Symbol 1130 User manual

1130/1134 Battery Charger
User's Guide

2
On December 1, 2000 Symbol Technologies, Inc. completed the purchase
of Telxon Corporation. References made throughout this document to
"Telxon" or "Telxon Corporation" are be replaced with "Symbol" or
"Symbol Technologies, Inc.", respectively. Any questions, contact your
Symbol representative.
©2000 by Symbol Technologies, Inc. All rights reserved.
No part of this publication may be reproduced or used in any form, or by any electrical or
mechanical means, without permission in writing from Symbol. This includes electronic or
mechanical means, such as photocopying, recording, or information storage and retrieval
systems. The material in this manual is subject to change without notice.
Symbol reserves the right to make changes to any software or product to improve reliability,
function, or design.
Symbol does not assume any product liability arising out of, or in connection with, the
application or use of any product, circuit, or application described herein.
No license is granted, either expressly or by implication, estoppel, or otherwise under any
Symbol Technologies, Inc., intellectual property rights. An implied license only exists for
equipment, circuits, and subsystems contained in Symbol products.
Symbol is a registered trademark of Symbol Technologies, Inc. Other product names
mentioned in this manual may be trademarks or registered trademarks of their respective
companies and are hereby acknowledged.
Symbol Technologies, Inc.
One Symbol Plaza
Holtsville, New York 11742-1300
http://www.symbol.com
Symbol Support Center: 1-800-653-5350

1130/1134 Battery Charger
User’s Guide

Part Number:19842-701-01
Release Date: 9/27/95
1130/1134 Battery Charger
User’s Guide

Telxon is a registered trademark of Telxon
Corporation.
The information contained in this manual is subject
to change without notice.
Telxon Corporation shall not be liable for technical or
editorial omissions or mistakes in this manual nor
shall it be liable for incidental or consequential
damages resulting from your use of the information
contained in this manual.
This manual is copyrighted. All rights are reserved.
No part of this manual may be photocopied or
reproduced in any form without the prior written
consent of Telxon.
© Copyright 1995 Telxon Corporation.
All Rights Reserved.

Contents
Regulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
FCC statement . . . . . . . . . . . . . . . . . . . . . . . 7
Safety information . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Disposing of nickel-cadmium batteries . . . . . . . . . . . 8
Scope of the manual . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Document conventions . . . . . . . . . . . . . . . . . . . 9
Cautions . . . . . . . . . . . . . . . . . . . . . . . . . 9
Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Overview of the battery charger . . . . . . . . . . . . . . . . . . . . . 10
Getting started . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Unpacking the 1130/1134 Battery Charger . . . . . . . . 11
Installing the battery charger . . . . . . . . . . . . . . . . 11
Running the power-on self test . . . . . . . . . . . . . . . 12
Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Power pack . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Recharging battery packs . . . . . . . . . . . . . . . . . . . . . . . . 15
Inserting a battery pack . . . . . . . . . . . . . . . . . . . 15
Removing a battery pack . . . . . . . . . . . . . . . . . . 16
Disposing of battery packs . . . . . . . . . . . . . . . . . 16
Cycling a battery pack . . . . . . . . . . . . . . . . . . . . . . . . . 17
Maintaining the charger . . . . . . . . . . . . . . . . . . . . . . . . . 18
Operating conditions . . . . . . . . . . . . . . . . . . . . 18
Handling the 1130/1134 Battery Charger . . . . . . . . . 18
4

Cleaning the 1130/1134 Battery Charger . . . . . . . . . . 19
Storing the 1130/1134 Battery Charger . . . . . . . . . . 19
Servicing the 1130/1134 Battery Charger . . . . . . . . . 19
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
The Power LED does not light . . . . . . . . . . . . . . . 20
LEDs remain on after the power-on self test . . . . . . . . 20
The red LED below a battery pack slot does not
light when a battery pack is in the slot . . . . . . . . . . 20
All of the battery pack slot LEDs are flashing . . . . . . . 20
A battery pack takes too long to recharge . . . . . . . . . 21
The green LED below a battery pack slot never lights . . . 21
Both battery pack slot LEDs do not light . . . . . . . . . . 21
The Cycle LED does not light when the Cycling button is
pressed . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
The battery packs are faulty . . . . . . . . . . . . . . . . 22
Other problems . . . . . . . . . . . . . . . . . . . . . . . 22
Appendix A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Specifications . . . . . . . . . . . . . . . . . . . . . . . . 23
Electrical . . . . . . . . . . . . . . . . . . . . . . . . . 23
Environmental . . . . . . . . . . . . . . . . . . . . . . 23
Physical . . . . . . . . . . . . . . . . . . . . . . . . . 23
Appendix B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Accessory part numbers . . . . . . . . . . . . . . . . . . . 24
Appendix C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Battery charger LED codes . . . . . . . . . . . . . . . . . 25
Both battery pack slot LEDs are off . . . . . . . . . . 25
The red LED is on, but the green LED is off . . . . . . 25
Both the red LED and the Cycle LED are on . . . . . 25
The red LED is off, but the green LED is on . . . . . . 26
Both battery pack slot LEDs are blinking . . . . . . . 26
Appendix D . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Power-on self test codes . . . . . . . . . . . . . . . . . . . 27
5

Glossary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
6

Regulations 1
FCC statement
This equipment has been tested and found to comply
with the limits for a Class A digital device pursuant to
Part 15 of Federal Communications Commission
(FCC) rules. These limits are designed to provide
reasonable protection against harmful interference
when the equipment is operated in a commercial
environment. This equipment generates, uses, and
can radiate radio frequency energy and, if not
installed and used in accordance with this operator’s
guide, may cause interference to radio
communications. Operation of this equipment in a
residential area is likely to cause harmful
interference, in which case users will be required to
correct the interference at their own expense.
7

Safety information 2
Disposing of nickel-cadmium batteries
Nickel-cadmium batteries contain chemically active
materials that are hazardous to the environment;
therefore, they must be disposed of properly. Never
attempt to incinerate a nickel-cadmium battery; doing
so could cause it to explode. Telxon urges you to
contact the Environmental Protection Agency, the
Department of Natural Resources, a local hazardous
waste disposal agency, or the Telxon Customer
Support Center for assistance prior to disposing of
your nickel-cadmium batteries.
8