is likely.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.

19 930300 Rev. D
Before you assist a rider, be sure to read the warnings “For Attendants” (p. 16) and
follow all instructions that apply. Be aware that you will need to learn safe meth-
ods best suited to your abilities.
A. DESCENDING A CURB OR SINGLE STEP
Follow these steps to help a rider descend a curb or single step going BACKWARD:
1. Stay at the rear of the chair.
2. Several feet before your reach the edge of the curb or step, turn the chair
around and pull it backward.
3. While looking over your shoulder, carefully step back until you are off the curb
or stair and standing on the lower level.
4. Pull the chair toward you until the rear wheels reach the edge of the curb or
step. Then allow the rear wheels to slowly roll down onto the lower level.
5. When the rear wheels are safely on the lower level, tilt the chair back to its
balance point. This will lift the front casters off the curb or step.
6. Keep the chair in balance and take small steps backward. Turn the chair around
and gently lower front casters to the ground.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
B. CLIMBING A CURB OR SINGLE STEP
Follow these steps to help the rider climb a curb or single step going FORWARD:
1. Stay behind the chair.
2. Face the curb and tilt the chair up on the rear wheels so that the front casters
clear the curb or step.
3. Move forward, placing the front casters on the upper level as soon as you are
sure they are past the edge.
4. Continue forward until the rear wheels contact the face of the curb or step.
Lift and roll the rear wheels to the upper level.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others
V I I . W A R N I N G S : F O R S A F E U S E

20
930300 Rev. D
V I I . W A R N I N G S : F O R S A F E U S E
C. CLIMBING STAIRS
1. Use at least two attendants to move a chair and rider up stairs.
2. Move the chair and rider BACKWARD up the stairs.
3. The person at the rear is in control. e or she tilts the chair back to its
balance point.
4. A second attendant at the front firmly grasps a non-detachable part of the
front frame and lifts the chair up and over one stair at a time.
5. The attendants move to the next stair up. Repeat for each stair, until you reach
the landing.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
D. DESCENDING STAIRS
1. Use at least two attendants to move a chair and rider down stairs.
2. Move the chair and rider FORWARD down the stairs.
3. The person at the rear is in control. e or she tilts the chair to the balance
point of the rear wheels and rolls it to the edge of the top step.
4. A second attendant stands on the third step from the top and grasps the chair
frame. e or she lowers the chair one step at a time by letting the rear wheels
roll over the stair edge.
5. The attendants move to the next stair down. Repeat for each stair, until you
reach the landing.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others.
E MAINTENANCE
1. Inspect and maintain this chair strictly per chart.
2. If you detect a problem, make sure to service or repair the chair before use.
3. At least once a year, have a complete inspection, safety check and service of
your chair made by an authorized supplier.
If you fail to heed these warnings damage to your chair, a fall, tip-over or loss of
control may occur and cause severe injury to the rider or others. For additional
maintenance information see Section XII: Maintenance.