Trane TTA240F Series Owner's manual

TTA-SVN03A-EN
June 2006
Installation
Operation
Maintenance
Split System Cooling Condensers
20-Ton
Model (60 Hz):
TTA240F***A
Model (50 Hz):
TTA200FD**A

© 2006 American Standard Inc All rights reserved TTA-SVN03A-EN
Literature Change History
TTA-SVN03A-EN (June 2006)
Release of 20T, R410A product.
Note: One copy of this document
ships inside the control panel
of each unit and is customer
property. It must be retained
by the unit’s maintenance
personnel.
This booklet describes proper
installation, operation, and
maintenance procedures for air
cooled systems. By carefully
reviewing the information within this
manual and following the
instructions, the risk of improper
operation and/or component damage
will be minimized.
It is important that periodic
maintenance be performed to help
assure trouble free operation. A
maintenance schedule is provided at
the end of this manual. Should
equipment failure occur, contact a
qualified service organization with
qualified, experienced HVAC
technicians to properly diagnose and
repair this equipment.
Note: All phases of this installation
must comply with the
NATIONAL, STATE & LOCAL
CODES. In addition to local
codes, the installation must
conform with National Electric
Code -ANSI/NFPA NO. 70
LATEST REVISION.
Note: Do Not release refrigerant
to the atmosphere! If
adding or removing
refrigerant is required, the
service technician must
comply with all federal,
state, and local laws.
Warnings and Cautions
Notice that warnings and cautions
appear at appropriate intervals
throughout this manual. Warnings are
provided to alert installing contractors
to potential hazards that could result
in personal injury or death, while
cautions are designed to alert
personnel to conditions that could
result in equipment damage.
Your personal safety and the proper
operation of this machine depend
upon the strict observance of these
precautions.
NOTICE: Warnings and Cautions appear at appropriate sections
throughout this literature. Read these carefully.
WARNING: Indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION: Indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate injury. It may also be used to
alert against unsafe practices.
CAUTION: Indicates a situation that may result in equipment or property-
damage only accidents.
Preface and Cautions and Warnings
!
!

TTA-SVN03A-EN 3
Preface and Cautions and Warnings......................................... 2
Model Number Description...................................................... 4
Electrical Data.............................................................................. 6
Installation.................................................................................... 7
System Prestart Procedure........................................................ 15
System Test Mode (ReliaTel)....................................................... 18
Troubleshooting (ReliaTel).......................................................... 19
Maintenance................................................................................ 22
Warranty....................................................................................... 24
Table of Contents

4TTA-SVN03A-EN
Model Number Description
All products are identified by a
multiple-character model number that
precisely identifies a particular type of
unit. An explanation of the
alphanumeric identification code is
provided. Its use will enable the
owner/operator, installing contractors,
and service engineers to define the
operation, specific components, and
other options for any specific unit.
When ordering replacement parts or
requesting service, be sure to refer to
the specific model number, serial
number, and DL number (if
applicable) stamped on the unit
nameplate.
DIGITS 1-3: PRODUCT TYPE
TTA = Split System Cooling
DIGITS 4-6: NOMINAL GROSS
COOLING CAPACITY (MBh)
200 = 200 MBh
240 = 240 MBh
DIGIT 7: REFRIGERATION CIRCUIT
A = 1 Refrigerant Circuit R22
B = 2 Refrigerant Circuit R22
C = Manifold Scroll Compressors R22
D = 1 Refrigerant Circuit R410A
E = 2 Refrigerant Circuit R410A
F = Manifold Scroll Compressors
R410A
DIGITS 8: ELECTRICAL
CHARACTERISTICS
3 = 208-230/60/3
4 = 460/60/3
W = 575/60/3
D = 380-415/50/3
K = 380/60/3
DIGITS 9, 10: FACTORY INSTALLED
OPTIONS
00 = Packed Stock
0S = Black Epoxy Coated Coil
0R = ReliaTel™, no LCI Board
0T = ReliaTel™, no LCI Board with
Black Epoxy Coated Coil
0U = ReliaTel™, with LCI Board
0W = ReliaTel™, with LCI Board and
Black Epoxy Coated Coil
DIGITS 11: MINOR DESIGN
SEQUENCE
CURRENT
DIGITS 12: Service Digit
A = First
Model Number Description
4
TTA 090 A 3 00 B A
10

TTA-SVN03A-EN 5
Dimensional Data
Figure 1. TTA200F, TTA240F, Dimensional Data, Connection Location, Clearances, Corner Weights
APPROXIMATE CORNER WEIGHT (MASS) TOTAL UNIT
WEIGHT
TOTAL SHIPPING
WEIGHTMODELNO. #1#2#3#4
TTA240F---A 292 lbs 181 lbs 222 lbs 140 lbs 835 lbs 920 lbs
TTA200FD--A 132 kg 82 kg 101 kg 64 kg 379 kg 418 kg